2000 PONTIAC SUNFIRE

3 recalls, 169 complaints - 430 TSBs

STEERING

Defect Description

DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DU... Read more

Consequence

IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy

DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

3,855 vehicles affected

Manufacturer: DORMAN PRODUCTS, INC.

FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:PRESSURE RELIEF DEVICES

Defect Description

CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.

Consequence

FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.

Remedy

DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.

742 vehicles affected

Manufacturer: DELPHI

ELECTRICAL SYSTEM:IGNITION:SWITCH

Defect Description

ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

Consequence

IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.

Remedy

DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE ... Read more

1,415,231 vehicles affected

Manufacturer: GENERAL MOTORS CORP.

Complaint Statistics

169 total complaints 15 crashes 6 fires 14 injuries 1 deaths

Top Reported Components

Component	Complaints
ELECTRICAL SYSTEM	10
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP	10
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE	10
ENGINE AND ENGINE COOLING	7
AIR BAGS:FRONTAL	6
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP	6
ENGINE AND ENGINE COOLING:ENGINE	5
ELECTRICAL SYSTEM:IGNITION	5
POWER TRAIN:AUTOMATIC TRANSMISSION	4
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH	4

Incident date: May 24, 2020

MY CAR WAS DRIVING PERFECT UNTIL 3 WEEKS AGO, IT HAS SINCE THEN WONT START BACK UP. THOUGHT IT WAS SOMETHING TO DO WITH SPARK, THEN TRIED SPARK PLUG WIRES, NEW BATTERY, CHECKED ALTERNATOR AND FUSES, COILS ALL GOOD. THEN I WAS LEAD TO MAYBE THE GAS THAT WAS IN IT. DROPPED GAS TANK, PUT NEW FUEL FILT... Read more

Incident date: May 24, 2020

Incident date: Jun 25, 2017

"TAKATA RECALL" WHILE DRIVING AT NIGHT ON A COUNTY ROAD AND SWITCHING FROM LOW BEAMS TO HIGH BEAMS, THE HEADLIGHTS WENT COMPLETELY DARK AND DID NOT COME BACK ON UNTIL SWITCHING BACK TO LOW BEAMS. AFTER INSPECTION, NOTICED THE DAY RUNNERS ALSO WERE NOT WORKING. ALL FUSES WERE PLUGGED IN AND GOOD. ... Read more

Incident date: Jun 25, 2017

Incident date: Mar 3, 2017

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE CONTACT STATED THAT THE VEHICLE'S TURN SIGNALS WOULD INTERMITTENTLY FAIL TO OPERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THERE WAS A RECALL THAT INVOLVED A SIMILAR FAI... Read more

Incident date: Sep 20, 2013

DAUGHTER HYDROPLANED, WENT INTO DITCH ON RIGHT SIDE OF ROAD, TRAVELED ACROSS ROAD INTO LEFT DITCH AND HIT TREE, OPENING THE CONVERTIBLE TOP DURING CRASH AND TOTALED VEHICLE AIRBAGS DIDN'T DEPLOY DURING CRASH.

Crash 1 injured

Incident date: Feb 5, 2013

MY DAUGHTERS CAR WAS HAVING STARTING PROBLEMS (NOT ENOUGH GAS GETTING TO THE ENGINE TO START, HAD TO PUMP THE GAS). I TOOK IT FOR A TEST DRIVE IN A EMPTY PARKING LOT ONCE IT STARTED. I WAS GOING APPROX 10MPH THE FIRST TIME I PUSHED THE GAS PEDAL TO THE FLOOR. WHEN I RELEASED THE PEDAL IT STAYED IN P... Read more

Incident date: Feb 5, 2013

Incident date: Apr 30, 2012

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED, A SMALL FIRE OCCURRED IN THE STEERING COLUMN AND INSTRUMENT PANEL. IN ADDITION, THE FRONT DRIVER'S SIDE WINDSHIELD WAS CRACKED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS N... Read more

Fire

Incident date: Apr 30, 2012

Fire

Incident date: Jan 2, 2008

REAR PASSENGER SIDE TURN SIGNAL SOCKET IT IS GETTING VERY HOT AND IS MELTING BULBS AND SOCKET. HAVE REPLACED BULBS VARIOUS TIMES WITH AND WITHOUT PROPER GREASE AND NO CHANGE. *TR

