STEERING
DUCATI IS RECALLING CERTAIN MODEL YEAR 2010-2011 MULTISTRADA 1200, AND MODEL YEAR 2011, DIAVEL MOTORCYCLES. THE ELECTRONIC STEERING LOCK MAY FAIL TO DISENGAGE DURING THE MOTORCYCLE "KEY-ON" PROCESS. THIS HAS BEEN LINKED DIRECTLY TO A CERTAIN REVISION OF THE HANDS FREE DEVICE SOFTWARE. IT COULD RESULT IN A SITUATION WHERE THE MOTORCYCLE'S ENGINE MIGHT START WHILE THE STEERING LOCK IS STILL ENGAGED. A RIDER COULD START THE MOTORCYCLE AND ATTEMPT TO RIDE AWAY WHILE THE STEERING IS STILL LOCKED.
Remedy: THE DEALER WILL UPDATE THE SOFTWARE OF THE HANDS FREE CONTROL UNIT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2011. OWNERS MAY CONTACT DUCATI AT 1-800-231-6696.
1,051 vehicles affected
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
DUCATI IS RECALLING CERTAIN MODEL YEAR 2010 MTS 1200S MOTORCYCLES. IN THE EVENT THE DRIVER SHOULD DOWNSHIFT OR MANEUVER WITH THE CLUTCH DISENGAGED AND THE ENGINE AT IDLE, THE VEHICLE COULD STALL.
Remedy: DEALERS WILL RE-FLASH THE ELECTRONIC CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 2, 2011. OWNERS MAY CONTACT DUCATI AT 800-231-6696.
1,196 vehicles affected
STEERING
DUCATI IS RECALLING CERTAIN MODEL YEAR 2010 MULTISTRADA 1200 MOTORCYCLES. DURING PRODUCTION AN INCORRECT SCREW MAY HAVE BEEN INSTALLED IN THE MOTORCYCLE'S STEERING HEAD. THIS SITUATION COULD CAUSE THE STEERING HEAD TO POSSIBLY BECOME LOOSE DURING NORMAL OPERATION.
Remedy: DEALER WILL REPLACE THE STEERING HEAD SCREW WITH THE CORRECT SCREW. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 13, 2010. OWNERS MAY CONTACT DUCATI AT 1-800-231-6696.
196 vehicles affected
VEHICLE SPEED CONTROL:CABLES
DUCATI IS RECALLING CERTAIN MODEL YEAR 2010 MULTISTRADA 1200 MOTORCYCLES. THE THROTTLE CABLES MAY COME INTO CONTACT WITH THE UPPER EDGE OF THE RADIATOR DURING NORMAL OPERATION OF THE MOTORCYCLE. THIS SITUATION COULD CAUSE THE THROTTLE CABLES TO BECOME CHAFED BY THE RADIATOR RESULTING IN DAMAGE TO THE MOTORCYCLE AND A POTENTIAL HAZARD TO THE RIDER.
Remedy: DEALER WILL SECURE THE THROTTLE CABLES TO THE FRAME ABOVE THE RADIATOR TO PREVENT CONTACT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 13, 2010. OWNERS MAY CONTACT DUCATI AT 1-800-231-6696.
396 vehicles affected
STRUCTURE:MOTORCYCLE:KICKSTAND/CENTER STAND
DUCATI IS RECALLING CERTAIN MODEL YEAR 2010 MULTISTRADA 1200 S TOURING EDITION MOTORCYCLES. THE MOTORCYCLE'S CENTER STAND MOUNTING SCREWS MAY COME LOOSE DURING NORMAL OPERATION. THIS SITUATION COULD CAUSE THE CENTER STAND TO POSSIBLY BECOME DISPLACED FROM ITS INTENDED MOUNTING POSITION RESULTING IN DAMAGE TO THE MOTORCYCLE AND A POTENTIAL HAZARD TO THE RIDER.
Remedy: DEALER WILL REMOVE THE CENTER STAND SCREWS APPLY THREAD-LOCKING COMPOUND AND REINSTALL THE SCREWS TO THE SPECIFIED TORQUE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 13, 2010. OWNERS MAY CONTACT DUCATI AT 1-800-231-6696.
495 vehicles affected
COMPLETE FAILURE OF REAR BRAKE.
