2025 CHEVROLET BLAZER EV
3 recalls, 37 complaints - 5/5 safety rating
26V031000 Jan 22, 2026
PARKING BRAKE
Defect Description
General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Blazer EV vehicles that may have been repaired incorrectly under recall 25V433. The rear parking brake wiring harness may become damaged or corroded, resulting in unintended activation of the parking brake or loss of the parking brake... Read more
Consequence
Unintended activation of the parking brake while driving increases the risk of a crash. Loss of the parking brake function while parked can result in a rollaway, increasing the risk of a crash.
Remedy
Dealers will replace the chassis harness, free of charge. Owner notification letters were mailed on February 25, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252532830.
25V433000 Jun 25, 2025
PARKING BRAKE
Defect Description
General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Blazer EV vehicles. The rear parking brake wiring harness may become damaged or corroded, resulting in unintended activation of the parking brake or loss of the parking brake function.
Consequence
Unintended activation of the parking brake while driving increases the risk of a crash. Loss of the parking brake function while parked can result in a rollaway, increasing the risk of a crash.
Remedy
Dealers will inspect the harness and, if necessary, reroute the harness and install anti-abrasive tape. Any harness that has existing damage will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed on October 1, 2025. Owners may contact Chevrolet customer se... Read more
24V737000 Oct 2, 2024
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Defect Description
General Motors, LLC (GM) is recalling certain 2025 Chevrolet Blazer, Blazer EV, and Equinox vehicles. The door strikers were not properly heat-treated, which can cause them to break.
Consequence
A broken door striker can cause the door to open unexpectedly, increasing the risk of injury.
Remedy
Dealers will replace all four side door strikers and attachment bolts, free of charge. All affected vehicles are still in dealership inventory and therefore no owner notification letters are expected to be mailed. Owners may call Chevrolet customer service at 1-800-222-1020. GM's number for this ... Read more
Complaint Statistics
37 total complaints
5 crashes 2 fires 4 injuries
Top Reported Components
| Component | Complaints |
|---|---|
| POWER TRAIN | 5 |
| ENGINE | 5 |
| ELECTRICAL SYSTEM | 4 |
| VEHICLE SPEED CONTROL | 3 |
| AIR BAGS | 3 |
| SUSPENSION | 3 |
| UNKNOWN OR OTHER | 2 |
| SERVICE BRAKES, HYDRAULIC | 2 |
| FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING | 1 |
| FUEL SYSTEM, GASOLINE | 1 |
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Jul 14, 2026
Incident date: Jul 14, 2026
While in rush hour traffic with over 100ft of clear road no cars, the car made its beeping noise and applied the ebrakes. This could've ended in a loss of life on the high way
ENGINE
Jun 21, 2026
Incident date: Jun 18, 2026
Power train the engine roars up and drops jarring you back and forth second car within a yr first blew up brand new both and Hyundia and dealership blew me off
FUEL/PROPULSION SYSTEM
Jun 21, 2026
Incident date: Jun 18, 2026
Power train the engine roars up and drops jarring you back and forth second car within a yr first blew up brand new both and Hyundia and dealership blew me off
POWER TRAIN
Jun 21, 2026
Incident date: Jun 18, 2026
Power train the engine roars up and drops jarring you back and forth second car within a yr first blew up brand new both and Hyundia and dealership blew me off
BACK OVER PREVENTION
May 28, 2026
Incident date: Mar 19, 2026
See attached document for complaint.
ENGINE
May 28, 2026
Incident date: Mar 19, 2026
I have a 2021 Silverado LT trailboss. Catastrophic engine failure. Camshaft bearing and lifter failure. First lifter replacement @ 16,000 miles. Second at 104,000 miles. Was told by GM the 6.2L L87 I have is not affected due to a Canadian VIN. The sticker on the truck says Assembled in Kentucky. Gm ... Read more
UNKNOWN OR OTHER
May 13, 2026
Incident date: May 6, 2026
Heard a pop sound, drove three-mile back to house, with car throttled speed to 20 MPH on 35 MPH roads. Leased 2025 Ioniq 5 at 4553 mi. Once back, completely died, vehicle wouldn't lock, start or move. We had vehicle towed to Dealer (20 miles away). No warning lights, no notices. The vehicle needs a... Read more
ENGINE
May 13, 2026
Incident date: May 6, 2026
The contact owns a 2017 HONDA CR-V. The contact stated that while driving at an undisclosed speed, numerous warning lights illuminated on the dashboard, including the ABS and check engine lights. Concurrently, the vehicle lost engine motive power and was unable to accelerate. The vehicle was driven ... Read more
SERVICE BRAKES, HYDRAULIC
May 13, 2026
Incident date: May 6, 2026
