STRUCTURE:FRAME AND MEMBERS
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
2,697,000 vehicles affected
VEHICLE SPEED CONTROL
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
212,700 vehicles affected
SUSPENSION:FRONT:SHOCK ABSORBER
THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY.
Remedy: MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.
98,000 vehicles affected
WHEELS
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.
Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
654,000 vehicles affected
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.
Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
325,000 vehicles affected
I HIT A SMALL POTHOLE AND THE STEERING WHEEL SUDDENLY MOVED TO A ONE O'CLOCK POSITION WHILE THE WHEELS WERE POINTING STRAIGHT AHEAD. MY ALIGNMENT SHOP INSPECTED THE CAR AND FOUND THAT THE CAUSE WAS A FAILURE OF THE PASSENGER SIDE SUB-FRAME MOUNTING BOLT ANCHOR. THE LOCAL DEALER SAID MY CAR IS NOT INCLUDED IN THE RECALL (98S36) I DEMAND AN ANSWER AS WHY MY CAR IS NOT INCLUDED. *TR
DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS, THERE WAS A NOTICEABLE DELAY TO DISENGAGED THE SPEED CONTROL. THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES UNTIL THE DRIVER REGAINED CONTROL OVER THE VEHICLE'S SPEED. THE CONTACT RECEIVED A RECALL LETTER # 97V025000 BUT MISPLACED IT. THE MANUFACTURER WAS CONTACTED WHO REFUSED TO PRODUCE A NEW LETTER BECAUSE THE RECALL WAS TOO OLD. THE CONTACT EXPRESSED CONCERN BECAUSE THE SPEED CONTROL MALFUNCTIONING ENTAILED A SERIOUS SAFETY RISK.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
OTHER THAN THE REST OF MY PROBLEMS WITH THE ABOVE MY NEWEST COMPLAINT IS THAT I JUST FOUND OUT THAT DUE TO THE FACT FORD INSTALLED AN ALUMINIM PISTON WHERE THERE SHOULD HAVE BEEN A STEEL ONE WHICH IS THE ONLY ONE AVAILABLE NOW SINCE YOU DISCOVERED YOUR PROBLEMS. MY CAR IS IN THE SHOP RIGHT NOW AND I'M BEING TOLD IT WILL COST BETWEEN $1200.00 - $1500.00 TO FIX DUE TO FORD'S POOR DESIGN. THIS IS NOT MY FIRST SABLE WAGON. THE FIRST ONE HAD ALL KINDS OF A/C PROBLEMS AND I'M GETTING TIRED OF PAYING FOR YOUR MISTAKES. MY A/C IS OUT NOW, I REPLACE BRAKE PADS ALL THE TIME.
WHILE DRIVING AT NIGHT THE VEHICLE'S HEADLIGHTS FAILED WITHOUT WARNING. THE DEALER STATES THE HEAD LAMP SENSOR SWITCH BURNED. A RECALL WAS ISSUED, HOWEVER THE VIN NUMBER IS OUTSIDE OF THE REMEDY SCOPE. *MR
