2022 LINCOLN AVIATOR

21 recalls, 74 complaints - 188 TSBs - 5/5 safety rating

SEATS:MID/REAR ASSEMBLY

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.

Consequence

A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy

Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters... Read more

387,911 vehicles affected

Manufacturer: Ford Motor Company

SEAT BELTS

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.

Consequence

A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.

Remedy

Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identific... Read more

561 vehicles affected

Manufacturer: Ford Motor Company

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.

Consequence

Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.

Remedy

Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer ser... Read more

604,533 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION:SOFTWARE

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles ... Read more

Consequence

An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy

Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in thi... Read more

889,950 vehicles affected

Manufacturer: Ford Motor Company

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Defect Description

Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.

Consequence

An engine stall increases the risk of a crash.

Remedy

Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's numb... Read more

850,318 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION:SOFTWARE

Defect Description

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2... Read more

Consequence

A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy

Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

200,237 vehicles affected

Manufacturer: Ford Motor Company

STRUCTURE:BODY

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator vehicles. The rear door window bars and C-pillar trim may have insufficient adhesive bonding, which can allow the trim to detach from the vehicle.

Consequence

Detached trim may cause a road hazard and increase the risk of a crash.

Remedy

Dealers will repair or replace C-pillar appliques and window division bars, free of charge. Owner notification letters were mailed September 29, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S66.

132,914 vehicles affected

Manufacturer: Ford Motor Company

SEATS:MID/REAR ASSEMBLY

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.

Consequence

A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.

Remedy

Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.

304,662 vehicles affected

Manufacturer: Ford Motor Company

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activ... Read more

Consequence

An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.

Remedy

Dealers will update the audio control module software, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C18.

4,442 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION:SOFTWARE

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.

Consequence

Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy

Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.

49,399 vehicles affected

Manufacturer: Ford Motor Company

EQUIPMENT:OTHER:LABELS

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requiremen... Read more

Consequence

Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy

Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

27,678 vehicles affected

Manufacturer: Ford Motor Company

ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL

Defect Description

Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive p... Read more

Consequence

A loss of drive power increases the risk of a crash.

Remedy

Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.

90,736 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION:DISPLAY FUNCTION

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2024 Lincoln Aviator vehicles. The accessory protocol image module (APIM) can be affected by electromagnetic interference with a cell phone in the vehicle, causing the rearview camera image to flicker or become distorted.

Consequence

A flickering or distorted rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy

Owners are advised not to use their cell phones while reversing until the remedy is completed. Dealers will install shielding on the accessory protocol image module (APIM), free of charge. Owner notification letters were mailed on October 23, 2024. Owners may contact Ford customer service at 1-86... Read more

109,283 vehicles affected

Manufacturer: Ford Motor Company

ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Consequence

Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Remedy

Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for... Read more

2,954 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.

Consequence

Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy

Dealers will replace the rearview camera, and update the software and wiring as necessary, free of charge. Owner notification letters were mailed November 20, 2023 to Lincoln owners. Ford vehicle owners notification letters were mailed March 4, 2024. Ford remedy parts are anticipated 2nd Quarter 202... Read more

177,402 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.

Consequence

Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy

Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previo... Read more

442,973 vehicles affected

Manufacturer: Ford Motor Company

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Defect Description

Consequence

Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.

Remedy

Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332.... Read more

382,759 vehicles affected

Manufacturer: Ford Motor Company

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Defect Description

Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles equipped with a Revel Audio System. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insuf... Read more

Consequence

An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.

Remedy

Dealers will update the audio control module software, free of charge. Owner notification letters were mailed February 7, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C35.

101,001 vehicles affected

Manufacturer: Ford Motor Company

STRUCTURE:FRAME AND MEMBERS

Defect Description

Ford Motor Company (Ford) is recalling certain 2022 Lincoln Aviator and Ford Explorer vehicles. The engine rails may have been improperly heat-treated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupant Crash Protection" and... Read more

Consequence

Improperly heat-treated engine rails may reduce the vehicle's structural protection in a crash, increasing the risk of injury. In addition, an engine rail may detach and contact the road while driving, increasing the risk of a crash.

Remedy

Dealers will perform an engine rail strength test and replace the rails as necessary, free of charge. If the engine rails require replacement, owners will have the option for a vehicle replacement or buyback. Owner notification letters were mailed August 22, 2022. Owners may contact Ford customer... Read more

776 vehicles affected

Manufacturer: Ford Motor Company

SEATS:FRONT ASSEMBLY:HEAD RESTRAINT

Defect Description

Ford Motor Company (Ford) is recalling certain 2022 Lincoln Aviator vehicles. The front-row driver and passenger seat power head restraint cushion may detach from the head restraint assembly when adjusted to the full forward position.