Incident date: Jan 2, 2008

REAR PASSENGER SIDE TURN SIGNAL SOCKET IT IS GETTING VERY HOT AND IS MELTING BULBS AND SOCKET. HAVE REPLACED BULBS VARIOUS TIMES WITH AND WITHOUT PROPER GREASE AND NO CHANGE. *TR

Incident date: Sep 1, 2002

TL*THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. UPON STARTING THE ENGINE AT NIGHT, THE INSTRUMENT PANEL WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS... Read more

Incident date: Dec 13, 2009

TL* THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE IGNITION SWITCH HAS MELTED,WHICH DISABLED VEHICLE OPERATION. THE DEALER AND THE MANUFACTURER WERE CONTACTED. HE WAS REFERRED TO THE DEALER FOR DIAGNOSTIC TESTING. THE WARRANTY EXPIRED, AND THERE WERE NO RECALLS THAT ADDRESSED THE FAILURE. THE FAILURE ... Read more

Fire

Incident date: Dec 1, 2008

TL*THE CONTACT OWNS A 2000 PONTIAC SUNFIRE. THE VEHICLE HAS CATALYST V TIRES, MODEL 20555R16 (NA). THE CONTACT STATED THAT ALL FOUR TIRES FAILED ON HER VEHICLE. SHE STATED THAT THE TIRES WERE SUPPOSED TO BE ALL SEASON TIRES; HOWEVER, THEY DO NOT PERFORM PROPERLY. THE VEHICLE CANNOT BE DRIVEN IN ... Read more

Incident date: Oct 1, 2007

PASSENGER TAIL LIGHT OR BRAKE LIGHT HAVE BEEN REPLACED SEVERAL TIMES. FUSES REPLACED SEVERAL TIMES. ONCE REPLACED BULBS DEFECT WITHIN AN HOUR OR SO. DOME LIGHT OR OVER HEAD LIGHT REPEATS SAME PROCESS. VEHICLE'S BATTERY AND TERMINALS REPLACED WITH NO CHANGE. $$$ *TR

Incident date: Oct 1, 2007

Incident date: Feb 27, 2004

NO MEMORY OF THE NIGHT OF THE ACCIDENT I SUSTAINED LIFE THREATENING INJURIES AND MY BOYFRIEND DIED. MY SPECIALISTS OUT OF STATE BELIEVES IT WAS SOMETHING KNOWN AS SUDDEN ACCELERATION. THIS IS A PROBLEM WHY DOES NHTSA KEEP IGNORING THAT THERE IS A MORE SERIOUS PROBLEM HERE INSTEAD OF BLAMING THE DRI... Read more

Crash 1 injured 1 deaths

Incident date: Feb 22, 2007

MY TURN SIGNALS HAVE BEEN ACTING UP LATELY. AFTER DOING SOME RESEARCH ONLINE, I DECIDED TO FILE THE CLAIM-SEEMS I AM NOT THE ONLY ONE HAVING THE SAME PROBLEM. WHEN I USE MY LEFT TURN SIGNAL, MORE OFTEN THEN NOT IT DOESN'T WORK, MY DASH LIGHTS FLASH AND MY WINDSHIELD WIPERS WILL NOT SHUT OFF. WHEN ... Read more

Incident date: Jan 1, 2002

VEHICLE: 2000 PONTIAC SUNFIRE THE DAYTIME RUNNING LIGHTS DO NOT WORK; WHEN THE VEHICLE IS PUT IN GEAR, THE LIGHTS "FLICKER" AS THE RELAY FIRES, BUT THE LIGHTS DO NOT REMAIN ON, THEN THE "SERVICE" LIGHT COMES ON. ABOUT 75% OF THE TIME, THE HEADLIGHTS WILL NOT TURN ON, AND IF THEY DO, THE BRIGHT L... Read more

Incident date: Jun 1, 2006

DT*: THE CONTACT STATED THE SERVICE LIGHT ILLUMINATED AND THE VEHICLE WAS TAKEN TO THE DEALERSHIP. THE DEALERSHIP PERFORMED A DIAGNOSTIC TEST AND DETERMINED THE WIRING HARNESS FOR THE HEADLIGHTS NEEDS TO BE REPLACED.

