2018 E-ONE TYPHOON
7 recalls, 0 complaints - 15 TSBs
21V332000 May 11, 2021
FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL
Defect Description
E-One Incorporated (E-One) is recalling certain 2017-2021 Cyclone 2, Cyclone N, Quest 2, Typhoon, and Typhoon N vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Dealers will inspect and replace the rail as necessary, free of charge. Owner notification letters were mailed out on May 28, 2021. Owners may contact E-One customer service at 1-352-237-1122.
20V546000 Sep 9, 2020
SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE
Defect Description
E-One Incorporated (E-One) is recalling certain 2018-2020 Cyclone 2 and Typhoon ambulances. The lower shock mount bracket may cause the U-bolts to bind and break, possibly preventing the rear axle from remaining secured.
Consequence
The unsecured rear axle may shift sideways, resulting in loss of control of the vehicle, thereby increasing the risk of crash.
Remedy
E-One has notified owners, and dealers replace any of the affected lower shock mount brackets, free of charge. The recall began September 21, 2020. Owners may contact E-One customer service at 1-888-237-1751.
19V730000 Oct 14, 2019
ELECTRICAL SYSTEM:STARTER ASSEMBLY
Defect Description
E-One Incorporated (E-One) is recalling certain 2013-2019 Typhoon and Cyclone 2, 2013-2014 Cyclone 3, 2014-2019 Quest 2 and 2017 CHSH emergency vehicles equipped with a Cummins ISL, L9, ISX12, X12, ISX15, or X15 engine. The engines do not have a diode in the starter solenoid circuit to improve the... Read more
Consequence
The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies, increasing the risk of an injury.
Remedy
E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began November 15, 2019. Owners may contact E-One customer service at 1-352-861-3612. Note: Vehicles previously repaired under recall 18V... Read more
19V649000 Sep 10, 2019
EQUIPMENT
Defect Description
E-One Incorporated (E-One) is recalling one 2018 Typhoon emergency vehicle equipped with a Hale SmartFoam 6.5 foam pump system with a 12 volt power supply. The foam pump system can overheat and fail, causing fire fighting foam chemical to be unavailable to fight a fire.
Consequence
If the fire fighting foam chemical injection is unavailable, it can impact the fire fighting and/or vapor mitigation efforts, which increases the risk of injury to bystanders and emergency personnel.
Remedy
E-One will notify owners, and a Hale dealer will replace the SmartFoam 6.5 12 volt system with SmartFoam 6.5 24 volt system and a voltage converter, free of charge. The recall began October 15, 2019. Owners may contact E-One customer service at 1-352-861-3612 or Hale at 1-800-533-3569.
19V598000 Aug 14, 2019
SUSPENSION:FRONT
Defect Description
E-One Incorporated (E-One) is recalling certain 2014-2019 Cyclone II, 2013-2014 and 2016-2019 Typhoon, 2015-2017 Quest fire trucks. The front shocks may separate from their upper mount on the front suspension. The loose shock may contact and damage the steering gear housing, possibly causing a ste... Read more
Consequence
A loss of hydraulic steering assist can increase the risk of a crash.
Remedy
E-One has notified owners, and dealers will install a new shock mount bolt and nut, hardened washer, and shims to keep the shocks secured, free of charge. The recall began August 28, 2019. Owners may contact E-One customer service at 1-352-861-3612.
18V748000 Oct 22, 2018
SUSPENSION:REAR
Defect Description
E-One Incorporated (E-One) is recalling certain 2016-2018 E-One Cyclone II and Typhoon aerial devices. The torque rod tower may crack causing failure of the tower, possibly affecting vehicle handling.
Consequence
If the torque rod tower fails and affects vehicle handling, it can increase the risk of a crash.
Remedy
E-One will notify owners, and direct owners to contact the manufacturer of the Atlas suspension for replacement parts, free of charge. The recall began January 10, 2019. Owners may contact E-One customer service at 1-352-861-3612.
18V606000 Sep 11, 2018
EXTERIOR LIGHTING:BRAKE LIGHTS
Defect Description
E-One Incorporated (E-One) is recalling certain 2017-2019 Cyclone II, Typhoon and Quest II emergency vehicles, equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these v... Read more
Consequence
If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Remedy
E-One will notify owners, and dealers will replace the brake lights, free of charge. The recall began October 26, 2018. Owners may contact E-One customer service at 1-352-861-3612.
No complaints found for this vehicle.
