2006 HYUNDAI TRANSLEAD VAN TRAILER

1 recalls — 0 complaints — 6 TSBs

SUSPENSION

Defect Description

ON CERTAIN VAN TRAILERS EQUIPPED WITH TUTHILL TRAILER SUSPENSIONS, MODELS 20/22 AND RS3162, THE BEAM/AXLE PIVOT CONNECTION JOINT IS MIS-ALIGNED CAUSING EXCESSIVE PLAY WITH THE TRAILER ALLOWING THE TRAILER TO WANDER.

Consequence

IF THIS WARNING IS IGNORED, A CRASH COULD RESULT.

Remedy

HYUNDAI TRANSLEAD IS WORKING WITH TUTHILL TO NOTIFY THE OWNERS OF THE AFFECTED VEHICLES AND PROVIDE FREE REMEDY. OWNERS MAY CONTACT TUTHILL AT 800-753-0025 OR HYUNDAI AT 1-619-574-1500.

188 vehicles affected

Manufacturer: HYUNDAI TRANSLEAD

No complaints found for this vehicle.

Technical Service Bulletins — 2006 HYUNDAI TRANSLEAD VAN TRAILER

6 manufacturer communications from 4 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
110000 ELECTRICAL SYSTEM	1
350000 EQUIPMENT	1
190000 TIRES	1
200000 WHEELS	1
030000 BRAKES (PWS)	1
130000 VISIBILITY	1

130000 VISIBILITY

This bulletin provides information regarding condensation related to the accumulated moisture in the headlamp, rear combination lamp, daytime running lamp (DRL), or fog lamp. This TSB illustrates the various causes of condensation inside th

030000 BRAKES (PWS)

This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.

190000 TIRES

This bulletin provides tire vibration service procedures, including how to optimize vehicle vibration performance. For all wheel/tire balance claims, the a??Tire Balance Data Sheeta?? must be fully completed including imbalance and Road For

200000 WHEELS

110000 ELECTRICAL SYSTEM

This bulletin provides information on identifying dealer stock vehicles with either: a?? A Battery SOC alert - low Battery State of Charge (SOC) at or below 50%. a?? A 30 Day alert - vehicle has not started and reported an SOC in 30 days.