Consequence

A detached head restraint cushion can increase the risk of injury during a crash.

Remedy

Dealers will replace the front-row passenger and driver head restraints, free of charge. Interim owner notification letters to notify owners of the safety risk were mailed May 11, 2022. Owner notification letters were mailed July 29, 2022. Owners may contact Ford customer service at 1-866-436-733... Read more

933 vehicles affected

Manufacturer: Ford Motor Company

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Defect Description

Ford Motor Company (Ford) is recalling certain 2022 Explorer and Lincoln Aviator vehicles. The fuel filler tube may detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 301, "Fuel System Integrity."

Consequence

A detached fuel filler tube can result in a fuel leak, increasing the risk of a fire.

Remedy

Dealers will install a fuel vapor line redundant locking clip, free of charge. Owner notification letters were mailed on April 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C02.

18,366 vehicles affected

Manufacturer: Ford Motor Company

Complaint Statistics

74 total complaints 7 crashes 2 fires

Top Reported Components

Component	Complaints
UNKNOWN OR OTHER	9
ENGINE	9
ELECTRICAL SYSTEM	8
POWER TRAIN	8
STEERING	5
FUEL/PROPULSION SYSTEM	4
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	4
WHEELS	3
VEHICLE SPEED CONTROL	2
AIR BAGS	2

Incident date: May 15, 2026

I was driving on the highway in Michigan, the speed limit is 70 mph. All of a sudden, I noticed that my car acceleration was not working. It ended up my engine misfired and in doing so, I could not go more than 20 mph on the actual highway!!! it was absolutely terrifying, even when I put on my emerg... Read more

Incident date: Jul 5, 2025

The engine burns oil excessively and the oil light does NOT come on when the oil is low. Our car is right at 90k miles, it began to shudder and malfunction out of the blue while we were driving on the highway. There was absolutely no indication the oil was low. Now the car will not turn on at all. W... Read more

Incident date: Mar 5, 2026

The contact stated while driving at approximately35 mph, minor occupant struggling, back right seatbelt was strangling child, kept tightening up when trying to retract the seatbelt but it would not. The contact had to pull over and received assistance from citizens the seatbelt ultimately had to ... Read more

Incident date: Mar 5, 2026

The contact owns a 1966 Ford Mustang equipped with Nexen Tires, Tire Line: N’Priz, Tire Size: P195/75R14, DOT Number: 1BE4X. Upon inspection, it was discovered that the sidewall of the tire had failed and the sidewall tire had unexpectedly swell. The cause of the failure had not yet been determin... Read more

Incident date: Feb 13, 2026

On Feb 7th, notice a Knocking/Clicking noise coming from right wheel when making slight right turn, but not often. Called my dealership and immediately they said they were aware of issue and said it is common in Prologues. But due to the prologue being a GM make and not Honda, they were told they ne... Read more

Incident date: Feb 13, 2026

I have been having an issue with my 2021 Hyundai Palisade's engine oil consumption. It is constantly burning oil at a high rate, requiring me to purchase oil constantly. I had it serviced at Hyundai in Gurnee, IL. An oil consumption test was conducted. Hyundai corporate stated that my vehicle's engi... Read more

Incident date: Feb 4, 2026

While stopped in heavy traffic at a traffic signal, the engine stopped and would not restart. This was due to the AIS system. The car became disabled in heavy traffic. I was only a few feet from the entrance to a gas station, however due to the interlock system that locks the transmission in Park, t... Read more

Incident date: Sep 15, 2025

Timeline of Maintenance & Failure: • October [Year]: I purc Timeline of Maintenance & Failure: • October [Year]: I purchased this vehicle. • February 11, 2026: I performed a full oil service (documented receipt attached). • April 3, 2026: While transporting my two grandsons—one of whom has... Read more

Incident date: Sep 15, 2025

For the second time, the integrated control unit, ICCU, has failed to this is AFTER being replaced under the recall. The recall solution has not fixed the problem, and is a fake bandaid on a problem that means cars will totally stop working in the middle of the road. This is totally unsafe and unacc... Read more

Incident date: Sep 15, 2025

Incident date: Nov 18, 2025

The contact owns a 2015 BMW X1. The contact stated that while the vehicle was at an independent mechanic for maintenance, the contact was informed that the water pump had failed. The vehicle was not repaired. The contact stated that prior to the visit, the vehicle was taken to the dealer; however, t... Read more

Incident date: Jul 25, 2025

On [XXX] my there was a loud pop from the rear of the vehicle and electric vehicle warnings popped up on my dash. I turned around at the light, and as I drove I could tell that the vehicle was slowly losing power. Speed was limited to 30mph. Barely made it back home before the warnings on the dash ... Read more

Incident date: Jul 25, 2025

Odometer Fraud. The contact purchased a 2010 Hyundai Santa Fe. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 142,000. It was later discovered, during a VIN check, that the mileage was 223,000. The mileage was... Read more

Incident date: Jul 25, 2025

I bought the vehicle with 14000 miles.had oil changed at dealership ever ,5000 miles.I drive 10 miles a day.at 55000 miles the lifters are ticking like a time bomb.It makes me sick that a vehicle with no more miles than this is in this shape.Gm should stand behind there junk motors with this afm.

