2007 BMW 530XI Recalls, Complaints & Safety

The contact owns a 2007 BMW 530XI. The contact stated that while driving at 35 MPH, the front driver’s side air bag deployed without an impact. The contact had not sustained any injuries during the failure. Despite the failure, the contact was able to drive the vehicle back to the residence. The local dealer was notified of the failure, and the vehicle was towed to a dealer. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 172,000.

in the trunk in the spare tire well. Water could be there, flooding some electronics. The wiring got wet causing my car to just turn off in the expressway due to the comments getting wet that are harnessed in this area. I tried to get it repaired when the class action lawsuit took place but the dealership I had my car at for 3 months never performed the repair. Then the next dealership refused to perform the repairs due to time constraints. Now every time it rains I am worried my car will short or just shut off. I have had to replace the part 2 times and now I just leave it unattached . the BMW agrees to settle vehicle water damage suit for up to $478 million. WASHINGTON (Reuters) - German automaker BMW AG has agreed to pay up to $477.7 million to settle a class-action lawsuit covering about 318,000 U.S. luxury car owners who may have suffered water damage harming electrical components in vehicle trunks.

Coolant hose has broken 4 times in the last 3 years it breaks at the attachment causing all my coolant to leak the area and part is plastic causing it to melt during summer months each summer I have owned it

Fire

The front Xenon Headlight Wiring protective plastic coating has degraded and prematurely failed on both headlight assemblies. This caused headlight bulb shorting and poses a potential fire hazard in the front engine compartment of the vehicle. The wiring used in the headlight assemblies was not up to proper standards and failed. The wiring used in other areas of the engine bay seems to be okay. The internal headlight wiring appears to be supplied by the OEM Headlight Manufacturer (HELLA) and does not seem to be up to proper standards to prevent the plastic protective coating from failing over time. This should not be considered a "wear item" as electrical wiring is used throughout millions of much older vehicles without incident.

Fire

The front Xenon Headlight Wiring protective plastic coating has degraded and prematurely failed on both headlight assemblies. This caused headlight bulb shorting and poses a potential fire hazard in the front engine compartment of the vehicle. The wiring used in the headlight assemblies was not up to proper standards and failed. The wiring used in other areas of the engine bay seems to be okay. The internal headlight wiring appears to be supplied by the OEM Headlight Manufacturer (HELLA) and does not seem to be up to proper standards to prevent the plastic protective coating from failing over time. This should not be considered a "wear item" as electrical wiring is used throughout millions of much older vehicles without incident.

Fire

The front Xenon Headlight Wiring protective plastic coating has degraded and prematurely failed on both headlight assemblies. This caused headlight bulb shorting and poses a potential fire hazard in the front engine compartment of the vehicle. The wiring used in the headlight assemblies was not up to proper standards and failed. The wiring used in other areas of the engine bay seems to be okay. The internal headlight wiring appears to be supplied by the OEM Headlight Manufacturer (HELLA) and does not seem to be up to proper standards to prevent the plastic protective coating from failing over time. This should not be considered a "wear item" as electrical wiring is used throughout millions of much older vehicles without incident.

Fire

BMW Headlight wiring on the 530 series is defective. Wire Insulation throughout the headlight assembly crumbles. The design and wire specification were not fit for use. Heat may be an issue but has nothing to do with climate. The vehicle has spent most of its life in Michigan where the problem was first noted when the age of the vehicle was approximately 8 years. High heat within the headlight assembly also caused deterioration of the covering on fiber optic cable. This problem is well known to BMW owners. The bare wires within the headlight housing pose a risk of electrical shorts and potentially fires.

Headlight wiring has disintegrated and making headlight short

The contact owns a 2007 BMW 530XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2007 BMW 530XI. The contact received notification of NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the vehicle was overheating while driving. The contact stated that the frame of the vehicle felt extremely hot after driving and the vehicle took a long time to cool down. There was no warning light illuminated. An unknown local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 100,000. VIN tool confirms parts not available.

The contact owns a 2007 BMW 530XI. The contact stated that while driving in the snow, the vehicle overheated. The contact was able to pull over to the shoulder. The engine overheated, and slow-down messages were displayed. The engine overheated and shut down immediately. warning indicator lights were illuminated. The vehicle was towed to the local dealer where it was diagnosed that the thermostat and water pump needed to be replaced but the dealer refused to repair the vehicle. The vehicle was not repaired. The vehicle was towed to the contact's residence. The manufacturer was notified about the failure and referred the contact to the dealer. The contact stated the failure was related to NHTSA Campaign Number: 22V119000 ( Engine and Engine Cooling). The approximate failure mileage was 178,000.

