2002 CHEVROLET AVALANCHE 1500 Recalls, Complaints & Safety

CAR CRASH AND BRAKS LOCKED AIR BAGS DIDNT DEPLOY, INJURIES LEFT UNPAID AND VEHICLE DAMAGES.

Crash 3 injured

CAR CRASH AND BRAKS LOCKED AIR BAGS DIDNT DEPLOY, INJURIES LEFT UNPAID AND VEHICLE DAMAGES.

Crash 3 injured

na

‘’’’’’FRAME’’’’’’I was heading to work and and something snapped while driving. I then brought vehicle to fire stone in Kingsport tn. I was told it tie rod end had it replaced well the sound was still thier. Then I returned with vehicle pitman arm and bracket replaced nope banging noise was still there. I then called corporate up spoke Mike I was told to return the vehicle bake to fire stone on a weds all day long they were looking over the vehicle come to find out frame snapped where cross member is on drivers side of vehicle. While the passenger side was still solid. I am not the only one dealing with issue as of now I am finding out more vehicles 2002 to the the 2005 chevy avalanches 5.3 4x4’s have this problem. Why hasn’t there been a recall on this issue like Toyota has done. I have 276,000 miles on this truck would like to have it fixed.

Crash

Vehicle was involved in a collision, striking a cement stair case and embankment, before rotating to final rest during which time the cab separated completely from the frame. One occupant was trapped in the cab and one was ejected. Information submitted by case investigator, Trp. [XXX] - Iowa State Patrol INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Crash 1 injured 1 deaths

While driving I suddenly experienced a loss of power. Immediately the truck sputtered to a rolling stop. I was unable to use power steering or power brakes due to the loss of fuel. I later discovered that the fuel line from the tank to the fuel filter was not properly connected. Upon attempting to reconnect, it was noticed that it had broken. The male nipple which goes from the fuel tank, outward about 1 inch, had broken off and was inside of the quick release connection for said fuel line.

1 injured

STEERING: I stopped in my daughter yard and was unloading a 16ft trailer of hay and everything was working normally. When I got back in cranked the engine I started pulling forward, I did not have any power steering at all. I first thought the steering wheel had locked but I really had to power down on the steering to get it to turn. No noise, no indication, no problems of any kind with the steering or anything wrong while driving just a few minutes before. The power steering just stopped working period. I told my daughter we were lucky this hadn't happened on the road while pulling the loaded trailer. This could have been very dangerous or deadly if it had gone out while we were pulling the loaded trailer while on the road. If we had been going around a curve or making a turn and it had happened like it did in the yard while parked with NO indication of a problem it would have been very, very bad especially again with NO indications of a problem with the steering and pulling a trailer loaded with hay. I shudder to think what could have happened if we had been going around a curve at 55mph on the highway and this had happened. Power steering fluid pump up to the full line on the check stick when I pulled it out of the power steering pump. I have had the Avalanche for 3 years and have never had to add fluid nor does it have leak anywhere. Again, NO steering problems whatsoever before this.

I went to stop my 2002 Chevy Avalanche 1500 and the pedal started to pulsate like my brake assist was gone as I nearly rear end a vehicle and had to swerve out of the way do to the brakes not wanting to stop the vehicle as there supposed to normally. The truck has a p0265 code which is a fault in the ECBM do to the solder joint on the relay in the board. I'm a mechanic for a living and i cant believe this recall still hasn't been addressed a long time ago! This needs to be looked into ASAP and its not just the 2002 avalanche. All these vehicle's listed have this issues but instead of recalling the EBCM for the solder issues they decide to recall it for corrosion on the wheel speed sensors big mistake that still to this day needs to be addressed. 2002-2006 Cadillac Escalade, EXT & ESV 1999-2007 Chevrolet Silverado 2000-2006 Chevrolet Suburban, Tahoe 2002-2006 Chevrolet Avalanche 2002-2007 Chevrolet TrailBlazer & EXT 2003-2006 Chevolet SSR 1999-2007 GMC Sierra 2000-2006 GMC Yukon / Denali / XL 2002-2007 GMC Envoy / XL 2004-2005 GMC Envoy XUV

Stopping, from between 5 and 10 mph, after a small drive - like a few yards.. the anti-lock brake engaged, made a pulsing / ratcheting noise and the brake pedal vibrated -- but the truck did not stop. I could not press down on the pedal any harder, and the truck took SUBSTANTIAL distance to come to a stop. --Dry road. -- I also have an ABS light on the dash from time to time.