NORTHPORT FORD IN COMMACK, NY FAILED TO PROPERLY PERFORM SAFETY RECALL 98S36 FOR THE SUBFRAME ON MY 1991 MERCURY SABLE. THE SUBFRAME SUBSEQUENTLY BROKE FREE CAUSING DAMAGE TO MY MOTOR MOUNTS, TRANSMISSION AND STEERING COMPONENTS. THE VEHICLE WAS TOWED TO THE CLOSEST FORD DEALER IN PATCHOGUE NY. FORD AGREED TO REINSTATE THE RECALL FOR THE DEALER TO REPAIR MY VEHICLE. THE DEALER CALLED FORD WITH THE PRICE OF THE SUBSEQUENT DAMAGE AND FORD WITHDREW THE OFFER TO REPAIR. THEY WANTED TO BUY THE VEHICLE BACK AT A PRICE THEY DECIDED ON. I AM ON DISABILITY WITH A WORK RELATED ACCIDENT. I CAN NOT AFFORD TO BE WITHOUT MY VEHICLE. I CAN NOT AFFORD TO BUY ANOTHER VEHICLE AT THE BUYOUT PRICE FORD WANTS TO GIVE ME. I FEEL THAT THIS ACCURED DUE TO A SAFETY RECALL THAT WAS NOT PERFORMED PROPERLY AND FORD SHOULD DEAL WITH THAT DEALERSHIP AND FIX MY VEHICLE AT NO CHARGE.*AK
CONSUMER STATES THAT THE VEHICLE BUSHINGS ARE MADE OF A VIBER MATERIAL THAT WEARS OUT, CAUSING THE VEHICLE TO STEER IMPROPERLY. *AK
CONSUMER STATES THAT THE VEHICLE BUSHINGS ARE MADE OF A VIBER MATERIAL THAT WEARS OUT, CAUSING THE VEHICLE TO STEER IMPROPERLY. *AK
THE STEERING WHEEL LOCKED UP WHEN THE CONSUMER MADE LEFT TURNS. *NLM
THE LEFT REAR SUB-FRAME MOUNT BROKE. THE RIGHT REAR SUB-FRAME MOUNT LOOKED LIKE IT WAS ABOUT TO BREAK. *NLM
THE CONSUMER VEHICLE EXPERIENCED SYMPTOMS OF NHTSA RECALL # 98-V-323-000 WHICH WAS RELATED TO THE REAR LOWER SUBFRAME MOUNT PLATE NUT. THE CONSUMER VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *NLM
PLNHTS#6954-94-E-036-000: SWAY BAR BRACKET WHERE IT ATTACHES TO THE STRUT RESERVE TUBE DID NOT FUSE PROPERTY. CONSUMER STATES HAS THE SAME PROBLEM (MAKING SOME NOISE). DEALER HAS BEEN NOTIFED. PLEASE PROVIDE FURTHER INFORMATION. TS
AUTO WAS PARKED. APPROXIMATELY ONE HALF LATER, ACCORDING TO THE FIRE DEPARTMENT REPORT, A FIRE WAS REPORTED COMING FROM UNDER THE HOOD OF THE VEHICLE. FIRE GUTTED OUT THE ENTIRE MOTOR AND THE CAR WAS TOTALED. NO INJURIES. THERE WAS NO PREVIOUS INDICATION OF ANY ELECTRICAL PROBLEM. MR
Fire
VEHICLE WOULD OVERHEAT WHILE DRIVING, VEHICLE TAKEN TO A REPAIR SHOP, AND INFORMED OF A BLOWN HEAD GASKET. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
CONSUMER STATED THAT THE WINDSHIELD WIPER WAS NOISY.*JB
CONSUMER STATED THE BRAKES WERE NEVER SATISFACTORY FROM THE DATE OF PURCHASE, CONSUMER COMPLAINED TO THE DEALER BUT WAS ALWAYS TOLD THAT THE BRAKES WERE OK, THE BRAKES WERE PULSATING AND THERE WAS EXCESSIVE DUST ON THE WHEELS, CONSUMER STATED THE DEFECT WAS THE FRONT ROTORS, WHICH WERE EVENTUALLY REPLACED, HOWEVER CONSUMER STATED THE DEALER DID NOT HONOR THE RECALL BEFORE OR AFTER THE VEHICLE WAS PURCHASED, THE DEALER ALSO CLEANED AND ADJUSTED THE REAR BRAKES.*JB
CONSUMER STATED THE BRAKES WERE NEVER SATISFACTORY FROM THE DATE OF PURCHASE, CONSUMER COMPLAINED TO THE DEALER BUT WAS ALWAYS TOLD THAT THE BRAKES WERE OK, THE BRAKES WERE PULSATING AND THERE WAS EXCESSIVE DUST ON THE WHEELS, CONSUMER STATED THE DEFECT WAS THE FRONT ROTORS, WHICH WERE EVENTUALLY REPLACED, HOWEVER CONSUMER STATED THE DEALER DID NOT HONOR THE RECALL BEFORE OR AFTER THE VEHICLE WAS PURCHASED, THE DEALER ALSO CLEANED AND ADJUSTED THE REAR BRAKES.*JB