The contact owns a 2007 BMW 530XI. The contact stated while driving 40 MPH, the vehicle overheated with a message to pull over displayed. The contact was able to pull over safely and had the vehicle towed to the dealer. The vehicle was diagnosed and the contact was informed that the failure was not related to NHTSA Campaign Number: 22V119000 (Engine and Engine Cooling). The contact was informed that the thermostat and water pump needed to be replaced. The vehicle was repaired. The manufacturer was contacted and stated confirmed that the failure was not related to the recall. The failure mileage was 160,519. The contact stated the dealer refuses to fix the recall.

The contact owns a 2007 BMW 530XI. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 13V564000 (Air Bags) however, the VIN was not included in the recall. The failure mileage was approximately 150,000.

A PROBLEM WITH THE POST IT I'VE CRANKCASE VENTALATINON SHORT CIRCUITING

WHILE SITTING AT A LIGHT CAR WAS IMPACTED BY ANOTHER VEHICLE FROM THE PASSENGER'S SIDE AT THE REAR AXLE WHEEL AREA. AUTO STRUCK VEHICLE AT SPEEDS NEAR 80-100 MPH. AIRBAGS DID NOT DEPLOY EVEN THOUGH WHEN THE CAR STUCK IT CONTINUED FROM THE REAR TO THE FRONT OF THE CAR EVEN PARTIALLY RIPPING THE FRONT BUMPER OUT OF PLACE.

Crash

WHILE SITTING AT A LIGHT CAR WAS IMPACTED BY ANOTHER VEHICLE FROM THE PASSENGER'S SIDE AT THE REAR AXLE WHEEL AREA. AUTO STRUCK VEHICLE AT SPEEDS NEAR 80-100 MPH. AIRBAGS DID NOT DEPLOY EVEN THOUGH WHEN THE CAR STUCK IT CONTINUED FROM THE REAR TO THE FRONT OF THE CAR EVEN PARTIALLY RIPPING THE FRONT BUMPER OUT OF PLACE.

Crash

WHILE SITTING AT A LIGHT CAR WAS IMPACTED BY ANOTHER VEHICLE FROM THE PASSENGER'S SIDE AT THE REAR AXLE WHEEL AREA. AUTO STRUCK VEHICLE AT SPEEDS NEAR 80-100 MPH. AIRBAGS DID NOT DEPLOY EVEN THOUGH WHEN THE CAR STUCK IT CONTINUED FROM THE REAR TO THE FRONT OF THE CAR EVEN PARTIALLY RIPPING THE FRONT BUMPER OUT OF PLACE.

Crash

WHILE SITTING AT A LIGHT CAR WAS IMPACTED BY ANOTHER VEHICLE FROM THE PASSENGER'S SIDE AT THE REAR AXLE WHEEL AREA. AUTO STRUCK VEHICLE AT SPEEDS NEAR 80-100 MPH. AIRBAGS DID NOT DEPLOY EVEN THOUGH WHEN THE CAR STUCK IT CONTINUED FROM THE REAR TO THE FRONT OF THE CAR EVEN PARTIALLY RIPPING THE FRONT BUMPER OUT OF PLACE.

Crash

VEHICLE WAS TRAVELLING 25-30 MPH ON A CITY STREET AND HIT A POTHOLE. IMMEDIATELY DRIVER HEARD A NOISE FROM THE ENGINE AREA AND CAR BEGAN SHAKING AND VIBRATING WHILE AT LOW SPEED/IDLE. SERVICE TECHNICIAN DISCOVERED THAT ALL 4 BOLTS FOR THE ENGINE MOUNT HAD SHEARED AS A RESULT OF THE IMPACT AND THE ENGINE WAS NOW HANGING FREE AND RESTING ON THE FRAME OF THE CAR. DRIVESHAFT WAS KNOCKED OUT OF ALIGNMENT AS WELL.

