2012 MACK TERRAPRO (MRU)
2 recalls, 0 complaints - 102 TSBs
21V953000 Dec 9, 2021
PARKING BRAKE
Defect Description
Mack Trucks, Inc. (Mack) is recalling certain 2008-2019 TerraPro (MRU) and 2019-2022 TerraPro (TE) vehicles. A brake control valve air leak into the attached exhaust hose can create excessive back pressure, causing the parking brake to release unexpectedly.
Consequence
The unexpected release of the parking brake may allow the vehicle to rollaway, increasing the risk of a crash.
Remedy
Dealers will remove the exhaust tube and fitting from the valve, free of charge. Owner notification letters were mailed February 8, 2022. Owners may contact Mack customer service at 1-800-866-1177. Mack's number for this recall is SC0433.
16V099000 Feb 19, 2016
POWER TRAIN:DRIVELINE:DRIVESHAFT
Defect Description
Mack Trucks, Inc. (Mack) is recalling certain model year 2012-2016 Granite (GU), Pinnacle (CHU, CXU), TerraPro (LEU, MRU), Titan (TD), and LR trucks manufactured from September 1, 2011, through September 8, 2015. The cap nut that retains the interaxle driveshaft yoke to the rear axle input shaft ma... Read more
Consequence
If he cap nut loosens and falls off, the yoke can separate from the axle input shaft and allow the drive shaft to disconnect, increasing the risk of a crash.
Remedy
Mack will notify owners, and dealers will replace the cap nut. The input shaft threads will be inspected for damage. Any damaged input shaft will be replaced. These repairs will be performed free of charge. An interim notice was sent to owners on April 25, 2016. The recall began on June 7, 201... Read more
No complaints found for this vehicle.
Technical Service Bulletins, 2012 MACK TERRAPRO (MRU)
102 manufacturer communications from 74 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 30 |
| 110000 ELECTRICAL SYSTEM | 15 |
| 100000 POWER TRAIN | 15 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 6 |
| 980000 UNKNOWN OR OTHER | 5 |
| 020000 SUSPENSION | 5 |
| 350000 EQUIPMENT | 4 |
| 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL | 3 |
CBR-2350 202402
Feb 21, 2024
110000 ELECTRICAL SYSTEM
CBR -Telematics Gateway (TGW) Connect Ability Issues
CBR-202 202402
Feb 16, 2024
100000 POWER TRAIN
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
CBR-2347 202402
Feb 16, 2024
110000 ELECTRICAL SYSTEM
CBR - Active "Set Park Brake" Message On Drivers Information Display (DID).
CBR-2320 202312
Dec 1, 2023
060000 ENGINE AND ENGINE COOLING
CBR: For vehicles equipped with an 11L engine, the plastic saddle bracket holding the a/c line on the left side of the engine may move excessively and rub the area where it secures the line.
M-465-001 202311
Nov 7, 2023
100000 POWER TRAIN
TSB: Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers. The new HD shaft went into production on January 23rd, 2023 for 2.54 - 3.50 axle ratios and April 1st, 2023 for 3.56 - 3.
CBR-24 202308
Aug 15, 2023
110000 ELECTRICAL SYSTEM
CBR: FSB 381-049, Instrument Cluster Reprogramming ( MID140 ) - (Fault Code MID 140 PSID 200 FMI 9 Being Displayed )
CBR-24 202308
Aug 15, 2023
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
CBR: FSB 381-049, Instrument Cluster Reprogramming ( MID140 ) - (Fault Code MID 140 PSID 200 FMI 9 Being Displayed )
M728-005A 202308
Aug 14, 2023
020000 SUSPENSION
TSB: Barksdale Leveling Valve, Leak Test
CBR-2112 202307
Jul 24, 2023
060000 ENGINE AND ENGINE COOLING
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR-2112 202307
Jul 24, 2023
100000 POWER TRAIN
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
CBR-2112 202307
Jul 24, 2023
110000 ELECTRICAL SYSTEM
CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-614-Ver4
May 24, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
CBR: eWarranty To UCHP Labor Code ( SCC Code ) Crossover, Conversion Information For Use With Campaigns ( FI, PI ) And Recalls ( EC, SC ), Location On Trucks Dealer Portal ( TDP )
KC-474-Ver5
May 2, 2023
100000 POWER TRAIN
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
M-170-001
Apr 18, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
TSB: Stock Vehicle Storage and Maintenance
M-170-002
Apr 18, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
TSB: New Vehicle Safety Certification Requirements for Vehicles, U.S. and Canada
KC-2116
Apr 18, 2023
060000 ENGINE AND ENGINE COOLING
CBR: Mack NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2116
Apr 18, 2023
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
CBR: Mack NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
M-170-003
Apr 18, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
TSB: Vibration Diagnostics
KC-2244
Feb 22, 2023
020000 SUSPENSION
Mack Model TE,LR - Frame Over Height
KC-2244
Feb 22, 2023
161000 STRUCTURE:FRAME AND MEMBERS
Mack Model TE,LR - Frame Over Height
KC-2254
Feb 13, 2023
110000 ELECTRICAL SYSTEM
Mack Chassis - No Gauge Cluster Backlight
M-265-002
Sep 22, 2022
060000 ENGINE AND ENGINE COOLING
TSB-Charge Air Cooler t-clamp install.
