2017 BUICK ENCORE Recalls, Complaints & Safety

The contact owns a 2017 Buick Encore. The contact stated that while driving at an undisclosed speed, the vehicle experienced a sudden loss of power and went into "LIMP Mode". Additionally, there was smoke coming from the rear of the vehicle. The dealer was notified of the issue but declined to service the vehicle because the vehicle had a salvage title. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 88,000.

The contact owns a 2017 Buick Encore. The contact stated that while driving at 40 MPH, the engine was running rough, and the vehicle experienced reduced power. The stabili-trak and the check engine warning lights were illuminated. The vehicle was taken to Auto Zone, where a diagnostic trouble code for a cylinder misfire was retrieved. The vehicle was taken to an independent mechanic, where the cylinder #1 ignition coil and spark plug were replaced, but the failure persisted. The mechanic determined that the engine might need to be replaced; however, the mechanic did not specialize in engine diagnostic tests. The manufacturer was notified of the failure and referred the contact to the dealer for a diagnostic test. The vehicle was taken to the dealer, where it was diagnosed, and it was determined that the engine needed to be replaced. The contact related the failure to GM Special Coverage Number: N232395330; however, the manufacturer informed the contact that the VIN was not included, and the contact was referred to the NHTSA Hotline for assistance. The vehicle was not repaired due to the cost. The failure mileage was approximately 44,000.

Rear passenger doors fail to engage internal lock when Child-Lock feature is on, door can still be opened from interior. Rear door locks fail to properly engage when locking and unlocking vehicle

The contact owns a 2017 Buick Encore. The contact stated that while driving approximately 25 MPH, the contact smelled smoke and became aware that the smoke was coming from under the hood. The failure reoccurred while driving the following day. The vehicle was driven to an independent mechanic, where it was diagnosed, and it was determined that the turbocharger needed to be replaced. The vehicle was repaired. The contact received notification of Special Coverage: N232395330 (Turbocharger Replacement), and the manufacturer was contacted for reimbursement. A case was opened; however, the manufacturer later informed the contact that the reimbursement claim was denied because the vehicle was not repaired by a dealer. The failure mileage was approximately 48,000.

Wipers will not shut off.

4/2025-Engine coolant water outlet needed to be replaced 5/2025- Turbo boost replaced (under recall) 6/2025- Engine fan needed to be replaced 12/2025- There was active leaking in the engine oil cooler and lines- needed to be replaced Engine ventilation , engine oil weep along valve cover seals- needed to be replaced

I have went to the dealership for the past two years with this problem and they keep saying they are not getting any codes: when the air conditioner is on it’s pulling the power from the motor and makes it hard to go up hill. Hard To accelerate when going on to the freeway as well. The problem is only getting worse and worse.

The turbo charge is not providing adequate power. I was on the highway and the car began to chugging then accelerated on its own and all the lights on the dash came on then all went off like it was going to shut down. I put my hazards on and started to pull to the side of the highway. I gave it a moment for the car and for me because I was terrified, my kids were in the car and traffic was going steady around 70-75 miles per hour and I was scared as it began to shut down that I would be hit by traffic behind me before I could get over. It started driving again. It still drives but is hard to accelerate and even when stopped you can see the RPM rising. It’s as if the car never idles, it feels as though is constantly under load. I have had it looked at professionally at Midas but they will only say they think it is the turbo as there are no codes coming up. I have had it looked at by mechanics I know who have fixed other things that may cause similar issues and nothing has worked and they also believe it is the turbo. I’ve know other people with Buicks and they have had similar problems I’m confused as to why this 1.4 liter turbo has not been recalled.

The contact owns a 2017 Buick Encore. The contact stated while driving at various speeds, the engine overheated, and there was smoke coming from the front of the vehicle. The contact stated that the temperature gauge indicated that the engine was hot. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed and the contact was informed that the water outlet housing, the blower motor, A/C condenser, water pump, thermostat, thermostat housing, turbo charger, and the fan were faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 60,189.

