2007 MACK CXP
6 recalls, 0 complaints - 80 TSBs
07V497000 Oct 23, 2007
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN... Read more
Consequence
THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.
07V360000 Aug 15, 2007
PARKING BRAKE
Defect Description
ON CERTAIN TRUCKS EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Consequence
THIS COULD DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.
Remedy
MACK IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 10, 2008. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000 OR MACK AT 1-800-528-6586.
07V346000 Aug 7, 2007
FUEL SYSTEM, DIESEL
Defect Description
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
Consequence
IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy
DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.
07V123000 Mar 21, 2007
POWER TRAIN:AXLE ASSEMBLY
Defect Description
ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.
Consequence
IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy
DEALERS WILL INSPECT AND REPLACE THE AXLES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT APRIL 9, 2007. OWNERS MAY CONTACT MACK TRUCKS AT 1-800-528-6586.
07V023000 Feb 1, 2007
STEERING
Defect Description
ON CERTAIN TRUCKS, THE NUT THAT RETAINS THE STEERING WHEEL MAY NOT HAVE BEEN INSTALLED.
Consequence
IF THE RETAINING NUT WAS NOT INSTALLED, THE STEERING WHEEL MAY COME OFF, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy
DEALERS WILL REMOVE THE HORN BUTTON TO CONFIRM THAT THE RETAINING NUT WAS INSTALLED. A RETAINING NUT WILL BE ADDED IF THE NUT IS MISSING. THE RECALL BEGAN ON FEBRUARY 12, 2007. OWNERS MAY CONTACT MACK TRUCKS AT 800-866-1177.
06V367000 Sep 26, 2006
SERVICE BRAKES, AIR
Defect Description
ON CERTAIN TRUCKS, THE BRAKE CAM TUBES ON THE STEER AND DRIVE AXLES MAY NOT HAVE BEEN GREASED.
Consequence
THE BRAKE CAM JOURNALS MAY CORRODE WHICH MAY LEAD TO THE BRAKES DRAGGING WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy
DEALERS WILL ADD GREASE TO THE BRAKE CAM TUBES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 29, 2006. OWNERS MAY CONTACT MACK AT 1-800-866-1177.
No complaints found for this vehicle.
Technical Service Bulletins, 2007 MACK CXP
80 manufacturer communications from 59 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 060000 ENGINE AND ENGINE COOLING | 17 |
| 100000 POWER TRAIN | 8 |
| 110000 ELECTRICAL SYSTEM | 7 |
| 020000 SUSPENSION | 5 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 4 |
| 980000 UNKNOWN OR OTHER | 3 |
| 101000 POWER TRAIN:CLUTCH ASSEMBLY | 3 |
| 022000 SUSPENSION:REAR | 2 |
CBR-202 202402
Feb 16, 2024
100000 POWER TRAIN
CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft.
M-465-001 202311
Nov 7, 2023
100000 POWER TRAIN
TSB: Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers. The new HD shaft went into production on January 23rd, 2023 for 2.54 - 3.50 axle ratios and April 1st, 2023 for 3.56 - 3.
M728-005A 202308
Aug 14, 2023
020000 SUSPENSION
TSB: Barksdale Leveling Valve, Leak Test
KC-614-Ver4
May 24, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
CBR: eWarranty To UCHP Labor Code ( SCC Code ) Crossover, Conversion Information For Use With Campaigns ( FI, PI ) And Recalls ( EC, SC ), Location On Trucks Dealer Portal ( TDP )
KC-474-Ver5
May 2, 2023
100000 POWER TRAIN
CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
M-265-002
Sep 22, 2022
060000 ENGINE AND ENGINE COOLING
TSB-Charge Air Cooler t-clamp install.