Technical Service Bulletins, 2018 E-ONE TYPHOON
15 manufacturer communications from 10 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.
Most Affected Components
| Component | Bulletins |
|---|---|
| 350000 EQUIPMENT | 6 |
| 980000 UNKNOWN OR OTHER | 2 |
| 110000 ELECTRICAL SYSTEM | 1 |
| 126000 EXTERIOR LIGHTING:TURN SIGNAL | 1 |
| 114000 ELECTRICAL SYSTEM:WIRING | 1 |
| 070000 FUEL SYSTEM, GASOLINE | 1 |
| 060000 ENGINE AND ENGINE COOLING | 1 |
| 060000 ENGINE (PWS) | 1 |
2023-1210
Jun 1, 2023
020000 SUSPENSION
E-ONE has been contacted by Reyco Granning concerning the Independent Front Suspension (IFS) on your vehicle. Some IFS-FT units may have shock absorbers that experience excessive loading during road events that cause full extension of the
MIC-EONE-090120
Sep 1, 2020
350000 EQUIPMENT
August 2020 TSB report for E-ONE, Inc.
MIC-EONE030320
Mar 3, 2020
350000 EQUIPMENT
E-ONE, Inc. TSB report for the month of February 2020.
MIC-EONE 020420
Feb 4, 2020
350000 EQUIPMENT
E-ONE, Inc. TSB report for January 2020 sent 02/03/20 missing Index of Manufacturer (MFR) Communications. This communication is to add that record.
2019-1068
Mar 22, 2019
060000 ENGINE AND ENGINE COOLING
Front intake Storz adapter (E-ONE part number 572138) does not include an intake strainer compliant with NFPA 1901. E-ONE is replacing the complete adapter with strainer at no charge.
2019-1068
Mar 22, 2019
350000 EQUIPMENT
Front intake Storz adapter (E-ONE part number 572138) does not include an intake strainer compliant with NFPA 1901. E-ONE is replacing the complete adapter with strainer at no charge.
2019-1068
Mar 22, 2019
060000 ENGINE (PWS)
Front intake Storz adapter (E-ONE part number 572138) does not include an intake strainer compliant with NFPA 1901. E-ONE is replacing the complete adapter with strainer at no charge.
2019-1068
Mar 22, 2019
350000 EQUIPMENT
The front intake Storz Adapter does not include an intake strainer compliant with NFPA 1901.
2018-1048
Nov 14, 2018
070000 FUEL SYSTEM, GASOLINE
E-ONE has identified that a large number of DEF tank senders that have been returned for evaluation have been diagnosed as no fault found from the manufacturer. In an effort to minimize this in the future, we are sending this bulletin alon
2018-1048
Nov 14, 2018
350000 EQUIPMENT
E-ONE has identified that a large number of DEF tank senders that have been returned for evaluation have been diagnosed as no fault found from the manufacturer. In an effort to minimize this in the future, we are sending this bulletin alon
2018-1047
Nov 5, 2018
114000 ELECTRICAL SYSTEM:WIRING
During a routine truck delivery inspection a malfunction of the air flow restriction indicator light was detected. Our investigation determined that the malfunction was introduced in 2007 with the launch of the new ISSPRO gauge cluster. The
TSB2018-1043
Oct 17, 2018
110000 ELECTRICAL SYSTEM
During a routine truck delivery inspection a malfunction of the air flow restriction indicator light was detected. Our investigation determined that the malfunction was introduced in 2010 with the launch of the new ISSPRO gauge cluster. The
TSB2018-1043
Oct 17, 2018
126000 EXTERIOR LIGHTING:TURN SIGNAL
During a routine truck delivery inspection a malfunction of the air flow restriction indicator light was detected. Our investigation determined that the malfunction was introduced in 2010 with the launch of the new ISSPRO gauge cluster. The
No comms 2022-08
Sep 1, 2022
980000 UNKNOWN OR OTHER
There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for August 2022 for E-One Incorporated.
No comms 2023-05
Jun 1, 2023
980000 UNKNOWN OR OTHER
There are no Manufacturer Communications in accordance with 49 CFR 579.5 to report for May 2023 for E-One Incorporated.
E-ONE TYPHOON - All Years Overview
Complete safety history for the E-ONE TYPHOON across all model years (2005, 2024).
99
Total Recalls
0
Total Complaints
0
Investigations
0
Reported Crashes
0
Reported Fires
0
Reported Deaths
E-ONE TYPHOON - Year by Year
Compare recalls and complaints across model years. Click any year to see full details.