Incident date: Jul 25, 2025

My keyless start system is going off and on and this is supposedly a well known problem with this year and model and the start stop buttoning going off and car stalling etc. it says to report to you all online.

Incident date: Sep 23, 2025

I was driving to work in the rain on the highway and I heard a big thump and I thought I had hit something and my wheel went sideways and I kept trying to keep my car on the road even though I didn’t hit anything.

Incident date: Nov 7, 2025

While driving at 70–75 mph on an interstate, my vehicle suddenly displayed a “Brake Failure” warning and limited speed to 62 mph. Power steering failed completely, and braking became ineffective despite hard pedal pressure. Multiple warnings followed: ABS, engine, and others. I was in heavy tr... Read more

Incident date: Nov 7, 2025

Incident date: Aug 15, 2025

Vehicle had no dashboard light indicators. While traveling on highway, started to sound like a motorcycle and decelerate. Pulled over and started to smoke from the hood, exited vehicle and smoke turned to flames. Fire deescalated by Fire Dept. and vehicle is a total loss. All maintenance was UpToDat... Read more

Fire

Incident date: Aug 9, 2023

Incident Date: August 20, 2025 Vehicle: BMW iX (2023 BMW iX XDrive 50 VIN - [XXX] ) On August 20, 2025, I was driving my BMW iX during heavy rain when the vehicle suddenly lost control and hydroplaned. Despite my efforts to steer and brake carefully, the vehicle skidded and hit the divider three ... Read more

Crash

Incident date: Aug 9, 2023

1. Turbo Actuator / Dealer is currently replacing the defective part. 2. When this part fails, you lose throttle control and acceleration capabilities. This part failed on me at highway speeds, and I had to drift over several lanes of high-speed traffic. I was unable to control the speed of my vehi... Read more

Incident date: Aug 9, 2023

After Super Cruise disengages and applies the transition brake, the brake pressure sometimes doesn’t release. The vehicle remains partially or fully braked and won’t roll freely for up to 30 minutes while on a freeway or highway. We are able to move the car to the side of road when this happens ... Read more

Incident date: Oct 1, 2025

April 2025, Vacuum Pump went out meaning lost breaks going 60 miles per hour down the road after engine light came on. Left me and two children stranded 2 hours from home with no way to get back except a tow. Now September 2025 Cam Shafts are out as well as Vacuum Pump. Stranded boyfriend and I two ... Read more

Incident date: Oct 1, 2025

On 8/25/2025 I purchased a used 2015 Chevy Silverado 2500HD from a auto dealer and they had put new tires on the truck that aren't rated for a 2500 HD, I contacted them and they offered me $400 to replace them with the correct tires that cost me $1319.78 they refuse to help me anymore which is putti... Read more

Incident date: Oct 1, 2025

Incident date: Oct 2, 2025

While driving my 2025 Toyota Camry, the infotainment/navigation display screen (center console multimedia system) will randomly and sporadically shut down completely, leaving the screen blank without warning. This has happened multiple times, including while I was backing up and relying on the backu... Read more

Incident date: Sep 18, 2025

The contact owns a 2014 Winnebago Tour. The contact stated that the turn signals were dim and not bright enough while driving at night. There were no warning lights illuminated. The contact linked the failure to NHTSA Campaign Number: 24V733000 (Exterior Lighting). The local dealer was not contacted... Read more

Incident date: Sep 18, 2025

While performing a left-hand U-turn across three lanes and into the far right-hand 4th turning lane, at less than 15mph my 2013 Ram 1500's power steering failed and jerked the wheel out of my hands back towards the neutral position. This action forced me across all the lanes and into the curb on the... Read more

Incident date: Aug 19, 2025

I have contacted a dealer on 3 occasions to help me with an unrepaired recall. I contacted GM directly regarding the recall. They won't look at my truck to determine what needs to be done.