M-652-002
Sep 15, 2022
020000 SUSPENSION
2008 Document reformated to be published as a TSB in Impact. Torque rod interference.
M-258-006
Aug 18, 2022
060000 ENGINE AND ENGINE COOLING
2009 Document reformatted to be published as a TSB in Impact. DRV Air Line Service Kit
M-263-003
Aug 18, 2022
060000 ENGINE AND ENGINE COOLING
2009 Document reformatted to be published as a TSB in Impact. Fan Drive Belt Replacement MP7 Engine
M-451-001
Aug 6, 2022
021000 SUSPENSION:FRONT
2007 Document reformatted to be published as a TSB in Impact. Updated Crossmember for improved clearance.
M-711-002
Aug 6, 2022
161100 STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
2008 Document reformated to be published as a TSB in Impact. Frame reinforcement plate.
M-711-002
Aug 6, 2022
160000 STRUCTURE
2008 Document reformated to be published as a TSB in Impact. Frame reinforcement plate.
M-711-001
Aug 6, 2022
022000 SUSPENSION:REAR
2008 Document reformatted to be published as a TSB in Impact. Rear Suspension Repair.
M-711-001
Aug 6, 2022
020000 SUSPENSION
2008 Document reformatted to be published as a TSB in Impact. Rear Suspension Repair.
M-451-001
Aug 6, 2022
160000 STRUCTURE
2007 Document reformatted to be published as a TSB in Impact. Updated Crossmember for improved clearance.
M-451-001
Aug 6, 2022
105000 POWER TRAIN:DRIVELINE
2007 Document reformatted to be published as a TSB in Impact. Updated Crossmember for improved clearance.
KC-750
Jun 28, 2022
060000 ENGINE AND ENGINE COOLING
US10 Emission Engines - Diagnostic Trouble Code ( DTC ) SPN 1231 FMI 9 Troubleshooting.
KC-745
Jun 22, 2022
100000 POWER TRAIN
Automated Manual Transmission ( AMT ) I-Shift / mDRIVE - Ribbon Harness Replacement - Speed Sensor Bolts, Possible Fault Codes P1058 - 21 Or MID 130 PID 161 FMI 1
KC-405
Jun 21, 2022
100000 POWER TRAIN
Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For Filing A Claim For Chassis Return Visit With Transmission Issues After A Repair Requiring Control Housing Removal And Reinstallation -
KC-2143
Jun 21, 2022
180000 VEHICLE SPEED CONTROL
(Back Office) - Cruise Control Inoperative After Updating Software VECU5 Without ESP Package (UESP).
KC-2112
Jun 21, 2022
060000 ENGINE AND ENGINE COOLING
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
100000 POWER TRAIN
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2112
Jun 21, 2022
110000 ELECTRICAL SYSTEM
Programming Failure - Chassis With Cummins Engine And An Allison Transmission
KC-2171
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Temperature Sensor Troubleshooting Guide - US10+OBD13 And Newer
KC-2165
May 26, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2158
May 26, 2022
060000 ENGINE AND ENGINE COOLING
Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-2131
May 26, 2022
060000 ENGINE AND ENGINE COOLING
USE FOR NEW VEHICLES (US21+OBD22 Emissions) - Intermittent Diagnostic Trouble Codes U02A3, U029D, U029E
KC-2116
May 26, 2022
060000 ENGINE AND ENGINE COOLING
NOx Sensor Troubleshooting Guide - US10+OBD13 And Newer Emissions
KC-714
May 25, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diagnostic Trouble Codes ( DTC's ) - P020113, P020213, P020313, P020413, P020513, P020613, Cylinders 1 Through 6 Injector A Open Circuit
KC-698
May 24, 2022