THE DRIVERS SIDE REAR PANEL ON 2002 AVALANCHES RUST. MY TRUCK WAS PARKED IN DRIVEWAY AND NOT RUNNING. I WALKED BY AND MY HAND MADE CONTACT WITH THE RUSTED SPOT CAUSING AN INJURY RESULTING IN ME HAVING TO GO TO THE ER TO GET THE CUT CLEANED AND A TETANUS SHOT. *TR

1 injured

STEERING WHEEL HARD TO TURNOVER WHEN YOU DRIVE

TL* THE CONTACT OWNED A 2002 CHEVROLET AVALANCHE. THE CONTACT'S SON WAS DRIVING AT AN UNKNOWN RATE OF SPEED WHEN HIS VEHICLE COLLIDED WITH A GUARDRAIL. AS A RESULT OF THE IMPACT, THE VEHICLE MADE A TAILSPIN AND VEERED THE VEHICLE INTO THE OPPOSITE LANE OF TRAFFIC. THE CONTACT'S SON'S VEHICLE MADE IMPACT WITH ANOTHER VEHICLE TRAVELING IN THE OPPOSITE DIRECTION. THE AIR BAGS DID NOT DEPLOY DURING THE INCIDENT. THE CONTACT'S SON SUSTAINED INJURIES TO HIS HEAD AND BACK AND RECEIVED MEDICAL ATTENTION AT THE SCENE. THE CONTACT'S SON WAS TRANSPORTED TO A WHERE HE WAS TREATED FOR GLASS REMOVAL FROM HIS HEAD AND BACK. THE DRIVER OF THE OTHER VEHICLE ALSO SUSTAINED INJURIES RESULTING FROM THE COLLISION. THE OTHER DRIVER WAS TAKEN TO THE SAME HOSPITAL FOR TREATMENT, HOWEVER, THE INJURIES WERE UNKNOWN. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS TOWED FROM THE SCENE AND TAKEN TO A TOW YARD. THE VEHICLE WAS DESTROYED DUE TO THE DAMAGE FROM THE ACCIDENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

Crash 2 injured

I LOST MY BRAKES TOTALLY NOT JUST HALF OF THEM PULLING A SMALL TRAILER WITH IRON GOING DOWN A LONG HILL IN MANKATO, MN. ON MADISON AVE. I REAR ENDED A PICK UP WHICH PULLED OVER AND I CONTINUED ROLLING DOWN THE HILL BUILDING SPEED SO I HAD TO DRIVE MY TRUCK INTO A WALL WITH MY DAUGHTER INSTEAD OF REACHING THE NEXT INTERSECTION. GM HAS NOW CHANGED THEIR BRAKE LINES IN TO STAINLESS STEAL SINCE 2003 BECAUSE THEY KNEW THEY HAD PROBLEMS WITH THEIR BRAKE LINES. MY BRAKE LINES ARE ON TOP OF FRAME RUNNING BACK TO THE REAR AXLE WITH THE GAS TANK BLOCKING MOST OF THE LINES. THERE IS ONLY 1.5 INCHES BETWEEN THE FRAME AND BODY. ALONG SIDE IS THE WIRING HARNESS GOING BACK TO THE REAR, NO ROOM TO INSPECT OR SEE YOUR BRAKE LINES. THIS COULD OF BEEN SO WORSE BECAUSE OF ALL THE TRAFFIC AND OUR LIVES. DO SOMETHING PLS... POLICE REPORT 18-25773 MANKATO POLICE DEPT. BEFORE SOMEONE GETS KILLED!

Crash

HEARD SNAP WHILE DRIVING HIT MEDIAN,AND TOTALED MY TRUCK.IT NEEDS TO BE NOTICED IF ANY BODY HASN'T BEEN KILLED YET

Crash

TURNING INTO MY DRIVEWAY, SLOWING DOWN, APPLYING BRAKES, THE PEDAL WENT TO THE FLOOR, NO RESISTANCE, PARK BRAKE DIDN'T ,HELP ALMOST HIT MY GARAGE, STEERED TOWARD GARDEN LANDSCAPE TIES, THAT STOPPED ME, LOOKED UNDER TRUCK, LARGE PUDDLE OF BRAKE FLUID DRIPPING , BOTH BRAKE LINES FROM THE MASTER CYLINDER TO THE ABS WERE RUSTED BADLY AND DRIPPING.