CONSUMER STATED THAT THE WINDSHIELD WIPER WAS NOISY.*JB
CONSUMER STATED THE BRAKES WERE NEVER SATISFACTORY FROM THE DATE OF PURCHASE, CONSUMER COMPLAINED TO THE DEALER BUT WAS ALWAYS TOLD THAT THE BRAKES WERE OK, THE BRAKES WERE PULSATING AND THERE WAS EXCESSIVE DUST ON THE WHEELS, CONSUMER STATED THE DEFECT WAS THE FRONT ROTORS, WHICH WERE EVENTUALLY REPLACED, HOWEVER CONSUMER STATED THE DEALER DID NOT HONOR THE RECALL BEFORE OR AFTER THE VEHICLE WAS PURCHASED, THE DEALER ALSO CLEANED AND ADJUSTED THE REAR BRAKES.*JB
CONSUMER STATED THE BRAKES WERE NEVER SATISFACTORY FROM THE DATE OF PURCHASE, CONSUMER COMPLAINED TO THE DEALER BUT WAS ALWAYS TOLD THAT THE BRAKES WERE OK, THE BRAKES WERE PULSATING AND THERE WAS EXCESSIVE DUST ON THE WHEELS, CONSUMER STATED THE DEFECT WAS THE FRONT ROTORS, WHICH WERE EVENTUALLY REPLACED, HOWEVER CONSUMER STATED THE DEALER DID NOT HONOR THE RECALL BEFORE OR AFTER THE VEHICLE WAS PURCHASED, THE DEALER ALSO CLEANED AND ADJUSTED THE REAR BRAKES.*JB
REPAIR IMMEDIATELY AFTER PURCHASE WAS POWER STEERING LINE - REPORTED TO SELLER IMMEDIATELY THE NEXT WEEK AFTER PURCHASE. *AK
LEFT/REAR COOPER TIRE, SIZE: P205/65R15, DOT: U9UREK7139 EXPERIENCED TREAD SEPARATION WHILE TRAVELING AT AN UNKNOWN SPEED. THERE WERE APPROXIMATELY 10,000 MILES ON THE TIRE, AND IT WAS NOT ORIGINAL EQUIPMENT ON 1991, MERCURY, SABLE. *AK
WHILE STARTING VEHICLE, THE ENGINE DID NOT TURN OVER. VEHICLE WAS SERVICED AND TECHNICIAN STATED HEAD GASKET HAD BLOWN. *AK *SLC
ENGINE MOTOR MOUNTS HAVE BROKEN AND NEEDED TO BE REPLACED. PROBLEM HAS NOT BEEN EXAMINED BY DEALERSHIP. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
THE AUTOMATIC TRANSMISSION FAILED WITHOUT WARNING WHILE STOPPED AT A TRAFFIC LIGHT. NLM
I HAVE LOCATED WHAT APPEARS TO BE A REPETITIVE SEVERE PROBLEMWHERE THE WIRE HARNESS IS RUBBING AGAINST A SHARP BENT METAL EDGE NEXT TO THE FUSE BOX AND AFTER TRYING TO LOCATE PARTS TO REPAIR I OBSERVED SEVERAL BURNED OUT TAURUS AND SABLE VEHICLES WHERE IT APPEARED TO HAVE STARTED AT OR UNDER THE DASH. ALSO A SIMILAR YEAR MK 7 BURNED THE SAME WAY. QUITE UNNERVING. ALSO HAVE A SECOND TAURUS WAGON I'VE HAD FOR SEVERAL YEARS AND EXAMINED IT WIRING AND SAME PROBLEM CHAFFED WIRE HARNESS APPROXIMATELY 3" FROM FUSE BOX. ALSO MY WIRES INTO BOX LOOSE ENOUGH TO COMPLETELY SHUT DOWN VEHICLE ELECTRICAL FUNCTION, FIRST TIME HAPPENED GOING 65 ON FREEWAY. ALSO SHIFT LEVER ON COLUMN POORLY DESIGNED TILL 93 WHEN IT APPEARS TO HAVE BEEN REDESIGNED TO CORRECT PROBLEM I HAD WHERE SHIFTS OUT OF GEAR BECAUSE OF SLOP AND WEAR. PREVIOUS OWNER SPENT FORTUNE REPLACING TRANS AND IT WASN'T PROBLEM LINKAGE COULDN'T BE PROPERLY LOCATED BECAUSE OF SLOP IN SHIFT LEVER DUE TO UNUSUAL WEAR. OTHERWISE MY CARS CANNOT BE TOLD FROM NEAR NE. *AK
