2016 HONDA PILOT

Based on everything we've documented, here's a tight, factual account written in the style NHTSA expects — first person, chronological, no fluff: "I own a 2016 Honda Pilot Touring AWD, VIN [XXX] , with 89,962 miles. The vehicle began producing a clunking noise from the engine. I brought it to Honda of Tomball [XXX] ), where the dealer diagnosed all main rod bearings as damaged and recommended full engine replacement. This failure is identical to the defect described in NHTSA Safety Recall 23V-751 (Honda Recall XG1/GG0): premature connecting rod bearing wear and seizure caused by improperly ground crankshaft crank pins. My vehicle is a 2016 Honda Pilot, a model year explicitly covered under the recall. However, my VIN was not included in the identified recall population, and Honda of Tomball has not offered to cover the repair under the recall. I am requesting that NHTSA investigate whether my vehicle's crankshaft contains the same manufacturing defect, and that Honda be required to extend recall coverage to my VIN. The repair cost for a full engine replacement is substantial, and the failure mode is mechanically indistinguishable from the acknowledged recall defect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

We were on the way home from a soccer tournament in [XXX] on rt. XXX and 4 hours into our trip the car's fuel pedal stopped responding and our speed started descending rapidly. The engine light was on with the vehicles stability system, Hill assistant, emission system, power system, TSA..... All of them were lit. Scared I put hazards on and pulled over on the side of the road. I waited about 20 min and tried to start the car. It started and drove us home on side streets on speed 30-40 to [XXX] , wouldn't go faster and it was shaking while driving. It was quite terrifying and looking back I should have called 911, this was a first time ever I have been in a situation like that with my daughter. We got home at night. In the morning I called AAA to see if the battery was bad, they said no. The dashboard was cleared, no lights appeared and when I went to the Honda dealer they couldn't a identify the specific problem. They told me it could be a few things and told me to do repairs for $5000.00 not knowing if it would fix the problem. This first incident happened in summer 2025. I stopped driving the car on a highway and long distances, the dashboard lit up few more times but always went back to normal. A couple of weeks ago, when I again called AAA to check my battery, I was advised to go to AutoZone when the board lits up again. So I did today and was told it was code P0087 and had to do with the fuel pressure pump. So I went to my mechanic to diagnose the problem and they are in the process of repairing it. But after some research I found online that there has been a recall on Honda Pilots 2016-2018, but my car didn't qualify. So I called Honda manufacturing explaining my situation and warning them that the same thing happened to me and they said there was nothing they could do if my car's VIN # wasn't included. So I am writing to you to advise the traffic safety administration and suggest to expand the recall #XXX to more vehicles INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.

Car fails to start and warning flashes, keyless start system problem.

Drive to work suddenly engine show emergency issues many symbols appearing in front of screen and break is not controlled and car is stop running.

Drive to work suddenly engine show emergency issues many symbols appearing in front of screen and break is not controlled and car is stop running.

Drive to work suddenly engine show emergency issues many symbols appearing in front of screen and break is not controlled and car is stop running.

Vehicle caught fire and completely burned up. It had no problems, had been serviced and recently inspected for emissions and safety in Virginia.

Vehicle caught fire and completely burned up. It had no problems, had been serviced and recently inspected for emissions and safety in Virginia.

The contact owns a 2016 Honda Pilot. The contact stated that while driving at approximately 60 MPH, the vehicle stalled and failed to return to normal functionality. Several unknown warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the rod bearings needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 121,632.

The contact owns a 2016 Honda Pilot. The contact stated that while driving at various speeds, the engine was knocking. There were no warning lights illuminated. The vehicle was taken to a certified mechanic, who diagnosed the vehicle with rod bearing failure. The vehicle was not repaired. The vehicle was taken to the dealer, who diagnosed that the vehicle was skipping timing, and the timing chain or belt had slipped from correct alignment, and the engine needed to be replaced. The vehicle was not repaired. The contact became aware of NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling); and associated the failure with the recall. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The manufacturer opened a case. The failure mileage was approximately 148,850.