The contact owns a 2017 HONDA CR-V. The contact stated that while driving at an undisclosed speed, numerous warning lights illuminated on the dashboard, including the ABS and check engine lights. Concurrently, the vehicle lost engine motive power and was unable to accelerate. The vehicle was driven ... Read more
ELECTRICAL SYSTEM
Apr 22, 2026
Incident date: Aug 22, 2024
The contact owns a 2020 Honda CR-V. The contact stated that while driving in a parking lot and depressing the brake pedal, there was a clunking sound coming from the braking system before the brakes became inoperable. The contact forcefully depressed the brake pedal, and the vehicle eventually came ... Read more
ENGINE
Apr 17, 2026
Incident date: Apr 9, 2026
2021 Chevrolet Trailblazer RS (123,000) - Coolant control Valve failure Cooling issues after 20-25 mins of driving. No Check engine lights initially just temperature gauge climbing. After 3 day of trying to drive to and from work. "Engine reduced" and P3075 code. Had it towed to dealershi... Read more
VEHICLE SPEED CONTROL
Apr 17, 2026
Incident date: Apr 9, 2026
While making a left turn at low speed, I applied the brakes, but the vehicle did not respond as expected and instead appeared to drift, surge, or accelerate forward. The vehicle struck a fire hydrant and a bus stop pole before crashing into a tree. Airbags deployed and both occupants sustained injur... Read more
Crash
2 injured
ELECTRICAL SYSTEM
Apr 17, 2026
Incident date: Apr 9, 2026
While making a left turn at low speed, I applied the brakes, but the vehicle did not respond as expected and instead appeared to drift, surge, or accelerate forward. The vehicle struck a fire hydrant and a bus stop pole before crashing into a tree. Airbags deployed and both occupants sustained injur... Read more
Crash
2 injured
ELECTRICAL SYSTEM
Feb 28, 2026
Incident date: Feb 20, 2026
The vehicle while parked and not running on our driveway burst into flames and had large fire and explosions that burned the vehicle front half completely. the whole engine compartment burned and melted and destroyed the vehicle. No warning lights, no issues. Just burst into flames and destroyed t... Read more
Fire
ENGINE
Feb 28, 2026
Incident date: Feb 20, 2026
The vehicle while parked and not running on our driveway burst into flames and had large fire and explosions that burned the vehicle front half completely. the whole engine compartment burned and melted and destroyed the vehicle. No warning lights, no issues. Just burst into flames and destroyed t... Read more
Fire
POWER TRAIN
Feb 28, 2026
Incident date: Feb 20, 2026
I am submitting this complaint regarding a sudden and premature transfer case failure on my 2021 Acura TLX Type S equipped with Acura’s Super Handling All-Wheel Drive (SH-AWD) system. The failure occurred during normal driving conditions and without prior warning indicators. Based on my experience... Read more
SEAT BELTS
Feb 4, 2026
Incident date: Sep 26, 2025
My seatbelt malfunctioned and does not latch. The part that the seat belt goes into is not catching
ELECTRICAL SYSTEM
Feb 4, 2026
Incident date: Sep 26, 2025
On [XXX], the vehicle was unable to be started - no lights, no power, unable to open the doors. I called Hyundai Roadside Assist and they sent someone from AAA a few hours later who was able to "jump start" the vehicle. I took it to the dealer, Manly Hyundai, on December 17th, 2025 and they determ... Read more
SUSPENSION
Feb 4, 2026
Incident date: Sep 26, 2025
My 2018 Tesla Model 3 started squeaking at 36k miles at the end of 2023 (5 year old) I took to the Tesla service center where they quoted me $570. The squeaky control arm issue in Tesla is well known on the internet with may forums complaining about it. Not sure if there is a safety issue but wanted... Read more
EQUIPMENT
Dec 10, 2025
Incident date: Dec 9, 2025
The contact owns a 2010 Chevrolet Silverado 2500 equipped with a Genesis Supreme trailer attached to the vehicle. The pin box bolted on the front of the trailer is a Lippert Rota-Flex Pin Box. The contact stated that upon pulling into a gas station, the contact discovered that the trailer was sittin... Read more
POWER TRAIN
Dec 9, 2025
Incident date: Dec 6, 2025
The contact owns a 2019 Jeep Cherokee. The contact received notification of NHTSA Campaign Number: 25V011000 (Power Train). The contact stated that while driving 75 MPH, the engine started revving, and the RPM was redlined. The vehicle then lost power. The vehicle was steered to the side of the road... Read more
SERVICE BRAKES, HYDRAULIC
Dec 9, 2025
Incident date: Dec 6, 2025
The contact owns a 2019 Jeep Grand Cherokee. The contact received notification of NHTSA Campaign Number: 24V838000 (Service Brakes, Hydraulic). The contact called a local dealer and was informed that the part was not yet available for the recall repair. The contact also called the manufacturer and w... Read more
AIR BAGS
Nov 13, 2025
Incident date: Mar 19, 2025
We were in an accident with heavy front end and right corner panel damage and none of my airbags deployed.