Incident date: Aug 19, 2025

We have a 2021 Kia Seltos. It was purchased 09/2023 as a certified pre-owned vehicle. Purchased from Putnam Chrysler Doge Jeep Kia in Putnam CT. It started using oil, about a quart a week. No oil spill on garage floor. Received notice of recall. We took it to the dealer for the recall in May of 2025... Read more

Incident date: Jul 13, 2025

I drove over a rough patch/bump in the road. A ton of warning messages and failure lights activated on the dash. In addition to the check engine light, there were warnings for electronic stability protection, sway bar disconnect, ABS failure, power steering failure, shift lever malfunction. In addit... Read more

Incident date: Jul 13, 2025

Incident date: Apr 20, 2025

Lead frame issue where truck downshifted hard as I was driving then was stuck in a higher gear. Had to have it towed into Ford for repair. Cost about $2,000

Incident date: Jul 1, 2022

The contact owns a 2017 Ford Explorer. The contact stated while accelerating from a complete stop from a traffic light, the vehicle made an abnormally loud popping sound. The contact exited and inspected the vehicle but could not determine the cause of the failure. The contact stated that upon attem... Read more

Incident date: Jul 1, 2022

The contact owns a 2024 Ford F-250 SD. The contact stated that while the dealer was performing a routine service on the vehicle, the dealer informed the contact that the vehicle was designed with 2 different 4-Wheel Drive hubs, a driver's side automatic hub and a passenger's side dummy hub. The cont... Read more

Incident date: Jan 1, 2021

While driving home from dinner I pulled off from a stop light as normal and shifted from 1st into 2nd then 3rd with zero issues. As I went to shift into 4th it was as if the gear was locked out, thinking there was just something I was missing I tried 5th and was met with the same issue, tried 4th ag... Read more

Incident date: Jan 1, 2021

The multipurpose camera that sits behind the windshield has completely failed, deactivating many automated safety features. The dealer quoted $2700.00 to replace.

Incident date: Jan 1, 2021

The multipurpose camera that sits behind the windshield has completely failed, deactivating many automated safety features. The dealer quoted $2700.00 to replace.

Incident date: Jul 28, 2022

Fuel pump has been recalled on other models but not mine. I have a 2018 audi q5. It had a warranty extension but the previous owner never claimed but if it would have been a recall then I wouldnt be having this problem . Now I have to replace the water pump and pay almost $2k for something that wasn... Read more

Incident date: Mar 27, 2025

Cylinder 1 and Cylinder 3 misfire (Cylinder 3 misfired multiple times, even after attempts to fix it), and now I have a blown head gasket. On more than three separate occasions, my car has either stopped completely in the middle of the road—sometimes on the highway in the fast lane, with cars trav... Read more

Incident date: Mar 26, 2025

on 2/15/2025, while backing out of a driveway at about 7:30PM, the vehicle backed into a parked car directly behind it parked in street. There was no warning signal emitted that an object was behind the car. There was no safety alert on the display. Essentially the vehicle's sensors did not see t... Read more

Crash

Incident date: Jan 27, 2025

We bought the car in January . When going through our regular car wash, we heard a boom on the roof. We looked and saw no damage. Went through again last week and heard it again. We expressed our concern to the manager who sat in the back as we went through again. She held her hand on the roo... Read more

Incident date: Jan 27, 2025

The contact owns a 2014 Chevrolet Silverado 1500. The contact stated that the headliner above the rear window had water stains. The contact stated that as a mechanic, he had inspected the vehicle and diagnosed that the water was leaking from the third brake light. The contact stated that the gasket ... Read more

Incident date: Jan 27, 2025

Dear National Highway Traffic Safety Administration, I am writing to formally report a serious safety issue with my 2024 GMC Sierra 1500 equipped with the 6.2-liter engine. At the time of the incident, my truck had only 17,000 miles on it and had received the two necessary oil changes as recommende... Read more

Incident date: Aug 23, 2024

I have reached out to the dealership several times about the open recall and they keep saying they have to order it and will call me when they receive it. Never got a call back and it’s been months almost and .

Incident date: Aug 23, 2024

Hesitation when trying to accelerate. When I come to a stop sign and hit the gas, there’s always a hesitation

Incident date: Dec 11, 2024

There has been no OTA updates issued to this date for my vehicle. I'm currently on 2.0 awaiting 2.2 update. Because of this I still have issues with braking, rolling while in park, and random and unexpected shutdowns of the vehicle while driving. THIS IS A VERY UNSAFE VEHICLE. PLEASE HELP!

Showing 50 of 74 complaints.