My vehicle was recently serviced at the local Honda dealership within the last 6 weeks for an oil leak at the oil filter. We had the work done and everything seemed fine until 3 days ago when the check engine light started flashing and the car couldn’t accelerate properly. I drove the car to the same dealership and after inspection they notified me that the car needed a new engine because a rod bearing had failed and was causing the engine to seize. We were quoted a price of approximately $10,000 to fix. Upon researching online for a cheaper engine/option I found that Honda had issued a recall for the same issue, but when I checked my VIN it said 0 recalls for my vehicle. Is there anything that I can do to have them honor the recall on my vehicle?

Engine tie rod bearing is worn on cylinder 3, engine is knocking. 119kmi.

The engine is making a noise underneath—I think it's a connecting rod bearing. We replaced the entire timing belt assembly because of that sound, but now I don't know what to do; when driving on narrow streets, it displays a "Collision Brake Warning" every time another car approaches.

The engine is making a noise underneath—I think it's a connecting rod bearing. We replaced the entire timing belt assembly because of that sound, but now I don't know what to do; when driving on narrow streets, it displays a "Collision Brake Warning" every time another car approaches.

Pulled up to intersection and check engine light started flashing. Vehicle was approximately 2miles from home. Drove home and parked in driveway. Turned vehicle off. Restarted to see if problem happened again. Check engine light went off but rattle/knocking could be heard upon startup and pressing gas pedal. Code was pulled P0303. Cylinder 3 misfire. Did some research and this has been an issue with 2016 Honda Pilots. We have owned the vehicle for 10yrs4months. Purchased new. 160k miles. Self inspected with experienced mechanic present and diagnosed with a rod bearing issue.

On my 2016 Honda pilot The engine started to fail and make a knocking noise when started, took it to Honda, they said i will need a new engine, i pushed for a goodwill repair, and they told me No. the car has been sitting ever since.

Loud Engine knock when starting and when running under light load around 2000 RPM

Engine failure, left rear cylinder knocking

My vehicle suffered a catastrophic failure of the exhaust and engine systems directly caused by the defective fuel injection system identified in Service Bulletin 20-100. Despite providing evidence that the failure was initiated by these defective injectors, Honda has only provided a partial, unexplained reimbursement and refuses to acknowledge the extensive "downstream" damages. Diagnostic Evidence: At the time of service, the vehicle stored the exact diagnostic trouble codes (DTCs) specified in the bulletin: Fuel/Misfire Codes: P0302, P0303, P0305, P219A Catalytic Efficiency Codes: P0420, P0430 Repairs & Financial Impact: The fueling imbalance and extreme heat caused by the faulty injectors led to: Replacement of both Catalytic Converters (directly cited as a potential result of injector failure in SB 20-100). Cylinder Head Gasket Replacement & Head Resurfacing (caused by excessive thermal stress and localized overheating from the lean/rich conditions). Fuel Injector Replacement. Dispute Details: Inadequate Reimbursement: After months of persistent hounding, American Honda issued a payment of $736. No explanation was provided, but this amount likely only covers the injectors, ignoring the thousands of dollars in consequential damage. Admission of Defect: By issuing this partial payment, Honda has formally acknowledged that my VIN was affected by the manufacturing defect described in the bulletin. Lack of Transparency: Honda has failed to provide any technical justification for how the catalytic converter and head gasket failures—which occurred simultaneously with the specific codes in the bulletin—could be considered unrelated to the admitted injector defect. Request for Action: I am requesting an investigation into Honda's failure to cover the full scope of damages caused by this known manufacturing defect. The partial payment is an admission of fault regarding the injectors, and the resulting engine and exhaust damage is a direct, documented consequence of that

