1996 NEW FLYER C40LF
3 recalls — 0 complaints — 14 TSBs
07V268000 Jun 11, 2007
STEERING
Defect Description
ON CERTAIN TRANSIT BUSES, THE U-JOINT ASSEMBLIES HAVE INADEQUATE SPLINE ENGAGEMENT ON ONE OF THE TWO END YOKES.
Consequence
EXCESSIVE PLAY IN THE STEERING SYSTEM COULD DEVELOP AND, IF NOT CORRECTED, CAUSE A LOSS OF STEERING CONTROL WHICH COULD RESULT IN A CRASH.
Remedy
THE U-JOINT ASSEMBLY WILL BE INSPECTED AND REPLACED IF NECESSARY. THE RECALL BEGAN ON JUNE 10, 2007. OWNERS MAY CONTACT NEW FLYER AT 1-204-934-4874.
07V068000 Feb 23, 2007
EXTERIOR LIGHTING
Defect Description
CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES.
Consequence
THE STANDARD REQUIRES THAT THE DECELERATION LAMP IS A SOLID LIGHT RATHER THAN A FLASHING LIGHT.
Remedy
DEALERS WILL REWIRE THE ELECTRICAL SYSTEM TO REMOVE THE FLASHING FUNCTION OR INSTALL A NEW PROGRAMMABLE LOGIC CONTROLLER (PLC) WHICH WILL MAKE THE LAMPS BURN STEADY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 5, 2007. OWNERS MAY CONTACT NEW FLYER AT 204-934-4874.
02V112000 May 22, 2002
STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
Defect Description
ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED.
Consequence
THE HOSE CAN LEAK, CREATING THE RISK OF AN ENGINE FIRE.
Remedy
DEALERS WILL REPLACE THE HOSE. OWNER NOTIFICATION BEGAN JULY 1, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NEW FLYER AT 1-204-228-8984.
No complaints found for this vehicle.
Technical Service Bulletins — 1996 NEW FLYER C40LF
14 manufacturer communications from 12 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 980000 UNKNOWN OR OTHER | 4 |
| 350000 EQUIPMENT | 2 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 2 |
| 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS | 1 |
| 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM | 1 |
| 042600 SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS | 1 |
| 036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP | 1 |
| 060000 ENGINE AND ENGINE COOLING | 1 |
SMB191
May 6, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
SMB191
May 6, 2020
060000 ENGINE (PWS)
Service Manual Bulletin - Changes to Cummins ISLG and L9N engine oil specifications and oil change intervals.
TSIB 20-01
Apr 3, 2020
060000 ENGINE AND ENGINE COOLING
Technical Service Information Bulletin describing changes to the Cummins ISLG, L9N, ISB6.7G and B6.7N engine oil specifications.
PMB049
Jan 5, 2018
350000 EQUIPMENT
This Parts Manual Bulletin provides new part number information for the moveable arm kit for the Kongsberg brake and accelerator assembly on specifically equipped vehicles.
SMB178
Jan 5, 2018
350000 EQUIPMENT
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
SMB178
Jan 5, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Service Manual Bulletin provides new OEM (Kongsberg) PM inspection requirements and new installation procedure for the adjustable floor pedal moveable arm on specifically equipped vehicles.
1525A
Jan 1, 2002
036000 SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
SUBJECT REGARDING INSTALLATION OF AN OUTPUT WIRE TO CONTROL THE START UP AND SHUT DOWN OF THE ANTI-SKID SYSTEM (ABS) ELECTRONIC CONTROL UNIT (ECU) USED ON D40LF AND C40LF MODELS. *TT
1571A
Jul 11, 2001
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
SUBJECT REGARDING ADDITIONAL NEWFLYER SERVICE MANUAL MAINTENANCE INSTRUCTIONS FOR SERVICING THE HYDRAULIC FAN DRIVE PUMP (PERMCO) AND POWER STEERING PUMP (VICKERS) ON A D30LF, D35LF, D40LF, C30LF, C35LF, C40LF COACHES WITH A CUMMINS 8.3 ENG
1593A
Jul 11, 2001
042600 SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS
SOME C40LF COACHES USING THE MERITOR LF AXLE SET UP, MAY HAVE A BRAKE LINE CONNECTED INCORRECTLY TO THE E10 BRAKE VAVLE, WHICH IS CAUSING THE BREAK LININGS TO WEAR OUT PRE-MATURELY.
ITS760
Oct 31, 1996
980000 UNKNOWN OR OTHER
CHIME CORD CRIMP REPLACEMENT. *TW
ITS758
Oct 29, 1996
980000 UNKNOWN OR OTHER
CHIME CORD CRIMP REPLACEMENT. *TW
ITS748
Oct 22, 1996
980000 UNKNOWN OR OTHER
RR WHEELCHAIR RAMP MECHANISM. *TW
ITS747
Oct 22, 1996
980000 UNKNOWN OR OTHER
RR WHEELCHAIR RAMP MECHANISM. *TW
ITS684
May 31, 1996
062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS
COOLANT HOSES ON TESCOM REGULATOR LEAKING. *TW
NHTSA Safety Investigations — NEW FLYER C40LF
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EA09010
Opened: Jun 18, 2009 — Closed: Nov 19, 2010
Air Brake System
INVESTIGATION HAS NOT IDENTIFIED A DEFECT.THERE HAVE BEEN NO REPORTED COMPLAINTS RELATING TO THIS ISSUE SINCE 2006. SEE CLOSING REPORT FOR FURTHER DETAILS.
PE09012
Opened: Feb 27, 2009 — Closed: Jun 18, 2009
AIR BRAKE SYSTEM
ODI IS CLOSING THIS PRELIMINARY EVALUATION AND OPENING AN ENGINEERING ANALYSIS (EA09-010) TO FURTHER IDENTIFY AND EVALUATE THE VEHICLE ENVIRONMENT AND BRAKE SYSTEM FACTORS THAT MAY BE CAUSING OR CONTRIBUTING TO EXTENDED STOPPING DISTANCE PERFORMANCE IN CERTAIN VEHICLES.
PE02006
Opened: Jan 28, 2002 — Closed: May 8, 2002
POWER STEERING HOSE
NEW FLYER C40LF — All Years Overview
Complete safety history for the NEW FLYER C40LF across all model years (1996–2013).
78
Total Recalls
1
Total Complaints
3
Investigations
1
Reported Crashes
0
Reported Fires
0
Reported Deaths
NEW FLYER C40LF — Year by Year
Compare recalls and complaints across model years. Click any year to see full details.