The contact owns a 2017 Buick Encore. The contact stated that the front passenger’s side seat belt failed to work as intended. No warning lights were illuminated. The front driver’s side seat belt also failed to work as intended. The contact had to push the front seat all the way back to release the seat belt. The contact stated that the seat belt was too tight and pressed into her stomach. No warning lights were illuminated. The contact had become aware of the failure after the vehicle was purchased. The contact stated that the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

While traveling at approximately 77 mph on the interstate, I was forced off the road by another vehicle, causing my car to collide with a cable barrier. The initial impact was to the front driver’s side corner, and the vehicle then scraped along the driver’s side against the barrier. Despite the high-speed impact, no airbags deployed. •Component or System That Failed: The frontal airbag system failed to deploy. •Safety Risk: The non-deployment of the airbags at this speed and impact angle posed a serious risk to my safety. The lack of airbag activation during a high-speed frontal crash greatly increased the likelihood of injury. •Has the Problem Been Reproduced or Confirmed by a Dealer or Independent Shop? No. The vehicle has not yet been inspected by a dealership or repair facility, and the issue has not been confirmed or diagnosed by a professional. •Has the Vehicle or Component Been Inspected by Manufacturer, Police, Insurance, or Others? No. The vehicle has not been inspected by the manufacturer, police, insurance representatives, or any other party as of this report. •Warning Lamps, Messages, or Symptoms Before the Incident: No warning lights or messages were active before the crash. There were no known symptoms or alerts indicating a problem with the airbag system.

Crash 1 injured

Steering wheel locked up, had to replace rack and pinion, locking up when turning, therefore needing a wheel alignment.

The contact owns a 2017 Buick Encore. The contact stated while driving at approximately 45 MPH, the accelerator pedal was depressed, and the vehicle hesitated with the check engine warning light illuminated. The contact stated that the vehicle lost motive power and then suddenly jerked forward. The contact had taken the vehicle to a local dealer where it was diagnosed and determined that the turbocharger was failing and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline to report the failure. The contact researched online and related the failure to Special Coverage Turbocharger Replacement: N232395330; however, the VIN was not included. The failure mileage was approximately 118,000.

First the car started to act odd, jumpy or you could tell there was issues with the turbo. On [XXX] car overheated??? Out of nowhere. Mileage 82049. No warnings, no lights. We had it towed to shop where we were told we need new turbo, new engine, power steering service, ac service. The total Cost was $6813.54. We had to take out 2 loans - 90 days same as cash then 145% interest as well as pay $243.54 in Cash. We were guaranteed the car was in great condition. We picked it up on 1/24/25. Then on [XXX] - Odometer reading 82509 - We pulled over on the side of the road to grab something from the trunk. Driver got back in car and all of a sudden the car just shut down saying overheated and smoke was coming out of the hood. Again, Absolutely no warning, no lights, no weird noises, nothing! We are now stuck in the middle of nowhere with our [XXX] granddaughter. Thank God a police man drove by. The next day we had to have it towed back to shop. Once back to the shop we were told that the engine or labor that they just put in our vehicle would not be covered by warranty. Nothing was fixed!!! I contacted the attorney general. We went to pick it up on 3/28/2025. Once they got involved the shop agreed to do all repairs for $1873.96. (pay $600 now and then post date 2 more checks). The owners said they looked over everything and nothing should be going wrong. It should be good as new. On [XXX] We were on our way to Puerto Penasco Mexico where we have a vacation home. About 20 miles into Mexico the car just stopped. Tons of Smoke from the tail pipe, Low oil pressure all of a sudden came on. I am attaching pics showing that the car was not showing overheated. So now my husband and i are stuck on the side of the road in Mexico with no cell phone service with a [XXX] car that we can not get fixed no matter how much money or time we put into it. When we finally got ahold of the shop they said they are washing their hands of it and do not want to see this car again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

The contact owns a 2017 Buick Encore. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 85,000.

This car is not mine but someone somehow fraudulently registered it in my name. I got the VIN # from truth finder when I did a search on myself. Please help.

The contact owns a 2017 Buick Encore. The contact stated that while driving at various speeds, the message "Engine Power Reduced" was displayed on the instrument panel. The check engine warning light was illuminated. The vehicle was taken to a local dealer however, the failure could not be duplicated. The contact stated that the failure persisted, and the vehicle was taken back to the same local dealer where it was diagnosed that the failure was related to Special Coverage: N232395330; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 88,881.

Passenger airbag light on dash is lit. Has ben lit for about a month.

The contact owns a 2017 Buick Encore. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the check engine warning light illuminated, and the vehicle lost motive power. In addition, the contact stated while the vehicle was at a stop light, the vehicle was idling roughly. The vehicle was towed to an independent mechanic where it was diagnosed with a failed turbo charger. The contact was informed that the turbo charger needed to be replaced. The vehicle was repaired. The dealer was made aware of the failure but provided no assistance. The manufacturer was made aware of the failure but provided no assistance. The contact was advised that the repair was not covered under any special coverage or recalls. The failure mileage was approximately 80,000.

