2004 NISSAN 350Z

3 recalls, 177 complaints - 107 TSBs

POWER TRAIN:CLUTCH ASSEMBLY

Defect Description

ZF SERVICE IS RECALL CERTAIN CLUTCH KIT ASSEMBLIES, PART NUMBER SX: K70358-01, SHIPPED TO WHOLESALERS AS SERVICE PARTS BETWEEN SEPTEMBER 1, 2010, AND MARCH 8, 2011. THESE SERVICE PARTS ARE INTENDED FOR USE ON MODEL YEAR 2003-2006 NISSAN 350Z AND INFINITI G35 VEHICLES. THE SX: K70358-01 CLUTCH KIT ... Read more

Consequence

AN OVERSIZED CLUTCH DISC COULD CAUSE THE VEHICLE TO MOVE UNINTENTIONALLY ON THE INITIAL START-UP, IF THE DRIVER DOES NOT FOLLOW THE INSTALLATION INSTRUCTIONS AND FAILS TO USE THE SERVICE BRAKES WHILE THE HAND BRAKE IS NOT APPLIED. UNINTENTIONAL MOVEMENT OF THE VEHICLE COULD RESULT IN A CRASH OR POS... Read more

Remedy

ZF SERVICE NOTIFY WHOLESALERS TO RETURN ANY AFFECTED CLUTCH KIT ASSEMBLIES STILL IN INVENTORY FOR FREE REPLACEMENT KITS. THIS CONDITION WILL CORRECT ITSELF AFTER THE FIRST START-UP AND USAGE OF THE CLUTCH KIT. HOWEVER, IF AN OWNER IS NOT SATISFIED WITH ITS PERFORMANCE, ZF SERVICES WILL REIMBURSE T... Read more

199 vehicles affected

Manufacturer: ZF SALES & SERVICE NORTH AMERICA, LLC

EXTERIOR LIGHTING

Defect Description

CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. ... Read more

Consequence

WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.

Remedy

CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.

27,176 vehicles affected

Manufacturer: CK MOTORSPORT, INC.

FUEL SYSTEM, GASOLINE

Defect Description

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE FUEL FILLER HOSE MAY CRACK AND RESULT IN FUEL LEAKAGE FROM THE HOSE WHILE REFUELING.

Consequence

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy

DEALERS WILL REPLACE THE FUEL FILLER HOSE. RECALL BEGAN ON FEBRUARY 27, 2006, FOR NISSAN OWNERS, AND ON MARCH 13, 2006, FOR INFINITI OWNERS. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261 OR INFINITI AT 1-800-662-6200.

192,659 vehicles affected

Manufacturer: NISSAN NORTH AMERICA, INC.

Complaint Statistics

177 total complaints 13 crashes 15 injuries

Top Reported Components

Component	Complaints
TIRES	27
SUSPENSION:FRONT	21
AIR BAGS	15
FUEL SYSTEM, GASOLINE	11
SUSPENSION	10
POWER TRAIN:MANUAL TRANSMISSION	6
STRUCTURE	6
POWER TRAIN	5
ENGINE AND ENGINE COOLING	5
TIRES:TREAD/BELT	5

Incident date: Feb 27, 2025

Transmission is failing in 2019 Camry XSE. Toyota will not back the repair. Transmissions are on backorder, so it should be a recall. The car is making a loud noise and starting to "lunge" while driving.

Incident date: Apr 20, 2024

The contact owns a 2013 Kia Soul. The contact received notification of NHTSA Campaign Number: 23V652000 (Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair... Read more

Incident date: Nov 10, 2021

The airbag light came on for no reason, has never come on before. No accidents, fender bender, no bumps. Shop read an error code of B1129. Checked right passenger SRS seat connections as code suggests and reset the light. Light came back on in two days. Shop says airbag may not deploy and can n... Read more

Incident date: Sep 13, 2021

The contact's girlfriend owns a 2004 Nissan 350Z. The contact stated that upon refueling the gas tank, a large amount of gasoline began to leak out from the gas tank and underneath the vehicle. The contact also stated that upon entering the vehicle, a strong fuel odor began to emit from the vehicle.... Read more

Incident date: Jan 15, 2020

I PURCHASED 4 NEW TIRES FOR MY 2004 NISSAN 350Z, THEY ARE THE FALKEN PRO G5 SPORT A/S TIRES P225/45R18 ON THE FRONT. 245/45/R18 ON THE REAR ON 2/06/19 THE MILEAGE IN WAS 16,292. ON 1/15/20 I TOOK THE CAR OUT AND THE CAR WAS BOUNCING ALL OVER THE ROAD, I TOOK IT BACK TO DISCOUNT TIRES IN LAS VEGAS NE... Read more