Crash
SUSPENSION
Nov 13, 2025
Incident date: Mar 19, 2025
On my way home about 2 mi from my house. I heard a little clunk noise coming from the front of my car and I keep driving and I hit a bump. It sounded really loud so I really drove slow. I got home back into my garage. I can hear it really loud sound from the front. The next morning I jacked my car u... Read more
POWER TRAIN
Nov 13, 2025
Incident date: Mar 19, 2025
All of a sudden, when I would shift the gear to neutral or reverse the car would only drive forward. While there are other recalls related to this issue for other models, there isn’t a recall for this 2022 model. The ford dealership said it needs a new transmission and that would cost around $10,0... Read more
WHEELS
Oct 5, 2025
Incident date: Sep 3, 2025
On September 4, 2025, I brought my 2001 Toyota Tundra to Midas at 5325 Olde Wadsworth Blvd, Arvada, CO 80002 for an oil change and inspection. Midas advertises a “Closer Look Vehicle Check,” which includes checking steering, suspension, and wheels. Their inspection report marked the steering sys... Read more
SUSPENSION
Oct 5, 2025
Incident date: Sep 3, 2025
On September 4, 2025, I brought my 2001 Toyota Tundra to Midas at 5325 Olde Wadsworth Blvd, Arvada, CO 80002 for an oil change and inspection. Midas advertises a “Closer Look Vehicle Check,” which includes checking steering, suspension, and wheels. Their inspection report marked the steering sys... Read more
TIRES
Sep 16, 2025
Incident date: Sep 1, 2025
TEST VOQ 20250916
AIR BAGS
Sep 16, 2025
Incident date: Sep 1, 2025
On September 16, 2025, while driving my 2023 Ford F-250 Super Duty at approximately 65 mph with cruise control engaged, I pressed the brake pedal to disengage cruise. The cruise control did not disengage. I pressed the brake pedal harder, but the truck did not slow down and maintained speed. There w... Read more
Crash
VEHICLE SPEED CONTROL
Sep 16, 2025
Incident date: Sep 1, 2025
On September 16, 2025, while driving my 2023 Ford F-250 Super Duty at approximately 65 mph with cruise control engaged, I pressed the brake pedal to disengage cruise. The cruise control did not disengage. I pressed the brake pedal harder, but the truck did not slow down and maintained speed. There w... Read more
Crash
AIR BAGS
Sep 3, 2025
Incident date: Sep 1, 2025
Vehicle is producing a "Service Airbag" warning message and red airbag light on the instrument cluster at each start. The problem code 'U0170' is found which correlates to 'Lost Communication With Passenger Presence Module'. The dealer advised that the part is discontinued and no longer available. ... Read more
SERVICE BRAKES
Aug 29, 2025
Incident date: Aug 29, 2025
Whenever parking the car and trying to stop (shut off) the engine it will randomly say “shift to park” and I cannot shut the vehicle off.
FUEL SYSTEM, GASOLINE
Aug 14, 2025
Incident date: Jun 7, 2025
The contact owns a 2020 Honda CR-V. The contact stated that while driving the vehicle , the vehicle failed to exceed 30 MPH. There were several unknown messages displayed, and the check engine, brake light, and fuel emissions warning lights were illuminated. The vehicle was driven to the local mecha... Read more
POWER TRAIN
Aug 14, 2025
Incident date: Jun 7, 2025
I was nearly in an accident because the vehicle was unable to accelerate quickly due to transmission shift delay.
UNKNOWN OR OTHER
May 13, 2025
Incident date: Nov 13, 2024
While driving, the transmission shuddered and jerked. I took the car to my garage, where it was diagnosed as needing a new transmission. At the time it had 98,258 miles. The transmission was replaced on 9/1/2023. In September, 2024, the transmission fault message and the check engine light came on... Read more
VEHICLE SPEED CONTROL
Jan 5, 2025
Incident date: Jan 5, 2025
I am the owner of a 2016 GMC Canyon truck, which i purchased used in approx 2020 with about 43,000 miles on it...today's date is now 1/5/25 and the truck has approx 99,0000 mile on it. Over the last 2 years the electronic stability control has failed approx 20 times. A warning light appears on the d... Read more
VISIBILITY/WIPER
Jan 5, 2025
Incident date: Jan 5, 2025
Rear window shield busted randomly in cold. Car was parked and when I returned to parked car the rear window was shattered.
NHTSA Safety Ratings, 2025 CHEVROLET BLAZER EV
2025 Chevrolet Blazer EV SUV AWD
| Category | Rating |
|---|---|
| Overall Rating | 5 / 5 ★★★★★ |
| Frontal Crash | 5 / 5 ★★★★★ |
| Frontal Crash, Driver | 5 / 5 ★★★★★ |
| Frontal Crash, Passenger | 5 / 5 ★★★★★ |
| Side Crash | 5 / 5 ★★★★★ |
| Side Crash, Driver | 5 / 5 ★★★★★ |
| Side Crash, Passenger | 5 / 5 ★★★★★ |
| Rollover | 4 / 5 ★★★★☆ |
| Rollover Risk | 10.5% |
Safety Technology
| Feature | Status |
|---|---|
| Electronic Stability Control | Standard |
| Forward Collision Warning | Optional |
| Lane Departure Warning | Optional |
Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.
CHEVROLET BLAZER EV - All Years Overview
Complete safety history for the CHEVROLET BLAZER EV across all model years (2024, 2026).
9
Total Recalls
164
Total Complaints
0
Investigations
12
Reported Crashes
3
Reported Fires
1
Reported Deaths