2002 FLEETWOOD FLAIR
4 recalls, 3 complaints
09V198000 Jun 2, 2009
SERVICE BRAKES, AIR
Defect Description
FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENE... Read more
Consequence
THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER ... Read more
07V120000 Mar 19, 2007
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Defect Description
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy
FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICY... Read more
03V452000 Nov 4, 2003
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
Defect Description
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING A... Read more
Consequence
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN F... Read more
03V066000 Mar 4, 2003
SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP
Defect Description
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence
IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy
DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.
Complaint Statistics
3 total complaints
Top Reported Components
| Component | Complaints |
|---|---|
| SERVICE BRAKES, HYDRAULIC | 1 |
| SERVICE BRAKES | 1 |
| PARKING BRAKE | 1 |
SERVICE BRAKES
Aug 20, 2013
Incident date: Jul 23, 2007
THE PARKING BRAKE STARTED LEAKING HYDRAULIC BRAKE FLUID AND I WAS NOT ABLE TO MOVE THE MOTORHOME. I HAD IT TOWED TO WORKHORSE DEALER TO HAVE IT FIXED. MY MOTORHOME IS NOW CURRENTLY IN MY DRIVEWAY WITH THE SAME PROBLEM! *TR
PARKING BRAKE
Aug 20, 2013
Incident date: Jul 23, 2007
THE PARKING BRAKE STARTED LEAKING HYDRAULIC BRAKE FLUID AND I WAS NOT ABLE TO MOVE THE MOTORHOME. I HAD IT TOWED TO WORKHORSE DEALER TO HAVE IT FIXED. MY MOTORHOME IS NOW CURRENTLY IN MY DRIVEWAY WITH THE SAME PROBLEM! *TR
SERVICE BRAKES, HYDRAULIC
Sep 22, 2003
Incident date: Sep 10, 2003
WHILE BRAKING 60 MPH PEDAL WAS HARD AND WENT TO THE FLOOR, CAUSING EXTENDED STOPPING DISTANCE. CONSUMER MANAGED TO STOP THE VEHICLE BY PULLING OVER INTO A DITCH. CAUSE HAS YET TO BE DETERMINED. HAD TAKEN VEHICLE TO DEALERSHIP, BUT THE PROBLEM HAD NOT BEEN RESOLVED. *AK CONSUMER RAN A... Read more
FLEETWOOD FLAIR - All Years Overview
Complete safety history for the FLEETWOOD FLAIR across all model years (1989, 2026).
89
Total Recalls
87
Total Complaints
0
Investigations
2
Reported Crashes
3
Reported Fires
0
Reported Deaths
FLEETWOOD FLAIR - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.
| Year | Recalls | Complaints | |
|---|---|---|---|
| 2026 | 1 | 0 | View |
| 2025 | 2 | 0 | View |
| 2024 | 3 | 3 | View |
| 2023 | 5 | 0 | View |
| 2022 | 5 | 4 | View |
| 2021 | 5 | 0 | View |
| 2020 | 4 | 4 | View |
| 2019 | 5 | 5 | View |
| 2018 | 4 | 0 | View |
| 2017 | 3 | 0 | View |
| 2016 | 2 | 2 | View |
| 2015 | 0 | 4 | View |
| 2008 | 1 | 0 | View |
| 2007 | 2 | 0 | View |
| 2006 | 5 | 4 | View |
| 2005 | 4 | 0 | View |
| 2004 | 7 | 2 | View |
| 2003 | 6 | 3 | View |
| 2002 (current) | 4 | 3 | |
| 2001 | 4 | 1 | View |
| 2000 | 3 | 11 | View |
| 1999 | 1 | 6 | View |
| 1998 | 3 | 3 | View |
| 1997 | 2 | 4 | View |
| 1996 | 0 | 9 | View |
| 1995 | 1 | 3 | View |
| 1994 | 2 | 2 | View |
| 1993 | 1 | 1 | View |
| 1992 | 0 | 2 | View |
| 1991 | 0 | 4 | View |
| 1990 | 2 | 1 | View |
| 1989 | 2 | 6 | View |