2003 GMC ENVOY
8 recalls, 511 complaints - 811 TSBs
07E014000 Feb 26, 2007
EXTERIOR LIGHTING:HEADLIGHTS
Defect Description
CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NO 335-1120L-AS, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. DURING PRODUCTION THE LAMP HOUSING SHAPE DEFORMED DISTORTING THE ASSEMBLY ANGLE OF THE REFLECTOR AND INFLUENCED THE AIMING POSITION. THESE HEADLAMPS F... Read more
Consequence
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy
MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON FEBRUARY 16, 2007. OWNERS MAY CONTACT MAXZONE AT 909-822-3288.
05V198000 May 5, 2005
EXTERIOR LIGHTING:TURN SIGNAL
Defect Description
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence
THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1... Read more
04V046000 Feb 4, 2004
VISIBILITY:WINDSHIELD WIPER/WASHER
Defect Description
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER... Read more
Consequence
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-... Read more
03V250000 Jul 15, 2003
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Defect Description
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE... Read more
Consequence
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CON... Read more
03V151000 Apr 23, 2003
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Defect Description
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A LEFT-FRONT BRAKE PIPE WITH A CIRCUMFERENTIAL SCORE AT A RANDOM LOCATION ALONG THE LENGTH OF THE PIPE AS THE RESULT OF THE MANUFACTURING PROCESS. IF THE BRAKE PIPE PARTIALLY OR FULLY FRACTURED, BRAKE PEDAL TRAVEL WOULD IMMEDIATELY INCREASE AND FRONT B... Read more
Consequence
IF BRAKING PERFORMANCE IS REDUCED, A CRASH COULD OCCUR.
Remedy
DEALERS WILL REPLACE THE LEFT-FRONT BRAKE PIPE. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-... Read more
03V075000 Mar 6, 2003
POWER TRAIN:AUTOMATIC TRANSMISSION
Defect Description
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN AD... Read more
Consequence
THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Remedy
DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020... Read more
03V051000 Feb 14, 2003
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Defect Description
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence
THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy
DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-... Read more
02V222000 Aug 9, 2002
AIR BAGS:FRONTAL
Defect Description
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CON... Read more
Complaint Statistics
511 total complaints
60 crashes 14 fires 52 injuries 9 deaths
Top Reported Components
| Component | Complaints |
|---|---|
| ELECTRICAL SYSTEM | 54 |
| FUEL SYSTEM, GASOLINE | 36 |
| AIR BAGS | 29 |
| FUEL/PROPULSION SYSTEM | 25 |
| EXTERIOR LIGHTING | 19 |
| STRUCTURE:BODY | 16 |
| ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL | 14 |
| POWER TRAIN:AUTOMATIC TRANSMISSION | 14 |
| SUSPENSION | 12 |
| STEERING | 12 |
VISIBILITY/WIPER
Jul 27, 2026
Incident date: Jul 20, 2026
My windshield wipers come on when you start the car, or when you just click the switch to put windows up, but the wiper switch is off. The wipers stay operating from 5 to 10 minutes before they shut off, and I am concerned the windshield and/or wipers may become damaged. This issue has just started ... Read more
ELECTRICAL SYSTEM
Mar 12, 2026
Incident date: Feb 27, 2026
I was commuting home, about 30 minutes into the drive, all of the dashboard and radio went blank for a few seconds. It came back on and the break light, anit-collision, lane departure, lights were all flashing. It did this 2 more times in the over the next 5 minutes. I was concerned for my safet... Read more
UNKNOWN OR OTHER
Mar 12, 2026
Incident date: Feb 27, 2026
I was commuting home, about 30 minutes into the drive, all of the dashboard and radio went blank for a few seconds. It came back on and the break light, anit-collision, lane departure, lights were all flashing. It did this 2 more times in the over the next 5 minutes. I was concerned for my safet... Read more
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
Feb 2, 2026
Incident date: Mar 13, 2008
The contact owns a 2019 Chevrolet Equinox. The contact stated that while driving 80 MPH, the vehicle lost motive power and failed to accelerate above 35 MPH. The vehicle was driven to the residence. The vehicle was taken to an independent mechanic to be diagnosed, and it was determined that the turb... Read more
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Jul 6, 2025
Incident date: May 1, 2025
Polestar's fix to the last recall for broken rearview camera did not work.
AIR BAGS
Jul 6, 2025
Incident date: May 1, 2025
Date of Incident: [XXX] Location: [XXX] To Whom It May Concern, I am submitting this letter to report a potential airbag malfunction involving my 2024 Kia Forte GT. On [XXX], I was the driver and sole occupant of my vehicle when I was T-boned on the driver’s side while traveling [XXX] on [XXX]... Read more
Crash
1 injured
ENGINE
Jul 6, 2025
Incident date: May 1, 2025
The car has issues with major oil consumption, and a chatter engine noise, also has issues with acceleration. Oil will run dry if not topped off every 3 weeks.
