FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 15, 2007. OWNERS CAN CONTACT FEDERAL-MOGUL AT 248-354-7700.
34,000 vehicles affected
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
THE FLEXIBLE BLADE ENGINE COOLING FAN BLADES MAY CRACK AND BREAK OFF. THIS MAY BE CAUSED BY HIGH BLADE STRESSES THAT CAN RESULT FROM VIBRATION DURING VEHICLE OPERATION.
Remedy: DEALER WILL REPLACE THE DEFECTIVE ENGINE COOLING FAN AT NO COST TO OWNER.
83,000 vehicles affected
STRUCTURE:BODY:BUMPERS
THE INVOLVED VEHICLES WERE ASSEMBLED WITH INCORRECT ATTACHING U-NUTS USED TO SECURE THE REAR BUMPER LEFT ISOLATOR AND BRACKET ASSEMBLY. IN THE EVENT OF A REAR-END COLLISION, THE U-NUTS COULD CONTACT AND CUT THE FUEL TANK, CAUSING FUEL LEAKAGE.
Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE ATTACHING HARDWARE, WITHOUT CHARGE TO OWNER.
642 vehicles affected
TIRES
THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS". THESE LIGHT TRUCKS WERE INCORRECTLY CLASSIFIED AS PASSENGER VEHICLES AND WERE EQUIPPED WITH LOAD RANGE "A" INSTEAD OF LOAD RANGE "B" TIRES. THIS COULD LEAD TO INADVERTENT VEHICLE OVERLOADING.
Remedy: DEALER WILL INSPECT AND REPLACE LOAD RANGE "A" WITH THE PROPER LOAD RANGE "B" TIRES, WITHOUT CHARGE TO OWNER.
46 vehicles affected
FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
18,000 vehicles affected