EXCESSIVE RUSTING OF THE FRAME, BRAKE LINES, TRANSMISSION LINES, AND FUEL LINES. THE BRAKE, TRANSMISSION AND FUEL LINES RUSTED COMPLETELY OUT AND REQUIRED A FULL REPLACEMENT. THE FRAME HAS EXTENSIVE RUST AND HAS DETERIORATED WELL BEYOND THE FRAME OF MY 2003 CAMARO Z28 WHICH IS 9 YEARS OLDER! THE TRUCK HAS LESS THAN 80K AND HAS BEEN WELL MAINTAINED, SO THERE IS NO EXPLANATION FOR THE AMOUNT AND LEVEL OF RUST, EXCEPT THAT THERE WERE INFERIOR METALS AND MANUFACTURING MATERIALS USED IN ITS CONSTRUCTION.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE DRIVING APPROXIMATELY 35 MPH AND ATTEMPTING TO MAKE A SUDDEN STOP, THE DRIVER FORCEFULLY DEPRESSED THE BRAKE PEDAL AND THE PEDAL EXTENDED TO THE FLOOR. AS A RESULT, THE BRAKING DISTANCE WAS EXTENDED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE FLUID WAS LEAKING DUE TO CORROSION IN MULTIPLE BRAKE LINES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 134,258. *TT *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE OPERATING THE VEHICLE, THE LOW BEAM HEADLIGHTS SUDDENLY SHUT OFF. WHEN THE CONTACT TAPPED THE FUSE BOX LOCATED UNDER THE HOOD, THE HEADLIGHTS TURNED BACK ON AND ILLUMINATED NORMALLY. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL DEALER (BOB BROWN CHEVROLET IN ERVINGDALE, IA) WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DECELERATED INDEPENDENTLY AND THE REDUCED ENGINE POWER, SERVICE ENGINE, AND TRACTION ASSIST INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO DON HEWLETT CHEVROLET BUICK (7601 N INTERSTATE HWY 35, GEORGETOWN, TX 78626) WHERE IT WAS DIAGNOSED THAT THE ACCELERATOR PEDAL FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO DON HEWLETT CHEVROLET WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SENSORS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED ONCE AGAIN. THE VEHICLE WAS TAKEN TO AUTONATION CHEVROLET LAUREL (500 WASHINGTON BLVD, LAUREL, MD 20707) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REBUILT, THE TAC MODULE NEEDED TO BE REPLACED, AND THE INTAKE GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THEY COULD NOT ASSIST. THE CONTACT WAS TRANSFERRED TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.

THE BRAKE LINE BROKE DUE TO RUST AND AS I HAVE SEEN THIS IS A ON GOING THING. GM SAYS IT IS NOT A SAFETY ISSUE BUT IT VERY MUCH IS AS WHEN THE LINE BRAKES YOU LOSE PADDLE AND AT HIGH SPEED THIS COULD KILL PEOPLE. THE FACT THAT THEY DO NOT SEE THIS AS A SAFETY ISSUE TELLS ME A LOT ABOUT GM AND HOW THEY DON'T CARE ABOUT THE PEOPLE THAT BUY FROM THEM. MY TRUCK WAS ON THE BOAT LAUNCH WHEN THE BRAKE FAILED I'M LUCKY I DID NOT LOSE MY TRUCK AND BOAT. THIS NEEDS TO BE FIXED AT NO COST