350000 EQUIPMENT

NHTSA Safety Investigations — HYUNDAI TRANSLEAD VAN TRAILER

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

DP — Closed — Model Year: 2015

Semi-Trailer Side Underride Guards

The Office of Defects Investigation (ODI) received a petition from Eric Hein, Director of the Institute for Safer Trucking dated July 3, 2024, requesting an investigation of all van-type (also known as box) semi-trailers due to collisions with passenger vehicles and other vulnerable road users (pede... strians, bicyclists, or motorcyclists) resulting in significant injuries or death due to the lack of side underride guards (SUGs). On August 26, 2024, NHTSA opened Defect Petition DP24004 to evaluate the petitioner’s request. No trailer manufacturer or equipment supplier was identified as the specific subject of the petition. The petition itself can be reviewed at NHTSA.gov under ODI Number 11599188. Currently, a Federal Motor Vehicle Safety Standard (FMVSS) requiring side underride guards on semi-trailers does not exist. The petitioner contends that a failure to include side underride guards equates to a safety defect in the semi-trailer’s design, construction and performance. ODI was petitioned in 2021 for this same issue and, after evaluation, denied the request (DP21004). The petitioner here states that evidence of SUG effectiveness to prevent fatalities and mitigate serious injuries “has continued to accumulate” since the denial of DP21004. The petitioner also alleges that “[d]espite a high severity of risk resulting in frequent severe or fatal injuries from side underride crashes, NHTSA has taken no action to investigate recalling semi-trailers without SUGs.” Pursuant to the Infrastructure Investment and Jobs Act (IIJA), NHTSA published an Advanced Notice of Proposed Rulemaking that summarized and requested comment on a 2022 NHTSA report with an analysis of potential effects of a requirement for side underride guards on new trailers and semitrailers. 88 Fed. Reg. 24536 (Apr. 21, 2023). NHTSA’s Office of Rulemaking is currently reviewing over 2,000 comments received. Also pursuant to the IIJA, on June 18, 2024, the NHTSA-facilitated Advisory Committee on Underride Protection (ACUP) issued its biennial report to Congress and the Secretary of Transportation. This biennial report consists of a majority report and a minority report summarizing its work to provide advice and recommendations to the Secretary on safety regulations related to underride crashes that have caused severe injury and death. Though the committee’s charter was extended through June 2025, the committee concluded its work following the publication of the biennial report in June 2024. In addition, NHTSA previously announced several actions related to truck trailer underride safety, including improving data collection of underride crashes by recommending inclusion of underride data in state crash data systems and by providing educational materials to state and local police departments on identifying and recording underride crashes. ODI also actively participates in the Commercial Vehicle Safety Alliance (CVSA) events where it has encouraged law enforcement to report underride crashes, and proposed CVSA focus on underride guards during the 2024 Operation Road Check, a nationwide 72-hour safety blitz. NHTSA is, further, conducting research on rear impact guard designs that better protect occupants of passenger vehicles in even more rear underride crash scenarios. And NHTSA, with the Federal Motor Carrier Safety Administration, published a pamphlet in August 2022—which was distributed to law enforcement through various channels—that explains how to identify and record such crashes (this pamphlet is available at https://www.nhtsa.gov/sites/nhtsa.gov/les/2022-08/Underride-Crash- Pamphlet_071522_v6atag.pdf). ODI searched its databases and found no injury or fatality trend specific to any make, model, or model year trailer within Vehicle Owner Questionnaire (VOQ) and Early Warning Reporting (EWR) data and found one EWR report of vulnerable road user injury or fatalities. ODI also met, separately, with Utility Trailer Manufacturing Co. (UTM) and Auto Haulers Association of America regarding UTM’s SUG and to better understand the operational environment of low clearance vehicles, respectively. Based on the information available to the agency, trailer manufacturers continue to pursue side underride guard technology, and at least one manufacturer is currently offering an optional guard. The petitioner submitted two documents to ODI on September 11, 2024. The first was a letter from UTM to Marianne Karth (Petitioner of DP21004 & DP22004) which recounted UTM’s testing of SUGs. The second document was an information sheet generated by the petitioner contesting UTM’s claims. The petitioner also submitted certain documents to ODI on October 1, 2024, which the petitioner had previously submitted separately as part of comments on a collection of information pertaining to Reporting and Documents About Potential Defects (Docket No. NHTSA-2024-0055). This included 45 files regarding 49 unique crashes. ODI reviewed that information and found that of the 49 crashes, twenty-nine (29) potentially involved a subject vehicle. The majority of the 45 files were from the Fatality Analysis Reporting System (FARS), which is a NHTSA-maintained database of state crash data comprised of certain, albeit often relatively limited information. Notably, of the 29 files, only 2 included the make, model, and model year of the subject vehicle. After consideration of the petition, including the reports and documents provided by the petitioner, NHTSA believes the issues raised here are best addressed through its recent rulemaking and the ongoing actions under IIJA. Accordingly, NHTSA has decided not to open a defect investigation, and the petition is denied. The denial of this petition does not foreclose the agency from taking further action if warranted or making a future finding that a safety-related defect exists based upon additional information the agency may receive.Read more

HYUNDAI TRANSLEAD VAN TRAILER — All Years Overview

Complete safety history for the HYUNDAI TRANSLEAD VAN TRAILER across all model years (2005–2016).

9 Total Recalls

3 Total Complaints

1 Investigations

1 Reported Crashes

0 Reported Fires

0 Reported Deaths

HYUNDAI TRANSLEAD VAN TRAILER — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2016	1	2	View
2015	2	1	View
2014	2	0	View
2011	1	0	View
2010	1	0	View
2006 (current)	1	0
2005	1	0	View

Other HYUNDAI TRANSLEAD Models

Model	Recalls	Complaints
20'/40' 12PIN EXTEN CHASS	0	0	View
CHASSIS	0	0	View
COMPOSITE	0	0	View
COMPOSITIVE	0	0	View
CONTAINER	0	0	View
CONVERTER DOLLY TRAILER	0	0	View
DRY VAN TRAILER	0	0	View
DURALITE HT	0	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health