Incident date: Nov 19, 2018

HELLO, I WAS LEAVING A STOP SIGN BARELY MOVING AND ALL OF A SUDDEN IT SOUNDED LIKE A GUN GOING OFF IN MY CAR. BEFORE I COULD GRASP MY NEXT THOUGHT MY CAR FLIPPED COMPLETELY OVER ON ITS SIDE NO TIRES TOUCHING THE GROUND! I HAD TO CRAWL OUT PASSENGER WINDOW . UPON INSPECTION OF VEHICLE THIS IS WHAT... Read more

Crash 1 injured

Incident date: Nov 19, 2018

Crash 1 injured

Incident date: Nov 19, 2018

Crash 1 injured

Incident date: May 11, 2019

I BOUGHT A 2004 Z350 AND I BOUGHT IT ON MOTHER'S DAY LAST MONTH AND I GOT THE CAR IN THE ABARAT WAS ALREADY ON THE CAR THE LIGHT WAS ALREADY ON WHEN I PURCHASED A CAR FROM A DEALERSHIP AND I WAS TOLD THAT IT WAS AGAINST THE LAW TO SELL A CAR WITH THE AIRBAG LIGHT ON.

Incident date: Apr 16, 2019

MY CAR LIGHT JUST CAME ON. I NEVER HAD AN ACCIDENT WITH MY CAR SINCE I PURCHASED IT FROM PALM SPRINGS NISSAN. IN 2004

Incident date: Feb 19, 2018

350Z RECALL. 2004 350Z . ORIGINAL OWNER OF CAR. A COUPLE WEEKS AGO, WHILE DRIVING CAR HESITATED, THEN RESUMED BUT CHECK ENGINE LIGHT TCS OFF LIGHT AND SLIP LIGHTS ON, AND REMAINED ON. THIS WEEK WHILE DRIVING 40MPH WITHOUT WARNING THE CAR HESITATED BUT ACTUALLY STALLED. I WAS ABLE TO SOMEWHAT SAFE... Read more

Incident date: Jul 20, 2017

SERVICE ENGINE WARNING LIGHT IS ON. CAR TURNS OF WITHOUT WARNING WHILE OPERATING. CAM SHAFT SENSOR WARNING. CAR IS CURRENTLY PARKED OUTSIDE HOME.

Incident date: Apr 5, 2016

AIRBAG WARNING LIGHT ILLUMINATED ON DASH ON 2004 350Z NISSAN. THIS VEHICLE IS NOT LISTED FOR NISSAN AIRBAG RECALL. WITHIN WARRANTY PERIOD THE AIRBAG WAS PREVIOUSLY REPLACED BY PLANET NISSAN (DEALER LAS VEGAS, NV) IN 2004 OR 2005, NOT SURE OF SPECIFIC DATE. DEALERSHIP SAID IT WASN'T COVERED UNDER... Read more

Incident date: Sep 16, 2015

HAPPENED IN THE DRIVEWAY, FORTUNATELY. WHEN THE CLUTCH PEDAL WAS DEPRESSED, IT STAYED DOWN, AND IN GEAR. IT WAS DIFFICULT TO FORCE THE CAR OUT OF GEAR. I WAS THEN ABLE TO MANUALLY LIFT THE PEDAL, AND PUMP IT SOFTLY TO MAKE IT STAY UP. THIS HAS NOT HAPPENED SINCE. IT IS A HYDRAULIC CLUTCH' NO LEAK... Read more

Incident date: Oct 17, 2014

I HAVE HAD A PROBLEM WITH THE NEUTRAL SAFETY SWITCH CAUSING THE CAR TO PERIODICALLY NOT START. A MECHANIC MADE A PREVIOUS DIAGNOSIS BUT SAID THERE WERE NO SAFETY CONCERNS. THE CAR EVENTUALLY WOULD START ALL, REQUIRING DOWNTIME FOR REPAIR. SOMETIMES AFTER SITTING OVER NIGHT AND SOMETIMES AFTER SEVER... Read more

Incident date: Feb 23, 2014

TL* THE CONTACT OWNS A 2004 NISSAN 350Z. THE CONTACT STATED THAT THE AIR BAG INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER RESET THE AIR BAG SENSOR, BUT THE FAILURE RECURRED. THE VEHICLE WAS BROUGHT BACK TO THE DEALER WHO STATED THAT BOTH THE DRIVER AND PASSENGER SIDE AIR BAG MODULES NE... Read more

Incident date: Oct 21, 2011

ON 2004 NISSAN 350Z THE CONVERTIBLE TOP WILL STICK IN THE HALF OPEN HALF CLOSED POSITION. NISSAN WILL NOT HELP FIX THIS COSTLY REPAIR $2200-$3000. THE MOTORS THAT CONTROL THE TOP CALLED THE (FIFTH BOW MOTOR) WILL GO OUT WITHOUT NOTICE. NO WAY TO MANUALLY CLOSE THE TOP. MANY OTHERS ON NISSAN FORUM SI... Read more