STEERING
Sep 19, 2024
Incident date: Aug 9, 2024
I was driving my 2016 Colorado of the freeway going about 70 mph. Suddenly, a stabilitrak warning came up on the dashboard and the power steering immediately turned off making the truck difficult to control. I managed to drive 20 miles home, but turning was extremely difficult. I'm frightened to dri... Read more
SEAT BELTS
May 27, 2024
Incident date: May 23, 2024
The seat belt in the 2nd row where my child sits, comes unlatched while driving. Happened in the driver seat as well. This is a major safety concern given they come unlatched without pressure. We always double check now that we pull it after inserting to double check it is all the way in and it sti... Read more
FORWARD COLLISION AVOIDANCE: WARNINGS
Apr 5, 2023
Incident date: Apr 5, 2012
The windshield wipers, which are automatic only do absolutely NOTHING when it is raining. The only thing I can do is hit a button on the steering wheel each time I need the wipers to clear the windshield. Tesla claims is it working as intended...which apparently is not at all. When it began raining ... Read more
SERVICE BRAKES
Apr 5, 2023
Incident date: Apr 5, 2012
The windshield wipers, which are automatic only do absolutely NOTHING when it is raining. The only thing I can do is hit a button on the steering wheel each time I need the wipers to clear the windshield. Tesla claims is it working as intended...which apparently is not at all. When it began raining ... Read more
STRUCTURE:BODY
Oct 8, 2021
Incident date: Sep 23, 2021
Rear door will not open. Window works but door handles inside and outside will not unlock door to open.
VISIBILITY/WIPER
Sep 17, 2021
Incident date: Aug 1, 2021
Back door latches sticking/very hard to open and at times won’t open at all. Visibility from wipers is very limited and not good. Rear exterior lights at times flicker and bulbs come loose at times
EXTERIOR LIGHTING
Sep 17, 2021
Incident date: Aug 1, 2021
Back door latches sticking/very hard to open and at times won’t open at all. Visibility from wipers is very limited and not good. Rear exterior lights at times flicker and bulbs come loose at times
UNKNOWN OR OTHER
Sep 17, 2021
Incident date: Aug 1, 2021
Back door latches sticking/very hard to open and at times won’t open at all. Visibility from wipers is very limited and not good. Rear exterior lights at times flicker and bulbs come loose at times
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Aug 31, 2021
Incident date: Jul 1, 2021
1. The air bag dummy light is on 2. The relay switch keeps going bad on my regular headlights, but the brights will turn on 3. Rear driver side door popped open on the highway while driving with my 12 year old nephew in the backseat. Will not latch shut.
EXTERIOR LIGHTING
Oct 5, 2020
Incident date: Oct 4, 2020
HEADLIGHTS AND BRAKE LIGHTS WENT OUT AT SAME TIME. HIGH BEAMS WORK, VEHICLE RUNS, HAS ALL POWERS. THIS HAPPENED WHEN I LEFT THE HOUSE, WHILE DRIVING, NOTICED WHEN IT BEGAN TO TURN INTO EARLY EVENING.