I HAVE ENCOUNTERED (3) COMPLETE ENGINE SHUT-DOWNS (FLAMEOUTS) ON MY MOTORCYCLE. FIRST INCIDENT OCCURRED WHILE IN THE VEHICLES "URBAN" MODE (200 MILES). AT ABOUT 20 MPH AS I WAS GEARING DOWN, THE MOTOR SUDDENLY SHUT OFF. I IMMEDIATELY PRESSED THE START BUTTON, AND PROCEEDED ON WITHOUT INCIDENT. ATTRIBUTED THE SHUTDOWN, AT THE TIME, TO A NEW BIKE ENDURING ITS BREAK-IN-PERIOD. SECOND EVENT HAPPENED WHILE ATTEMPTING TO PULL OUT FROM AN INTERSECTION (400 MILES). I ROLLED ON THE THROTTLE, AND BEFORE I LEFT THE CLUTCH OUT, THE ENGINE SHUT OFF. I AM AN EXPERIENCED MOTORCYCLIST. I HAVE STALLED MOTORCYCLES BEFORE. THIS INCIDENT WAS DUE TO THE MACHINE AND WAS A BIT SCARY. INTERSECTION, CROSS TRAFFIC, ETC. I RE-STARTED THE MOTORCYCLE, AND DROVE AWAY WITHOUT INCIDENT. THIRD EVENT TRANSPIRED AT NIGHTTIME (1750 MILES). THIS WAS BY FAR THE MOST ALARMING OF THE THREE. WHILE APPROACHING AN INTERSECTION, I PULLED IN THE CLUTCH LEVER TO DOWNSHIFT INTO FIRST GEAR, (20-25 MPH) AGAIN, THE ENGINE ABRUPTLY SHUT OFF. ALSO, WHEN THE SHUT-DOWN OCCURRED, THE MOTORCYCLES HEADLIGHTS WENT DARK. I WAS IN A PREDICAMENT. MY NIGHT-VISION WAS HANDICAPPED FURTHER BY THE INSTRUMENT LIGHTS SHINING TOWARD MY EYES. I IMMEDIATELY/CAUTIOUSLY BEGAN LEAVING THE CLUTCH LEVER OUT AS AN ATTEMPT TO REGAIN IGNITION AND LIGHTING(DRIFT START). I HAD ALREADY SELECTED FIRST GEAR, SO, THE COMPRESSION OF THE ENGINE, WAS GREATER THAN MY REAR WHEEL TRACTION, AND I BEGAN A REAR TIRE SKID THAT WAS RESOLVED BY PULLING THE CLUTCH LEVER. I THEN, WITH LOW NIGHTTIME VISIBILITY, DRIFTED THE MOTORCYCLE TO THE ROADWAY SHOULDER. I THEN RESTARTED THE DUCATI, AND CAUTIOUSLY DROVE HOME. I HAVE DISCOVERED THERE ARE MANY MULTISTRADA OWNERS ON THE NET, AT "DUCATI.MS.", THAT ARE EXPERIENCING THE UNEXPECTED FLAW WITH THE 2010 MODEL YEAR.
I HAVE ENCOUNTERED (3) COMPLETE ENGINE SHUT-DOWNS (FLAMEOUTS) ON MY MOTORCYCLE. FIRST INCIDENT OCCURRED WHILE IN THE VEHICLES "URBAN" MODE (200 MILES). AT ABOUT 20 MPH AS I WAS GEARING DOWN, THE MOTOR SUDDENLY SHUT OFF. I IMMEDIATELY PRESSED THE START BUTTON, AND PROCEEDED ON WITHOUT INCIDENT. ATTRIBUTED THE SHUTDOWN, AT THE TIME, TO A NEW BIKE ENDURING ITS BREAK-IN-PERIOD. SECOND EVENT HAPPENED WHILE ATTEMPTING TO PULL OUT FROM AN INTERSECTION (400 MILES). I ROLLED ON THE THROTTLE, AND BEFORE I LEFT THE CLUTCH OUT, THE ENGINE SHUT OFF. I AM AN EXPERIENCED MOTORCYCLIST. I HAVE STALLED MOTORCYCLES BEFORE. THIS INCIDENT WAS DUE TO THE MACHINE AND WAS A BIT SCARY. INTERSECTION, CROSS TRAFFIC, ETC. I RE-STARTED THE MOTORCYCLE, AND DROVE AWAY WITHOUT INCIDENT. THIRD EVENT TRANSPIRED AT NIGHTTIME (1750 MILES). THIS WAS BY FAR THE MOST ALARMING OF THE THREE. WHILE APPROACHING AN INTERSECTION, I