2018 GRAND DESIGN MOMENTUM
2 recalls, 15 complaints - 2 TSBs
22V038000 Jan 28, 2022
EQUIPMENT:APPLIANCE:REFRIGERATOR
Defect Description
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Consequence
An electrical arc increases the risk of a fire.
Remedy
Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
21V393000 May 26, 2021
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS
Defect Description
Grand Design RV, LLC (Grand Design) is recalling certain 2016-2021 Imagine, Transcend, and Momentum travel trailers. The LP regulator that controls the LP gas pressure may fail, allowing excessive gas pressure that causes the appliance flame to increase.
Consequence
Excessive gas pressure and a larger than intended appliance flame can increase the risk of a fire.
Remedy
Dealers will replace the LP regulator, free of charge. Owner notification letters were mailed June 24, 2021. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910023.
Complaint Statistics
15 total complaints
1 crashes
Top Reported Components
| Component | Complaints |
|---|---|
| UNKNOWN OR OTHER | 5 |
| POWER TRAIN | 2 |
| ENGINE | 2 |
| FORWARD COLLISION AVOIDANCE | 1 |
| VISIBILITY/WIPER | 1 |
| POWER TRAIN:CLUTCH ASSEMBLY | 1 |
| ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE | 1 |
| WHEELS | 1 |
| SUSPENSION | 1 |
ENGINE
May 14, 2026
Incident date: May 1, 2026
This is an extremely common issue plaguing Hyundai & Kia vehicles with the Theta III 2.5L Turbo engine, Such as Kia K5 GT, Hyundai Sante Fe, Hyundai Santa Cruz, & Hyundai Sonata N-Line. Its a failing ITM (integrated thermal management) unit or otherwise known as an ITMS unit. There is a rod within ... Read more
POWER TRAIN
May 14, 2026
Incident date: May 1, 2026
I am writing to report a safety defect regarding the 8-speed automatic transmission in my 2017 Toyota Sienna. The vehicle exhibits severe hesitation during acceleration, harsh shifting, and a high-pitched whining noise, specifically consistent with the 'whine of death' described in Toyota's Customer... Read more
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
May 27, 2025
Incident date: Sep 1, 2024
The contact owns a 2019 Ford F-150. The contact stated that while driving at various speeds, there was an abnormal sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the exhaust manif... Read more
WHEELS
May 27, 2025
Incident date: Sep 1, 2024
Catastrophic failure of rear upper control arm / suspension resulting in temporary loss of control. Occurred driving straight at 35mph without any prior damage or symptoms.
SUSPENSION
May 27, 2025
Incident date: Sep 1, 2024
Catastrophic failure of rear upper control arm / suspension resulting in temporary loss of control. Occurred driving straight at 35mph without any prior damage or symptoms.
UNKNOWN OR OTHER
Apr 16, 2025
Incident date: Nov 25, 2024
I purchased a volkswagen atlas in 2021. Within the first year of owning the vehicle the air conditioning system had a malfunction where it would blow hot on the passenger side and remain cold on the driver side. I took it in to the dealership for service and was told the passenger side blower motor ... Read more
ENGINE
Apr 16, 2025
Incident date: Nov 25, 2024
The engine started smoking and knocking really bad. Took it to the kia dealership and was told a piston o ring and gasket went bad because of heavy oil consumption that caused antifreeze to leak inside the motor while sitting still and this was causing the burning smell because the cylinder had gone... Read more
UNKNOWN OR OTHER
Apr 16, 2025
Incident date: Nov 25, 2024
The recall was originally done by the selling dealer in February 21. We purchased the RV in February 21. The recall failed 6 months later. It was repaired by the frame manufacturer BAL while we were in Florida. The recall is failing AGAIN. This recall is inadequate. RV is no longer safe to tow. Keys... Read more
UNKNOWN OR OTHER
Nov 27, 2024
Incident date: Nov 26, 2024
THE REAR WINDSHIELD SHATTERED INTO PIECES WHILE I GOT TO MY CAR AFTER WORK :( WARRANTY DID NOT COVER IT HAD TO PAY OUT OF POCKET I HAVE SEEN MANY POST ABOUT THE REAR WINDSHIELD SHATTERED SHOULD BE RECALLED !!
POWER TRAIN
Mar 18, 2024
Incident date: Mar 18, 2024
See attached document for complaint
POWER TRAIN:CLUTCH ASSEMBLY
Mar 18, 2024
Incident date: Mar 18, 2024
See attached document for complaint
UNKNOWN OR OTHER
Mar 18, 2024
Incident date: Mar 18, 2024
While driving car trying to stall in middle of traffic.
UNKNOWN OR OTHER
Feb 24, 2024
Incident date: Oct 15, 2022
getting intermittent exhaust fumes inside the cabin. co2 and other exhaust gasses getting inhaled by my family
VISIBILITY/WIPER
Feb 24, 2024
Incident date: Oct 15, 2022
My rear window unexpectedly shattered without any force while I was sitting in the car parked.
FORWARD COLLISION AVOIDANCE
Feb 5, 2024
Incident date: Dec 30, 2023
See attached document for complaint
Crash
Technical Service Bulletins, 2018 GRAND DESIGN MOMENTUM
2 manufacturer communications from 2 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 2 |
CSP 910019
Apr 1, 2020
350000 EQUIPMENT
Customer Satisfaction Program released to have a protective heat shield installed behind convection microwave on units identified below to address concerns with excessive heat buildup.
No comms 2021-01
Feb 15, 2021
350000 EQUIPMENT
There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for January 2021 for Grand Design RV, LLC.
NHTSA Safety Investigations, GRAND DESIGN MOMENTUM
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE24029
Opened: Oct 9, 2024
Frame Flex on Grand Design Fifth Wheel Recreational Trailers
The Office of Defects Investigation (ODI) has received twenty-three complaints alleging excessive frame flex on model year 2017-2023 Grand Design fifth wheel recreational trailers, models Momentum and Solitude. Twenty-two of the complaints allege that excessive frame flex resulted in a cargo or ent... Read more
GRAND DESIGN MOMENTUM - All Years Overview
Complete safety history for the GRAND DESIGN MOMENTUM across all model years (2013, 2025).
45
Total Recalls
366
Total Complaints
1
Investigations
22
Reported Crashes
10
Reported Fires
0
Reported Deaths
GRAND DESIGN MOMENTUM - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.