FUEL/PROPULSION SYSTEM
Sep 30, 2020
Incident date: Aug 28, 2020
CHECK ENGINE LIGHT STAYS ON. HAD A DIAGNOSTIC DONE AND THEY SAID THERE'S A GAS LEAK COMING FROM THE GAS TANK FUEL INLET VALVE. COMMON PROBLEM FOR THE GMC ENVOY AND CORRECTION INVOLVES REPLACING THE WHOLE FUEL TANK COSTING AN AVERAGE $1,400. DANGEROUS TO DRIVE IF LEFT UNTREATED. CALLED GMC CORPORATE ... Read more
POWER TRAIN
Jul 22, 2020
Incident date: Jul 13, 2020
SHIFT CABLE BROKE BETWEEN THE SHIFTER AND THE TRANSMISSION WHILE SHIFTING FROM DRIVE TO REVERSE TO PARK ON A STREET. IF THIS HAD HAPPEN WHILE SHIFTING DOWN GEAR TO LOWER SPEED WHILE DRIVING DOWN A HILL, A LOSS OF CONTROL OF THE VEHICLE WOULD HAVE HAPPEN THAT WOULD HAVE LED TO A CRASH WITH EXTREME P... Read more
STRUCTURE:BODY
May 11, 2020
Incident date: Apr 23, 2020
MY WIFE WAS SITTING IN THE BACKSEAT AND THE BACK DOOR FLEW OPEN ON THE HIGHWAY. I HAVE ALSO NOTICED THE OTHER BACK DOOR IS NOT CLICKING SHUT AND THIS IS A VERY DANGEROUS SITUATION. *TR
AIR BAGS
May 11, 2020
Incident date: Apr 23, 2020
MY WIFE WAS SITTING IN THE BACKSEAT AND THE BACK DOOR FLEW OPEN ON THE HIGHWAY. I HAVE ALSO NOTICED THE OTHER BACK DOOR IS NOT CLICKING SHUT AND THIS IS A VERY DANGEROUS SITUATION. *TR
FUEL/PROPULSION SYSTEM
May 11, 2020
Incident date: Jan 12, 2020
U GUYS ISSUED RECALLED ALL GMC VEHICLES FOR A LEAKING GAS CK VALVE ON GAS TANK NO MATTER HOW LONG IN SERVICE STATIONARY OR ON MOTION CK WITH MY LOCAL DEALER KARL CHEVROLET ANKENY IOWA THEY SAY EXPIRED I'M 2017 AT 150000 YOUR RECALLED AS LONG AS IN SERVICE. *TR
EXTERIOR LIGHTING
Jan 23, 2020
Incident date: Dec 27, 2019
WHEN TRAILER IS CONNECTED TO THE 7 WAY TO BOX TRAILER CONNECTION TRAILER TAIL LAMPS DO NOT LIGHT CORRECTLY. BRAKE AND LEFT TURN SIGNAL LAMPS WORK PROPERLY. THE RIGHT TURN TRAILER LAMP IS PARTIALLY LIT WHEN TURN SIGNAL IS NOT ENGAGED. WHEN RIGHT TURN SIGNAL IS ENGAGED THE LEFT AND RIGHT TURN SIGNALS... Read more
FUEL/PROPULSION SYSTEM
Jan 12, 2020
Incident date: Dec 25, 2019
THE FUEL FILL LINE IS BROKEN FROM THE GAS TANK. I WAS FILLING THE TANK FOR HOLIDAY TRAVEL AND THE THE TANK BEGAN TO LEAK. EVERY TANK THAT IS ORDERED BY THE REPAIR SHOP IS DAMAGED IN THE SAME PLACE
FUEL/PROPULSION SYSTEM
Dec 20, 2019
Incident date: Dec 15, 2019
BULLETIN NO.:14423 DATE: NOVEMBER 2015 PART NUMBER: 15077622 TANK, FUEL (18.7 GAL.) THE ICV IS LOCATED ABOVE THE FULL FUEL LEVEL. A FRACTURED ICV COULD ALLOW FUEL VAPORS TO PASS THROUGH AND DROPLETS OF FUEL TO ACCUMULATE ON THE SIDE OF THE FUEL TANK AS IT PASSES OVER THE FRACTURE DURING REFU... Read more
ELECTRICAL SYSTEM
Dec 17, 2019
Incident date: Dec 17, 2019
VEHICLE CAUGHT FIRE UNDER DASH SOMEWHERE WITHOUT VEHICLE BEING TURNED ON.
Fire
SEATS
Dec 17, 2019
Incident date: Dec 17, 2019
VEHICLE CAUGHT FIRE UNDER DASH SOMEWHERE WITHOUT VEHICLE BEING TURNED ON.
Fire
AIR BAGS
Dec 17, 2019
Incident date: Dec 17, 2019
VEHICLE CAUGHT FIRE UNDER DASH SOMEWHERE WITHOUT VEHICLE BEING TURNED ON.