The contact owns a 2017 Buick Encore. The contact stated that while driving at various speeds, the vehicle failed to properly accelerate while depressing the accelerator pedal. The check engine warning light remained illuminated. The vehicle was taken to the local dealer who was unable the determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. The VIN was not available.

I HAVE AN AUTOMATIC TRANSMISSION. WHEN I AM STOPPED AT A TRAFFIC LIGHT ON AN INCLINE, THE CAR WILL SOMETIMES ROLL BACKWARDS WITH MY FOOT ON THE BRAKE OR WHEN CHANGING MY FOOT TO THE GAS PEDAL TO MOVE FORWARD ONCE THE LIGHT CHANGES. THE MORE THE INCLINE; THE WORSE THE PROBLEM. This happens at a bus stop in a community with an incline and kids at a bus stop. This feeling is as I am driving a manual vehicle. It's not a good feeling knowing that there's children around and knowing that we want our children around for the future and something like this happens with a vehicle, the service department in the dealership cannot find what the problem is. This has happened to my car more than once. I have complained about it once and I am complaining about it again. I have low mi on my car and now, this has happened between the low miles of my car after purchasing up to miles. I have on it now .I've got 110,000 mi on my car and it still is not being repaired and is still happening. And it's bad. Once the car is paid off it turns into multiple problems with my car. Up

1. Valve cover gaskets been replaced in valve covers been replaced twice. 04/16/2024. 95113 miles 2. Air conditioning cooling leak and the fan motor would not shut off unless disconnecting the battery cable. 08/26/2024 at 100,254 miles 3. The turbocharger inline for the oil intake has been replaced . The car cannot completely carry a full carload without having no power to get up hills. I have no power once in a while if I'm alone driving just on a straight road or going uphills it seems like there's no gas getting to it I have good gas but it doesn't happen all the time. And I guess to where it will slow down from 55 to 35 pushing on the gas pedal with no power at all and then all the sudden it will go. Trying to explain this the best I can. 09/29/2024 at 101, 313 miles

Turbo has cracked like multiple other encores covered under a recall N232395330 id like to know why my car is not covered but the others are??

My vehicle just got diagnosed with a turbocharger issue, check engine light is on and cannot get inspected due to this fact. Due to repair costs, I will now be living with no vehicle for the foreseeable future. I understand this is a known issue for this type of vehicle and wanted to report it attached to my VIN

Turbo replaced under recall in March 2024 at local GMC dealership. June 2024 oil changed at independent service center and was informed that oil leak from turbo present. Vehicle brought back to dealership in June 2024 where vehicle was repaired for oil feed line being loose at the feed line. July 2024 car taken to independent mechanic and informed that a new turbo is needed. If turbo problem persists it will result in the vehicle shutting down while driving, violent shaking of the engine, and acceleration issues that could result in full engine failure if not resolved. The repairs done for the recall has not rectified the faulty turbo problem. The faulty turbos originally installed and being used for replacements are a safety hazard for any Buick Encore driver.

Engine, vehicle purchased end 2019. Several repairs, New Battery, some warranty repairs. March of 2022 PO131 - HO2s PO171 fuel trim lean PO300 engine misfire Evap system flow PO496 P1101 intake airflow UO401, 71 invalid data from the motor. Jun 2023 Need a New Engine 10k (Dealership) Sought out 2nd opinion 8k for New Engine Vehicle has been dead ever since. Repairs surpass what’s owed.

My check engine light came on in February 2024, vehicle mileage at the time was approximately 70,000 miles. My certified GM independent mechanic's diagnostic check revealed a DTC-P0299 code: faulty turbo charger. He advised repairs be made at a GM dealer under Special Coverage N-232395330 released in February 2024 by GM. My GM dealer (where I purchaser the vehicle) has also received the P0299 code and advised replacing the turbo charger. But since my VIN number is not a part of the Special Coverage, the cost of repairs would be my responsibility. I am requesting my vehicle's VIN be added to the Special Coverage and GM provide me the appropriate customer letter to cover all costs related my repair work.

The contact owns a 2017 Buick Encore. The contact stated that while the front passenger's side seat was occupied, the seat belt chime reminder failed to engage while the front passenger's side seat belt was not buckled, and the message "Air Bag Off" was displayed. The contact stated that the failure had been recurring. The vehicle was taken to the dealer, where it was diagnosed that the front passenger's side seat presence module had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Numbers: 17V437000 (Air Bags, Seat Belts) and 16V651000 (Air Bags, Seat Belts); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The failure mileage was approximately 45,000.