NHTSA Safety Ratings, 2022 LINCOLN AVIATOR

2022 Lincoln Aviator SUV 4WD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	4 / 5 ★★★★☆
Rollover Risk	15.1%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2022 LINCOLN AVIATOR

188 manufacturer communications from 131 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	34
100000 POWER TRAIN	27
350000 EQUIPMENT	16
060000 ENGINE AND ENGINE COOLING	12
220000 SEATS	10
980000 UNKNOWN OR OTHER	9
118000 ELECTRICAL SYSTEM:SOFTWARE	5
353000 EQUIPMENT:ELECTRICAL	4

980000 UNKNOWN OR OTHER

Some 2020-2024 Explorer/Aviator vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). Diagnosis should include checking the

980000 UNKNOWN OR OTHER

Various vehicles have had pinpoint tests, guided routines and the Warranty and Policy Manual recentlyupdated for diagnostics and repairs on SYNC generation 3 and later applications. When performingdiagnostics and repairs on SYNC Gen 3 or la

100000 POWER TRAIN

This article supersedes TSB 24-2059 to update the Service Procedure LTIS statement. Some 2021-2022 F-150, 2022-2023 Expedition/Navigator/Mustang and 2020-2023 Transit/Explorer/Aviator vehicles equipped with a 10R80/10R80MHT transmission may

060000 ENGINE AND ENGINE COOLING

This TSB supersedes TSB 22-2377 to update the vehicle model years affected and Parts List. Some 2020-2023 Explorer vehicles equipped with a 3.0L EcoBoost engine or 2020-2023 Aviator vehicles equipped with a 3.0L EcoBoost or 3.0L PHEV engine

138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Some 2020-2024 Aviator vehicles equipped with auto air refresh option (minor feature code G1DAG) may exhibit a buzzing/clicking/humming/ticking sound from the OHC and/or diagnostic trouble code (DTC) P24AE in the heating ventilation and air

350000 EQUIPMENT

100000 POWER TRAIN

This article supersedes TSB 23-2351 to remove 2023 F-150 10R80 and 10R80 MHT vehicle applications. The 2023 F-150 10R80 and 10R80 MHT vehicles will be the subject of a separate article. Some 2021-2022 F-150, 2022-2023 Expedition/Navigator/M

060000 ENGINE AND ENGINE COOLING

For 2015-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual (WSM), Section 303-00 for oil leak inspection and testing methods. Ford has evaluated turbocharg

115000 ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM

Many body control module C (BCMC) warranty return parts are coming back with no trouble found. To verify that the BCMC is at fault prior to replacing, perform the following. First, disconnect the battery then check all BCMC connectors for t

100000 POWER TRAIN

During service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the tim

110000 ELECTRICAL SYSTEM

Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass??A?/LincolnWay??A? app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected

110000 ELECTRICAL SYSTEM

This article supersedes TSB 23-2208 to add 2024 model year vehicles. Some 2020-2024 Explorer/Aviator non-hybrid vehicles may exhibit radio static and/or poor radio sound quality when moving. This may be more noticeable on AM radio stations.

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

160000 STRUCTURE

This article supersedes TSB 23-2181 to add 2024 vehicle model year. Some 2020-2024 Explorer/Aviator vehicles may exhibit a lack of audio and/or a water leak in the rear liftgate area and/or water in the spare tire area. The customer may ind

350000 EQUIPMENT

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

2022-2024 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2024 Expedition/Navigator vehicles built on or after 08-Jun-2022, 2022-2024 Escape vehicles built on or after 01-Jun-2022 and 2022 Corsair vehicles built on or after 01

350000 EQUIPMENT

160000 STRUCTURE

Some 2020-2024 Aviator vehicles may exhibit concerns that reqiure loadspace trim panel vent register replacement. The vent register is now available separately (service base part number 19893). It is no longer necessary to replace the entir

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some 2020-2024 Explorer/Aviator vehicles may exhibit poor speaker sound quality and/or tick-tock noise while activating turn signals and streaming audio over Bluetooth. Customers may describe static heard during a Bluetooth phone call or a

980000 UNKNOWN OR OTHER

Certain 2021 - 2023 Model Year Aviator Vehicles Equipped With SYNC - Reprogram Accessory Protocol Interface Module Owner letter submitted 09/06/23

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Certain 2021 - 2023 Model Year Aviator Vehicles Equipped With SYNC - Reprogram Accessory Protocol Interface Module Owner letter submitted 09/06/23

110000 ELECTRICAL SYSTEM

Some 2020-2023 Explorer/Aviator vehicles equipped with all-wheel drive (AWD) may exhibit an illuminated powertrain malfunction (wrench) indicator and/or 4WD Fault Service Required message with diagnostic trouble codes (DTCs) C00A6:71, C00A6

100000 POWER TRAIN

Some 2021-2023 F-150, 2022-2023 Expedition/Navigator, 2022-2023 Mustang, 2020-2023 Transit, 2020-2023 Explorer/Aviator vehicles equipped with a 10R80/10R80MHT transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, a