My vehicle suffered a catastrophic failure of the exhaust and engine systems directly caused by the defective fuel injection system identified in Service Bulletin 20-100. Despite providing evidence that the failure was initiated by these defective injectors, Honda has only provided a partial, unexplained reimbursement and refuses to acknowledge the extensive "downstream" damages. Diagnostic Evidence: At the time of service, the vehicle stored the exact diagnostic trouble codes (DTCs) specified in the bulletin: Fuel/Misfire Codes: P0302, P0303, P0305, P219A Catalytic Efficiency Codes: P0420, P0430 Repairs & Financial Impact: The fueling imbalance and extreme heat caused by the faulty injectors led to: Replacement of both Catalytic Converters (directly cited as a potential result of injector failure in SB 20-100). Cylinder Head Gasket Replacement & Head Resurfacing (caused by excessive thermal stress and localized overheating from the lean/rich conditions). Fuel Injector Replacement. Dispute Details: Inadequate Reimbursement: After months of persistent hounding, American Honda issued a payment of $736. No explanation was provided, but this amount likely only covers the injectors, ignoring the thousands of dollars in consequential damage. Admission of Defect: By issuing this partial payment, Honda has formally acknowledged that my VIN was affected by the manufacturing defect described in the bulletin. Lack of Transparency: Honda has failed to provide any technical justification for how the catalytic converter and head gasket failures—which occurred simultaneously with the specific codes in the bulletin—could be considered unrelated to the admitted injector defect. Request for Action: I am requesting an investigation into Honda's failure to cover the full scope of damages caused by this known manufacturing defect. The partial payment is an admission of fault regarding the injectors, and the resulting engine and exhaust damage is a direct, documented consequence of that

The contact owns a 2016 Honda Pilot. The contact stated that the rear-view camera displayed a blank or blue image while in reverse(R). In addition, there was an abnormal scrambling sound coming from the radio before the radio failed to operate as needed. The contact stated that other electrical features failed to operate as needed. Additionally, the contact stated that an abnormal, burning odor was coming from the vehicle with the check engine warning light illuminated on the instrument panel. The vehicle was initially taken to a dealer, where the contact was informed that the catalytic converter needed to be replaced. The vehicle was taken to an independent mechanic who replaced the catalytic converter; however, the check engine warning light remained on the instrument panel. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 130,000.

The contact owns a 2016 Honda Pilot. The contact stated that the rear-view camera displayed a blank or blue image while in reverse(R). In addition, there was an abnormal scrambling sound coming from the radio before the radio failed to operate as needed. The contact stated that other electrical features failed to operate as needed. Additionally, the contact stated that an abnormal, burning odor was coming from the vehicle with the check engine warning light illuminated on the instrument panel. The vehicle was initially taken to a dealer, where the contact was informed that the catalytic converter needed to be replaced. The vehicle was taken to an independent mechanic who replaced the catalytic converter; however, the check engine warning light remained on the instrument panel. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 130,000.

The contact owns a 2016 Honda Pilot. The contact stated that the rear-view camera displayed a blank or blue image while in reverse(R). In addition, there was an abnormal scrambling sound coming from the radio before the radio failed to operate as needed. The contact stated that other electrical features failed to operate as needed. Additionally, the contact stated that an abnormal, burning odor was coming from the vehicle with the check engine warning light illuminated on the instrument panel. The vehicle was initially taken to a dealer, where the contact was informed that the catalytic converter needed to be replaced. The vehicle was taken to an independent mechanic who replaced the catalytic converter; however, the check engine warning light remained on the instrument panel. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 130,000.

The contact owns a 2016 Honda Pilot. The contact stated that upon leaving a gas station, there was an abnormal grinding sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, and the contact was informed that the engine rod bearing might be defective and referred the contact to another independent mechanic for assistance. The vehicle was taken to the second independent mechanic who confirmed that the engine rod bearing failure, and the contact was given an estimate for the repair. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not yet repaired. The failure mileage was approximately 103,000.

Lug studs keep breaking i have had honda and other dealers change the studs over 8 times new studs new lugs and 60-90 days one-two are broken again

Our fuel pump went out, causing us to be stranded and having to have our Honda Pilot toward 45 minutes away to the Honda dealer to have it replaced. There were no warning lights on until we were going down the highway and all of a sudden the dash warning codes were flashing like crazy. We turned our car off, then when we turned it back everything kept flashing, many warning lights at once. Honda diagnosed with Code P0098 and replaced the high pressure fuel pump. There was a recall made the week after we had ours fixed, but not for our model.

When driving vehicle shuts off for no reason. Then I have to put my four-way on and turn my vehicle back on. It has already happened four times, and no one seems to know what the problem is or what is causing the issue.

Three times at a stop light my car goes into the engine idle stop mode and when the light turns green my car won’t get out of the mode. I have to put it into park and restart the car to go. I have almost been hit twice.