060000 ENGINE AND ENGINE COOLING
Mack Chassis - Diesel Exhaust Fluid ( DEF ) System Cleaning/Flush After DEF Pump Failure Or System Contamination
KC-699
May 24, 2022
110000 ELECTRICAL SYSTEM
Mack Chassis - Bendix Vendor Configuration Program ( VCP ) Software Download Information
KC-686
May 20, 2022
180000 VEHICLE SPEED CONTROL
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-686
May 20, 2022
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
(Back Office Only) Mack Chassis - Cruise Control Inoperative After Disabling The Electronic Stability Program (ESP)
KC-663
May 18, 2022
060000 ENGINE AND ENGINE COOLING
Emcon (Spark Assist) Engine Aftertreatment System Troubleshooting Check Sheet - US07 Emissions
KC-653
May 17, 2022
060000 ENGINE AND ENGINE COOLING
Low Oil Pressure Diagnostic Process For 11 Liter Engines
KC-648
May 17, 2022
100000 POWER TRAIN
Mack - PTO Pump Speed Calculator
KC-648
May 17, 2022
980000 UNKNOWN OR OTHER
Mack - PTO Pump Speed Calculator
KC-2172
May 16, 2022
980000 UNKNOWN OR OTHER
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2172
May 16, 2022
110000 ELECTRICAL SYSTEM
No Start Condition After Over The Air Programing - VECU5 No Start "Safe State"
KC-2170
May 16, 2022
020000 SUSPENSION
Electronically Controlled Suspension (ECS) Losing Air Pressure
KC-2169
May 16, 2022
110000 ELECTRICAL SYSTEM
Low Voltage Disconnect (LVD), Function Description
KC-2161
May 13, 2022
060000 ENGINE AND ENGINE COOLING
DEF Pump Cycling periodically Hours After Key Off
KC-627
May 9, 2022
350000 EQUIPMENT
Premium Tech Tool ( PTT ) Training Materials And Support Tools
KC-626
May 9, 2022
100000 POWER TRAIN
Mack Chassis - Vehicles Equipped With An Automated Manual Transmission Model F ( AMT-F, mDrive ), Premium Tech Tool ( PTT ) Gearbox Calibration Failure; Gearbox Calibration Operation Stops And Fails At 33% When Run With Transmission Removed
KC-593
Apr 21, 2022
040000 SERVICE BRAKES, AIR
V-MAC - ABS Malfunction Lamp On - ( Eaton ABS Active Code 17-10 / Arvin Meritor Wabco Active Code 7-4 )
KC-593
Apr 21, 2022
350000 EQUIPMENT
V-MAC - ABS Malfunction Lamp On - ( Eaton ABS Active Code 17-10 / Arvin Meritor Wabco Active Code 7-4 )
KC-525
Feb 21, 2022
060000 ENGINE AND ENGINE COOLING
US07 / US10 D13 Turbocharger Gasket - Low Power, Poor Regen Performance
KC-525
Feb 21, 2022
102500 POWER TRAIN:MANUAL TRANSMISSION:SEALS/GASKETS
US07 / US10 D13 Turbocharger Gasket - Low Power, Poor Regen Performance
KC-692
Oct 11, 2021
110000 ELECTRICAL SYSTEM
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
120000 EXTERIOR LIGHTING
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
KC-692
Oct 11, 2021
120100 EXTERIOR LIGHTING:LIGHTING CONTROL MODULE
Lighting Control Module ( LCM ) Replacement - Refer To Technical Parts Information ( TPI ) 364 - 034 Control Unit
K15194127
Jan 10, 2019
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Mack Chassis - Fault Code SID 158 FMI 0 Logging In Instrument Cluster ( MID 140, IC ), No Code Description Or Diagnostic Information
K72614548
Feb 28, 2018
110000 ELECTRICAL SYSTEM
Diagnostic Trouble Code ( DTC ) P02FA Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K01050303
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0471 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K04342327
