2004 FORD FIVE HUNDRED Recalls, Complaints & Safety

No recalls found for this vehicle.

Complaint Statistics

1 total complaints

Top Reported Components

Component	Complaints
SERVICE BRAKES, HYDRAULIC	1

Incident date: Jul 1, 2010

TL*THE CONTACT OWNS A 2004 FORD FIVE HUNDRED. THE CONTACT RECEIVED A SAFETY IMPROVEMENT CAMPAIGN PERTAINING TO THE BRAKES. THE CAMPAIGN NUMBER WAS NOT AVAILABLE. THE RECALL ADVISED CONSUMERS WITH 15,000 MILES OR MORE ON THEIR VEHICLE TO HAVE THE REMEDY PERFORMED AT THE MANUFACTURER'S EXPENSE. THE CO... Read more

NHTSA Safety Investigations, FORD FIVE HUNDRED

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2005

Idle instability

On November 29, 2012, Ford Motor Company (Ford) initiated Customer Satisfaction Program 12N03 to extend warranty coverage terms for repair of engine idle RPM surge caused by throttle body deposits in all model year (MY) 2005 through 2007 Ford Freestyle, Five Hundred and Mercury Montego vehicles.The ... program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle (all vehicles are eligible for the program through May 31, 2013, regardless of mileage).Dealers will repair vehicles exhibiting the condition by removing and cleaning the throttle body and reprogramming the PCM with software containing an updated idle speed control strategy.According to Ford, some of the affected vehicles may experience momentary, intermittent engine idle RPM surge (idle flare) when stopped or during low speed driving maneuvers such as in a parking lot or driveway.Unstable idle speed control (dips and flares) around the target engine speed (700 rpm) can occur in vehicles with deposit build-up in the throttle body when the system adjusts engine speed in response to changes in engine load, typically from power steering application or air-conditioner compressor cycling.Idle speed control logic is only active at vehicle speeds below 3.5 mph and when the accelerator pedal is not applied.Ford testing of a vehicle with a worst case throttle body measured a maximum idle flare of 1360 RPM lasting approximately 1 second, which Ford indicated was consistent with system design to limit vehicle speed and acceleration in idle control mode.Ford indicated that the test vehicle was held in place with normal brake effort and that vehicle speed remained under 4 mph without the brake pedal applied.In addition to throttle body deposit accumulation, symptoms associated with the condition may include Check Engine lamp illumination and diagnostic trouble codes (DTCs) P0505, P0506 or P061B.Ford attributed the surge condition to changes in idle air flow resulting from the progressive buildup of deposits in the throttle body from normal Positive Crankcase Ventilation (PCV) system operation.This condition was not adequately compensated for in the original Powertrain Control Module (PCM) calibration.Ford issued a technical service bulletin on August 15, 2011 (TSB 11-8-5), releasing an updated powertrain control calibration for vehicles with CVT transmissions.On October 19, 2011, Ford issued a second bulletin (TSB 11-10-21) superseding TSB 11-8-5 and including updated powertrain control calibration for vehicles with 6-speed transmissions.Prior to Ford issuing the TSB?s, owner?s experiencing the alleged defect either received no repairs, if dealers could not duplicate the condition, or had the throttle body cleaned or replaced, which only provided temporary correction until the throttle deposit build-up returned.Ford?s revised powertrain calibrations appear to be effective remedies for the idle instability caused by build-up of throttle body deposits.However, even after the TSB?s were released, many owners experiencing the condition continued to have difficulty with proper diagnosis and repair as dealers were often either unable to duplicate the condition or were unfamiliar with the new repair procedures.Ford's new program addresses those concerns.NHTSA's testing and complaint analysis indicate that the idle speed control issue in the subject vehicles can only occur at very low speeds, are very brief events, are easily controlled by moderate brake pedal forces and result in minor increases in vehicle speed even with no braking.This investigation is closed.The closing of this inRead more

PE, Closed , Model Year: 2005

INSTRUMENT CLUSTER FAILURE

THE SUBJECT VEHICLES EXPERIENCE A LOSS OF PROPER INSTRUMENT CLUSTER OPERATION.TYPICALLY, THE PROBLEM APPEARS AS THE NEEDLE ON THE GAUGE (SPEEDOMETER, TACHOMETER, FUEL, AND/OR TEMPERATURE) SWEEPS AND RESETS INTERMITTENTLY.FORD REPORTS THE PROBLEM AS MOMENTARY POWER INTERRUPTION CAUSES THE GAUGES TO S... Read more

FORD FIVE HUNDRED - All Years Overview

Complete safety history for the FORD FIVE HUNDRED across all model years (2005, 2007).

6 Total Recalls

1,527 Total Complaints

2 Investigations

85 Reported Crashes

24 Reported Fires

0 Reported Deaths

FORD FIVE HUNDRED - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2007	2	287	View
2006	1	523	View
2005	3	716	View
2004 (current)	0	1

Other FORD Models

Model	Recalls	Complaints
MUSTANG	1,104	11,600	View
RANGER	928	10,371	View
F-350 SD	776	2,363	View
F-450 SD	692	624	View
F-150	692	46,142	View
F-250 SD	638	3,635	View
EXPLORER	624	42,549	View
F-550 SD	578	603	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2004 FORD FIVE HUNDRED