Incident date: Dec 15, 2013

AIR BAG FAULT LIGHT FOR PASSENGER SEAT STAYED ON. INVESTIGATION BY NISSAN DETERMINED IT TO BE A FAULTY SENSOR. ANOTHER INCIDENT OCCURRED ON 3/05/14, WITH SAME PROBLEM. APPEARS TO BE THE SAME PROBLEM AS RECALL OF 2013-2014 NISSANS. I THINK RECALL SHOULD BE EXTENDED TO INCLUDE MY 2004 Z350. *TR

Incident date: Feb 20, 2013

MY DAUGHTER WAS DRIVING IN ORLANDO WHEN HER CHECK ENGINE LIGHT AND THE SLIP CONTROL LIGHT CAME ON AND THE ENGINE LOST POWER AND STALLED. WE HAD TO HAVE THE VEHICLE TOWED TO AN ORLANDO NISSAN DEALER. THEY DIAGNOSED IT AS THE CAMSHAFT AND CRANKSHAFT SENSORS AND WE HAD TO HAVE IT FIXED AT A COST OF $... Read more

Incident date: Feb 20, 2013

Incident date: Apr 10, 2012

THE GAS GAUGE DOES NOT SHOW FULL WHEN THE TANK IS FULL. THIS IS CAUSED BY FAULTY SENSORS IN THE TWO TANKS WHICH NISSAN REFUSES TO ADMIT. I ALONG WITH HUNDREDS OF OTHERS ON ONLINE FORUMS HAVE HAD THIS ISSUE AND HAVE TO SPEND MONEY OUT OF OUR POCKETS ALTHOUGH THIS IS CLEARLY A DEFECT. IT SEEMS TO BE W... Read more

Incident date: Jun 28, 2013

THE CAR'S FUEL SENSORS WILL NOT ALLOW ME TO FILL UP THE GAS TANK COMPLETELY. IT STOPS ABOUT HALFWAY EVERY TIME. *TR

Incident date: Oct 1, 2011

TL* THE CONTACT OWNS A 2004 NISSAN 350Z. THE CONTACT STATED THAT THE AIR BAG SENSOR WARNING LAMP ILLUMINATED. IN ADDITION, THE WATER TEMPERATURE AND FUEL LEVEL GAUGES CONTINUOUSLY FLUCTUATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE ... Read more

Incident date: Oct 1, 2011

Incident date: Nov 1, 2004

THE DRIVERSIDE POWER WINDOW MOTOR HAD TO BE REPLACED WITHIN MONTHS OF PURCHASE AFTER WINDOW BECAME STUCK IN THE OPEN POSITION, THE DEALERSHIP WHERE I PURCHASED CAR REPLACED AT NO COST OF COURSE DUE TO IT WAS STILL UNDER WARRANTY. THE SAME PROBLEM HAPPENED AGAIN ON 2/19/09 AND DEALER INFORMED ME NO L... Read more

Incident date: Nov 1, 2004

Incident date: Apr 1, 2009

THOUSAND OF REPORTED CASES OF NOT BEING ABLE TO FUEL UP THE NISSAN 350Z. THE PROBLEM SOURCE IS THE FILLER NECK SHUTTER VALVE. NISSAN IS AWARE OF THE ISSUE FOR YEARS AND HAVE BEEN MAKING CUSTOMER FOOT THE $400-$500 BILL INSTEAD OF TAKING ACTION ON THE FAULTY PART. THE FAULTY SHUTTER VALVE CAUSES FUE... Read more

Incident date: Dec 30, 2011

TL* THE CONTACT OWNS A 2004 NISSAN 350Z. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED UPON STARTING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AW... Read more

Incident date: Dec 30, 2011

Incident date: Nov 5, 2007

THE FUEL GAUGE DOESN'T ACCURATELY REFLECT THE AMOUNT OF GASOLINE IN THE FUEL TANK. EXAMPLES INCLUDE WHEN THE FUEL TANK IS FILLED TO THE POINT OF OVERFLOWING, THE FUEL GAUGE RANDOMLY REPORTS, 3/4, 1/2 1/4 AND SOMETIMES EMPTY. THE FUEL GAUGE RANDOMLY REPORTS DIFFERENT FUEL LEVELS EACH TIME THE IGNIT... Read more