I WAS DRIVING IN TOWN WITH MY NEWBORN BABY IN THE BACK SEAT WHEN THE AC/HEAT SYSTEM CAUGHT ON FIRE AND SMOKE CAME BILLOWING INTO THE CABIN THROUGH THE AIR VENTS. IT IMMEDIATELY SMELLED LIKE BURNING PLASTIC/ELECTRICAL FIRE. I PULLED THE CAR OVER BECAUSE I WAS WORRIED ABOUT A FIRE AND GOT MY CHILD OUT OF THE VEHICLE. AFTER DOING SOME RESEARCH, I HAVE SINCE NOTICED THAT THIS IS A KNOWN PROBLEM BY BMW AND THAT THEY HAVE AN ACTIVE RECALL FOR THIS PRECISE ISSUE, BUT IT DOES NOT COVER MY SPECIFIC MODEL. THE RECALL CURRENTLY OUT FOR THIS ISSUE IS # 17V-676, WHICH COVERS A NUMBER OF 3-SERIES MODELS, BUT NOT MY 530XI. I JUST GOT WORD FROM MY MECHANIC THAT IT WILL COST $1800 TO REPLACE THE FRIED SYSTEM, AND HE ALSO WARNED ME THAT IT COULD HAVE CAUGHT THE ENTIRE CAR ON FIRE. I HAD HIM PUT THIS IN WRITING FOR ME SO I CAN HAVE RECORD OF IT. PLEASE HELP ME WITH THIS! BMW NEEDS TO WIDEN THE SCOPE OF THIS RECALL TO COVER OTHER AFFECTED VEHICLES! THANK YOU

Fire

RECENTLY THERE WAS A CLASS ACTION LAWSUIT SETTLEMENT (WWW.E6061INGRESSSETTLEMENT.COM). THE SETTLEMENT STATES THAT THE CAR SHOULD HAVE LESS THAN 120K MILES. MY CAR HAS THE EXACT SAME ISSUE AND I HAVE A SERVICE RECORD FROM 2015 WHEN THE CAR HAD LESS THAN 100K MILES. BY THE TIME THE LAWSUIT WAS SETTLED AND THE DEALERS WERE ACCEPTING CARS, I CROSSED 120K MILES AND NOW THEY ARE SAYING I'M NOT ELIGIBLE FOR THE REPAIRS.

WHILE DRIVING MY VEHICLE ON EITHER THE STREET OR HIGHWAY. MY VEHICLE BEGINS TO RELEASE LARGE AMOUNTS OF SMOKE FROM UNDER THE HOOD AND SOME SORT OF FUMES COME INTO THE CAR THROUGH THE VENTILATION SYSTEM WHICH MAKES IT HARD TO BREATHE AND SEE.

THE AIR BAG ON PASSENGER SIDE IS STILL SAYING FAULT IN AIRBAG ON CAR SYSTEM

TL* THE CONTACT OWNS A 2007 BMW 530XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING). THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED BMW OF SPRINGFIELD AT (973) 379-7744 (391 U.S. 22, SPRINGFIELD TOWNSHIP, NJ 07081) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2007 BMW 530XI. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING). THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. PAUL MILLER BMW (1515 NJ-23, WAYNE, NJ 07470, (973) 696-6060) WAS CONTACTED AND CONFIRMED THAT THE REMEDY WAS NOT YET AVAILABLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *TT *TR

I PURCHASED THIS BMW FROM LOMBARD TOYOTA . AS PER THEM THEY HAVE ENSURED NOTHING IS WRONG WITH THE CAR . I WAS DRIVING THE CAR AND WHEN I APPLY THE BRAKES THE CAR TRIES TO JUMP FORWARD. MY CAR IS A ALL WHEEL DRIVE AND IT CAUSED A SKID . THIS HAS CAUSED ME TO HAVE THE CAR GO OUT OF CONTROL WHEN IT WAS SNOWING . WHEN I INVESTIGATED THIS , IT SEEMS TO BE A COMMON PROBLEM WITH BMW AND BMW USA DOESNT WANT TO DO ANYTHING . THIS IS A VERY DANGEROUS SITUATION AND BMW DOESNT WANT TO TAKE RESPONSIBILITY AS PER LOMBARD TOYOTA .