ABS PUMP OR SPEED SENSOR ARE DAMAGED AND NOT WORKING ON THIS TRUCK. WHEN MY VEHICLE WAS TURNED OFF THE ABS PUMP KEPT RUNNING CAUSING ME TO PULL THE FUSE FOR THE ABS. CHEVROLET IS AWARE OF THIS PROBLEM AS I HAVE BEEN CALLING THEM TRYING TO HAVE THEM INCLUDE MY TRUCK IN THE ABS/SPEED SENSOR RECALL WHICH IS ON OTHER TRUCKS LIKE MINE. CHEVROLET CONTINUES ONLY TO RECALL THESE TRUCKS WHICH WERE MANUFACTURED IN THE "SALT STATES" ONLY. AS STATED ON: HTTP://WWW.CHEVROLETPROBLEMS.COM/RECALLS/AVALANCHE/2002/ SERVICE BRAKES, HYDRAULIC:ANTILOCK RECALL FOR 2002 CHEVROLET AVALANCHE RECALL ANNOUNCED AUGUST 29 2005 NHTSA REFERENCE #05V379000 NUMBER AFFECTED 1,353,718 SUMMARY: CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY. CONSEQUENCE: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH. FIX: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463. FOR DETAILED INFORMATION & SUPPORTING DOCUMENTS, SEE THE OFFICIAL NHTSA PAGE CONCERNING RECALL #05V379000

CABLES THAT HOLD ON THE TAILGATE HAVE BROKEN ON ONE SIDE. CHEVROLET CLAIMS NO RECALL FOR THIS VIN NUMBER VEHICLE. YET ONLINE IT SAYS 2002 AVALANCHE HAS RECALL FOR CABLES.

THE BRAKES FAILED DUE TO RUSTED LINES ALMOST CAUSING ME TO WRECK

I STARTED TO PULL OUT OF MY DRIVE WAY AND PRESSED ON THE BRAKE PEDAL AND IT WENT ALL THE WAY TO THE FLOOR I GOT OUT AND CHECKED UNDER THE TRUCK AND THERE WAS BRAKE FLUID LEAKING OUT OF THE LINE AND I FOUND OUT THAT THE LINES HAD RUSTED INTO AND THIS SHOCKED ME BECAUSE I DON'T THINK A BRAKE LINE SHOULD RUST .ALL MY BRAKE LINES ARE REALLY RUSTY.

FOUND FRAME ROTTED AND CRACKED .THOUGHT THE FRAME SHOULD LAST TRUCK ONLY 14 YEARS OLD THIS SHOULD NOT HAVE HAPPEN.

BRAKE LINES CORRODED

TAKATA AIRBAG DEPLOYED AND IMPACTED ACCIDENT.. MY VEHICLE WAS MOVING WHEN I WAS HIT AND AIRBAG DEPLOYED. I'VE SINCE HAD 2 UNSUCCESSFUL BACK SURGERIES AND I CONTINUE UNCEASINGLY TO RECEIVE MEDICAL TREATMENT. I AM DISABLE RETIRED. THERE IS A WASHINGTON DC POLICE REPORT, PICTURES, INSURANCE CLAIM PAPERWORK, INVESTIGATION ETC. THERE IS A BOX OF PAPERWORK. TO MUCH TO UPLOAD, BUT I CAN GATHER THE INFO AND FORWARD TO AN ADDRESS PROVIDED TO ME. THIS WEBSITE STATED DO NOT INCLUDE PERSONAL INFORMATION SO MY EMAIL ADDRESS IS [XXX] FOR FUTURE. REFERENCE..I JUST HAPPEN TO SEE A COMMERCIAL ON TV A FEW MINUTES AGO ABOUT THE AIRBAGS SO I HAVE TO GATHER SOME REQUESTED INFO. LIKE THE EXACT DATE. I KNOW IT WAS IN 2010, SO I'M SIMPLY PUTTING IN A DATE FILLER UNTIL I CAN LOOK UP THE EXACT DATE.. I BELIEVE MY FIRST SURGERY WAS IN SEPTEMBER OF THE SAME YEAR. DO I NEED TO CONTACT AN ATTORNEY OR DO I NEED TO CONTACT TAKATA? I DON'T KNOW WHAT TO DO NEXT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Crash Fire 2 injured

REPEATED PARKING/EMERGENCY BRAKE SYSTEM FAILURES. THE VEHICLE FAILS COMMONWEALTH OF VIRGINIA SAFETY INSPECTIONS AT LEAST EVERY OTHER YEAR. REPAIRS END UP COSTING AROUND $800. THIS IS A COMMON FEATURE IN MOST CARS AND TRUCKS. THE INTERNET IS FILLED WITH COMPLAINS REGARDING THE CHEVY AVALANCHE. WHY WAS A RECALL NEVER ISSUED FOR THE AUTOMATIC TRANSMISSION MODELS?