Fire
SEAT BELTS
Nov 30, 2019
Incident date: Nov 30, 2019
MY SPOUSE WAS DRIVING DOWN S/B ON RT 313 @ RT 290 MARYLAND. HE HIT A DEER AND ROLLED MY ENVOY AND THE AIR BAGS NEVER DEPLOYED. MY SON WAS IN FRONT PASSAGER SET WITH A SET BELT ON AND WHEN THE ENVOY ROLLED HIS SET BELT DID NOT HOLD HIM ON. MY SPOUSE TOLD ME THE ANIT-LOCK BREAKS DID NOT ENGAGE WHEN H... Read more
Crash
SERVICE BRAKES
Nov 30, 2019
Incident date: Nov 30, 2019
MY SPOUSE WAS DRIVING DOWN S/B ON RT 313 @ RT 290 MARYLAND. HE HIT A DEER AND ROLLED MY ENVOY AND THE AIR BAGS NEVER DEPLOYED. MY SON WAS IN FRONT PASSAGER SET WITH A SET BELT ON AND WHEN THE ENVOY ROLLED HIS SET BELT DID NOT HOLD HIM ON. MY SPOUSE TOLD ME THE ANIT-LOCK BREAKS DID NOT ENGAGE WHEN H... Read more
Crash
AIR BAGS
Nov 30, 2019
Incident date: Nov 30, 2019
MY SPOUSE WAS DRIVING DOWN S/B ON RT 313 @ RT 290 MARYLAND. HE HIT A DEER AND ROLLED MY ENVOY AND THE AIR BAGS NEVER DEPLOYED. MY SON WAS IN FRONT PASSAGER SET WITH A SET BELT ON AND WHEN THE ENVOY ROLLED HIS SET BELT DID NOT HOLD HIM ON. MY SPOUSE TOLD ME THE ANIT-LOCK BREAKS DID NOT ENGAGE WHEN H... Read more
Crash
FUEL/PROPULSION SYSTEM
Oct 23, 2019
Incident date: Oct 1, 2017
2 YEARS AGO THE MAINTENANCE REQUIRED LIGHT HAS BEEN ON, WHEN CHECKED BY 2-3 MECHANICS THEY SAID IT COULD BE THE GAS CAP. THAT DIDN'T REMEDY THE SITUATION, THE LIGHT STAYED ON, THEN RECENTLY THE FUEL GAUGE STARTED DROPPING TO EMPTY AFTER A LITTLE LESS THAN HALF A TANK WAS USED. THEN FILLING THE GAS T... Read more
UNKNOWN OR OTHER
Oct 23, 2019
Incident date: Oct 1, 2017
2 YEARS AGO THE MAINTENANCE REQUIRED LIGHT HAS BEEN ON, WHEN CHECKED BY 2-3 MECHANICS THEY SAID IT COULD BE THE GAS CAP. THAT DIDN'T REMEDY THE SITUATION, THE LIGHT STAYED ON, THEN RECENTLY THE FUEL GAUGE STARTED DROPPING TO EMPTY AFTER A LITTLE LESS THAN HALF A TANK WAS USED. THEN FILLING THE GAS T... Read more
EXTERIOR LIGHTING
Oct 8, 2019
Incident date: Sep 3, 2019
NO DAMAGE TO TURN SIGNAL WHEN I TURN ON LEFT TURN SIGNAL SOMETIMES IT DOESN'T WORK SOMETIMES I CAN MOVE STEERING WHEEL AND IT WILL COME ON FOR SECOND OTHER TIMES NOTHING HAVE TO TRY TO TURN OFF AND ON SOMETIMES WORKS SOMETIMES DOESN'T CAN NOT GET A GOOD REASON WHY WON'T WORK. HAVE AUTOMOTIVE EXPERIE... Read more
STRUCTURE:BODY
Apr 13, 2019
Incident date: Jan 5, 2018
DRIVER DOOR WILL LOCK AND UNLOCK ELECTRONICALLY BUT IF YOU TRY TO UNLOCK DOOR MANUALLY IT DOES NOT UNLOCK. IF CAR CRASHES PERSON COULD GET TRAPPED IF CAR IS ON FIRE COULD CAUSE A DEATH IF NO POWER TO ELECTRONIC LOCKS
STRUCTURE:BODY
Jan 2, 2019
Incident date: Jan 2, 2019
WE HAVE BEEN TOLD BY TWO DIFFERENT REPAIR GARAGES THAT THE FRAME OF THE VEHICLE IS TOTALLY RUSTED AND DANGEROUS. WE HAVE 150,000 MILES ON THE VEHICLE.
ELECTRICAL SYSTEM
Jan 1, 2019
Incident date: Dec 21, 2018
THE ELECTRIC WIRING FOR THE WINDOWS AND SIDE MIRRORS WILL START MAKING A CLICKING NOISE AND WHEN I PUT THE KEY INTO THE IGNITION AND TURN THE KEY JUST ONE TURN THE FRONT PASSENGER WINDOW GOES COMPLETELY DOWN AND WILL NOT GO BACK UP UNTIL IT IS DONE CLICKING AND TURNING THE HEATED SEATS ON AND OFF. T... Read more
FUEL/PROPULSION SYSTEM
Dec 3, 2018
Incident date: Dec 2, 2018
STRONG SMELL OF GAS AND LEAKING FROM TOP OF TANK.