Incident date: Mar 9, 2008

2003 2004 350Z CAME WITH OUT CAMBER ADJUSTMENT WEARING FRONT TIRES INSIDE WERE YOU DONT SEE CAUSEING BLOW OUTS AT HIGHWAY SPEEDS THEY MAKE CAMBER KIT BUT ARE NOT BY NISSAN SO THEY WONT PAY TO GET THIS LIFE SAVING PART PUT ON I HAVE PUT ON 6 PAIRS OF FRONT TIRES IN 3 YEARS WITH NO HELP FROM NISSAN BE... Read more

Incident date: Sep 1, 2004

MORE THAN 50 PERCENT OF 2003-2007 NISSAN'S HAVE ISSUES WITH POWER WINDOWS, EVEN HIGHER PERCENTAGE WITH THE 350Z. STILL NO RECALLS HAVE BEEN ISSUED, IT IS A SAFETY ISSUE SHOULD THE DOOR BE JAMMED THE NEXT ESCAPE ROUTE WOULD BE THREW THE WINDOW. IF THE WINDOW IS NOT OPERATING THEN YOU HAVE A VERY SER... Read more

Incident date: Sep 2, 2011

I HAVE A 2004 350Z NISSAN I BOUGHT USED IN 2007 @ 16K MILES. I'M UNABLE TO FILL THE FUEL TANK COMPLETELY. APPARENTLY THE FUEL NOZZLE SENSOR DETECTS THE TANK AS FILLED WHEN IT IS NOT. BEFORE TANK FUEL GAUGE SHOWS 3/4 FILLED @ 12-13 GALLONS WHEN NOZZLE SHUTS OFF RANDOMLY. OTHERWISE I COULD FILL UP NO... Read more

Incident date: Jul 17, 2011

THE CAR AT 28,241 NEEDED A DRIVE BELT, NEW CLUTCH AND FLYWHEEL. KEEP UP WITH ALL REQUIRED MAINTENANCE AND KNOW HOW TO DRIVE CARS WITH CLUTCHES (35 YEARS). GEICO SENT REPRESENTATIVE TO INSPECT THE CAR AND NOTED THAT IT WAS NOT THE NORMAL WEAR AND TEAR FOR THIS CAR AND AGREE TO REPAIR IT. THIS WAS AF... Read more

Incident date: Jul 17, 2011

Incident date: Jul 1, 2010

THE FUEL GAUGE IN MY 2004 NISSAN 350Z FLUCTUATES UP AND DOWN. IT HAPPENS AFTER FUELING, AND UPON DRIVING THE CAR. I HAVE TAKEN THE CAR TO 2 DIFFERENT NISSAN SERVICE DEPTS. FOR REPAIR. THE FIRST TIME, THEY SAID IT WAS A FAULTY FUEL SENSOR, AND REPLACED IT. THEY SAID IT WAS FIXED, BUT WHEN I DROVE IT,... Read more

Incident date: Jun 27, 2010

TL* THE CONTACT INQUIRED ABOUT A 2004 NISSAN 350Z. THE CONTACT STATED THAT AFTER REFUELING, THE FUEL GAUGE DISPLAYED A READING OF BEING OF THE WAY FULL. UPON DRIVING, THE FUEL GAUGE BEGAN TO FLUCTATE UP AND DOWN. THE CONTACT EXPRESSED CONCERN ABOUT NOT KNOWING HOW MUCH FUEL WAS IN THE VEHICLE. THE ... Read more

Incident date: Jan 15, 2011

MY NISSAN 350Z THE GAS GAUGE IS CURRENTLY NOT WORKING. I CAN FILL MY CAR TO CAPACITY AND WITHIN A DAY THE LIGHT INDICATOR FOR EMPTY IS ON. I WAS INFORMED THAT THERE WAS A RECALL FOR THIS PROBLEM AND I NEVER RECEIVED A NOTICE. *TR

Incident date: Jan 15, 2011

Incident date: Jan 10, 2009

NISSAN 350Z HAVE A FUEL GAUGE PROBLEM IN WHICH MANY ARE EXPERIENCING. WHEN THE GAUGE REACHES BELOW 1/4 TANK FULL IT WILL SHOW AS EMPTY. ONCE THE CAR IS TURNED OFF THE GAUGE WILL SHOW AS EMPTY EVEN WHEN FUEL IS IN IT. THE IN ACCURACY OF THE GAUGE LEADS TO PEOPLE OVER FILLING THEIR TANKS WITH G... Read more

Incident date: Oct 1, 2010

2004 NISSAN 350Z. CONSUMER WRITES REGARDING MOTOR PROBLEMS *TGW THE CONSUMER STATED THE VEHICLE CONSUMED AN EXCESSIVE AMOUNT OF OIL. THE CONSUMER STATED NISSAN KNOWINGLY HAS ENGINE PROBLEMS WITH THE 350Z ENGINES USING EXCESSIVE AMOUNTS OF OIL WHICH PASSES THROUGH THE PISTON RINGS OUT THE EXHAUST TH... Read more