LOST ALL BRAKING POWER WHILE DRIVING. PEDAL WENT TO THE FLOOR. DROVE HOME SLOWLY, LOOKED UNDERNEATH AND THE FRONT BRAKE LINE HAD RUSTED THROUGH. PUDDLES OF BRAKE FLUID.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE CONTACT STATED THAT THE VEHICLE EVENTUALLY STARTED UP AFTER WAITING FOR A WHILE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE FUEL PUMP, BATTERY, AND STARTER WERE CHANGED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE STARTER WAS REPLACED AGAIN; HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

ENGINE STALL WITH LOSS OF STEERING AND BRAKES WHEN TURNING FROM TOWER OAKS ST ONTO JONES ROAD, A BUSY 4 LANE ROAD. CAR STOPPED IN ONCOMING LANE ON JONES ROAD, JUST AVOIDING A HEAD ON COLLISION. CRANKSHAFT SENSOR FAILURE. HAD CAR TOWED TO DEALER WHO INFOMED ME THAT THERE WAS NO RECALL ON THE CRANKSHAFT SENSOR OF THE CHEVROLETE AVALANCHE PAID DEALER $540. FOR CRANSSHAFT SENSOR REPLACEMENT. HAVE NOT HAD A STALLING PROBLEM SENCE REPLACING THE CRANSHAFT SENSOR. THIS IS A VERY DANGEROUS SITUATION AND CAN CAUSE SEVERE ACCIDENTS AS THE LOSS OF STEERING AND BRAKES IS CRITICAL.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500 EQUIPPED WITH BF GOODRICH RUGGED TERRAIN TIRES, SIZE: LT265/75R16. WHILE DRIVING 70 MPH, THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS NOT DIAGNOSED, BUT WAS REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 230,500 AND THE TIRE FAILURE MILEAGE WAS 45,000.

MY 02 AVALANCHE HAS HAD ALL THE FUEL, EM BRAKE, WHEEL HUB WHILE HUSBAND WAS STOPPING AT LIGHT WHEN THE TOP CALIPER BOLT CAME OUT WEDGING THE CALIPER BETWEEN THE WHEEL AND BOLT THIS STOPPED THE TRUCK SOUNDED LIKE GUN FIRE AND THE REST END WENT 8 FT INTO THE AIR. AIR BAG NOT DEPLOYED. COST DAYS PAYS AND $ NEW BOLT TO GET BACK ON ROAD, NO INJURY. PLUS DRVR FR AXLE PASS TOO. 2ND TRANNY ONLY 4YRS APART HAS FAILED AGAIN WITH MY 6 GRKIDS ON MY 56TH B.D. IN TX 105 * HEAT INDEX. IT TOOK 4 HOURS TO GET HOME HAVING TO STOP EVERY 10 MIN FOR 20 MIN BECAUSE IT WAS OVERHEATING. MY GRKIDS WERE HEAT EXHAUSTED AS WAS I. I HAVE HAD TO REPLACE THE SHORT COLUMN IN MY STEERING AND I HAVE BEEN JIGGLING THE KEY TO START IT FOR APPX 8 YEARS NOW. 2 FUEL PUMPS IN LESS THAN A YEAR THE LAST ONE WAS STUCK FOR 3 HOURS AT GAS STATION W/3 GRKIDS WHILE MY D-N-LAW WAS WAITING TO MEET ME 2 HOURS FROM HER HOME. I THINK THAT COVERS MOST OF THE INVESTIGATIONS AND COMPLAINTS AND NOT ONE DID CHEVY PAY FOR. I DIDN'T BOTHER ASKING MY HUSBAND HAS 2500 SCHOOL HOURS IN AUTO MECHANIC REPAIR. MY TRIM IS FADED AND HAVE TO OIL IT TO KEEP IT FROM CRACKING. THE TRUCK STILL DRIVES EXCELLENT BUT YOU PEOPLE ARE WHO I'M GOING TO SUE IF SOMETHING CATASTROPHIC HAPPENS IN THAT TRUCK FOR YOUR LACKADAISICAL ATTITUDE IN ENFORCING THE SAFETY LAWS. HOW MUCH KICK BACK DO YOU RECEIVE FROM THE CAR COMPANIES TO NOT RECALL THEIR CARS AND TRUCKS? DON'T BE SHOCKED IT IS OBVIOUS BIG MONEY DICTATES WHAT GETS RECALLED. PEOPLE DIE FOR THE GREED OF OTHERS AND THAT IS PATHETIC. IF YOU ENFORCED THE SAFETY LAWS STRICTER THERE WOULD NOT BE PEOPLE DYING OR BADLY MFT'D VEHICLES CAUSING WRECKS SCARING PEOPLE CAUSING PTSS. I THINK THIS AGENCY IS ALL ABOUT MAKING PEOPLE THINK YOU DO SOMETHING WHEN YOU DON'T, AT LEAST NOT UNTIL 600MILLION CARS HAVE TO BE RECALLED. 2 SHOULD BE ENOUGH. 1 A REPAIR 2 NOT A COINCIDENCE. THANK YOU, [XXX] ALL WHILE DRIVING INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING AND THE BRAKES FAILED TO STOP THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT MENTIONED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,400. UPDATED 08/04/16*LJ