M-652-001
Aug 6, 2022
020000 SUSPENSION
2009 Document reformatted to be published as a TSB in Impact. Axle Alignment Specifications
M-451-002
Aug 6, 2022
020000 SUSPENSION
2009 Document reformatted to be published as a TSB in Impact. Axle Carrier Pinion Angles
M-375-001
Aug 6, 2022
110000 ELECTRICAL SYSTEM
2009 Document reformatted to be published as a TSB in Impact. Cab Roof Harness Repair and Pass-Through Hole Modification
KC-751
Jun 28, 2022
100000 POWER TRAIN
Vehicles Equipped With An Automated Manual Transmission Model D or F ( AMT-D, AMT-F ) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And Newer.
KC-750
Jun 28, 2022
060000 ENGINE AND ENGINE COOLING
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.
KC-745
Jun 22, 2022
100000 POWER TRAIN
Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault Codes P1058 - 21 Or MID 130 PID 161 FMI 1
KC-405
Jun 21, 2022
100000 POWER TRAIN
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation -
KC-2143
Jun 21, 2022
180000 VEHICLE SPEED CONTROL
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).
KC-2112
Jun 21, 2022
060000 ENGINE AND ENGINE COOLING
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
100000 POWER TRAIN
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
110000 ELECTRICAL SYSTEM
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-735
Jun 6, 2022
350000 EQUIPMENT
Premium Tech Tool (PTT) - Message For Data Mismatch, Product Configuration Mismatch; Instruction To Run An Accessory Kit Displayed When Attempting To Run Diagnostics For Diagnostic Trouble Codes (DTC) Or Programming - US10+OBD13 And Newer E
KC-2165
Jun 3, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions.
KC-2158
Jun 3, 2022
060000 ENGINE AND ENGINE COOLING
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions.
KC-2116
Jun 3, 2022
060000 ENGINE AND ENGINE COOLING
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions.
KC-731
May 27, 2022
100000 POWER TRAIN
Mack Chassis - Equipped With An Automated Manual Transmission Model D or F (mDrive, AMT-D, AMT-F) - Transmission Oil Leakage From Transmission Input Shaft Seal Or Output Shaft Seal - US10 And Newer Emissions, Common Model Years 2010 And New
KC-2116
May 26, 2022
060000 ENGINE AND ENGINE COOLING
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2131
May 26, 2022
060000 ENGINE AND ENGINE COOLING
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
KC-2158
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2165
May 26, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2171
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-714
May 25, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1 Through 6 Injector A Open Circuit
KC-699
May 24, 2022
110000 ELECTRICAL SYSTEM
Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information
KC-698
May 24, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination
KC-686
May 20, 2022
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-686
May 20, 2022
180000 VEHICLE SPEED CONTROL
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-663
May 18, 2022
060000 ENGINE AND ENGINE COOLING
Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions
KC-648
May 17, 2022
100000 POWER TRAIN
Mack - PTO Pump Speed Calculator
KC-648
May 17, 2022
980000 UNKNOWN OR OTHER
Mack - PTO Pump Speed Calculator
KC-644
May 17, 2022
060000 ENGINE AND ENGINE COOLING
Manual Compression Test Adapter For Engines With Stainless Steel Injector Sleeves (Conical Tip Injectors) - US07 And Newer Emissions, Model Year 2008 And Newer
KC-653
May 17, 2022
060000 ENGINE AND ENGINE COOLING
Low Oil Pressure Diagnostic Process For 11 Liter Engines
KC-2169
May 16, 2022
110000 ELECTRICAL SYSTEM