Fire
WHEN ACCELERATING FROM A STOP VEHICLE WILL HESITATE , FEELS AS THOUGH VEHICLE IS IN NEUTRAL , LIKE IT IS OUT OF GEAR AND WILL NOT MOVE. CONSUMER MUST RESTART VEHICLE, BUT EVENTUALLY DEFECT WILL REOCCUR. CONSUMER RECEIVED AN EXTENDED WARRANTY IN NOVEMBER 1994 FOR THIS PROBLEM WHICH STATED THAT DEFECT WILL CAUSE ERRATIC TRANSMISSION OPERATION. MANUFACTURER CLAIMED IT HAS PASSED THE WARRANTY BY YEARS AND WILL NOT COVER COSTS. *AK *SLC
AIR BAG LIGHT FLASHES ON AND OFF, INDICTATING A DEFECT. CONSUMER HAS NOT TAKEN VEHICLE TO DEALER. *AK
TRANSMISSION HAS BEEN REPLACED TWICE, AND CURRENT TRANSMISSION WAS SLIPPING OUT OF GEAR AT ANY SPEED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
CONSUMER HAS CONTACTED MANUFACTURER REGARDING TRANSMISSION ,AND WAS TOLD THERE WERE NO RECALLS ON "TRANSMISSIONS" FOR THIS VEHICLE... VEHICLE REGISTERED IN NEBRASKA WHERE THERE WAS RECALL 98V323000 REGARDING SUBFRAME CORROSION WHICH COULD EFFECT TRANSMISSION/ENGINE. CONSUMER WAS GOING TO HAVE TO HAVE TRANSMISSION REPLACED. *AK
THIS IS VERY SERIOUS AND DANGEROUS AFTER ADDING OIL TO THE ENGINE OF THIS VEHICLE YESTERDAY I MADE SURE THE HOOD WAS SECURLY LATCHED ( BECAUSE IT HAS COME OPEN ON ME PREVIOUSLY WHILE IN MOTION ) I PULLED UP ON THE HOOD AND IT WOULD NOT OPEN. I LEFT THE GAS STATION AND GOT ON THE INTERSTATE. WHILE IN THE FAST LANE DOING APPROXAMATLY 70 MPH THE HOOD CAME COMPLETELY OPEN BENT BACK AND SMASHED THE FRONT WINDSHIELD. I WAS TOTALY BLINDED BY IT. I WAS LUKY TO GET THE CAR STOPED WITH OUT GETTING KILLED IN THE PROCESS. I WOULD LIKE THIS CHECKED OUT TO SEE IF IT IS A DEFAULT. I WOULD HATE TO SEE ANYONE DYE OVER THIS TYPE OF THING. *AK
Crash
THE TRANSMISSION FAILED PRIOR TO SERVICE PROGRAM #94M84 IN SEPT OF 1994, IN 2000 THE TRANSMISSION FAILED AGAIN, CONSUMER BELIEVES FORD REPLACED THE INITIAL TRANSMISSION WITH ANOTHER TRANSMISSION CONTAINING THE SAME INHERENT DEFECT. NLM
THERE WAS NO HEAT AND ENGINE OVERHEATED, CAUSING TEMPARATURE TO RISE. CONSUMER HADTO TURN OFF CAR WHEN THIS HAPPENED TO AVOID OVER HEATING. WHITE SMOKE CAME OUT OF TAIL PIPE. *AK
RIGHT GOODYEAR TIRE EXPERIENCED BLOWOUT. *SLC
REAR BRAKES RUSTED THROUGH THE DRUMS. *SLC
BEFORE CONSUMER PURCHASED VEHICLE THEY NOTICED THAT THE AIR BAG LIGHT WAS ON, THE DEALER TOLD THE CONSUMER THEY COULD NOT FIX THE LIGHT DUE TO A FEDERAL LAW AND NEVER SAID THE AIR BAGS DID NOT WORK, THERE WAS AN ACCIDENT WHERE THE AIR BAGS EXPERIENCED NO DEPLOYMENT AND 2 OF THE OCCUPANTS INJURIES WERE SORENESS. *SLC
Crash
2 injured