On Friday, January 30th, I took my car into Bill Pearce Courtesy Honda in Reno NV, to get a pretty big service done for $3400. Basically the 100k service with new timing belt, spark plugs, etc. I wanted to make sure that this car would last 3-5 more years. A week later, my [XXX] old daughter took my car to the ski mountain for work and on the way, the car started making a loud knocking sound and started losing power. She called me in fear so I talked her through pulling off on the next exit. I met her up at the mountain and called a tow truck and had them tow to the Bill Pearce Courtesy Honda service department. The following day, which was Monday, I got a call from the service rep and he said they were going to figure out what was going on. At the end of the day I got a call stating that the computer diagnostics said the issue was there Rod Bearings and they were going to drop the oil pan the following day to see how bad the damage was. As it turns out, Honda said that the short block will need to be replaced. That’s the bottom half of the engine. This will cost more than the car is worth and I just spent thousands on maintenance. So, Honda is giving me a Goodwill discount of 50%, but I still have to come up with $3800 for the fix. After doing much research, this is a known issue for other Hondas and Acura's, but my VIN wasn’t under the recall. I feel like this is a miss on Honda’s part and now I’m out of a vehicle and cash to get it fixed. The car hasn’t been fixed yet. They are waiting for the short block part to come in. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine began sputtering and then shut off. I had it towed in to a third party mechanic we frequently use, and they confirmed that the engine had seized, and they could not ascertain the cause. It didn't seem to have anything to do with low oil. I wondered if it was an issue with the fuel pumps failing again, because they recently failed and we had to have them replaced. I checked our VIN number to see if there were any recalls for our 2016 Honda Pilot, and there weren't, but I did find recalls for 2016 Honda Pilots related to fuel pump failure (ID# 23V858000) and engine damage from connecting rod bearing wear (ID# 23V751000). I shared this information with the third party mechanic, and they suggested that this could very well be the cause of engine failure. I'm concerned that my Pilot has suffered related failures but was not included in the recall. I have reached out to the Honda hotline included in this site, and they asked me to have the vehicle towed to the dealership for a diagnostic, after which I can submit a Goodwill Request to Honda for them to consider covering expenses related to engine replacement, but again, my concern is these issues seem to be related to the relevant recalls that do not technically apply to my VIN number. If helpful, I can file a follow-up complaint once I have documentation from the diagnostic.

Component or system that failed: The engine failed suddenly while driving. The suspected failure is an internal connecting-rod bearing or related bottom-end engine component. The vehicle is currently at a repair facility and the engine is available for inspection upon request. How safety was put at risk: The engine lost power suddenly and became inoperable while driving. This created a hazardous situation because the vehicle could no longer maintain speed or safely continue in traffic. Sudden engine failure without warning increases the risk of a crash, especially at highway speeds or in heavy traffic. Has the problem been reproduced or confirmed by a dealer or independent shop: An independent repair shop inspected the vehicle and confirmed that the engine has experienced a catastrophic internal failure and will not rotate. The timing belt was confirmed to be intact. The shop advised that the engine requires replacement. A dealer diagnostic is pending or in progress. Has the vehicle or component been inspected by manufacturer, police, insurance, or others: The vehicle has been inspected by an independent repair facility. It has also been presented to a Honda dealership for diagnostic evaluation. The manufacturer has not yet physically inspected the vehicle. Warning lamps, messages, or prior symptoms: Prior to the failure, the engine developed a knocking noise between approximately 3,000 and 4,000 RPM. The vehicle was driven approximately 80 miles after the noise first appeared. No check-engine light or other warning messages appeared before the engine suddenly failed and the vehicle became inoperable.

Mechanic at Lee Street Garage reported lower end noise issues with engine and told me they don't recommend fixing other issues until I have vehicle looked at by dealership (in case they can address potential engine failure issue linked below). I took vehicle to dealer and they reported $5000 in repairs (to fix other issues) - nothing about a potential recall - [XXX] for this issue. I understand this vehicle is not currently in any recall for this issue. I want to report as I do not want to pay for all the other repairs only to have the engine failure issue as noted above. I asked for trade-in value for vehicle and they said $2000 (blue book value, fair/lowest value estimate is - $6885) Link to maintenance advised by honda dealership. No mention of NHTSA article above nor any follow-up from Honda on the same as it is not in any current recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The fuel injector failed which cause safety issues such as reduced speed, failing safety issues, and the car is misfiring and not running safely. When driving the car started to misfire and was not running correctly. It then reduced speed and the safety features were disabled. Yes this issue was confirmed by Ken Vance Honda in Eau Claire WI. There was a flashing check engine light, hill start assist problem, emissions system problem, power steering system problem, trailer stability assist problem, and vehicle stability assistance problem lights that came on. This is a known safety issue with 2016 Honda Pilot as Honda America did an extended warranty to cover the expense to replace the injectors. Unfortunately, our car missed the deadline by a few months to get this covered. Since this was a known defective part from the factory this should have been taken care of by Honda as a full recall. There are many cars like this that are going to have safety issues and not realize what is happening.