118000 ELECTRICAL SYSTEM:SOFTWARE

Certain 2021 - 2023 Model Year Aviator Vehicles Equipped With SYNC - Reprogram Accessory Protocol Interface Module

100000 POWER TRAIN

Some 2020-2023 Explorer/Aviator and 2021-2023 Bronco vehicles equipped with a 10R60 transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code

060000 ENGINE AND ENGINE COOLING

This article supersedes TSB 23-2279 to update the Service Procedure. Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost hybrid engine, 2020-2023 Explorer vehicles equipped with a 3.3L hybrid engine and 2020-2023 Aviator vehicles

350000 EQUIPMENT

353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)

Some 2019-2020 Edge/F-150/Fusion/Continental/MKZ/Nautilus, 2019-2021 Mustang/Ranger/Transit Connect, 2020-2021 EcoSport/Escape/Expedition/Explorer/F-Super Duty/Aviator/Corsair/Navigator, 2021 Bronco Sport and 2020-2022 Explorer/Aviator vehi

980000 UNKNOWN OR OTHER

118000 ELECTRICAL SYSTEM:SOFTWARE

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

100000 POWER TRAIN

Some 2020-2023 Explorer/Aviator vehicles equipped with a 10R80 MHT transmission may exhibit an illuminated powertrain malfunction (wrench) lamp with diagnostic trouble code (DTC) P084B stored in the PCM. The Workshop Manual (WSM) has recent

100000 POWER TRAIN

Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmissi

100000 POWER TRAIN

Some 2020-2023 Explorer/Aviator all-wheel drive (AWD) vehicles with a hybrid powertrain may experience a harshness and/or vibration felt through the seat, steering wheel and/or center console at 25-50 mph (40-80 km/h). This may be due to co

350000 EQUIPMENT

Some vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash,

110000 ELECTRICAL SYSTEM

Some 2022 Explorer/Aviator vehicles may exhibit an intermittent passenger seat massage function with no diagnostic trouble codes (DTCs). This may be due to the configuration of the seat control module G (SCMG) and seat control module H (SCM

100000 POWER TRAIN

Some 2021-2023 F-150 vehicles equipped with a 3.5L hybrid engine, 2020-2023 Explorer vehicles equipped with a 3.3L hybrid engine and 2020-2023 Aviator vehicles equipped with a 3.0L hybrid engine may exhibit a powertrain malfunction indicato

110000 ELECTRICAL SYSTEM

Some 2020-2022 Aviator/Explorer Hybrid vehicles may exhibit a concern where the EV power flow does not display in the center display screen. This may be due to the SYNC module (APIM) software. Download and run the APIM-SYNC Module (APIM) St

280100 BACK OVER PREVENTION:SOFTWARE

Certain 2021 - 2023 Model Year Aviator Vehicles Equipped With SYNC - Reprogram Accessory Protocol Interface Module

060000 ENGINE AND ENGINE COOLING

2020-2023 Explorer non-hybrid vehicles and equipped with a 3.0L EcoBoost or 3.3L Duratec engine and 2020-2023 Aviator non-hybrid vehicles equipped with a 3.0L EcoBoost engine built on or before 01-Jan-2023 may exhibit an exhaust rattle requ

100000 POWER TRAIN

This article supersedes TSB 22-2428 and 23-2176 to update the Issue, Action and Service Procedure. Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehic

110000 ELECTRICAL SYSTEM

In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app thr

063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR

2020-2023 Explorer non-hybrid vehicles equipped with a 3.0L EcoBoost or 3.3L Duratec engine and 2020-2023 Aviator non-hybrid vehicles equipped with a 3.0L EcoBoost engine may exhibit an exhaust rattle requiring replacement of the left or ri

063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE

081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

110000 ELECTRICAL SYSTEM

Some 2020-2023 Explorer/Aviator vehicles may exhibit poor speaker sound quality and/or tick-tock noise while activating turn signals and streaming audio over Bluetooth. Customers may describe static heard during a Bluetooth phone call, or a

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

162300 STRUCTURE:BODY:DOOR

Some 2020-2023 Aviator vehicles built on or before 12-Oct-2022 may exhibit a door ajar or door fault warning message present in the message center with diagnostic trouble codes (DTCs) B1175:19, B1176:19, B11C0:19 and/or B11C1:19 present in

118000 ELECTRICAL SYSTEM:SOFTWARE

110000 ELECTRICAL SYSTEM

Some 2020-2023 Explorer/Aviator non-hybrid vehicles may exhibit radio static and/or poor radio sound quality when moving. This may be more noticeable on AM radio stations. This may be caused by an electromagnetic interference concern. To co