PULLED IN THE CLUTCH LEVER TO DOWNSHIFT INTO FIRST GEAR, (20-25 MPH) AGAIN, THE ENGINE ABRUPTLY SHUT OFF. ALSO, WHEN THE SHUT-DOWN OCCURRED, THE MOTORCYCLES HEADLIGHTS WENT DARK. I WAS IN A PREDICAMENT. MY NIGHT-VISION WAS HANDICAPPED FURTHER BY THE INSTRUMENT LIGHTS SHINING TOWARD MY EYES. I IMMEDIATELY/CAUTIOUSLY BEGAN LEAVING THE CLUTCH LEVER OUT AS AN ATTEMPT TO REGAIN IGNITION AND LIGHTING(DRIFT START). I HAD ALREADY SELECTED FIRST GEAR, SO, THE COMPRESSION OF THE ENGINE, WAS GREATER THAN MY REAR WHEEL TRACTION, AND I BEGAN A REAR TIRE SKID THAT WAS RESOLVED BY PULLING THE CLUTCH LEVER. I THEN, WITH LOW NIGHTTIME VISIBILITY, DRIFTED THE MOTORCYCLE TO THE ROADWAY SHOULDER. I THEN RESTARTED THE DUCATI, AND CAUTIOUSLY DROVE HOME. I HAVE DISCOVERED THERE ARE MANY MULTISTRADA OWNERS ON THE NET, AT "DUCATI.MS.", THAT ARE EXPERIENCING THE UNEXPECTED FLAW WITH THE 2010 MODEL YEAR.
I HAVE ENCOUNTERED (3) COMPLETE ENGINE SHUT-DOWNS (FLAMEOUTS) ON MY MOTORCYCLE. FIRST INCIDENT OCCURRED WHILE IN THE VEHICLES "URBAN" MODE (200 MILES). AT ABOUT 20 MPH AS I WAS GEARING DOWN, THE MOTOR SUDDENLY SHUT OFF. I IMMEDIATELY PRESSED THE START BUTTON, AND PROCEEDED ON WITHOUT INCIDENT. ATTRIBUTED THE SHUTDOWN, AT THE TIME, TO A NEW BIKE ENDURING ITS BREAK-IN-PERIOD. SECOND EVENT HAPPENED WHILE ATTEMPTING TO PULL OUT FROM AN INTERSECTION (400 MILES). I ROLLED ON THE THROTTLE, AND BEFORE I LEFT THE CLUTCH OUT, THE ENGINE SHUT OFF. I AM AN EXPERIENCED MOTORCYCLIST. I HAVE STALLED MOTORCYCLES BEFORE. THIS INCIDENT WAS DUE TO THE MACHINE AND WAS A BIT SCARY. INTERSECTION, CROSS TRAFFIC, ETC. I RE-STARTED THE MOTORCYCLE, AND DROVE AWAY WITHOUT INCIDENT. THIRD EVENT TRANSPIRED AT NIGHTTIME (1750 MILES). THIS WAS BY FAR THE MOST ALARMING OF THE THREE. WHILE APPROACHING AN INTERSECTION, I PULLED IN THE CLUTCH LEVER TO DOWNSHIFT INTO FIRST GEAR, (20-25 MPH) AGAIN, THE ENGINE ABRUPTLY SHUT OFF. ALSO, WHEN THE SHUT-DOWN OCCURRED, THE MOTORCYCLES HEADLIGHTS WENT DARK. I WAS IN A PREDICAMENT. MY NIGHT-VISION WAS HANDICAPPED FURTHER BY THE INSTRUMENT LIGHTS SHINING TOWARD MY EYES. I IMMEDIATELY/CAUTIOUSLY BEGAN LEAVING THE CLUTCH LEVER OUT AS AN ATTEMPT TO REGAIN IGNITION AND LIGHTING(DRIFT START). I HAD ALREADY SELECTED FIRST GEAR, SO, THE COMPRESSION OF THE ENGINE, WAS GREATER THAN MY REAR WHEEL TRACTION, AND I BEGAN A REAR TIRE SKID THAT WAS RESOLVED BY PULLING THE CLUTCH LEVER. I THEN, WITH LOW NIGHTTIME VISIBILITY, DRIFTED THE MOTORCYCLE TO THE ROADWAY SHOULDER. I THEN RESTARTED THE DUCATI, AND CAUTIOUSLY DROVE HOME. I HAVE DISCOVERED THERE ARE MANY MULTISTRADA OWNERS ON THE NET, AT "DUCATI.MS.", THAT ARE EXPERIENCING THE UNEXPECTED FLAW WITH THE 2010 MODEL YEAR.