The fuel injector failed which cause safety issues such as reduced speed, failing safety issues, and the car is misfiring and not running safely. When driving the car started to misfire and was not running correctly. It then reduced speed and the safety features were disabled. Yes this issue was confirmed by Ken Vance Honda in Eau Claire WI. There was a flashing check engine light, hill start assist problem, emissions system problem, power steering system problem, trailer stability assist problem, and vehicle stability assistance problem lights that came on. This is a known safety issue with 2016 Honda Pilot as Honda America did an extended warranty to cover the expense to replace the injectors. Unfortunately, our car missed the deadline by a few months to get this covered. Since this was a known defective part from the factory this should have been taken care of by Honda as a full recall. There are many cars like this that are going to have safety issues and not realize what is happening.

The fuel injector failed which cause safety issues such as reduced speed, failing safety issues, and the car is misfiring and not running safely. When driving the car started to misfire and was not running correctly. It then reduced speed and the safety features were disabled. Yes this issue was confirmed by Ken Vance Honda in Eau Claire WI. There was a flashing check engine light, hill start assist problem, emissions system problem, power steering system problem, trailer stability assist problem, and vehicle stability assistance problem lights that came on. This is a known safety issue with 2016 Honda Pilot as Honda America did an extended warranty to cover the expense to replace the injectors. Unfortunately, our car missed the deadline by a few months to get this covered. Since this was a known defective part from the factory this should have been taken care of by Honda as a full recall. There are many cars like this that are going to have safety issues and not realize what is happening.

Complete engine failure, threw rod through block. Oil was changed in October, still has 2000 miles before needing changing again.

To Whom It May Concern, I am submitting this complaint to report ongoing engine and emissions system problems with my 2016 Honda Pilot that raise serious safety concerns and may be related to a broader defect currently under investigation. I purchased this vehicle from a dealership in April of 2024 and the issues began shortly afterward at approximately 67,000 miles. The vehicle currently has approximately 74,600 miles and has received regular oil changes and routine maintenance. The vehicle has repeatedly displayed emissions system warning messages and engine fault codes. It has experienced persistent engine misfiring even after a mechanic performed repairs on cylinder 1. In addition, the vehicle exhibits rough engine shaking during driving and idling, engine stalling, and rough or delayed gear changes continuously since 2024. Despite attempted repairs, the problems continue to occur to present. The stalling, misfiring, and unstable engine operation create a potential safety risk, particularly while driving at speed or in traffic. The rough shifting and loss of smooth power delivery further impact safe vehicle operation. Given the relatively low mileage, proper maintenance, and the recurrence of these symptoms, this does not appear to be normal wear and tear. I am aware that similar engine-related complaints have been reported by other owners of 2016 Honda Pilot vehicles and that this model year is included in an ongoing federal investigation into potential engine defects. I am requesting that this complaint be reviewed as part of that investigation and considered for further action, including possible recall or service remedy, to address the safety risks posed by these engine and emissions system failures. Vehicle Information: Make/Model: 2016 Honda Pilot Mileage: Approximately 74,600 miles VIN: [XXX] Thank you for your attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

