2004 INTERNATIONAL 8600
6 recalls, 0 complaints - 98 TSBs
23V353000 May 18, 2023
EXTERIOR LIGHTING:BACK UP LIGHTS
Defect Description
Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 99... Read more
Consequence
Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy
Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.
05V567000 Dec 21, 2005
ENGINE AND ENGINE COOLING
Defect Description
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE ENGINE ELECTRICAL GROUND CABLE THAT CONNECTS THE ENGINE BLOCK WITH THE STARTER MAY BE ROUTED IN A WAY THAT COULD CAUSE CHAFING AGAINST THE STARTER'S POSITIVE BATTERY CABLES.
Consequence
IF CHAFING OCCURS BETWEEN THE POSITIVE AND NEGATIVE CABLES, AN ELECTRICAL SHORT MAY RESULT AND MAY CAUSE A VEHICLE FIRE, POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy
DEALERS WILL INSPECT THE ENGINE GROUND CABLES FOR PROPER ROUTING. IF ANY CHAFING IS FOUND, THE ENGINE BLOCK GROUND CABLE WILL BE REPLACED WITH A SHORTER (280MM) CABLE AND ANY OTHER DAMAGED CABLES WILL BE REPLACED AND ROUTED CORRECTLY FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 21, 2005. OWNERS M... Read more
05V188000 Apr 28, 2005
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Defect Description
ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.
Consequence
IF THE SLIDE CONTROL ACTUATES WHILE THE VEHICLE IS IN MOTION, MOMENTUM FROM THE TRAILER CAN CAUSE THE FIFTH WHEEL TO SLIDE WITHOUT INPUT FROM THE DRIVER, WHICH COULD RESULT IN A CRASH WITHOUT WARNING.
Remedy
DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-4... Read more
04V569000 Dec 3, 2004
STRUCTURE
Defect Description
ON CERTAIN TRUCKS, THE BOLTS THAT MOUNT THE FRONT OF THE CAB TO THE MOUNTING BRACKETS WERE NOT PROPERLY TORQUED AT THE MANUFACTURING PLANT.
Consequence
THESE BOLTS CAN LOOSEN DURING NORMAL VEHICLE USE AND FALL OUT. THIS MAY LEAD TO THE CAB SEPARATING FROM THE VEHICLE'S CHASSIS DURING A VEHICLE CRASH THAT MAY RESULT IN PROPERTY DAMAGE, PERSONAL INJURY OR DEATH.
Remedy
AS AN INTERIM ACTION, DEALERS WILL PROPERLY TIGHTEN THE EXISTING CAB MOUNTING BOLTS AND REPLACE ANY MISSING BOLTS. AS SOON AS PARTS ARE AVAILABLE, DEALERS WILL REPLACE ALL SIXTEEN BOLTS AND TIGHTEN THEM PROPERLY. AN INTERIM LETTER WAS SENT TO OWNERS ON FEBRUARY 11, 2005. ANOTHER LETTER WAS SENT ... Read more
04V306000 Jun 30, 2004
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
Defect Description
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH INTERNATIONAL DT530, CUMMINS, OR CATERPILLAR I-6 ENGINES, THE POSITIVE BATTERY CABLE BETWEEN THE BATTERIES AND THE STARTER MAY RUB AGAINST AN ELECTRICAL GROUND CABLE BETWEEN THE STARTER AND FRAME RAIL.
Consequence
THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.
Remedy
DEALERS WILL INSPECT FOR ANY CHAFING. IF THERE IS NO EVIDENCE OF CHAFING, A SADDLE CLAMP WILL BE INSTALLED. IF THERE IS EVIDENCE OF CHAFING, THE DAMAGED CABLES WILL BE REPLACED AND THE SADDLE CLAMP INSTALLED. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7... Read more
04V193000 Apr 22, 2004
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Defect Description
CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SEAT BELT LATCH FAILED A QUALITY REVIEW.
Consequence
THIS COULD CAUSE THE SEAT BELT LATCH TO BECOME DISENGAGED WITHOUT WARNING IN A VEHICLE CRASH OR DURING EPISODES OF HIGH SEAT BELT LOADING.
Remedy
DEALERS WILL REPLACE THE SEAT BELT ASSEMBLIES. OWNER NOTIFICATION IS BEGAN ON JUNE 11, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-445-7825.
No complaints found for this vehicle.
Technical Service Bulletins, 2004 INTERNATIONAL 8600
98 manufacturer communications from 56 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 110000 ELECTRICAL SYSTEM | 19 |
| 060000 ENGINE AND ENGINE COOLING | 10 |
| 118000 ELECTRICAL SYSTEM:SOFTWARE | 9 |
| 350000 EQUIPMENT | 7 |
| 060000 ENGINE (PWS) | 6 |
| 010000 STEERING | 5 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 5 |
| 020000 SUSPENSION | 4 |
IK0800407
Feb 21, 2024
110000 ELECTRICAL SYSTEM
Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
IK0800407
Feb 21, 2024
060000 ENGINE AND ENGINE COOLING
Starter Diagnostics and warranty claim procedure; all engines EXCLUDING Cummins ISB engine with Allison transmission or PSI engine.
IK0200013
Feb 21, 2024
020000 SUSPENSION
Suggested alignment target values when performing a vehicle axle alignment.
IK0200013
Feb 21, 2024
010000 STEERING
Suggested alignment target values when performing a vehicle axle alignment.
IK0800351
Nov 21, 2023
110000 ELECTRICAL SYSTEM
J1939 Data Link Source Address Information
IK0300010
Sep 29, 2023
020000 SUSPENSION
Diagnosis of chassis wander complaints.
IK0300010
Sep 29, 2023
010000 STEERING
Diagnosis of chassis wander complaints.
IK0400040
Sep 26, 2023
030000 BRAKES (PWS)
General Wheel Speed Sensor Troubleshooting
IK2600069
Sep 7, 2023
060000 ENGINE AND ENGINE COOLING
How to request a horsepower quote; all International and Cummins engines
IK0800407
Mar 15, 2023
060000 ENGINE AND ENGINE COOLING
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
IK0800407
Mar 15, 2023
110000 ELECTRICAL SYSTEM
Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions
IK0800351
Nov 16, 2022
110000 ELECTRICAL SYSTEM
J1939 Data link source address information
IK1201472
Sep 29, 2022
060000 ENGINE AND ENGINE COOLING
Pico Scope CCOS (Crankcase Separator Test)
IK0800605
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test 5V & 12V Intermittent Open and Short circuit diagnostics
IK1201469
Aug 23, 2022
060000 ENGINE AND ENGINE COOLING
PicoScope Test One Channel RCT
IK0800607
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test - Battery Loss of Charge - Parasitic Draw Test
IK0800610
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test Resistance and Ohmmeter
IK0800609
Aug 23, 2022
110000 ELECTRICAL SYSTEM
PicoScope Test for Datalink (CAN) Health Shorts & opens
IK2600052
Mar 14, 2022
117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
Calculating pulses per mile (speedometer setting); only models equipped with International engines
IK2600052
Mar 14, 2022
110000 ELECTRICAL SYSTEM
Calculating pulses per mile (speedometer setting); only models equipped with International engines
IK0800351
Feb 10, 2022
350000 EQUIPMENT
J1939 Data Link Source Address Information
IK0800351
Feb 10, 2022
110000 ELECTRICAL SYSTEM
J1939 Data Link Source Address Information
IK0800080
Nov 2, 2021
110000 ELECTRICAL SYSTEM
J1939 Data Link Troubleshooting
IK1000003
Nov 2, 2021
010000 STEERING
Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps
IK1201299
Sep 30, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
IK1201299
Sep 30, 2021
060000 ENGINE AND ENGINE COOLING
Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines
IK1600131
Aug 10, 2021
160000 STRUCTURE
Cab water leak troubleshooting tips
IK0400040
Jul 19, 2021
040000 SERVICE BRAKES, AIR
General wheel speed sensor troubleshooting
IK0400040
Jul 19, 2021
030000 SERVICE BRAKES, HYDRAULIC
General wheel speed sensor troubleshooting
IK0700112
Jun 4, 2021
060000 ENGINE AND ENGINE COOLING
Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems
IK0100051
Mar 15, 2021
160000 STRUCTURE
Frame Rail Straightness Inspection Procedure
IK0200013
Mar 4, 2021
020000 SUSPENSION
Suggested alignment target values when performing a vehicle axle alignment
IK1600233
Oct 9, 2020
160000 STRUCTURE
Cab Lean Concern
IK1600233
Oct 9, 2020
350000 EQUIPMENT
Cab Lean Concern
IK1600233
Oct 9, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
Cab Lean Concern
IK1400005
Aug 25, 2020
060000 ENGINE (PWS)
Driveline Information Center and Troubleshooting Procedures
IK1400005
Aug 25, 2020
350000 EQUIPMENT
Driveline Information Center and Troubleshooting Procedures
IK0800504
Aug 3, 2020
060000 ENGINE (PWS)
Repair Procedures for Vehicles Struck by Lightning
IK0800504
Aug 3, 2020
110000 ELECTRICAL SYSTEM
Repair Procedures for Vehicles Struck by Lightning
IK0800504
Aug 3, 2020
100000 POWER TRAIN
Repair Procedures for Vehicles Struck by Lightning
IK1900022
Jun 18, 2020
061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION
A/C Refrigerant and Oil Capacities
IK1600258
Mar 26, 2020
980000 UNKNOWN OR OTHER
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
350000 EQUIPMENT
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
220000 SEATS
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
170000 LATCHES/LOCKS/LINKAGES
Cleaning and Disinfecting Trucks and Buses
IK1600258
Mar 26, 2020
150000 SEAT BELTS
Cleaning and Disinfecting Trucks and Buses
IK0800080
Feb 27, 2020
110000 ELECTRICAL SYSTEM
J1939 Data Link Troubleshooting
IK0400159
Jan 13, 2020
030000 SERVICE BRAKES, HYDRAULIC
Bendix EC80 Blank Module Replacement Program; This document will guide the user through selecting the correct ABS module when it has been determined a replacement is needed. Only Models with EC-80 ABS Controller
IK0800533
Dec 19, 2019
350000 EQUIPMENT
Key Codes and Key Cutting Information (Not for CV Series)
IK0800533
Dec 19, 2019
110000 ELECTRICAL SYSTEM
Key Codes and Key Cutting Information (Not for CV Series)
IK1201299
Sep 9, 2019
060000 ENGINE AND ENGINE COOLING
Oil Capacities; All Electronic International Engines 1994 - Present. Cummins ISB, ISM & ISX
IK1600094
Aug 6, 2019
176100 LATCHES/LOCKS/LINKAGES:HOOD:LATCH
8600/TranStar Hood Latches Do Not Fit Correctly. Only models that have had or will have the hood latches and/or the fender extensions replaced.
IK1600094
Aug 6, 2019
160000 STRUCTURE
8600/TranStar Hood Latches Do Not Fit Correctly. Only models that have had or will have the hood latches and/or the fender extensions replaced.
IK1400023
Jul 15, 2019
020000 SUSPENSION
Suspension Lean Diagnostics; All models
IK0800351
Jun 26, 2019
110000 ELECTRICAL SYSTEM
J1939 Data Link Source Address Information
IK1400005
Nov 13, 2018
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Driveline Information Center and Troubleshooting Procedures
IK1400005
Nov 13, 2018
350000 EQUIPMENT
Driveline Information Center and Troubleshooting Procedures
IK1400005
Nov 13, 2018
105000 POWER TRAIN:DRIVELINE
Driveline Information Center and Troubleshooting Procedures
4328530R1
Nov 1, 2018
110000 ELECTRICAL SYSTEM
Tool Instruction - BCM Programming Harness
4328530R1
Nov 1, 2018
350000 EQUIPMENT
Tool Instruction - BCM Programming Harness
IK1201299
Sep 20, 2018
060000 ENGINE (PWS)
Engine Oil Capacities All Electronic International Engines 1994 - Present. Cummins ISB, ISM & ISX
IK0800475
Sep 17, 2018
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Radio Diagnostics and Information
IK1900022
Sep 6, 2018
060000 ENGINE (PWS)
A/C Refrigerant and Oil Capacities
IK4300001
Jan 30, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
Updating OnCommand Link with Accelerator
IK0800080
Jan 22, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
J1939 Data Link Troubleshooting
IK1200921
Jan 22, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
ISX, N13, and N9 / N10 Aftertreatment Private Data Link Troubleshooting
IK1201009
Jan 19, 2018
060000 ENGINE (PWS)
Winter Front Usage
IK1201299
Jan 18, 2018
060000 ENGINE (PWS)
Engine Oil Capacities
IK2700100
Jan 10, 2018
118000 ELECTRICAL SYSTEM:SOFTWARE
OnCommand EZ-Tech
IK2500511
Dec 8, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
Using Supplier Software to Check DTCs
IK0800341
Nov 9, 2017
110000 ELECTRICAL SYSTEM
Trailer Auxiliary Switch Lamp Burning Out; Only Vehicles Equipped with Feature Code 0008TTH or 0008THG
IK0700097
Sep 22, 2017
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
IK0700097
Sep 22, 2017
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
NEW Ultrasonic DEF Tank Sending Unit; only models with SCR Aftertreatment system.
IK0700096
Sep 5, 2017
110000 ELECTRICAL SYSTEM
Urea Quality Sensor (UQS) Supplemental Diagnostic and Service Information; only models with SCR Aftertreatment system and N9, N10, N13, A26 or Cummins ISB, ISL, ISX engines built from January 2016
IK0800546
Sep 1, 2017
060000 ENGINE AND ENGINE COOLING
HVAC fault 2609-19 with 4th Gen BCM; Only models equipped with 4th generation BCM
IK1900022
Jun 30, 2017
357100 EQUIPMENT:APPLIANCE:AIR CONDITIONER
A/C Refrigerant and Oil Capacities
IK2900030
Jun 29, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
Dealer EZ-Tech and Diagnostic Software Support Resource Center
IK0800080
Jun 28, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
J1939 Data Link Troubleshooting
IK1201363
Jun 27, 2017
070000 FUEL SYSTEM, GASOLINE
CPA Injector Misfire Detection; Only models with 2004 thru 2017 International engines.
IK2700100
Jun 21, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
OnCommand EZTech
IK1201360
Jun 7, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Cylinder Performance Analyzer (CPA) Resource Center; Only models with 2004 thru 2017 International engines.
IK2700090
Jun 5, 2017
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
OnCommand EZ-Tech Download Center
IK0500038
Jan 30, 2017
010000 STEERING
Steering Shake, Shimmy, Shudder, or Steering Vibration; only with 14k front weight rated axles and below
IK0500058
Jan 23, 2017
010000 STEERING
Steering Fluids
IK0800080
Jan 12, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
J1939 Data Link Troubleshooting
IK0800351
Jan 9, 2017
118000 ELECTRICAL SYSTEM:SOFTWARE
J1939 Data Link Source Address Information
IK1201248
Jan 3, 2017
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
Cooling System Flush Procedure
IK1200029
Jul 25, 2016
062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
RADIATOR INTERNAL RESTRICTION AND FLUSH PROCEDURE
IK-1500051
Mar 23, 2016
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
IK1500051 - DAVCO FUEL PRO 382 TECHNICAL MANUAL, INSTALLATION, DIAGNOSTICS, AND SERVICE
IK0800080
Oct 1, 2014
353000 EQUIPMENT:ELECTRICAL
J1939 Data Link Troubleshooting
IK 1300064
Jun 20, 2014
102200 POWER TRAIN:MANUAL TRANSMISSION:FLOOR SHIFT ASSEMBLY
INTERNATIONAL: MANUAL SHIFT LEVER JUMPS OUT OF GEAR ON 7000'S AND 8000'S VEHICLES. 7600 (1/1/02-2/1/08); 7700 (1/1/04-2/1/08): 8600 (1/1/02-2/1/08). *PE UPDATED 10/21/14. *PE
IK0900007
Dec 13, 2013
060000 ENGINE AND ENGINE COOLING
Ethylene Glycol Coolant Color Change to be Phased-In Approximately April 1, 2004
AFC-09902
Apr 1, 2009
063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
NAVISTAR: IN EXTREMELY COLD WEATHER CONDITIONS, THE CRANKCASE BREATHER OUTLET TUBE AND ENGINE RETARDER CONTROL VALVE SENSOR TUBE MAY FREEZE IN SOME OF THE VEHICLES. IF BREATHER TUBE FREEZES, THE INCREASED CRANKCASE PRESSURE CAN RESULT IN VA
IK0800172
Feb 25, 2009
114400 ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
NAVISTAR: VARIOUS TYPES OF VEHICLES INCLUDING LONESTAR, PROSTAR, 8600, AND 7600 VEHICLES WILL NEED AN OPERATION TO IMPROVE THE CAB CIRCUIT GROUNDS. 7/17/15 *TA
0508
Jan 28, 2005
061000 ENGINE AND ENGINE COOLING:ENGINE
SOME UNITS MAY EXPERIENCE THE AIR RESTRICTION GAUGE FALLING OUT OF ITS PUSH TO CONNECT MOUNTING. *TT
0438
Jun 22, 2004
110000 ELECTRICAL SYSTEM
HVAC SETTING FAULT CODE 613-14-1-6 PREMATURELY. *MJ
041603
Jun 1, 2004
135000 VISIBILITY:REARVIEW MIRRORS/DEVICES
DESIGN CHANGES TO SIDE MOUNTED MIRRORS FOR HPV MODELS. *MJ
031220
Jun 1, 2004
061000 ENGINE AND ENGINE COOLING:ENGINE
ETHYLENE GLYCOL COOLANT COLOR CHANGE TO BE PHASED - IN APPROXIMATELY APRIL 1, 2004. *MJ
NHTSA Safety Investigations, INTERNATIONAL 8600
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
EQ12011
Opened: Dec 4, 2012 , Closed: Jul 12, 2013
Leaking MGM brake chambers
The summary for this investigation is provided in a separate attachment to this resume.This equipment query is closed.
INTERNATIONAL 8600 - All Years Overview
Complete safety history for the INTERNATIONAL 8600 across all model years (2002, 2018).
50
Total Recalls
3
Total Complaints
1
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
INTERNATIONAL 8600 - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.