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHILE DRIVING 20 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO STOP THE VEHICLE. THE CONTACT COLLIDED HEAD ON INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THE VEHICLE WAS TOWED. THE CONTACT SUSTAINED MINOR INJURIES, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE CONTACT, A LICENSED MECHANIC, DIAGNOSED THAT THE BRAKE LINE WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.

Crash 1 injured

I AM AN OWNER OF A 2002 CHEVROLET AVALANCHE 1500. LATELY I HAVE HAD CONTINUED AND CONSISTENT UNWANTED ANTI-LOCK BRAKE (ABS) ACTIVATION WHEN TRAVELING AT LOW SPEEDS AND APPROACHING STOP SIGNS, STOP LIGHTS, AND YIELD SIGNS AT OR NEAR INTERSECTIONS. THE UNWANTED ABS ACTIVATION APPEARS IDENTICAL AND CONSISTENT WITH GM PRODUCT RECALL 05068 AND NHTSA CAMPAIGN NUMBER 05V-379 IN WHICH 804,000 GMC AND CHEVROLET VEHICLES WERE RECALLED FOR UNWANTED ABS ACTIVATION. THE PRIMARY GEOGRAPHIC REGIONS AFFECTED APPEARS TO BE THE SALT BELT STATES. THE PROBLEM APPEARED TO BE ABS WHEEL SENSORS NOT PROPERLY PREPARED PRIOR TO INSTALLATION CAUSING RUST AND/OR CORROSION TO AFFECT THE WHEEL SENSORS. ALTHOUGH A CHECK OF MY VIN DOES NOT YIELD ANY SAFETY RECALLS ON MY SPECIFIC VEHICLE, I BELIEVE MY VEHICLE IS AFFECTED BY THE SAME FRONT WHEEL SENSOR CORROSION ISSUE AS THOSE VEHICLES LISTED IN THE RECALL. MY VEHICLE AVALANCHE WHICH IS ONE OF THE VEHICLES AFFECTED. I ALSO RESIDE IN ILLINOIS WHICH IS ONE OF THE STATES AFFECTED. I AM CONCERNED THIS MAY CAUSE AND ACCIDENT. I ALSO BELIEVE THIS IS A MANUFACTURER DEFECT AND THEREFOR THE MANUFACTURER SHOULD BE ACCOUNTABLE FOR ANY DEFECT THAT MAY JEOPARDIZE CONSUMER SAFETY. I WOULD LIKE MY WHEEL SENSORS CLEANED AND/OR REPLACED PER GM RECALL AND AT NO COST TO ME.

TL* THE CONTACT OWNS A 2002 CHEVROLET AVALANCHE 1500. WHEN APPLYING THE BRAKES, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS PREVIOUSLY REPAIRED FOR THIS FAILURE; HOWEVER, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE CALIPERS WERE CORRODED. THE BRAKE LINES WERE REPLACED, BUT THE FAILURE WAS NOT REMEDIED. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 04/04/16*LJ

HEAD LAMPS WERE VERY DIM AND THERE IS A WHITE FILM ON THE INSIDE OF THEM, MAKING IT VERY DIFFICULT FOR NIGHT TIME DRIVING. SABERSPORT IS THE COMPANY WHO MANUFACTURES THEM, BUT WHEN CONTACTED THEIR PHONE # HAS BEEN DISCONNECTED. THE # IS 1 909 598 7589.