Incident date: Feb 20, 2006

I WOULD LIKE TO REPORT A PATTERN OF SMALL (BUT ANNOYING) COMPLAINTS WITH THE 2000 PONTIAC SUNFIRE I RECENTLY OWNED. I STATE "RECENTLY OWNED" BECAUSE I GRATEFULLY TRADED IT IN LAST WEEK WITH JUST 56,234 MILES ON IT ON A NEW 2006 SUBARU IMPREZA. I BOUGHT THE PONTIAC NEW IN 2000 AND CARED FOR IT UP UNT... Read more

Incident date: Oct 18, 2005

DT:THE CONTACT STATED TWO FRONTAL AIR BAGS DEPLOYED WHILE TURNING INTO A GAS STATION. THIS OCCURRED WHILE DRIVING AT A LOW SPEED. SHE WAS THE ONLY OCCUPANT IN THE VEHICLE AND WAS WEARING HER SEAT BELT AT THE TIME. THEE AIRBAGS DEPLOYED ON THE PASSENGER SIDE. THERE WAS CORROSION AND WATER IN THE AI... Read more

1 injured

Incident date: Aug 20, 2004

MY CAR IS A 2000 PONTIAC SUNFIRE, AND TWICE WITHIN 12 MONTHS I HAVE HAD THE SAME PROBLEM WITH THIS VEHICLE. THE DAY TIME RUNNING LIGHTS AND THE BRIGHT LIGHTS QUIT WORKING , THE 1ST TIME THE DEALERSHIP SAID IT WAS A BAD WIRE AND REPLACED IT, WITHIN ONE YEAR IT HAPPENED AGAIN, BUT THE DEALERSHIP SAI... Read more

Incident date: Aug 20, 2004

Incident date: Aug 7, 2005

I WAS ON ROUTE 65 IN NORTH SEWICKELY IN PENNSYLVANIA. I WAS STOPPED DUE TO ANOTHER DRIVER IN FRONT OF ME MAKING A LEFT HAND TURN. A CAR CAME FROM BEHIND HITTING ME AND I WAS PROPELLED IN FRONT OF ONCOMING TRAFFIC WHICH HIT THE FRONT END OF MY CAR. THE AIR BAGS DID NOT DEPLOY FROM THE HEAD ON COLLIS... Read more

Crash 1 injured

Incident date: Apr 21, 2005

WHILE TRAVELING VEHICLE SHUT DOWN ON THE HIGHWAY AT 70 MPH. VEHICLE WAS TOWED TO A DEALER AND THE ALTERNATOR WAS REPLACED. AFTER GETTING BACK ON THE ROAD VEHICLE CONTINUED TO SHUT DOWN. HOWEVER, IT RESTARTED. AFTER ARRIVING HOME THE VEHICLE WAS STILL DEFECTIVE.*AK

Incident date: Mar 28, 2004

IIN DECEMBER OF 2004 MY SON WAS IN THE BACKSEAT PUTTING ON HIS SEAT BELT AND AN IT BROKE. SINCE THEN HE HAS BEEN SITTING IN THE MIDDLE. ABOUT 3 WEEKS AGO THE SAME THING HAPPENED TO THE SEAT BELT. ON MONDAY THE 21ST OF MARCH I WAS PUTTING MY OTHER SONS CAR SEAT IN THE CAR AND WAS TIGHTNING UP THE BEL... Read more

Incident date: Dec 19, 2004

MY 2000 SUNFIRE AUTOMATIC CAR STOPPED MOVING ON DECEMBER 19, 2004 WITH 64,000 MILES ON IT. I HAD IT IN THE DEALERSHIP IN VIROQUA, WI ON MON., DEC. 21. THEY TOLD ME ON DEC. 22 THE TRANSMISSION WENT OUT AND THE PART WOULD BE IN AT THE BEGINNING OF JANUARY 2005. I CALLED THEM EVERY WEEK IN THE BEGI... Read more