Incident date: Aug 18, 2010

AIRBAG LIGHT ON 2004 350Z TOURING ROADSTER CONTINUES TO FLASH. DIAGNOSTIC INVESTIGATION GIVES NO PARTICULAR CODE THAT LEADS TO PROMPT CORRECTION OF AIRBAG SYSTEM MALFUNCTION. *TR

Incident date: Feb 7, 2011

2004 NISSAN 350Z. CURRENT MILEAGE - 58,000+. PURCHASED NEW FROM A LOCAL DEALER IN NOVEMBER OF 2004, AFTER SEARCHING ALL OF THE DEALERS IN CENTRAL FLORIDA FOR THE Z THAT HAD THE TRIM AND SAFETY PACKAGE THAT WE WANTED. BEGINNING IN 2007, THE VEHICLE HAS HAD ONGOING PROBLEMS WITH THE AIRBAG LIGHT ... Read more

Incident date: Jun 8, 2009

ON 06/08/09, I TOOK MY NISSAN 350Z IN TO FOR AN OIL CHANGE AND BECAUSE THE AIR BAG LIGHT WAS FLASHING. I RECEIVED A CALL LATER THAT DAY INDICATING THAT THE 'ENTIRE SYSTEM WOULD NEED TO BE REPLACED'. THE COSTS QUOTED FOR THIS SERVICE WERE: - DIAGNOSIS (ALREADY PAID) $120.00 - REPLACEMEN... Read more

Incident date: May 6, 2010

MY 350Z HAS A PROBLEM WITH THE GAS GAUGE WHEN ITS BELOW THE 1/4 AT START IT WILL DISPLAY NO GAS BUT THE DTE WILL DISPLAY 75-90 MILES LEFT. DON'T UNDERSTAND THIS PROBLEM HAS SEEN A LOT OF FORMS BUT NO RECALL YET OR DEALERS DON'T KNOW WHAT TO DO. HAVE RAN OUT OF GAS A LOT OF TIMES. THANK GOD NEVER ON ... Read more

Incident date: Jan 1, 2008

I HAVE A 2004 NISSAN 350Z TOURING EDITION, I BEEN HAVING A PROBLEM WITH THE GAS GAUGE FROM WHAT I HAVE NOTICED IS WHEN THE GAUGE IS BELOW THE HALF IT STARTS FLUCTUATING FROM E TO ABOUT A 1/4 OR EVEN TO 1/2 TANK. WHEN I TURN THE CAR ON AND OFF IT STARTS OFF AT EMPTY AND WILL SLOWLY MAKE IT WAY UP TO ... Read more

Incident date: Mar 29, 2010

TWO CAR ACCIDENT ON 5/29/10 AT 5:12 P.M. ON INTERSTATE I-40 WESTBOUND AT SARA ROAD, CANDIAN COUNTY, OKLAHOMA. DURING HIGHLY CONGESTED TRAFFIC, I REAR-ENDED A 2007 BUICK ENCLAVE WITH MY 2004 NISSAN 350 Z AT APPROXIMATELY 45 MPH. THE PASSENGER AIRBAG DEPLOYED, BUT THE DRIVERS AIRBAG DID NOT DEPLOY.

Crash

Incident date: Jun 15, 2007

THERE IS SOMETHING IN THE CLUTCH SYSTEM THAT IS CAUSING THE CLUTCH AND OTHER PARTS TO BURN FAST AND EARLIER THAN USUAL. THE PREVIOUS OWNER OF MY 2004 NISSAN 350Z HAD THE SAME PROBLEM. 2 NEW CLUTCHES AT $2,500 EACH BY THE TIME IT HIT 35,000 MILES. I BOUGHT THE CAR NOT KNOWING ABOUT THE PROBLEM AND T... Read more

Incident date: Mar 1, 2009

CONVERTIBLE TOP DOESN'T CLOSE, OR OPEN WHILE IN PROGRESS. *TR

Incident date: Feb 5, 2010

I WAS TOLD, BY THE DEALER, THAT THE AIRBAGS ON MY 2004 NISSAN 350Z WILL NO LONGER WORK UNLESS I REPLACE THE LEFT AND RIGHT MODULES AND SENSOR AT AN APPROX COST OF $1700. NISSAN IS NO LONGER WILLING TO WARRANTY THE ARIBAGS, SINCE THE CAR HAS 116,000 MILES (PER 2/5/10 CALL FROM CONSUMER AFFAIRS DIVIS... Read more

Showing 50 of 177 complaints.