To Whom It May Concern, I am submitting this complaint to report ongoing engine and emissions system problems with my 2016 Honda Pilot that raise serious safety concerns and may be related to a broader defect currently under investigation. I purchased this vehicle from a dealership in April of 2024 and the issues began shortly afterward at approximately 67,000 miles. The vehicle currently has approximately 74,600 miles and has received regular oil changes and routine maintenance. The vehicle has repeatedly displayed emissions system warning messages and engine fault codes. It has experienced persistent engine misfiring even after a mechanic performed repairs on cylinder 1. In addition, the vehicle exhibits rough engine shaking during driving and idling, engine stalling, and rough or delayed gear changes continuously since 2024. Despite attempted repairs, the problems continue to occur to present. The stalling, misfiring, and unstable engine operation create a potential safety risk, particularly while driving at speed or in traffic. The rough shifting and loss of smooth power delivery further impact safe vehicle operation. Given the relatively low mileage, proper maintenance, and the recurrence of these symptoms, this does not appear to be normal wear and tear. I am aware that similar engine-related complaints have been reported by other owners of 2016 Honda Pilot vehicles and that this model year is included in an ongoing federal investigation into potential engine defects. I am requesting that this complaint be reviewed as part of that investigation and considered for further action, including possible recall or service remedy, to address the safety risks posed by these engine and emissions system failures. Vehicle Information: Make/Model: 2016 Honda Pilot Mileage: Approximately 74,600 miles VIN: [XXX] Thank you for your attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

To Whom It May Concern, I am submitting this complaint to report ongoing engine and emissions system problems with my 2016 Honda Pilot that raise serious safety concerns and may be related to a broader defect currently under investigation. I purchased this vehicle from a dealership in April of 2024 and the issues began shortly afterward at approximately 67,000 miles. The vehicle currently has approximately 74,600 miles and has received regular oil changes and routine maintenance. The vehicle has repeatedly displayed emissions system warning messages and engine fault codes. It has experienced persistent engine misfiring even after a mechanic performed repairs on cylinder 1. In addition, the vehicle exhibits rough engine shaking during driving and idling, engine stalling, and rough or delayed gear changes continuously since 2024. Despite attempted repairs, the problems continue to occur to present. The stalling, misfiring, and unstable engine operation create a potential safety risk, particularly while driving at speed or in traffic. The rough shifting and loss of smooth power delivery further impact safe vehicle operation. Given the relatively low mileage, proper maintenance, and the recurrence of these symptoms, this does not appear to be normal wear and tear. I am aware that similar engine-related complaints have been reported by other owners of 2016 Honda Pilot vehicles and that this model year is included in an ongoing federal investigation into potential engine defects. I am requesting that this complaint be reviewed as part of that investigation and considered for further action, including possible recall or service remedy, to address the safety risks posed by these engine and emissions system failures. Vehicle Information: Make/Model: 2016 Honda Pilot Mileage: Approximately 74,600 miles VIN: [XXX] Thank you for your attention to this matter. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Honda Pilot. The contact stated that while driving at slow and moderate speeds, the transmission was slipping, and the vehicle lurched and jerked. The failure was more evident while driving uphill. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the torque converter had failed and needed to be replaced. The vehicle was repaired. Additionally, the contact stated that while driving and exceeding 40 MPH, the hood was flapping. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 21V932000 (Structure, Latches/Locks/Linkages); however, the VIN was not included. The failure mileage was approximately 100,000.

The contact owns a 2016 Honda Pilot. The contact stated that while driving at slow and moderate speeds, the transmission was slipping, and the vehicle lurched and jerked. The failure was more evident while driving uphill. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that the torque converter had failed and needed to be replaced. The vehicle was repaired. Additionally, the contact stated that while driving and exceeding 40 MPH, the hood was flapping. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 21V932000 (Structure, Latches/Locks/Linkages); however, the VIN was not included. The failure mileage was approximately 100,000.

Engine noise, check engine light illuminating causing reduced engine power. Mechanic states rod bearing issue likely the cause

Driving the car the engine bearing went out and wrecked the engine which has caused the engine to be replaced.

Engine failure while on highway traffic in construction zone caused engine shut off, losing power steering and odd braking. I was driving on a split 4 lane highway (2 lanes each direction), with a large ditch median between the directional lanes. My direction had construction cones for several miles limiting traffic to 1 lane, still at a 65 MPH speed limit with heavy semi traffic. The right lane was closed for construction, so all traffic was lined in left lane, though maintaining the speed limit. A few hundred yards into the construction my check engine light came on, and then after a minute or so it started blinking but there was no place to pull over safely. I reduced speed and semi traffic was lining up behind me. Then the engine and rest of car shut off, losing power steering. I ended up weaving into the construction part and was finally able to stop but not without danger to myself and others. Motor would restart but sounded terrible and I did not feel safe driving further and did not have faith it would make it far, especially since I'd have to re-enter the highway construction traffic. I had it towed to local mechanic, who diagnosed the problem as a piston rod bearing spin/stuck, or in other words a spun/slipped rod/crank bearing.