Incident date: Dec 28, 2004

REPEAT ISSUE ON 12-28-04 - COLD WEATHER, EXPRESSWAY SPEEDS - NO WARNING CAR LOST POWER AND STALLED ON EXPRESSWAY. FINALLY RESTARTED AFTER TOW TRUCK ARRIVED. STALLED AGAIN ON 12-29-04 SAME CONDITIONS - WOULD NOT RESTART - TOWED TO GM DEALERSHIP. FUEL PUMP AND SYSTEM REPLACED. *JB

Incident date: Jan 14, 2005

REPEAT FAILURE: AFTER FUEL PUMP WAS REPLACED ON 12-29-04, ON 1-14-05 UNDER SAME CONDITIONS - COLD WEATHER - EXPRESSWAY SPEED - THE CAR LOST POWER AND STALLED - WOULD NOT RESTART AND REQUIRED TOW TO DEALERSHIP. ANALYSIS SHOWED THE REPLACEMENT FUEL PUMP ALSO BECAME DEFECTIVE. (CAR LOST POWER AN... Read more

Incident date: Jan 14, 2005

Incident date: Dec 16, 2004

PONTIAC SUNFIRE 2000 WILL BE DRIVING THE CARS, IT STALLS OUT, THEN RESTARTS WITHOUT TURNING THE KEY. HAVE TALKED TO THE PONTIAC DEALER. BRINGING IT IN ON 12/20/2004 FOR FURTHER DIAGNOSTICS FROM WHAT I HAVE READ THIS IS A COMMON PROBLEM RELATED TO A COLLAPSED FUEL STRAINER THATWILL CAOST IN THE ARE... Read more

Incident date: Oct 23, 2004

LAST YEAR I TOOK MY 2000 PONTIAC SUNFIRE TO THE DEALER DUE TO IT'S LEAKING BREAK FLUID AND LOSS OF BREAKING POWER. THE DEALER REPLACED THE BREAK LINE GOING TO THE RIGHT REAR BRAKE. I WAS TOLD THAT THE CRACK IN THE LINE WAS DUE TO "OIL'S AND OTHER FLUIDS FROM DRIVING ON THE ROAD CAUSED IT TO CORROD... Read more

Incident date: Jun 30, 2004

THE TRANSMISSION FAILED AT 62000 MILES. *NM THE CONSUMER REQUESTED REIMBURSEMENT FROM THE MANUFACTURER BUT WAS DENIED. *NM

Incident date: Sep 24, 2001

WHILE ON ACTIVE DUTY IN THE ARMY, I PURCHASED A USED 2000 PONTIAC SUNFIRE IN GEORGIA. THE CAR BEGAN GIVING ME PROBLEMS ONLY 6 MONTHS AFTER THE PURCHASE. LUCKILY, I FORCED THE DEALERSHIP TO PAY FOR A WARRANTY BECAUSE I HAD TO HAVE 3 MAJOR REPAIRS WITHIN A 11/2 AFTER THAT. UNFORTUNATELY, SHORTLY AFTE... Read more

Incident date: Sep 24, 2001

Incident date: Sep 9, 2004

VEHICLE WAS INVOLVED IN A FRONTAL COLLISION CRASHING INTO A TREE, IMPACT WAS APPROXIMATELY 45-50 MPH. UPON IMPACT, BOTH FRONTAL AIR BAGS DEPLOYED 15 MINUTE AFTERWARD. CONSUMER WAS AIR CARRIES TO THE LOCAL HOSPITAL WITH MAJOR INJURIES. DEALER AND THE MANUFACTURER WERE BOTH NOTIFIED. *AK

Crash 1 injured

Incident date: Sep 6, 2004

WHILE DRIVING 5 MPH, THE VEHICLE ACCELERATED ON ITS OWN. UPON PARKING NEAR A STOP WITH FOOT OFF ACCELERATOR AND ON BRAKE PEDAL, THE VEHICLE JUMPED ONTO THE SIDEWALK. THE FRONT NEEDED TO BE REPLACED, AND WILL COST $4,700. NO POLICE REPORT.*AK *JB

Crash

Incident date: Sep 7, 2004

THE CONSUMER APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. THE VEHICLE SLOWED DOWN ON ITS ON. THE CONSUMER WAS ABLE TO CONTROL THE VEHICLE. THE DRIVER WAS ABLE TO DRIVE IT TO DEALER. THE MECHANIC INFORMED THE DRIVER THAT THE PROBLEM COULD NOT BE DUPLICATE. THE ENGINE LIGHT APPEARED ON TH... Read more