EPA Fuel Economy, 2004 NISSAN 350Z

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
3.5L 6-cyl, Manual 6-spd (Rear-Wheel Drive)	18.0	24.0	20.0	Premium	$3,800
3.5L 6-cyl, Automatic (S5) (Rear-Wheel Drive)	17.0	24.0	19.0	Premium	$4,000

CO2 Emissions: -1.0 g/mile (Two Seaters)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2004 NISSAN 350Z

107 manufacturer communications from 75 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	9
162900 STRUCTURE:BODY:ROOF AND PILLARS	7
350000 EQUIPMENT	7
070000 FUEL SYSTEM, GASOLINE	5
020000 SUSPENSION	5
200000 WHEELS	5
160000 STRUCTURE	4
061000 ENGINE AND ENGINE COOLING:ENGINE	4

010000 STEERING

DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

110000 ELECTRICAL SYSTEM

SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal

110000 ELECTRICAL SYSTEM

12 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations ar

110000 ELECTRICAL SYSTEM

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

110000 ELECTRICAL SYSTEM

INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.

130000 VISIBILITY

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

160000 STRUCTURE

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

130000 VISIBILITY

REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

160000 STRUCTURE

REMOVING FOREIGN MATERIAL FROM THE WINDOW GLASS This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

010000 STEERING

DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

200000 WHEELS

WHEEL BEARING COLLISION DAMAGE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

020000 SUSPENSION

STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

020000 SUSPENSION

STRUT AND SHOCK ABSORBER REPLACEMENT GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

110000 ELECTRICAL SYSTEM

CONFIGURATION FOR BLANK REPLACEMENT BCM This bulletin is no longer applicable. Discard previous versions of NTB15-041.

070000 FUEL SYSTEM, GASOLINE

NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. The update below was sent out to Regions and Dealers in August of this year. We are re-circulating this update to make reg

350000 EQUIPMENT

OBD II EVAP Tube Warranty Enhancement The update below was sent out to Regions and Dealers in August of this year. We are re-circulating this update to make regional and dealer personnel aware that we are re-notifying customers at this

060000 ENGINE (PWS)

070000 FUEL SYSTEM, GASOLINE

NISSAN; FUEL TANK IS EXTREMELY DIFFICULT TO FILL This bulletin applies to Titan XD vehicles with a gas engine. This bulletin has been amended. Changes have been made throughout. It is necessary for you to read this revised procedure t

070000 FUEL SYSTEM, GASOLINE

042300 SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

NISSAN; DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING This bulletin has been amended. The APPLIED VEHICLES and CLAIMS INFORMATION sections have been revised. No other changes have been made. Please discard previous versions

070000 FUEL SYSTEM, GASOLINE

NISSAN; FUEL TANK IS SLOW OR DIFFICULT TO FILL IF YOU CONFIRM The fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). IMPORTANT: Make sure this incident has been duplicated at a gas station by dealer

071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

021000 SUSPENSION:FRONT

BALL JOINT AXIAL END PLAY PROCEDURE SERVICE INFORMATION When working on the front suspension, use the updated service information in this bulletin along with the Electronic Service Manual (ESM). The updated information in this bulletin

350000 EQUIPMENT

100000 POWER TRAIN

SERVICE INFORMATION Replacement 5-speed rear wheel drive Automatic Transmission (A/T) assemblies and replacement control valves (valve bodies) now come with blank Transmission Control Modules (TCMs). Blank TCMs come without software and

350000 EQUIPMENT

356000 EQUIPMENT ADAPTIVE/MOBILITY

357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER

IF YOU CONFIRM A refrigerant leak at a refrigerant pipe/hose joint location. ACTIONS 1. Inspect the metal surfaces of the pipe/hose joint for damage or contamination. NOTE: Do not replace a refrigerant pipe, hose, or other A/C compon

356000 EQUIPMENT ADAPTIVE/MOBILITY

355100 EQUIPMENT:OTHER:LABELS

SERVICE INFORMATION Because of collision damage or other vehicle repair, a replacement "Certification Label" or "VIN Plate / Label" may be needed. These items may be available from Nissan by request if certain criteria are met. Th

260000 FORWARD COLLISION AVOIDANCE

130000 VISIBILITY

SERVICE INFORMATION Windshield "foreign material" that is on the surface of the glass in some cases can be cleaned off with a very particular type and grade of steel wool. * Most any foreign material on the surface of the Windshield c

200000 WHEELS

SERVICE INFORMATION This bulletin has compiled Tire Pressure Monitor System (TPMS) and Low Tire Pressure Warning System (LTPWS) information for: - Basic diagnosing of TPMS/LTPWS systems - Radio frequency interference causing a "No Da