Low Voltage Disconnect (LVD), Function Description
KC-2170
May 16, 2022
020000 SUSPENSION
Electronically Controlled Suspension (ECS) Losing Air Pressure
KC-2172
May 16, 2022
110000 ELECTRICAL SYSTEM
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2172
May 16, 2022
980000 UNKNOWN OR OTHER
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-633
May 13, 2022
200000 WHEELS
Mack Chassis - Front Hub With Unit-Bearings ( Unitized Wheel Bearings ), Inspection Information And Guidelines - Commonly Model Year 2008 And Newer
KC-2161
May 13, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Cycling periodically Hours After Key Off
KC-626
May 9, 2022
100000 POWER TRAIN
Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool ( PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% When Run With Transmission Removed
KC-627
May 9, 2022
350000 EQUIPMENT
Premium Tech Tool ( PTT ) Training Materials And Support Tools
KC-630
May 9, 2022
060000 ENGINE AND ENGINE COOLING
Sensor And Parameter Value Monitor - Template Parameter List For Pre-OBD (9-Pin Diagnostic Connector) Chassis In Premium Tech Tool ( PTT ); Regeneration And Road Test Sensor Monitor Parameters - US07 And US10 Emissions, Model Years 2008 To
KC-2157
Feb 25, 2022
060000 ENGINE AND ENGINE COOLING
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-552
Feb 22, 2022
060000 ENGINE AND ENGINE COOLING
Aftertreatment Control Module ( ACM ) Diagnostic Trouble Codes ( DTC ) U0001-88 and U0010-88 Lighting The Malfunction Indicator Lamp ( MIL ); Possible Derate Warning a?? US10 And Newer Chassis
KC-561
Feb 22, 2022
060000 ENGINE AND ENGINE COOLING
Engine Oil Analysis Specifications - US10 And Newer Emissions
KC-529
Feb 21, 2022
980000 UNKNOWN OR OTHER
System Date And Time, Information; Diagnostic Tool ( J-Pro, Premium Tech Tool ( PTT ) ) Displays Incorrect Timestamp For Diagnostic Trouble Code ( DTC ) / Fault Code Occurrences, Possible Data Link Codes Present - US07 And Newer Emissions,
KC-529
Feb 21, 2022
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
System Date And Time, Information; Diagnostic Tool ( J-Pro, Premium Tech Tool ( PTT ) ) Displays Incorrect Timestamp For Diagnostic Trouble Code ( DTC ) / Fault Code Occurrences, Possible Data Link Codes Present - US07 And Newer Emissions,
KC-538
Feb 21, 2022
060000 ENGINE AND ENGINE COOLING
Regen Fails to Start/Initiate Or Starts And Immediately Stops - US10 And US10+OBD13 Emissions
KC-492
Feb 16, 2022
060000 ENGINE AND ENGINE COOLING
Diagnostic Trouble Code (DTC) P04DB - Crankcase Ventilation Disconnected; US10+OBD13 To US14+OBD16 Emissions
KC-492
Feb 16, 2022
063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
Diagnostic Trouble Code (DTC) P04DB - Crankcase Ventilation Disconnected; US10+OBD13 To US14+OBD16 Emissions
KC-495
Feb 16, 2022
060000 ENGINE AND ENGINE COOLING
Intake Pre-heater Electrical Schematics (Diagrams) - US10+OBD13, US14+OBD13 To US14+OBD16 Emissions
KC-495
Feb 16, 2022
110000 ELECTRICAL SYSTEM
Intake Pre-heater Electrical Schematics (Diagrams) - US10+OBD13, US14+OBD13 To US14+OBD16 Emissions
KC-2157
Feb 10, 2022
060000 ENGINE AND ENGINE COOLING
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2157
Feb 10, 2022
980000 UNKNOWN OR OTHER
Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-417
Jan 20, 2022
040000 SERVICE BRAKES, AIR
Mack Chassis - Air System Schematics For Models - MRU, LEU And ( LR ) Using The Same Schematic As the LEU
KC-402
Jan 19, 2022
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Volvo Chassis - Diagnostic Trouble Code (DTC) SA 0 FMI 0 or SPN 0 FMI 0 Present On Fault Code Readout - US10 And Newer Emissions, Model Year 2011 And Newer