Incident date: Sep 7, 2004

Incident date: Jan 1, 2003

WHILE DRIVING ON FREEWAY AT 60 MPH VEHICLE COMPLETELY SHUT DOWN. T WHEN DRIVING 30 MILES OR LESS VEHICLE WAS FINE. TOOK VEHICLE TO THE DEALER, THEY PUT IT ON THE DIAGNOSTIC MACHINE, SAID NOTHING WAS WRONG. HOWEVER, THE PROBLEM RECURRED WHEN DRIVING ON THE FREEWAY AT A HIGH SPEED. *AK

Incident date: Jun 11, 2004

DAUGHTER WAS TRAVELING DOWN INTERSTATE AND STEERING WHEEL LOCKED UP. SHE WAS UNABLE TO CONTROL CAR SO SHE PULLED AND JERKED THE WHEEL. IN DOING SO WHEN THE STEERING UNFROZE HER CAR ROLLED OVER TWICE. CAR WAS TOTALED. WE ADVISED GM, WHO TOLD US THEY WOULD INVESTIGATE. AT THIS TIME THEY ARE ADMIT... Read more

Crash 1 injured

Incident date: Feb 1, 2004

VEHICLE BROKE DOWN, SMOKE WAS COMING FROM THE ENGINE AND THE ENGINE WOULD NOT TURN OVER. *MR THE ENGINE MELTED HOSES AND OTHER PARTS DUE TO THE GASKET BLOWING OUT WHILE THE VEHICLE WAS IN MOTION. THE DASHBOARD FAILED TO SIGNAL THE PROBLEM. THE CONSUMER REQUESTED REIMBURSEMENT. *SC *JB

Incident date: Jun 4, 2004

I OWN A 2000 PONTIAC SUNFIRE - PURCHASED NEW. I HAD NO PROBLEMS UNTIL 2003 WHEN MY CAR WOULD DECCELERATE FOR NO REASON WHILE DRIVING AT ANY SPEED, HESITATE WHILE DRIVING AT ANY SPEED, OR, AFTER STOPPING AT AN INTERSECTION, SIMPLY WOULD NOT ALLOW ACCELERATION. THIS HAS HAPPENED WHILE TRYING TO GO T... Read more

Showing 50 of 169 complaints.

EPA Fuel Economy, 2000 PONTIAC SUNFIRE

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
2.2L 4-cyl, Automatic 3-spd (Front-Wheel Drive)	20.0	26.0	22.0	Regular	$2,850
2.2L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	20.0	29.0	23.0	Regular	$2,700
2.2L 4-cyl, Manual 5-spd (Front-Wheel Drive)	21.0	31.0	24.0	Regular	$2,600
2.4L 4-cyl, Automatic 4-spd (Front-Wheel Drive)	19.0	28.0	23.0	Regular	$2,700
2.4L 4-cyl, Manual 5-spd (Front-Wheel Drive)	20.0	30.0	24.0	Regular	$2,600

CO2 Emissions: -1.0 g/mile (Subcompact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2000 PONTIAC SUNFIRE

430 manufacturer communications from 323 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	43
980000 UNKNOWN OR OTHER	26
110000 ELECTRICAL SYSTEM	25
060000 ENGINE AND ENGINE COOLING	24
353000 EQUIPMENT:ELECTRICAL	22
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	20
060000 ENGINE (PWS)	19
356000 EQUIPMENT ADAPTIVE/MOBILITY	17

060000 ENGINE AND ENGINE COOLING

This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.

100000 POWER TRAIN

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

060000 ENGINE AND ENGINE COOLING

This PI bulletin advises the technician on the proper way to install the pistons in an engine.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi

060000 ENGINE AND ENGINE COOLING

This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the

200000 WHEELS

This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.

061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT

This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component

060000 ENGINE AND ENGINE COOLING

980000 UNKNOWN OR OTHER

This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

100000 POWER TRAIN

This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

160000 STRUCTURE

060000 ENGINE AND ENGINE COOLING

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and

030000 SERVICE BRAKES, HYDRAULIC

061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN

This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician

356000 EQUIPMENT ADAPTIVE/MOBILITY

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

120000 EXTERIOR LIGHTING

This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.

350000 EQUIPMENT

160000 STRUCTURE

200000 WHEELS

350000 EQUIPMENT

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

070000 FUEL SYSTEM, GASOLINE

This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo

061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR

350000 EQUIPMENT

This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in

350000 EQUIPMENT

This informational bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

060000 ENGINE AND ENGINE COOLING

This informational bulletin provides guidelines and diagnostic/repair information to technicians regarding vehicle engine oil consumption.

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.

060000 ENGINE (PWS)

This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is

350000 EQUIPMENT

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

355100 EQUIPMENT:OTHER:LABELS

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

060000 ENGINE (PWS)

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

060000 ENGINE (PWS)

356000 EQUIPMENT ADAPTIVE/MOBILITY

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

070000 FUEL SYSTEM, GASOLINE

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

This informational bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

110000 ELECTRICAL SYSTEM

This informational bulletin provides information for dealers/technicians on Procedures to Unlock Delco Radio with Theftlock.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock ce

353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES

120000 LIGHTING (PWS)

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

356000 EQUIPMENT ADAPTIVE/MOBILITY

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

350000 EQUIPMENT

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

060000 ENGINE (PWS)

110000 ELECTRICAL SYSTEM

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

118000 ELECTRICAL SYSTEM:SOFTWARE

This informational bulletin provides information for the GM of Canada OnStar Cellular Communication Upgrade to 3G/4G LTE for vehicles that may need an upgrade.

350000 EQUIPMENT

353000 EQUIPMENT:ELECTRICAL

350000 EQUIPMENT

063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

This informational bulletin advises of a new fuel injection kit used for decarbonizing the intake valves, and explains how toptier fuels should be used to reduce carbon build up.

060000 ENGINE (PWS)

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D

350000 EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

120000 EXTERIOR LIGHTING

This informational bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Replacement Guidelines.

060000 ENGINE AND ENGINE COOLING

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

This preliminary information document communicates a tip on the way to diagnose possible induction or exhaust air leaks using the evaporative emission cart smoke machine and ultrasonic leak detector tools.

350000 EQUIPMENT

This Preliminary information communicates

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

060000 ENGINE (PWS)

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

356000 EQUIPMENT ADAPTIVE/MOBILITY

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco Theft Lock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock c

350000 EQUIPMENT

This Preliminary Information communication provides information to the technician about connectivity concerns when connecting an Apple device via USB cord. Technician should insure the customer is using an original equipment manufacturer Ap

110000 ELECTRICAL SYSTEM

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

020000 SUSPENSION

060000 ENGINE (PWS)

Showing 100 of 430 bulletins.

PONTIAC SUNFIRE - All Years Overview

Complete safety history for the PONTIAC SUNFIRE across all model years (1995, 2005).

51 Total Recalls

1,643 Total Complaints

0 Investigations

153 Reported Crashes

61 Reported Fires

8 Reported Deaths

PONTIAC SUNFIRE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2005	1	94	View
2004	2	41	View
2003	2	113	View
2002	2	128	View
2001	3	83	View
2000 (current)	3	169
1999	5	128	View
1998	7	149	View
1997	9	257	View
1996	10	320	View
1995	7	154	View
1994	0	2	View
1991	0	1	View
1985	0	2	View

Other PONTIAC Models

Model	Recalls	Complaints
GRAND PRIX	178	7,320	View
FIREBIRD	96	804	View
GRAND AM	89	8,116	View
BONNEVILLE	61	2,579	View
G6	59	8,415	View
MONTANA	57	1,455	View
LEMANS	53	172	View
VIBE	51	2,135	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2000 PONTIAC SUNFIRE

Complaint Statistics

Top Reported Components

EPA Fuel Economy, 2000 PONTIAC SUNFIRE

Technical Service Bulletins, 2000 PONTIAC SUNFIRE

Most Affected Components

PONTIAC SUNFIRE - All Years Overview

PONTIAC SUNFIRE - Year by Year

Other PONTIAC Models