STRUCTURE:BODY
Oct 13, 2018
Incident date: Oct 8, 2018
2003 GMC ENVOY ... THE REAR DRIVER SIDE DOOR WILL NOT LATCH ... THE DOOR OPENED WHILE IN MOTION DOING ABOUT 30 MPH
STRUCTURE:BODY
Oct 13, 2018
Incident date: Oct 8, 2018
2003 GMC ENVOY... THE REAR PASSENGER SIDE DOOR WILL NOT LATCH ... THE DOOR OPENED DOING ABOUT 30 MPH
VEHICLE SPEED CONTROL
Oct 12, 2018
Incident date: Mar 19, 2018
THE DASH CLUSTER DOES NOT WORK CORRECTLY, ALL THE LIGHTS TURN ON AND DOORS LOCK WHILE I AM DRIVING ON IN TOWN OR ON THE HIGHWAY , ALL THE GAUGES COME ON AT ONCE WHILE DRIVING ON THE STREETS AT RANDOM TIMES.. THE REAR HAS AIRBAGS IN THE SUSPENSION AND AND AREN'T WORKING PROPERLY, I TOOK IT TO THE SHO... Read more
ELECTRICAL SYSTEM
Oct 12, 2018
Incident date: Mar 19, 2018
THE DASH CLUSTER DOES NOT WORK CORRECTLY, ALL THE LIGHTS TURN ON AND DOORS LOCK WHILE I AM DRIVING ON IN TOWN OR ON THE HIGHWAY , ALL THE GAUGES COME ON AT ONCE WHILE DRIVING ON THE STREETS AT RANDOM TIMES.. THE REAR HAS AIRBAGS IN THE SUSPENSION AND AND AREN'T WORKING PROPERLY, I TOOK IT TO THE SHO... Read more
ELECTRONIC STABILITY CONTROL (ESC)
Oct 12, 2018
Incident date: Mar 19, 2018
THE DASH CLUSTER DOES NOT WORK CORRECTLY, ALL THE LIGHTS TURN ON AND DOORS LOCK WHILE I AM DRIVING ON IN TOWN OR ON THE HIGHWAY , ALL THE GAUGES COME ON AT ONCE WHILE DRIVING ON THE STREETS AT RANDOM TIMES.. THE REAR HAS AIRBAGS IN THE SUSPENSION AND AND AREN'T WORKING PROPERLY, I TOOK IT TO THE SHO... Read more
EXTERIOR LIGHTING
Aug 12, 2018
Incident date: Aug 10, 2018
THE LIGHTS COME ON BY THEMSELVES AND DRAINS THE BATTERY. TWO BATTERIES HAVE BEEN INSTALLED. THE CAR HAS HAD ROAD SERVICE JUMP STARTS 3 TIMES IN 2 WKS. THE LIGHTS COME ON THEMSELVES WHEN THEY'R'E OFF. THE ALTERNATOR WAS CHECKED AND IS GOOD. THE VEHICLE WAS PARKED IN A GARAGE WHEN THIS OCCURRED A... Read more
ELECTRICAL SYSTEM
Aug 12, 2018
Incident date: Aug 10, 2018
THE LIGHTS COME ON BY THEMSELVES AND DRAINS THE BATTERY. TWO BATTERIES HAVE BEEN INSTALLED. THE CAR HAS HAD ROAD SERVICE JUMP STARTS 3 TIMES IN 2 WKS. THE LIGHTS COME ON THEMSELVES WHEN THEY'R'E OFF. THE ALTERNATOR WAS CHECKED AND IS GOOD. THE VEHICLE WAS PARKED IN A GARAGE WHEN THIS OCCURRED A... Read more
ENGINE
Jul 24, 2018
Incident date: Jul 11, 2018
GRADUAL COOLANT LOSS OVER TIME AND NO EVIDENCE OF LEAK. THIS WAS DUE TO A CRACK IN THE CYLINDER HEAD THAT GM ADMITTED TO KNOWING ABOUT IN TSB 06-06-01-019B ON JUNE 12, 2007). COOLANT WAS SLOWLY LEAKING INTO THE OIL, BUT WAS UNNOTICEABLE UNTIL IT STARTED TO AFFECT OIL PRESSURE FROM THE OIL BECOMING S... Read more
FUEL/PROPULSION SYSTEM
Jul 2, 2018
Incident date: Feb 15, 2018
LEAKING FUEL ON TANK AT FUEL NECK...FUEL FUMES, FUEL ON GROUND MAY CAUSE FIRE, NOT ENVIRONMENTALLY SAFE AS FUEL IS DUMPING ON THE GROUND WHERE EVER YOU DRIVE
ELECTRICAL SYSTEM
Jun 12, 2018
Incident date: Aug 15, 2017
TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. IN ADDITION, THE HEADLIGHTS FAILED TO ILLUMINATE WHILE DRIVING AT NIGHT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING O... Read more
EXTERIOR LIGHTING:HEADLIGHTS
Jun 12, 2018
Incident date: Aug 15, 2017
TL* THE CONTACT OWNS A 2003 GMC ENVOY. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. IN ADDITION, THE HEADLIGHTS FAILED TO ILLUMINATE WHILE DRIVING AT NIGHT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING O... Read more
AIR BAGS
May 11, 2018
Incident date: Apr 20, 2018
TL* THE CONTACT OWNED A 2003 GMC ENVOY. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO MAKE A LEFT TURN, THE CONTACT CRASHED INTO THE FRONT END OF ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT SUSTAINED INJURIES THAT DID NOT REQUIRE MED... Read more
Crash
1 injured
Showing 50 of 511 complaints.
Technical Service Bulletins, 2003 GMC ENVOY
811 manufacturer communications from 612 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 82 |
| 110000 ELECTRICAL SYSTEM | 75 |
| 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL | 62 |
| 061000 ENGINE AND ENGINE COOLING:ENGINE | 46 |
| 060000 ENGINE AND ENGINE COOLING | 43 |
| 060000 ENGINE (PWS) | 31 |
| 353000 EQUIPMENT:ELECTRICAL | 30 |
| 356000 EQUIPMENT ADAPTIVE/MOBILITY | 26 |
10-08-45-001H
Mar 28, 2024
110000 ELECTRICAL SYSTEM
This bulletin provides information for electrical ground repairs using new General Motors replacement fasteners with conductive finish.
06-06-01-019C
Mar 14, 2024
060000 ENGINE AND ENGINE COOLING
This bulletin advises the technician of possible location of an internal coolant leak from a specific cylinder head and location.
16-NA-383
Mar 13, 2024
060000 ENGINE AND ENGINE COOLING
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
22-NA-074
Feb 22, 2024
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
18-NA-099
Jan 16, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PI1394B
Jan 12, 2024
100000 POWER TRAIN
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
PI1394B
Jan 12, 2024
060000 ENGINE AND ENGINE COOLING
This PI bulletin advises the technician on the proper way to install the pistons in an engine.
02-08-42-001J
Jan 12, 2024
120000 EXTERIOR LIGHTING
This informational bulletin provides information for dealers/technicians on Headlamp, Tail Lamp, License Lamp or Fog/Driving Lamp Damage.
PIP5601B
Jan 12, 2024
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vibration complaints that are one of the most challenging complaints to accurately diagnose and repair. Technician will need to use Pico Oscilloscope Di
23-NA-219
Dec 12, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
23-NA-219
Dec 12, 2023
350000 EQUIPMENT
This service bulletin provides information on Concerns or Questions Regarding Installation of Dealer Installed Accessories.
17-NA-170
Oct 6, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
PIT5099G
Sep 26, 2023
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
10-00-89-006J
Sep 26, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
07-08-49-020R
Sep 21, 2023
117100 ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
350000 EQUIPMENT
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
07-08-49-020R
Sep 21, 2023
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
23-NA-153
Sep 1, 2023
100000 POWER TRAIN
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
23-NA-153
Sep 1, 2023
060000 ENGINE AND ENGINE COOLING
The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the customer that it is normal for the delay.
18-NA-073
Aug 24, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and prevent unnecessary engine replacement.
PIP5628G
Aug 10, 2023
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIP5358C
Jul 18, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
17-NA-170
Apr 27, 2023
200000 WHEELS
This service bulletin provides information about the Hunter wheel Road Force balancers that should be utilized for all repairs requiring balance and Road Force measurement.
19-NA-219
Apr 24, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
PIP5628F
Apr 24, 2023
061600 ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
04-00-89-015Z
Apr 19, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information on Warranty Administration a?? Required Operating Procedures - 8 Points (U.S. Only).
19-NA-219
Mar 23, 2023
060000 ENGINE AND ENGINE COOLING
This diagnostic tip bulletin provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
22-NA-009
Mar 17, 2023
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
17-NA-073
Feb 21, 2023
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This warranty administration bulletin provides information regarding the field action courtesy transportation policy.
01-08-42-001O
Feb 15, 2023
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
PIP5628E
Feb 10, 2023
353720 EQUIPMENT:ELECTRICAL:ACCESSORY GENERATOR:OUTLETS/RECEPTACLE
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
09-00-89-008F
Dec 21, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Warranty Administration bulletin provides retail and wholesale service personnel with the policies/procedures and the warranty transaction submission procedures that support the Personal Property Damage process.
PIP5540J
Dec 15, 2022
138220 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW:ELECTRICAL HEATING ELEMENT
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
21-NA-124
Dec 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
PIT3271N
Nov 29, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271N
Nov 29, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
22-NA-074
Nov 9, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-205
Oct 19, 2022
110000 ELECTRICAL SYSTEM
This service bulletin provides information on Module Harvesting.
PIT3033B
Oct 18, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician that the Cam gear alignment can be incorrect after replacing the HVAC mode actuator.
PIT3033B
Oct 18, 2022
061700 ENGINE AND ENGINE COOLING:ENGINE:CRANK/CAMSHAFT POSITION SENSOR
This Preliminary Information communication provides information to the technician that the Cam gear alignment can be incorrect after replacing the HVAC mode actuator.
10-00-89-006I
Oct 7, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
PIC5453D
Sep 30, 2022
980000 UNKNOWN OR OTHER
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
22-NA-195
Sep 28, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This service bulletin provides information on Handling Requests for Modifications to Permanently Import/Export Vehicles Between the U.S. and Canada.
06-00-89-031H
Sep 16, 2022
100000 POWER TRAIN
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
06-00-89-031H
Sep 16, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides information on OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification.
22-NA-009
Sep 14, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
22-NA-181
Sep 1, 2022
100000 POWER TRAIN
This diagnostic tip advises the tech not to separate the flexplate from the torque convertor or damage my occur if the engine is started while diagnosing for noise from the engine or transmission.
PIP5640A
Sep 1, 2022
100000 POWER TRAIN
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
20-NA-065
Aug 15, 2022
060000 ENGINE AND ENGINE COOLING
This bulletin provides information on tools available to find an intake vacuum leak or exhaust leak to correct a condition of MIL Illuminated with Multiple Fuel Trim and/or Oxygen Sensor Codes Set.
22-NA-009
Jun 15, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT5099F
Jun 13, 2022
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIP5358B
May 31, 2022
160000 STRUCTURE
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
18-NA-099
May 16, 2022
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
12-00-89-003B
May 2, 2022
060000 ENGINE (PWS)
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
12-00-89-003B
May 2, 2022
353000 EQUIPMENT:ELECTRICAL
This service bulletin provides policy information on warranty administration guidelines for multiple repairs with independent causes (GM Canada Dealers Only).
22-NA-074
Mar 31, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large amounts of debris has flowed throughout the oiling system.
22-NA-009
Mar 22, 2022
060000 ENGINE AND ENGINE COOLING
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
PIT3271M
Mar 7, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271M
Mar 7, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271L
Feb 3, 2022
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271L
Feb 3, 2022
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIP4723F
Jan 14, 2022
070000 FUEL SYSTEM, GASOLINE
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
PIP4723F
Jan 14, 2022
030000 SERVICE BRAKES, HYDRAULIC
This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester and
22NA009
Jan 11, 2022
061520 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:FILTER/SCREEN
This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
000090002L
Jan 4, 2022
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
This service bulletin provides information for accurate tire pressures that ensure the safe handling and appropriate ride characteristics of GM cars and trucks.
PIP5628E
Dec 14, 2021
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
PIT3099U
Aug 11, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts/kits. Technicians should refer to Service Information for information regarding most accessories. Technician
010842001N
Jun 21, 2021
356000 EQUIPMENT ADAPTIVE/MOBILITY
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
010842001N
Jun 21, 2021
350000 EQUIPMENT
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
010842001N
Jun 21, 2021
120000 EXTERIOR LIGHTING
This service bulletin provides information for dealers/technicians on Exterior Lamp Condensation and Water Leaks and Replacement Guidelines.
21NA124
May 25, 2021
071410 FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
21NA124
May 25, 2021
110000 ELECTRICAL SYSTEM
This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or P0455 Set.
100089006H
May 17, 2021
350000 EQUIPMENT
This service bulletin provides information for dealers on how to submit a product information report (PIR) (Canada Only).
PIP5358A
May 12, 2021
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
PIP5358A
May 12, 2021
160000 STRUCTURE
This Preliminary Information communication provides information to the technician about vehicles that have an unusual noise and is difficult to identify, isolate or pinpoint. Technician should get record a sound clip or take a video of the
PIP5640A
Apr 12, 2021
200000 WHEELS
This Preliminary Information communication provides information to the technician to not remove the torque converter bolts and start the engine as this may cause damage to the torque converter of the crankshaft on vehicles equipped with an
PIP5163E
Mar 30, 2021
070000 FUEL SYSTEM, GASOLINE
This Preliminary Information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
18NA099
Mar 30, 2021
350000 EQUIPMENT
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PIP5540G
Mar 22, 2021
061560 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION:PRESSURE/TEMPERATURE SENSOR
This Preliminary information communicates to the technician the need to inspect the induction system for potential icing issues in very cold ambient temperatures. To allow the ice to melt so that it can be drained from the related component
PIP5725A
Mar 19, 2021
350000 EQUIPMENT
This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in
RFI20201207_599-
Dec 7, 2020
110000 ELECTRICAL SYSTEM
This SKU is a Climate Control Module. The customer communication requested return of unsold inventory to inspect for a software issue. If the software issue exists it can cause a fan in the climate control system to stay on even when the
PIT3271K
Nov 11, 2020
190000 TIRES
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIT3271K
Nov 11, 2020
200000 WHEELS
This Preliminary Information communication provides information to the technician about changing the tire and wheel size on vehicles. General Motors will only support a tire calibration for tires that have been sized, tested and designed fo
PIP5628C
Oct 8, 2020
060000 ENGINE AND ENGINE COOLING
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
18NA099
Aug 5, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This bulletin provides information for use on a Product Assistance Claim (PAC), which is formerly known as a Product Allegation Resolution (PAR) claim.
PIP5226D
Jul 27, 2020
060000 ENGINE (PWS)
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIP5226D
Jul 27, 2020
350000 EQUIPMENT
This Preliminary Information communication provides information to the technician about finding needle bearings during an oil change. Technician will gain access to the roller rockers to inspect them. Only replace the roller rocker that is
PIT5099E
Jul 27, 2020
138000 VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
This Preliminary Information communication provides information to the technician about vehicles that the Heater-Vent-Air Conditioning blows warm air. Before calling General Motors Technical Assistance Center technician will need to have hi
PIC5453D
Jul 22, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIC5453D
Jul 22, 2020
355100 EQUIPMENT:OTHER:LABELS
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIC5453C
Jun 5, 2020
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
This Preliminary Information communication provides information to the technician that General Motors and General Motors of Canada Company do not support cross border sales. The General Motors of Canada Customer Care Centre is the sole auth
PIP5628B
May 21, 2020
060000 ENGINE (PWS)
This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308 and/or P050D
070849020Q
May 20, 2020
110000 ELECTRICAL SYSTEM
This informational bulletin provides information for the IPC odometer programming method quick reference guide.
PIT3116B
May 13, 2020
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
This Preliminary information communicates information to Clean the throttle body if the engine stalls at idle when the A/C comes on.
PIP5725
May 8, 2020
070000 FUEL SYSTEM, GASOLINE
This Preliminary information communicates the use of Winter grade fuel during the warm months of 2020 and the potential rivability issues that it can cause. The ongoing Coronavirus (COVID-19) pandemic has caused significant reductions in
16NA383
May 8, 2020
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
16NA383
May 8, 2020
060000 ENGINE (PWS)
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
16NA383
May 8, 2020
356000 EQUIPMENT ADAPTIVE/MOBILITY
This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank or misfire, MIL with DTCs, and explains how Top Tier fuels shou
19NA219
Feb 28, 2020
060000 ENGINE (PWS)
This diagnostic tip provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
19NA219
Feb 28, 2020
350000 EQUIPMENT
This diagnostic tip provides additional information on how to diagnose a possible valve, lifter or camshaft issue.
Showing 100 of 811 bulletins.
NHTSA Safety Investigations, GMC ENVOY
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
PE05006
Opened: Feb 4, 2005 , Closed: May 6, 2005
TURN SIGNAL FAILURES
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES B... Read more
EA03007
Opened: May 6, 2003 , Closed: Jun 18, 2004
ENGINE STALL
MODEL YEAR (MY) 2002 BRAVADA AND CERTAIN MY 2002 ENVOY VEHICLES WITH OPTIONAL ELECTRONICALLY CONTROLLED AIR SUSPENSION (ECAS) MAY BE SUBJECT TO ENGINE STALL CAUSED BY AN ERRANT VOLTAGE SPIKE TRANSMITTED TO THE POWERTRAIN CONTROL MODULE (PCM).IN ADDITION TO ENGINE STALL, IF THE SPIKE DAMAGES THE PCM,... Read more
PE03001
Opened: Jan 3, 2003 , Closed: May 6, 2003
ENGINE STALL
OF THE 697 TOTAL COMPLAINTS, 240 WERE RECEIVED FOR THEENVOY AND 457 FOR THE BRAVADA.GM HAS IDENTIFIED ABOUT 5,000 WARRANTY CLAIMS RELATED TO STALLING IN THE SUBJECT VEHICLES.GM REPORTS THAT A TRANSIENT VOLTAGE SPIKE GENERATED IN THE ECAS DEGRADES THE PERFORMANCE OF THE PCM RESULTING IN ENGINE STALL.... Read more
GMC ENVOY - All Years Overview
Complete safety history for the GMC ENVOY across all model years (1998, 2007).
46
Total Recalls
3,281
Total Complaints
3
Investigations
218
Reported Crashes
121
Reported Fires
17
Reported Deaths
GMC ENVOY - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.