030000 BRAKES (PWS)

270000 LANE DEPARTURE

280000 BACK OVER PREVENTION

110000 ELECTRICAL SYSTEM

SERVICE INFORMATION The Body Control Module (BCM) for the Applied Vehicles in this bulletin is now shipped as a blank unit. As with previous BCM replacements, when a blank unit is installed, the configuration process must be performed. Se

160000 STRUCTURE

140000 AIR BAGS

SERVICE INFORMATION Changes or modifications to the front seat assembly trim materials may affect the proper operation of the Front Seat-Mounted Side-Impact Supplemental Air Bags and Passenger Occupant Classification Sensor and could resul

350000 EQUIPMENT

280000 BACK OVER PREVENTION

141100 AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE

NISSAN: SRS PRECAUTIONS DURING SERVICE;IMPROPER MAINTENANCE, INCLUDING INCORRECT REMOVAL AND INSTALLATION OF THE SRS, CAN LEAD TO A SERIOUS INJURY OR DEATH CAUSED BY UNINTENTIONAL ACTIVATION OF THE SRS ON ALL NISSAN MODELS WITH THE SRS SYS

140000 AIR BAGS

SERVICE INFORMATION Information necessary to service the Supplemental Restraint System (SRS) safely is included in the "RESTRAINTS" section of the Electronic Service Manual (ESM) for each vehicle. IMPORTANT: Turn the ignition switch OFF

350000 EQUIPMENT

120000 EXTERIOR LIGHTING

NISSAN: EXTERIOR LAMP FOGGING. OCCASIONALLY WATER IS NOTICED IN THE EXTERIOR LAMPS. THIS IS GENERALLY NOT DUE TO A DEFECT. ALL CURRENT EXTERIOR LAMP ASSEMBLIES ARE VENTED TO THE ATMOSPHERE (NOT SEALED). THIS IS NECESSARY TO ALLOW FOR E

121000 EXTERIOR LIGHTING:HEADLIGHTS

121100 EXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES

122000 EXTERIOR LIGHTING:FOG LIGHTS

123000 EXTERIOR LIGHTING:TAIL LIGHTS

200000 WHEELS

Nissan Original Equipment or Genuine Accessory Alloy wheels, along with their finish coating (clear, chrome, titanium, etc.), are specifically developed to achieve Nissan design and performance standards. These Original Equipment or Genuin

350000 EQUIPMENT

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Two methods are used to update/upgrade Navigation Map Data: 1. The customer goes to www.nissannavigation.com and is mailed update disc(s) or SD Card and installs data, OR 2. The dealership is mailed update disc(s) and the customer mu

010000 STEERING

SERVICE INFORMATION - This bulletin is to assist you in responding to customer questions about brake operation, and provides diagnostic and repair information for each item listed, if any should occur. - Most brake incidents fall into

020000 SUSPENSION

200000 WHEELS

030000 BRAKES (PWS)

010000 STEERING

If YOU CONFIRM: A vehicle needs to have the brake rotors resurfaced (front or rear). ACTION: Use the ProCut PFM Series on-car brake lathe to perform brake rotor resurfacing and follow the tips listed in this bulletin. - The ProCut P

200000 WHEELS

030000 BRAKES (PWS)

110000 ELECTRICAL SYSTEM

As part of an enhanced emissions test for Inspection & Maintenance (I/M), some States may require the System Readiness Test (SRT) status be checked. - The SRT is used to indicate whether the engine control module (ECM) has completed sel

170000 LATCHES/LOCKS/LINKAGES

NISSAN: LOCK/UNLOCK REQUEST BUTTON ON OUTSIDE HANDLE DOES NOT RESPOND. *JS

020000 SUSPENSION

SERVICE INFORMATION This bulletin provides information to identify: - A leaking strut or a shock absorber that qualifies for replacement under warranty. - A strut or shock absorber that has slight oil seepage, a condition wh

103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

NISSAN: ECM REPLACEMENT PROCEDURES WITH CONSULT III PLUS. APPLIES TO ALL 2004 AND LATER (DOES NOT APPLY TO LEAF/EV) VEHICLES. *JS

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

NISSAN: NAVIGATION MAP DATA UPDATE MATRIX. AFFECTING ALL VEHICLES 2003-11 EXCEPT LEAF, EQUIPPED WITH NAVIGATION SYSTEM. CUSTOMER IS MAILED UPDATE DISC(S) OR SD CARD AND INSTALLS DATA; DEALERSHIP IS MAILED UPDATE DISC(S) AND THE DEALERSHI

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

NISSAN: TIRE PRESSURE MONITORING SYSTEM (TPMS) WARNING LIGHT ON/FLASHING. NO MODELS OR MODEL YEARS LISTED. *PE UPDATED ON 08-11-2011. *KB