350000 EQUIPMENT

353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

110000 ELECTRICAL SYSTEM

Some 2021-2023 Ford and Lincoln vehicles may exhibit a condition where the high voltage battery stops charging when connected to level 1 or level 2 chargers with an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (D

220000 SEATS

Some 2020-2023 Explorer/Aviator vehicles may have a concern where the second row outboard manual/power seats do not fold, exhibit excess effort to fold, or do not slide forward/backward easily. Power or manual second row seats must be pushe

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

Some 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPassA?/LincolnWayA? app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if

100000 POWER TRAIN

Some 2020-2023 Aviator/Explorer vehicles equipped with a 3.0L hybrid engine may exhibit illuminated powertrain malfunction (wrench) indicator and stop safely now warning. Diagnostic trouble code (DTC) P0AA6:00 may be stored in the battery e

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

TSB 22-2428 is missing some labor operations. For any missing labor operations, claim available new model labor operations or m-time. Refer to this article on the repair order. When replacing the CDF cylinder, the current TSB does not requi

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

980000 UNKNOWN OR OTHER

100000 POWER TRAIN

Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehicles equipped with a 10R60 transmission and built on or before 23-Dec-2022 or with a 18R80/10R80MHT

060000 ENGINE AND ENGINE COOLING

Some 2021-2023 Ford and Lincoln vehicles equipped with a 2.7L or 3.0L engine may exhibit an upper engine thump/knock noise coming from the left cylinder head. This condition is most noticeable at idle and may lessen at higher engine speed o

100000 POWER TRAIN

Some 2022 Aviator/Bronco/Expedition/Explorer/F-150/Mustang/Navigator/Ranger/Transit vehicles built on or before 31-Jul-2022 equipped with a 10R60/10R80/10R80 MHT automatic transmission may exhibit a fluid leak from the selector shaft seal.

020000 SUSPENSION

Some 2020-2023 Aviator vehicles equipped with air suspension may require service of a front air spring/strut. Complete front air spring/strut assemblies are now available and can be replaced instead of replacing individual components of the

020000 SUSPENSION

Some 2020-2023 Aviator vehicles equipped with air suspension may exhibit a drive malfunction and/or suspension fault message in the instrument panel cluster (IPC) with diagnostic trouble codes (DTCs) B1041 and U2100 stored in the SUMA. This

350000 EQUIPMENT

2022-2023 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2023 Expedition/Navigator vehicles built on or after 08-Jun-2022 and 2022 Escape/Corsair vehicles built on or after 01-Jun-2022 are no longer equipped with a hands free

160000 STRUCTURE

For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification numbe

162300 STRUCTURE:BODY:DOOR

Some 2020-2023 Aviator vehicles built on or before 20-March-2023 may exhibit a passenger door window control switch to bezel rattle while audio volume is playing from speakers that could be mistakenly diagnosed as a speaker issue. This may

100000 POWER TRAIN

Some 2020-2023 Explorer/Aviator/Transit, 2021-2023 F-150/Bronco, 2022-2023 Expedition/Navigator/Mustang and 2023 F-250/F-350 Super Duty vehicles may exhibit harsh/delayed engagement and/or harsh/delayed shift concerns. These may be addresse

110000 ELECTRICAL SYSTEM

2020-2023 Explorer/Aviator with start/stop push button ignition switch may exhibit an illuminated malfunction indicator lamp (MIL) and powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) B108A:01 (general electrical

110000 ELECTRICAL SYSTEM

353000 EQUIPMENT:ELECTRICAL

100000 POWER TRAIN

Some 2020-2023 Explorer/Aviator 4x4/AWD vehicles with hybrid powertrain may experience a harshness and/or vibration felt through the seat, steering wheel and/or center console after initial driveaway between 25-50 MPH (40-80 Km/h) that less

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Certain 2022 Model Year Aviator Invoiced with Hands-Free Liftgate Incorrect Window Label Owner Letter

355100 EQUIPMENT:OTHER:LABELS

Certain 2022 Model Year Aviator Invoiced with Hands-Free Liftgate Incorrect Window Label Owner Letter

100000 POWER TRAIN

Some 2022 Explorer/Aviator/Bronco vehicles built on or before 9-Aug-2022 and equipped with a 10R60 automatic transmission may exhibit a harsh 7-6 gear downshift. This may be caused by the A clutch piston return spring snap ring becoming dis

160000 STRUCTURE

Certain 2022 Model Year Aviator Invoiced with Hands-Free Liftgate Incorrect Window Label

162600 STRUCTURE:BODY:HATCHBACK/LIFTGATE

Certain 2022 Model Year Aviator Invoiced with Hands-Free Liftgate Incorrect Window Label

350000 EQUIPMENT

Certain 2022 Model Year Aviator Invoiced with Hands-Free Liftgate Incorrect Window Label

355100 EQUIPMENT:OTHER:LABELS

Certain 2022 Model Year Aviator Invoiced with Hands-Free Liftgate Incorrect Window Label

350000 EQUIPMENT

Some vehicles equipped with a 2.7L, 3.0L,3.5L or 5.0L engine may require replacement of the long block engine assembly. New service kits have been released which include all the one-time-use components required in the service procedure for

110000 ELECTRICAL SYSTEM

Some 2020-2023 Explorer/Aviator vehicles may exhibit the A/C blowing warm air with DTCs P0645, P2CFC, and/or P2CFD present in the heating ventilation and air conditioning (HVAC) module. This may be due to spread terminal/terminal pushout in

110000 ELECTRICAL SYSTEM

Some 2020-2023 Aviator vehicles may exhibit a concern where the center display screen will not shift to night mode or has lines on the center display screen with multi color or rainbow hue. This may be due to accessory protocol interface mo

284100 BACK OVER PREVENTION:DISPLAY FUNCTION

100000 POWER TRAIN

2020-2022 Aviator/Explorer/Police Interceptor, 2021-2022 F-150 vehicles equipped with a 10R80 MHT transmission and built on or before 15-Nov-2022 may exhibit an 8th gear start after coming to a stop and/or a no movement in Reverse condition

110000 ELECTRICAL SYSTEM

Some 2018-2023 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

Some 2020-2022 Aviator vehicles may exhibit a concern where the center display screen will not shift to night mode or has lines on the center display screen with multi color or rainbow hue. This may be due to accessory protocol interface mo

100000 POWER TRAIN

Some 2020-2023 Explorer/Aviator/Police Interceptor Utility vehicles equipped with a hybrid powertrain may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P2D40. This may be due to the high voltage

220000 SEATS

2022-2023 Lincoln Aviator vehicles equipped with multi-contour front seats have driver seat control module G (SCMG) and passenger seat control module H (SCMH) seat modules available separately at a lower level service part from the seat bac

135200 VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR

350000 EQUIPMENT

081100 FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

This article supersedes TSB 22-2176 to increase the labor operation allowance and update the part list. Some 2020-2022 Escape/Corsair vehicles built on or before 3-Jan-2022, 2020-2022 Explorer vehicles built on or before 14-Feb-2022, 2020-2

030000 BRAKES (PWS)

Some Ford and Lincoln vehicles may exhibit noise when the brakes are applied. When diagnosing and repairing brake noise conditions, use the Workshop Manual (WSM) and the appropriate pinpoint test in section 206-00. The brake rotors should o

346000 COMMUNICATION:MANUFACTURER TELEMATICS

Some 2020-2023 Ford and Lincoln vehicles equipped with a telematic control unit (TCU) may exhibit inoperative remote features via Ford Pass/Lincoln Way mobile app, incomplete user authorization, and/or modem electronic serial number (ESN) c

110000 ELECTRICAL SYSTEM

Some 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles may exhibit courtesy lamps not illuminating with a door open or always on. Also, ambient lighting may be inoperative or always on. If this concern occurs, check the cente

220000 SEATS

Some 2022 Aviator vehicles built on 19-Apr-2022 and through 11-Jul-2022 may exhibit the seat lumbar settings not populating in the center display screen. The customer may also indicate that the headrest moves the opposite way of the front s

Showing 100 of 188 bulletins.

LINCOLN AVIATOR - All Years Overview

Complete safety history for the LINCOLN AVIATOR across all model years (2003, 2027).

127 Total Recalls

725 Total Complaints

0 Investigations

29 Reported Crashes

5 Reported Fires

0 Reported Deaths

LINCOLN AVIATOR - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2027	2	0	View
2026	6	3	View
2025	15	24	View
2024	8	7	View
2023	16	37	View
2022 (current)	21	74
2021	28	62	View
2020	30	173	View
2005	0	62	View
2004	0	115	View
2003	1	168	View

Other LINCOLN Models

Model	Recalls	Complaints
NAVIGATOR	549	1,731	View
MKX	365	1,718	View
MKZ	351	1,974	View
CORSAIR	266	204	View
TOWN CAR	125	4,351	View
NAUTILUS	112	229	View
ZEPHYR	111	289	View
MKC	102	666	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2022 LINCOLN AVIATOR

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2022 LINCOLN AVIATOR

Safety Technology

Technical Service Bulletins, 2022 LINCOLN AVIATOR

Most Affected Components

LINCOLN AVIATOR - All Years Overview

LINCOLN AVIATOR - Year by Year

Other LINCOLN Models