2011 MAZDA RX-8 Recalls, Complaints & Safety

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

Mazda North American Operations (Mazda) is recalling certain 2009-2011 RX-8 and 2006-2007 MazdaSpeed6 vehicles. Fuel may leak from the fuel pump mounting rings.

Consequence

A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy

Dealers will install new fuel pump mounting rings. Dealers will also add a thermal insulation pad to the fuel tank on RX-8 vehicles. Repairs will be performed free of charge. Owner notification letters were mailed November 17, 2021. Owners may contact Mazda customer service at 1-800-222-5500, Op... Read more

13,891 vehicles affected

Manufacturer: Mazda North American Operations

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Defect Description

Mazda North American Operations (Mazda) is recalling certain 2010-2011 Mazda RX-8 vehicles that were previously recalled under recall 18V-716 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used ... Read more

Consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy

Owners are advised not to drive their vehicles until the repair has been performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began July 9, 2019. Owners may contact Mazda customer service at 1-800-222-... Read more

211 vehicles affected

Manufacturer: Mazda North American Operations

AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE

Defect Description

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Ind... Read more

Consequence

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy

Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. ... Read more

308,591 vehicles affected

Manufacturer: Mazda North American Operations

Complaint Statistics

5 total complaints 1 crashes 2 fires

Top Reported Components

Component	Complaints
SUSPENSION	1
VISIBILITY/WIPER	1
UNKNOWN OR OTHER	1
FUEL SYSTEM, GASOLINE	1
FUEL/PROPULSION SYSTEM	1

Incident date: Feb 28, 2023

The contact owns a 2011 Mazda Rx 8. The contact stated after performing NHTSA Campaign Number: 21V744000 (Fuel System, Gasoline) while driving at 35 MPH, the contact smelled the odor of smoke in the vehicle, but no warning light illuminated. The vehicle was towed to the dealer. While the vehicle was... Read more

Fire

Incident date: Feb 7, 2023

The incident occurred on 02/08/2023. Prior to this, I brought my car to the dealership due to a recall to fix gas mounting rings, recall number . I do not feel comfortable with their repairs and I do not believe that the dealership performed the repairs properly which caused my car to smoke and stal... Read more

Fire

Incident date: Jul 10, 2018

THE RING/ASSEMBLY HOLDING THE DRIVER SIDE VISOR CRACKED WITH NORMAL USE (PUTTING THE VISOR DOWN (NO EXCESS FORCE WAS USED) AND THE VISOR FELL INTO THE DRIVER'S LINE OF VISION, OBSCURING VISION. IT WAS NOT POSSIBLE TO PUT THE VISOR BACK UP AGAIN. THE RING FELL OUT OF THE CAR INTERIOR.

Incident date: Jul 10, 2018

Incident date: May 9, 2013

ON MAY 7, 2013, I BROUGHT THE VEHICLE TO PARETTI MAZDA OF METAIRIE BECAUSE A FLUID WAS LEAKING FROM SOMEWHERE NEAR THE DRIVER'S SIDE REAR TIRE. THE SERVICE TECH TOLD ME THEY WOULD TAKE CARE OF IT AND DIRECTED ME TO ENTERPRISE RENTAL FOR A RENTAL CAR. ABOUT AN HOUR AFTER I OBTAINED THE RENTAL CAR, TH... Read more

Crash

EPA Fuel Economy — 2011 MAZDA RX-8

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.3L 2-cyl, Manual 6-spd (Rear-Wheel Drive)	16.0	22.0	18.0	Premium	$3,850
1.3L 2-cyl, Automatic (S6) (Rear-Wheel Drive)	16.0	23.0	19.0	Premium	$3,650

CO2 Emissions: 493.7 g/mile (Subcompact Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

NHTSA Safety Investigations — MAZDA RX-8

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 2005

CLUTCH PEDAL BRACKET FAILURE

On September 23, 2009, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation to investigate allegations of the clutch pedal bracket failures in MY 2004 - 2006 Mazda RX8 vehicles.In response to an information request letter sent by ODI, Mazda stated that the failure mechanism may ... be related to an improper fastener attachment sequence to the body.The improper sequence may create a distortion of the pedal bracket and create a stress amplitude during pedal usage that may go beyond the wear out limit of the bracket.Mazda stated that the percentages of vehicles experiencing the defect is low at approximately 1% of the vehicle population projected to 10 years in service based on analysis of warranty claim data that best represented the alleged defect.In terms of risk to motor vehicle safety, Mazda stated that the failure is progressive with warning manifested in noise and difficulty in shifting gears prior to complete failure of the bracket.Mazda also stated that when a bracket fracture occurs the clutch pedal may lean towards the brake pedal however gear shifting becomes impossible prior to any contact of the clutch pedal to the brake pedal. ODI is not aware of any crashes associated with a clutch pedal bracket failure in the subject vehicles.ODI's analysis of warranty claim data provided by Mazda yielded failure rates of approximately 3% projected over 10 years in service. ODI's analysis of Vehicle Owner Questionnaire (VOQ) data complaint indicates that approximately 5% of the VOQ complainants allege they were unable to get out of the roadway as a result of a clutch pedal bracket failure.None of these incidents occurred on a highway. Approximately 7% of the complainants alleged a contact condition after a clutch pedal bracket failure of the clutch pedal to the brake pedal. None of these complaints noted difficulty in getting the vehicle stopped.Mazda has informed ODI that it will conducted an Owner Notification of an extended warranty coverage program increasing the clutch pedal assembly warranty to 8 years and limited at 100K miles for model years 2004 through 2009 RX8 vehicles.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor this issue and will take further action if warranted by the circumstances.Read more

Model	Recalls	Complaints
MAZDA6	98	2,911	View
TRIBUTE	65	2,831	View
B-SERIES TRUCK	65	888	View
MAZDA3	64	3,983	View
CX-9	59	1,796	View
626	54	3,892	View
MPV	44	1,157	View
PROTEGE	38	1,380	View

2011 MAZDA RX-8

Complaint Statistics

Top Reported Components

EPA Fuel Economy — 2011 MAZDA RX-8

NHTSA Safety Investigations — MAZDA RX-8

MAZDA RX-8 — All Years Overview

MAZDA RX-8 — Year by Year

Other MAZDA Models

Year	Recalls	Complaints
2011 (current)	3	5
2010	4	5	View
2009	4	9	View
2008	5	23	View
2007	5	51	View
2006	5	74	View
2005	6	212	View
2004	10	624	View