Feb 27, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Diagnostic Trouble Code ( DTC ) P0420 Illuminating The Malfunction Indicator Lamp (MIL) - US17 (GHG17, Common Rail Fuel System) Chassis ONLY
K58557784
Feb 20, 2018
110000 ELECTRICAL SYSTEM
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
K58557784
Feb 20, 2018
070000 FUEL SYSTEM, GASOLINE
Fuel Injector Offset Learning Diagnostic Trouble Codes ( DTC ) / Fault Codes Logged In Engine Control Module ( EMS ); Possible Rough / Uneven Idle - OBD15 Chassis
FSB-413-003
Dec 1, 2013
101200 POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING
MACK: ON SOME TRUCKS, MORE LEG AND KNEE ROOM WAS PROVIDED FOR OPERATOR COMFORT DUE TO AIR OPERATED CLUTCH ASSIST SYSTEM DESIGNED TO REDUCE CLUTCH PEDAL EFFORT BY 20% AND CLUTCH PEDAL TRAVEL BY 2' (50.8MM). MODEL CHU, CTP, CXP, CXU, GU. N
FSB-413-003
Dec 1, 2013
101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
MACK: ON SOME TRUCKS, MORE LEG AND KNEE ROOM WAS PROVIDED FOR OPERATOR COMFORT DUE TO AIR OPERATED CLUTCH ASSIST SYSTEM DESIGNED TO REDUCE CLUTCH PEDAL EFFORT BY 20% AND CLUTCH PEDAL TRAVEL BY 2' (50.8MM). MODEL CHU, CTP, CXP, CXU, GU. N
FSB-413-003
Dec 1, 2013
101000 POWER TRAIN:CLUTCH ASSEMBLY
MACK: ON SOME TRUCKS, MORE LEG AND KNEE ROOM WAS PROVIDED FOR OPERATOR COMFORT DUE TO AIR OPERATED CLUTCH ASSIST SYSTEM DESIGNED TO REDUCE CLUTCH PEDAL EFFORT BY 20% AND CLUTCH PEDAL TRAVEL BY 2' (50.8MM). MODEL CHU, CTP, CXP, CXU, GU. N
FSB-491-029
Sep 1, 2011
980000 UNKNOWN OR OTHER
MACK TRUCKS: THERE ARE CRACKS IN A STEEL OIL TUBE THAT CAN LEAD TO LEAKING. *RM UPDATED 2/21/12. *PE
FSB-437-001
Sep 1, 2011
103700 POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER
MACK TRUCK: THE EASY INSTALLATION OF ALLISON TRANSMISSION AND PREVENTING BINDING OF TORQUE CONVERTER PILOT DURING THERMAL EXPANSION CYCLE OF NORMAL OPERATION BY USING HIGH TEMPERATURE MOLYBDENUM DISULFIDE GREASE. *PE
FSB-461-001
Feb 1, 2011
022520 SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
MACK TRUCKS: REAR AXLE HOUSING REPLACEMENT. *RM
FSB-214-024
Jan 1, 2011
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
MACK TRUCKS: THERE IS REVISED MOUNTING HARDWARE FOR THE EXHAUST MANIFOLD AND TURBOCHARGER. *RM
SB-262-008
Dec 1, 2010
060000 ENGINE AND ENGINE COOLING
MACK TRUCKS: THERE IS A NEW THERMOSTAT SEAL AND COVER TO PREVENT COOLANT LEAKAGE. *RM
SB-214-024
Nov 1, 2010
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
MACK TRUCKS: IF THERE IS A FAILED OUTER VALVE SPRING THERE IS A REPLACEMENT PROCEDURE. *RM
SB-214-024
Nov 1, 2010
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
MACK TRUCKS: IF THERE IS A FAILED OUTER VALVE SPRING THERE IS A REPLACEMENT PROCEDURE. *RM
SB-313006
Aug 6, 2009
101000 POWER TRAIN:CLUTCH ASSEMBLY
MACK TRUCK: AIR ASSIST CLUTCH CONVERSION. AIR ASSIST TO NON ASSIST CLUTCH CABLE CONVERSION. THE AIR OPERATED CLUTCH ASSIST SYSTEM WAS DESIGNED TO REDUCE CLUTCH PEDAL EFFORT BY APPROXIMATELY 20%, ALONG WITH REDUCING THE CLUTCH PEDAL TRAVE
SB-313006
Aug 6, 2009
101200 POWER TRAIN:CLUTCH ASSEMBLY:BELL HOUSING
MACK TRUCK: AIR ASSIST CLUTCH CONVERSION. AIR ASSIST TO NON ASSIST CLUTCH CABLE CONVERSION. THE AIR OPERATED CLUTCH ASSIST SYSTEM WAS DESIGNED TO REDUCE CLUTCH PEDAL EFFORT BY APPROXIMATELY 20%, ALONG WITH REDUCING THE CLUTCH PEDAL TRAVE