IT APPEARS THAT THE HEAD GASKETS ARE PREMATURELY FAILING ON THE 3.8 LITRE ENGINES MANUFACTURED BY FORD ON MODELS 1988 TO PRESENT. THEY ARE AWARE OF THE PROBLEM AND HAVE A SERVICE BULLETIN TSB #98-4-9 EXPLAINING THE COMPLAINT BUT HAVE FAILED TO REPAIR THIS KNOW PROBLEM OR MAKE RESOLUTION TO THE COMPLAINTS. *AK
HEAD GASKETS FAILED WITH ONLY 57,000 MILES ON CAR. VEHICLE IS A 1991 MERCURY SABLE WAGON WITH A 3.8 L 6 CYLINDER ENGINE. CAR HAS ALLWAYS BEEN WELL MAINTAINED. I THINK FORDS WARRANTY SHOULD BE FOR ANY 3.8 LITER 6 CYL. VEHICLE PERIOD!!!!!!!. *AK
THE TRANSAXLE FORWARD CLUTCH PISTON DESIGN IS MADE OF ALUMINUM WHICH FAILS (CRACKS), THE REPLACEMENT IS MADE OF STEEL, CONSUMER FEELS A RECALL SHOULD BE ISSUED DUE TO DESIGN FLAW *MJS
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
MY 1991 SABLE TRANSMISSION HAD TO BE REPAIRED DUE TO THE FRONT ENGINE MOUNT BOLT FELL-OUT, OR BREAKAGE. AFTER REPAIRS WAS MADE THE FRONT ENGINE MOUNT BOLT CAME OUT OR BREAK OUT TWO OTHER TIMES AS OF 23 OCTOBER 2000. MY SABLE WAS PURCHASED IN WASHINGTON STATE AND REGISTERED IN ALASKA, HOWEVER IT IS LOCATED IN MARYLAND WHERE I LIVE FOR THE PASSED TWO YEARS. *AK
MY 1991 SABLE TRANSMISSION HAD TO BE REPAIRED DUE TO THE FRONT ENGINE MOUNT BOLT FELL-OUT, OR BREAKAGE. AFTER REPAIRS WAS MADE THE FRONT ENGINE MOUNT BOLT CAME OUT OR BREAK OUT TWO OTHER TIMES AS OF 23 OCTOBER 2000. MY SABLE WAS PURCHASED IN WASHINGTON STATE AND REGISTERED IN ALASKA, HOWEVER IT IS LOCATED IN MARYLAND WHERE I LIVE FOR THE PASSED TWO YEARS. *AK
REPLACED HEAD GASKET AND O2 SENSORS. THIS IS THE SAME FLAWED ENGINE DESIGN AS THOSE THAT FORD ISSUED AN EXTENDED WARRANTY. FOR SOME UNKNOWN REASON FORD HAS NOT INCLUDED THE '91 ENGINES.
REPLACED HEAD GASKET AND O2 SENSORS. THIS IS THE SAME FLAWED ENGINE DESIGN AS THOSE THAT FORD ISSUED AN EXTENDED WARRANTY. FOR SOME UNKNOWN REASON FORD HAS NOT INCLUDED THE '91 ENGINES.
VEHICLE WAS ON THE ENTRANCE RAMP TO A MAJOR HIGHWAY WHEN ENGINE POWER WAS SUDDENLY LOST. CAR WAS RESTARTED AFTER A TEN MINUTE COOL DOWN. DROVE FOR ANOTHER 10 MINUTES WHEN ENGINE POWER WAS LOST FOR A SECOND TIME. CAR WAS UNABLE TO START AFTER THE SECOND FAILURE. ROOT CAUSE OF THE FAILURE WAS A CORRODED GROUND CONNECT, ITENTIFIED AS C112 (FORD #). THIS CONNECTOR PROVIDES THE GROUND (NEGATIVE) FOR MAJOR ENGINE AND INSTRUMENTATION COMPONENTS (INSTRUMENT CLUSTER, INTEGRATED CONTROL MODULE, POWER STEERING MODULE, COOLING FAN, ELECTRONIC ENGINE CONTROL MODULE, OXYGEN SENSORS). THE LOCATION OF THIS GROUND CONNECTOR NEXT TO THE BATTERY, INCREASES ITS SUSCEPTABILITY TO ACCELERATED CORROSION. THE GROUND PLUG IS NOT A WATER TIGHT DESIGN. SEVERE CORROSION OF THE CONNECTOR BLADES WERE FOUND UPON DISASSEMBLY . CONNECTOR SHOULD BE REPLACED WITH A TYPE LESS SUSCEPTABLE TO CORROSION. FAILURES ARE MORE LIKELY WHEN THE CAR IS OPERATING IN HOT DRY WEATHER AND WITH HIGHER ELECTRICAL LOADS.