KC-402
Jan 19, 2022
110000 ELECTRICAL SYSTEM
Volvo Chassis - Diagnostic Trouble Code (DTC) SA 0 FMI 0 or SPN 0 FMI 0 Present On Fault Code Readout - US10 And Newer Emissions, Model Year 2011 And Newer
KC-404
Jan 19, 2022
060000 ENGINE AND ENGINE COOLING
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 ( Non-Common Rail Fuel System )
KC-404
Jan 19, 2022
083200 FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:INJECTORS
Volvo Chassis - Diesel Exhaust Fluid ( DEF ) Contamination In Fuel System, Inspection And Repair - US10 to US14 ( Non-Common Rail Fuel System )
KC-286
Dec 21, 2021
040000 SERVICE BRAKES, AIR
Mack Chassis - FSB 563-008 Plugs, Pressure Protection Manifold - New Brass Plugs For Noregon Pressure Protection Manifold (PPM)
KC-286
Dec 21, 2021
980000 UNKNOWN OR OTHER
Mack Chassis - FSB 563-008 Plugs, Pressure Protection Manifold - New Brass Plugs For Noregon Pressure Protection Manifold (PPM)
KC-238
Dec 14, 2021
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Mack Chassis - Where To Find The Body Builder Portal - Body Builder Manual ( BBM ) Information - US04 And Newer Emissions, Model Year 2008 And Newer
KC-145
Nov 24, 2021
100000 POWER TRAIN
Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number Information, Reference Guide - US07 And Newer Emissions, Model Year 2008 And Newer
KC-119
Nov 22, 2021
100000 POWER TRAIN
Mack Chassis - Equipped With An Automated Manual Transmission (mDrive, AMT) AMT-C, AMT-D Or AMT-F - Transmission Oil Specifications - Model Years 2010 To 2020
KC-73
Nov 18, 2021
350000 EQUIPMENT
Mack Chassis - Disabling The Driver ID; Removing the Driver ID Prompt - US07 To US14+OBD16 Emissions, Model Years 2008 To 2017
KC-163
Nov 4, 2021
080000 FUEL SYSTEM, DIESEL
Diesel Fuel Information - Acceptable Biodiesel, Fuel Blend For Summer And Winter - US07 And Newer Emissions, Model Year 2008 And Newer
KC-136
Oct 26, 2021
060000 ENGINE AND ENGINE COOLING
Aftertreatment Control Module (ACM) Offline/Not Visible/Missing From Control Unit Information in Premium Tech Tool (PTT) - US10+OBD13 And Newer Emissions
KC-124
Oct 22, 2021
100000 POWER TRAIN
Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24 FMI 1, P1072-92 Unintentional Disengagement Of High Range - US07 And Newer Emissions, Model Year 2008 And Newer
KC-692
Oct 11, 2021
110000 ELECTRICAL SYSTEM
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
120000 EXTERIOR LIGHTING
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
120100 EXTERIOR LIGHTING:LIGHTING CONTROL MODULE
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
FSB 491-032
Mar 23, 2021
100000 POWER TRAIN
Transmission Oil Cooler Hose, Replacement
FSB 491-032
Mar 23, 2021
350000 EQUIPMENT
Transmission Oil Cooler Hose, Replacement
K23315031
Dec 5, 2018
070000 FUEL SYSTEM, GASOLINE
Fuel Tank Strap Insulator Design Update; Fuel Tank Strap Appearance Changed
K72614548
Feb 28, 2018
110000 ELECTRICAL SYSTEM
Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K04342327
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K01050303
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K58557784
Feb 20, 2018
070000 FUEL SYSTEM, GASOLINE
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
K58557784
Feb 20, 2018
110000 ELECTRICAL SYSTEM
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
FSB284064
Jan 30, 2018
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
ECM and ACM Reprogramming, OBD2015
Showing 100 of 102 bulletins.
MACK TERRAPRO (MRU) - All Years Overview
Complete safety history for the MACK TERRAPRO (MRU) across all model years (2011, 2019).
16
Total Recalls
0
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths