Complaint Statistics
18 total complaints
3 fires
Top Reported Components
| Component | Complaints |
|---|
| POWER TRAIN | 6 |
| FUEL/PROPULSION SYSTEM | 3 |
| ELECTRICAL SYSTEM | 2 |
| ENGINE | 2 |
| UNKNOWN OR OTHER | 2 |
| TIRES | 1 |
| ELECTRICAL SYSTEM:IGNITION | 1 |
| STEERING | 1 |
Incident date: Dec 31, 1969
Transmission shifting issues. The transmission will shift very slowly (engine revs high and vehicle lurches) when driving the truck each morning. I reported the issue to the dealership within 0ne month of purchasing the truck in 2019 and again in 2024. The dealership stated there is nothing wrong wi
... th the transmission. The transmission is now starting to slip at low/moderate speeds when accelerating. The vehicle has less than 50,000 miles.Read more
Incident date: Jul 9, 2025
Formal Complaint to NHTSA: 2019 GMC Canyon Transmission Issue To Whom It May Concern at the National Highway Traffic Safety Administration (NHTSA): I am writing to formally report a recurring and dangerous transmission issue in my 2019 GMC Canyon, and to request that NHTSA open an investigation into
... why General Motors has not issued a safety recall — despite widespread complaints and technical service bulletins. My vehicle exhibits jerking, hesitation, slipping, and hard shifting — especially during acceleration or when moving from a complete stop. These symptoms are consistent with hundreds of other consumer reports across forums, NHTSA complaints, and class-action lawsuits tied to GM’s 8L45 8-speed automatic transmission. I was quoted approximately $5,700 for a transmission repair and $8,800 for replacement. This problem is not simply an inconvenience or comfort issue. Hesitation and sudden surges in acceleration pose a legitimate safety hazard, especially when merging onto highways, pulling into traffic, or driving on slippery roads. At times, I’ve experienced delayed throttle response and unexpected lurching — which could easily result in a rear-end collision or intersection mishap. Despite the well-documented nature of this defect, GM has not recalled these transmissions — and owners are left to bear the financial burden of expensive repairs on a known design flaw. That is unacceptable. NHTSA’s mandate is to protect consumers from safety-related defects. In my view, and in the experience of many other drivers, this transmission issue meets the criteria for a recall: - It affects safe operation and control of the vehicle - It has been confirmed by internal GM service documentation - It recurs even after manufacturer-prescribed remedies - It places drivers, passengers, and others at risk Please consider this a formal request to investigate this matter and hold General Motors accountable for a recall or reimbursement program for affected consumers. Joanne HolsteinRead more
Incident date: Sep 30, 2024
The contact owns a 2019 GMC Canyon. The contact stated that while driving at undisclosed speeds and making a right turn, the steering wheel seized. The contact continued to drive, and the steering wheel seized again. There were no warning lights illuminated. The local dealer was not contacted. The v
... ehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 65,200.Read more
Incident date: Jun 13, 2024
The contact owns a 2019 GMC Canyon. The contact stated while driving 60 MPH, the vehicle stalled and failed to restart. There was an abnormal scratching noise detected. The check engine warning light was illuminated. The vehicle was towed to the local dealer, where it was diagnosed and determined th
... at an unknown part had fractured inside the engine. The mechanic informed the contact that the engine needed to be replaced. The contact was informed that there was no warranty coverage on the vehicle. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 64,000. The VIN was not available.Read more
Incident date: May 31, 2024
The contact owns a 2019 GMC Canyon. The contact stated that the key failed to release from the ignition. Additionally, the key failed to turn in the ignition switch. The vehicle failed to turn on or off. There were no warning lights illuminated. The contact called the local dealer and was informed t
... hat a diagnostic test needed to be performed. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and informed the contact that there was no Warranty coverage for the vehicle. The failure mileage was approximately 52,000.Read more
Incident date: Nov 2, 2023
The high pressure fuel pump broke twice within a 6 month period. The first time, I was traveling at 70 mph in the middle of 100 degree weather in Texas. When I took it to the shop, the mechanic mentioned that the bolt broke inside of the engine and caused the high pressure fuel pump to break and dum
... p gasoline everywhere. It was repaired by adding a new pump and fuel line. After driving it for 5 months, the same issue happened again while driving 30 mph. My safety was put at risk since it was large amounts of gasoline that it was throwing which could have easily caused a explosion/fire. The warning message was a check engine light and the truck going into limp mode. From my research, this exact issue was a recall for the 2018 version of the truck.Read more
Incident date: Aug 17, 2023
All 5 tires including the spare are dry rotted, and have become extremely unsafe in wet weather conditions. Truck came with these tires and only has 27k miles with a lot of tread left.
Incident date: Mar 21, 2020
Truck jerks and makes loud noises when going up incline when transmission is shifting and constantly shifting even at low speed.
Incident date: Feb 8, 2023
High pressure fuel pump broke off while driving on highway causing truck to stall. Stabilitrack warning was activated and Engine Power Reduced message came on dash. Speed was rapidly reduced to 15 mph on the highway and started knocking hard. Mechanic found the pump physically broke and a bolt was s
... heered off inside of head.Read more
Incident date: Dec 14, 2022
Noticed oil on snow in driveway. Upon inspection, noted that engine oil cooler pipe is corroded-through and oil, under pressure, is leaking when engine is running and blowing back onto hot engine components. Also noted smoke from under hood/engine compartment.
Incident date: Sep 22, 2021
On Wednesday September 22nd at approximately 9:45 pm. My 2019 GMC Canyon was parked on my street and caught fire and was destroyed for no known reason. The fire department came ruled the cause as un known. The cabin and the bed were totally destroyed. Appears to be no issue to the engine compartme
... nt.Read more
Fire
Incident date: Sep 22, 2021
On Wednesday September 22nd at approximately 9:45 pm. My 2019 GMC Canyon was parked on my street and caught fire and was destroyed for no known reason. The fire department came ruled the cause as un known. The cabin and the bed were totally destroyed. Appears to be no issue to the engine compartme
... nt.Read more
Fire
Incident date: Sep 22, 2021
On Wednesday September 22nd at approximately 9:45 pm. My 2019 GMC Canyon was parked on my street and caught fire and was destroyed for no known reason. The fire department came ruled the cause as un known. The cabin and the bed were totally destroyed. Appears to be no issue to the engine compartme
... nt.Read more
Fire
Incident date: Jun 27, 2021
The vehicle hesitates and shifts harshly as if it will stall at low speed acceleration leaving my driveway and when going forward from a full stop at red light to green. Very jerky ride, uneven acceleration, fear of stalling.
Incident date: Apr 1, 2019
TRANSMISSION SLIPS ON INCLINES. HAVE TAKEN IT TO DEALER SEVERAL TIMES . THEY CHANGED FLUID AND IT STILL SLIPS ON INCLINES. DOESN'T SLIP ALL OF THE TIME, BUT DOES STILL SLIP! THIS STARTED APPROX. 2 MONTHS AFTER PURCHASE. BOUGHT NEW.
Incident date: Sep 9, 2019
ON COLD STARTUP THERE IS A LOUD CLUNK COMING FROM FRONT OF VEHICLE AND THE VIBRATION CAN BE FELT FROM INSIDE THE TRUCK AS IF SOMETHING HIT THE FLOOR UNDERNEATH.
Incident date: Sep 9, 2019
ON COLD STARTUP THERE IS A LOUD CLUNK COMING FROM FRONT OF VEHICLE AND THE VIBRATION CAN BE FELT FROM INSIDE THE TRUCK AS IF SOMETHING HIT THE FLOOR UNDERNEATH.
Incident date: Sep 9, 2019
ON COLD STARTUP THERE IS A LOUD CLUNK COMING FROM FRONT OF VEHICLE AND THE VIBRATION CAN BE FELT FROM INSIDE THE TRUCK AS IF SOMETHING HIT THE FLOOR UNDERNEATH.
NHTSA Safety Investigations — GMC CANYON
Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.
RQ — Closed
— Model Year: 2006
BRAKE LAMP SWITCH MALFUNCTION
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 V
... EHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).Read more
PE — Closed
— Model Year: 2005
BRAKE LAMP SWITCH FAILURE
BY LETTER DATED APRIL 26, 2006, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO. 06V139) INVOLVING CERTAIN MODEL YEAR (MY) 2004-06 CHEVROLET COLORADO, GMC CANYON AND 2006 MY ISUZU I280/I350 VEHICLES.GM'S RECALL COVERS 404,733 VEHICLES.GM REPORTS THAT LOSS OF BRAKE LAMP
... ILLUMINATION WAS CAUSED BY INSUFFICIENT PLATING ON THE STATIONARY CONTACT IN THE BRAKE LAMP SWITCH.GM WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY ON ALL INVOLVED VEHICLES WITH THE NEW SWITCH THAT HAS THE INCREASED PLATING ON THE STATIONARY CONTACT.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.Read more
PE — Closed
— Model Year: 2004
INADVERTENT FRONT AIRBAG DEPLOYMENT
ALL REPORTS INDICATE INADVERTENT DEPLOYMENT DURING IGNITION START-UP (KEY-ON) AND WITH THE VEHICLE NOT IN MOTION.REPORTED INJURIES WERE MINOR AND CONSIST OF SKIN ABRASION AND BRUISES.THE INCIDENT DATES RANGED FROM JULY THROUGH NOVEMBER 2004.ODI HAS RECEIVED NO ADDITIONAL REPORTS SINCE OPENING THIS I
... NVESTIGATION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.Read more