SB-313006
Aug 6, 2009
101100 POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
MACK TRUCK: AIR ASSIST CLUTCH CONVERSION. AIR ASSIST TO NON ASSIST CLUTCH CABLE CONVERSION. THE AIR OPERATED CLUTCH ASSIST SYSTEM WAS DESIGNED TO REDUCE CLUTCH PEDAL EFFORT BY APPROXIMATELY 20%, ALONG WITH REDUCING THE CLUTCH PEDAL TRAVE
SB-262001
Mar 20, 2009
015100 STEERING:HYDRAULIC POWER ASSIST:PUMP
MACK TRUCK: POWER STEERING PUMPS WITH METRIC FITTINGS. SERVICE REPLACEMENT POWER STEERING PUMPS SUPPLIED THROUGH THE MACK PARTS SYSTEM FOR MP7 AND MP8 ENGINES UTILIZE METRIC THREADS AT THE HIGH PRESSURE AND SUCTION PORTS. NO MODEL YEARS
TSB-517009
Nov 21, 2008
106000 POWER TRAIN:AXLE ASSEMBLY
MACK TRUCK: BROKEN LONGITUDINAL TORQUE ROD MOUNTING STUD IN AXLE SPRING SEAT DUE TO WING BRACKET INTERFERENCE. THIS INCLUDES THE TD MODEL. NO MODEL YEARS LISTED. *PE
SB-12-1043
Oct 10, 2008
020000 SUSPENSION
MACK TRUCK: SUSPENSION CROSSMEMBERS, PRIMAAX REAR SUSPENSION. MODELS EQUIPPED WITH THE HENDRICKSON PRIMAAX REAR AIR SUSPENSION MAY DEVELOP A CRACK IN THE RADIUS OF THE LOWER END GUSSET. *PE
SB-12-1043
Oct 10, 2008
022000 SUSPENSION:REAR
MACK TRUCK: SUSPENSION CROSSMEMBERS, PRIMAAX REAR SUSPENSION. MODELS EQUIPPED WITH THE HENDRICKSON PRIMAAX REAR AIR SUSPENSION MAY DEVELOP A CRACK IN THE RADIUS OF THE LOWER END GUSSET. *PE
SB724008
Mar 26, 2008
114000 ELECTRICAL SYSTEM:WIRING
MACK - BLOWER MOTOR SWITCH WIRING UPGRADE--ALL WITH BEHR HVAC UNITS. MANUFACTURED PRIOR TO FEB. 1, 2008. *NJ
SB-313004
Jan 23, 2008
101000 POWER TRAIN:CLUTCH ASSEMBLY
MACK TRUCK: REVISED AIR ASSIST CLUTCH CABLE. EFFECTIVE 9/17/07, A REVISED AIR ASSIST CLUTCH CABLE (PART NO. 27RC410M) WAS IMPLEMENTED INTO PRODUCTION ON CXU, CHU, AND GU MODEL CHASSIS. NO MODEL YEARS LISTED. *PE
SC-334
Jan 11, 2008
042300 SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
MACK TRUCK: IT HAS BEEN DETERMINED THAT THE 90 DEGREE SINGLE CHECK VALVE FITTING MANUFACTURED BY PARKER HANNIFIN CORP. WHICH IS USED IN THE SUPPLY PORT OF THE SPRING BRAKE MODULATING RELAY VALVE (BENDIX SR 7 VALVE) MAY HAVE A DEFECT WHEREB
SB-214052
Jan 10, 2008
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
MACK TRUCK: EXHAUST MANIFOLDS WITH STAINLESS STEEL SEAL RINGS-CXP AND CTP MODELS EQUIPPED WITH US04 EMISSION COMPLIANT MP7 ENGINES. TO PROVIDE IMPROVED SEALING AT THE EXHAUST MANIFOLD JOINTS, A REVISED EXHAUST MANIFOLD ASSEMBLY (PART NO.
SB-214052
Jan 10, 2008
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
MACK TRUCK: EXHAUST MANIFOLDS WITH STAINLESS STEEL SEAL RINGS-CXP AND CTP MODELS EQUIPPED WITH US04 EMISSION COMPLIANT MP7 ENGINES. TO PROVIDE IMPROVED SEALING AT THE EXHAUST MANIFOLD JOINTS, A REVISED EXHAUST MANIFOLD ASSEMBLY (PART NO.
SB-635012
Jan 4, 2008
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
MACK TRUCK: FINE PARTICULATE FILTER FOR HVAC UNITS-CXU, CHU, GU, CXP AND CTP MODELS. A PLEATED FINE PARTICULATE HVAC FILTER (PART NO. 85112361) HAS BEEN DEVELOPED FOR THE HVAC UNITS IN CERTAIN MODELS. NO MODEL YEARS LISTED.
MACK CXP - All Years Overview
Complete safety history for the MACK CXP across all model years (2006, 2008).
8
Total Recalls
0
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths