ENGINE AND ENGINE COOLING
INTERNATIONAL IS RECALLING 34,993 MY 2006-2008 SCHOOL AND TRANSIT BUSES AND HEAVY DUTY TRUCKS/TRACTORS MANUFACTURED BETWEEN JUNE 1, 2006 AND JUNE 28, 2007, EQUIPPED WITH INTERNATIONAL DT466 OR DT570 ENGINES. THE BASE PLATE OF THE ENGINE OIL COOLER MAY CRACK ALLOWING PRESSURIZED OIL TO LEAK INTO THE ENGINE COMPARTMENT.
Remedy: INTERNATIONAL WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 21, 2008. OWNERS MAY CONTACT INTERNATIONAL AT 800-448-7825.
34,993 vehicles affected
PARKING BRAKE
ON CERTAIN 6X4 OR 6X6 TRUCKS WITH AIR BRAKES OR TRACTORS WITH AIR BRAKES AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Remedy: INTERNATIONAL IS WORKING WITH BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 28, 2007. OWNERS MAY CONTACT BENDIX AT 440-329-9000 AND INTERNATIONAL AT 1-800-448-7825.
10,882 vehicles affected
SUSPENSION:REAR:AXLE:SPINDLE
ON CERTAIN TRUCKS, THE REAR-REAR AXLE BRAKE SLACK ADJUSTERS MAY CONTACT THE REAR AXLE HOUSING PREVENTING THE BRAKES FROM BEING FULLY APPLIED POSSIBLY CAUSING EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE ALL REAR-REAR AXLE BRAKE SPIDERS WITH A SPIDER THAT HAS A DIFFERENT BRAKE GROUP CLOCKING ANGLE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2007. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
230 vehicles affected
TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
ON CERTAIN VEHICLES EQUIPPED WITH AIR OPERATED FIFTH WHEEL SLIDES AND AN MSVA 7-PACK ACCESSORY CONTROLLER, THE 7-PACK CAN ALLOW WATER TO CONTAMINATE ITS CIRCUIT BOARD. THIS COULD RESULT IN INADVERTENT OPERATION OF THE FIFTH WHEEL SLIDE CONTROL.
Remedy: DEALERS WILL RELOCATE THE MSVA 7-PACK TO A LESS WATER INTENSIVE ENVIRONMENT. A NEW MSVA 7-PACK BASE, THAT HAS BEEN IMPROVED TO PREVENT WATER INTRUSION, AND ALL AIR ACCESSORY SOLENOIDS WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 5, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
4,616 vehicles affected
ALL OF THE 2006 INTERNATIONAL 7400 TRUCKS WITH THE DT 570 ENGINE. THAT I HAVE IN MY FLEET(4) HAVE BLOWN THE BLOCK HEATER OUT OF THE ENGINE , DUMPING UP 10 GALLONS OF COOLANT ON THE ROADWAY CAUSING A BIG MESS AND SLIPPERY SURFACE. THE HIGHEST MILEAGE TRUCK I HAVE IS 10162.MI ONE OF THE TRUCKS HAS DONE IT TWICE. *TR
2006 INTERNATIONAL TRUCK CAUGHT ON FIRE IN OUR SERVICE GARAGE. THE VEHICLE WAS UNATTENDED FOR A SHORT TIME BEFORE THE FIRE. THIS HAPPENED DAYS AFTER WE HEARD THAT THE OHIO DEPARTMENT OF TRANSPORTATION NO LONGER PARKS THEIR TRUCKS INSIDE DUE TO FIRES OF THIS NATURE. *TR
Fire