See attached document for complaint

The contact owns a 2017 Buick Encore. The contact stated that while driving at approximately 65 MPH, the vehicle suddenly stalled, with the check engine warning light illuminated. The vehicle was able to be restarted. The contact was able to drive a short distance to the residence. The vehicle was taken to the dealer where it was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 176,000.

P215/55R18 94H M+S Nothing has happened yet, but we need to get all new tires! When we got these [XXX] they were 80,000 mile tires. The mileage on our car when installed was 33,231 and is now 74,434, so no where near 80,000 miles. There are cracks all around all 4 tires L Front the worst, on the sidewall by the tread! We have only been back to Sams once for rotation etc., because it is 20 miles away, so we do it locally at our Buick dealership, or the Les Schwab tire store every 3500 miles. Needless to say we will not be going back to Sams to get tires, ever again! I seriously have never seen tires so bad, and there isn't any recall on them. I know there are 5 complaints about these tires, at least the Goodyear Assurance MaxLife! One comment from a Sams in Kingston, NY was that, "that was the 19th one with the same problem". This was on the inner sidewall, and mine is on the outside, but I cannot see the inside, it probably looks the same! We hadn't noticed until the Dealership pointed it out when they serviced the car. SAMS, where we got them won't do anything, saying it is weather related cracking????? Seriously, I have never had a tire that looks like these do! As you can see from the photos attached, that there should have been enough tread to get us through the summer, but they are not SAFE! Just glad nothing has happened! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Suspension problems rattle in front end.Found both front stabilizer links failed in test drive. Had to replace front stabilizer links on both sides in front.

Stop at inclined, stopping at stop sign, releasing foot off brake pedal, car rolls to the rear,

There is a known defect with the GM Ecotec engines, specifically the lack of retaining clip for the internal PCV valve, allowing it to become dislodged and drawn into the engine. Without the PCV valve, tremendous engine pressure is produced, leading to broken gaskets causing vacuum leaks, misfiring, severe vibration, and loss of power when accelerating (which can be a safety issue). Dorman produced a video outlining the issue and has re-engineered the part to prevent the issue from occurring: "Why GM 1.4L Ecotec engine intake manifold and valve covers repairs are often related" [XXX] This appears to be a fairly wide-spread issue with the GM Ecotec engines, and GM should perform a recall to replace these parts, and reimburse those who had to replace themselves. This also causes error codes requiring spark plugs to be replaced (they get fouled by oil) and the MAF Sensor. In troubleshooting, I also had to replace the distributor power bar and air intake hose. I have recipts for all parts, but file upload is not working on this site. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Buick Encore. The contact stated when the vehicle was first started, the vehicle accelerated to approximately 10 MPH and then the vehicle shifted into LIMP Mode. The contact stated that the check engine and stabili-trak warning lights were illuminated. The contact had taken the vehicle to an Auto Parts store where DTC code: P2138 was retrieved. The failure was related to the accelerator position sensor. The contact was informed that the accelerator pedal needed to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 22,000.

The contact owns a 2017 Buick Encore. The contact stated while driving 45-50 MPH, the vehicle started overheating and the high engine temperature warning light illuminated. The contact was able to pull over and waited for the vehicle to cool down. Once the vehicle cooled down, the contact was able to operate the vehicle normally. The vehicle was taken to the dealer and the contact was informed that the water pump needed to be replaced. The vehicle was repaired but the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the engine needed to be replaced. The vehicle was repaired but the failure recurred. The vehicle was taken back to the dealer and the contact was informed that the engine needed to be replaced again. The vehicle was not repaired because the warranty had expired. The manufacturer was not contacted. The failure mileage was 80,000.

The contact owned a 2017 Buick Encore. The contact stated that the vehicle was at a standstill in a traffic light, she saw smoke exiting from the hood of the vehicle. The contact stated no warning light was illuminated. The contact stated a bystander informed the vehicle was on fire. The contact was able to exit the vehicle safely before the vehicle was engulfed in flames. The contact stated no one was injured nor sought medical attention. The fire department was able to extinguish the fire. A police report was filed. The insurance company deemed the vehicle was a total loss. The vehicle was towed to a towing lot. The vehicle was not diagnosed. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 47,000.

Fire