AT SLOW SPEEDS, THE ABS COMES ON WITHOUT WARNING ON DRY PAVEMENT, SO THIS IS NOT A RESULT OF A SLIPPERY ROAD SURFACE. I HAVE ALMOST HIT SEVERAL THINGS/CARS. THERE WAS A PREVIOUS RECALL FOR THIS EXACT ISSUE (050068A), BUT THE DEALER SAYS THAT THE RECALL REPAIR WAS ALREADY DONE AND THEY WILL NOT PERFORM THE REPAIR AGAIN. I CAN UNDERSTAND THE DEALER'S POSITION IF THIS WERE NOT THE RESULT OF A RECALL, BUT THIS SEEMS TO BE AN ONGOING ISSUE. THE RECALL REPAIR WORK WAS COMPLETED IN 2006, AND NOW IN 2015, I AM SURE IT HAS RUSTED AGAIN TO THE POINT THAT THE SAME PROBELM IS OCCURRING. RUST IN THE BRAKING SYSTEM IS A PROBLEM WITH THIS VEHICLE, AS THE BRAKE LINES HAVE RUSTED OUT AND FAILED TWICE ALREADY.

I PURCHASED A USED 2002 CHEVROLET AVALANCHE 1500 IN NOVEMBER 2014. I HAVE HAD CONTINUED AND CONSISTENT UNWANTED ANTI-LOCK BRAKE (ABS) ACTIVATION WHEN TRAVELING AT LOW SPEEDS AND APPROACHING STOP SIGNS, STOP LIGHTS, AND YIELD SIGNS AT OR NEAR INTERSECTIONS. THE UNWANTED ABS ACTIVATION HAS NEARLY CAUSED SEVERAL ACCIDENTS. THE UNWANTED ABS ACTIVATION APPEARS IDENTICAL AND CONSISTENT WITH GM PRODUCT RECALL 05068 AND NHTSA CAMPAIGN NUMBER 05V-379 IN WHICH 804,000 GMC AND CHEVROLET VEHICLES WERE RECALLED FOR UNWANTED ABS ACTIVATION. THE PRIMARY GEOGRAPHIC REGIONS AFFECTED APPEARS TO BE THE SALT BELT STATES. THE PROBLEM APPEARED TO BE ABS WHEEL SENSORS NOT PROPERLY PREPARED PRIOR TO INSTALLATION CAUSING RUST AND/OR CORROSION TO AFFECT THE WHEEL SENSORS. ALTHOUGH A CHECK OF MY VIN DOES NOT YIELD ANY SAFETY RECALLS ON MY SPECIFIC VEHICLE, I BELIEVE MY VEHICLE IS AFFECTED BY THE SAME FRONT WHEEL SENSOR CORROSION ISSUE AS THOSE VEHICLES LISTED IN THE RECALL. MY VEHICLE IS A 2002 AVALANCHE WHICH IS ONE OF THE VEHICLES AFFECTED. I ALSO RESIDE IN MINNESOTA WHICH IS ONE OF THE STATES AFFECTED. I AM CONCERNED THIS MAY CAUSE AND ACCIDENT. I ALSO BELIEVE THIS IS A MANUFACTURER DEFECT AND THEREFOR THE MANUFACTURER SHOULD BE ACCOUNTABLE FOR ANY DEFECT THAT MAY JEOPARDIZE CONSUMER SAFETY. I WOULD LIKE MY WHEEL SENSORS CLEANED AND/OR REPLACED PER GM RECALL AND AT NO COST TO ME.

MY BRAKES FELT SPONGY DURING A DRIVE, AFTER ARRIVING AT HOME AND VISUALLY INSPECTING MY BRAKES I PUMPED THE BRAKE PEDAL TWICE AND THE BRAKE LINE RUPTURED WHICH RUNS DIRECTLY UNDER THE DRIVERS SEAT. THERE IS SIGNIFICANT RUST ON ALL BRAKE LINES, I JUST WANT TO MAKE SURE MY RUPTURE IS RECORDED AFTER READING EA11-001.