Engine failure while on highway traffic in construction zone caused engine shut off, losing power steering and odd braking. I was driving on a split 4 lane highway (2 lanes each direction), with a large ditch median between the directional lanes. My direction had construction cones for several miles limiting traffic to 1 lane, still at a 65 MPH speed limit with heavy semi traffic. The right lane was closed for construction, so all traffic was lined in left lane, though maintaining the speed limit. A few hundred yards into the construction my check engine light came on, and then after a minute or so it started blinking but there was no place to pull over safely. I reduced speed and semi traffic was lining up behind me. Then the engine and rest of car shut off, losing power steering. I ended up weaving into the construction part and was finally able to stop but not without danger to myself and others. Motor would restart but sounded terrible and I did not feel safe driving further and did not have faith it would make it far, especially since I'd have to re-enter the highway construction traffic. I had it towed to local mechanic, who diagnosed the problem as a piston rod bearing spin/stuck, or in other words a spun/slipped rod/crank bearing.

Engine failure while on highway traffic in construction zone caused engine shut off, losing power steering and odd braking. I was driving on a split 4 lane highway (2 lanes each direction), with a large ditch median between the directional lanes. My direction had construction cones for several miles limiting traffic to 1 lane, still at a 65 MPH speed limit with heavy semi traffic. The right lane was closed for construction, so all traffic was lined in left lane, though maintaining the speed limit. A few hundred yards into the construction my check engine light came on, and then after a minute or so it started blinking but there was no place to pull over safely. I reduced speed and semi traffic was lining up behind me. Then the engine and rest of car shut off, losing power steering. I ended up weaving into the construction part and was finally able to stop but not without danger to myself and others. Motor would restart but sounded terrible and I did not feel safe driving further and did not have faith it would make it far, especially since I'd have to re-enter the highway construction traffic. I had it towed to local mechanic, who diagnosed the problem as a piston rod bearing spin/stuck, or in other words a spun/slipped rod/crank bearing.

We are being denied a repair that is exactly like the service recall Service Bulletin 24-001 Safety Recall: 2016 (&2018-19) Pilot Connecting Rod Bearing. They found metal shavings in the oil that are identical to vehicles that are covered. The dealership said they received 4 other 2016 Honda Pilots this week where the VIN wasn't in the range but the same issue. Honda is trying to avoid a recall when it is clear that all 2016 Honda Pilots are affected.

Auto idle stop function causing car to not start back up. Could be at a stop sign, in a left turn lane, in the middle of an intersection waiting to turn. Very stressful and unsafe driving conditions. This has been ongoing for years. Dealership has blamed it on the battery, which has been replaced theee times (one of those times under warranty), dealership has looked at the car multiple times. Also made recommended Honda repairs per the issued safety bulletin. But it continues to happen.

We started having problems with the catalytic converter clogging so we put Heat in it and then only used 100%gas. Then we went to my daughter’s house and when we went to leave the car wouldn’t start. We could smell burning. We had it towed to our mechanic and he replaced the starter but he had a hard time getting it off because it was almost fused because of the heat. Then 3-4 days later all the check engine lights came on. We had it checked out by Christian Brothers and he had to replace all of the fuel injectors. He also had to replace the ERG valve. It all I feel was caused by the fuel injectors and was causing problems in the engine and causing the burning smell. I have read that this has been a problem on the vehicles and wanted to report it for a Recall. We love the vehicle but with the mileage only being at 143,400.

We started having problems with the catalytic converter clogging so we put Heat in it and then only used 100%gas. Then we went to my daughter’s house and when we went to leave the car wouldn’t start. We could smell burning. We had it towed to our mechanic and he replaced the starter but he had a hard time getting it off because it was almost fused because of the heat. Then 3-4 days later all the check engine lights came on. We had it checked out by Christian Brothers and he had to replace all of the fuel injectors. He also had to replace the ERG valve. It all I feel was caused by the fuel injectors and was causing problems in the engine and causing the burning smell. I have read that this has been a problem on the vehicles and wanted to report it for a Recall. We love the vehicle but with the mileage only being at 143,400.