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

NISSAN: VENT CONTROL VALVE REPLACEMENT. WHEN REPLACING THE EVAP CANISTER VENT CONTROL VALVE FOR REASON: USE THE ONE LISTED ON PAGE 2; FOR VENT CONTROL VALVE REPLACEMENT PROCEDURE, REFER TO THE APPROPRIATE SECTION OF THE ELECTRONIC SERVICE

114000 ELECTRICAL SYSTEM:WIRING

TRAILER LIGHT WIRING. *MR UPDATED *EH UPDATED 09-12-07. *KB UPDATED 6/21/10. *PE

110000 ELECTRICAL SYSTEM

NISSAN: THE 12 VOLT BATTERY IS AN IMPORTANT PART OF THE VEHICLE ELECTRICAL SYSTEM AND IS REQUIRED TO STAY CONNECTED WHEN THE ENGINE IS RUNNING. TO PREVENT DAMAGE TO VEHICLE ELECTRONIC COMPONENTS FOLLOW THE INSTRUCTIONS/CAUTIONS. NO MOD

111000 ELECTRICAL SYSTEM:12V/24V/48V BATTERY

111100 ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

NISSAN: HARD TO FILL FUEL TANK. THE FUEL TANK IS DIFFICULT TO FILL MORE THAN 1/2. NOTE: FILLING NOZZLE CONTINUES TO CLICK OFF WHEN THE FUEL TANK IS MORE THAN 1/2 FULL. *PE

091100 FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY

NISSAN: HARD TO FILL FUEL TANK. THE FUEL TANK IS DIFFICULT TO FILL MORE THAN 1/2. NOTE: FILLING NOZZLE CONTINUES TO CLICK OFF WHEN THE FUEL TANK IS MORE THAN 1/2 FULL. *PE

103000 POWER TRAIN:AUTOMATIC TRANSMISSION

NISSAN; SPECIAL AUTOMATIC TRANSMISSION FLUID REQUIREMENT. 2004 TO CURRENT NISSAN VEHICLES. *NJ

061000 ENGINE AND ENGINE COOLING:ENGINE

AIRFLOWMETER SERVICE. *PE

061000 ENGINE AND ENGINE COOLING:ENGINE

MIL ON WITH DTC U1000 OR U1010 STORED IN ENGINE CONTROL UNIT. *TT

061000 ENGINE AND ENGINE COOLING:ENGINE

MALFUNCTION INDICATOR LAMP ON WITH DIAGNOSTIC TROUBLE CODE U1000 OR U1010 STORED IN ENGINE CONTROL UNIT. *AK

061000 ENGINE AND ENGINE COOLING:ENGINE

ENGINE WILL NOT CRANK WITH OUTSIDE TEMPERATURE BELOW 10 F. *JB *SC

106000 POWER TRAIN:AXLE ASSEMBLY

CLICKING NOISE FROM REAR AXLES. *MR *SC

036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP

ANTILOCK BRAKING SYSTEM (ABS) LIGHT ON AND / OR DIAGNOSTIC TROUBLE CODE FOR ABS WHEEL SPEED SENSOR. *TT

020000 SUSPENSION

EXCESSIVE FRONT TIRE ROAR OR GROWL NOISE WHEN BRAKING MODERATELY; AT SPEEDS BELOW 30 MPH AND ON SMOOTH ROAD SURFACES. *TT

071100 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

FUEL TANK DIFFICULT TO FILL AT TIMES. *TT UPDATE *SC

135000 VISIBILITY:REARVIEW MIRRORS/DEVICES

RATTLE NOISE FROM REAR VIEW MIRROR HARNESS COVER. *TT

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

NAVIGATION SYSTEM IS INOPERATIVE AND THE DISPLAY SHOWS DISC ERROR OR DVD-ROM VERSION IS NOT CORRECT. *TT

133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

WINDOW REGULATOR MOTOR RESET PROCEDURE. *TT

063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

ESSENTIAL TOOL - J-44626 AIR FUEL SENSOR SOCKET. ALSO INCLUDING 2005 ALL NISSAN VEHICLES. *TT

110000 ELECTRICAL SYSTEM

MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P1031, 1051, P1148, P1168 A/F SENSOR HEATER / CLOSED LOOP. *MJ

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

LOW TIRE PRESSURE MONITOR SYSTEM. *JB THIS BULLETIN REPLACES 02-070A DATED FEB 05, 2003. *TT

199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

LOW TIRE PRESSURE MONITOR SYSTEM. *MJ

160000 STRUCTURE

SOFT TOP SQUEAKS RATTLES AND WIND NOISE.*MR

070000 FUEL SYSTEM, GASOLINE

FUEL FILLER LID DOES NOT OPEN ON FIRST PUSH OF RELEASE BUTTON.*MR