FRONT GLASS PANEL ON THE PANORAMIC GLASS ROOF SPONTANEOUSLY EXPLODED ON FLAT STRAIGHT STRETCH OF HIGHWAY AT 75 MPH. ALL WINDOWS WERE CLOSED, NO RADIO PLAYING, NO FORWARD TRAFFIC OR WIND TO PRODUCE AIRBORNE ROAD DEBRIS. THE ORIGINAL FACTORY ROOF WAS NOT MADE WITH LAMINATED GLASS PRODUCING A DEAFENING EXPLOSIVE SHOWER OF GLASS PIECES. PANORAMIC SUNROOF NOT COVERED UNDER REGULAR GLASS INSURANCE, REQUIRED AN EXPENSIVE AUTO CLAIM TO REPLACE.

1 injured

2007 BMW 530 XI. CONSUMER WRITES IN REGARDS TO FRONTAL SENSOR/CONTROL MODULE SAFETY RECALL. *LD THE CONSUMER REQUESTED TO BE INCLUDED IN THE SAFETY RECALL. *JS

TL* THE CONTACT OWNS A 2007 BMW 530XI. WITHIN MONTHS OF OWNING THE VEHICLE, SMOKE APPEARED UNDER THE HOOD AND ENTERED THE VEHICLE MORE THAN TWICE. THE COOLANT WAS LOW AND REPLACED, AND AN UNKNOWN WARNING INDICATOR RANDOMLY ILLUMINATED FREQUENTLY. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V683000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *TT

Fire

I RECEIVED A RECALL NOTICE FROM BMW - NO. 13V-564 I HAVE GONE TO TWO DEALERSHIPS, INCLUDING THE ONE WHERE I BOUGHT THE CAR BRAND NEW AND THEY WILL NOT COMPLETE THE REPAIRS DUE TO A REPLACEMENT PART ON HOLD NOTICE FROM BMW. THEY ALSO WILL NOT TELL ME WHEN THEY CAN COMPLETE THE REPAIR. I CALLED BMW AND RECEIVED NO HELP AT ALL, JUST TO TRY ANOTHER DEALER.

WHILE ON HIGHWAY FOUR MOTOR MOUNT BOLTS SUDDENLY BROKE, CAUSING THE MOTOR VIBRATIONS, TO BREAK THE WATER PUMP, AXLE AND MORE, IF CONTINUED TO DRIVE MOTOR COULD FALL ON THE ROAD.

ON DAYS WARMER THAN 85 DEGREES, THE BRAKE PEDAL BECOMES STIFF AND GREAT FORCE MUST BE APPLIED TO STOP THE VEHICLE. IF THE CAR IS PLACED IN NEUTRAL AND THE ENGINE IS REVVED, THE BRAKE PEDAL RETURNS TO NORMAL, BUT RETURNS TO THE SAME PROBLEM SHORTLY. THIS ISSUE APPEARS TO BE THE SAME ISSUE THAT BMW ISSUED A RECALL FOR ON E60 VEHICLES WITH V8 ENGINES.

THE AIRBAG LIGHT AND THE SEATBELT LIGHT CAME ON, THIS IS A SAFETY ISSUE SO I DON'T KNOW IF THE CAR OF THAT YEAR HAD A RECALL OR NOT ..IT WAS CITY STREET

TL* THE CONTACT OWNS A 2007 BMW 530XI. WHILE DRIVING 20 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEGE WAS 116,000.

MY CAR DO NOT GO PASS 50 MILES PER HOUR.

PASSENGER RESTRAINT SYSTEM ERROR CODE. THE AIRBAG WILL NOT DEPLOY! I AM AFRAID TO ALLOW ANYONE TO RIDE IN THE PASSENGER SEAT! THE EXACT SAME ISSUE BROUGHT A RECALL FOR ALL 5 SERIES FROM 2004 - 2006 AND APPARENTLY SOME 2007 MODELS. THEY ARE TELLING ME MINE ISN'T COVERED! THIS IS A SAFETY ISSUE! DO I HAVE ANY RECOURSE??

I GOT A MESSAGE ON THE DASHBOARD SAYING STEERING WHEEL LOCK MALFUNCTION. BUT THE CAR IS STILL RUNNING, I GOT SCARED IN CASE SOME THING HAPPENED I NEED YOUR ADVICE.

AFTER DRIVING ABOUT 5 MINUTES FROM HOME, I PARKED THE CAR IN THE PARKING LOT IN FRONT OF MY OFFICE. ABOUT 5 MINUTES LATER, BYSTANDERS NOTICED A FIRE IN ENGINE COMPARTMENT OF THE CAR AND CALLED 911. THE CAR WAS IN FLAMES IN A SHORT TIME. THE FIRE DEPARTMENT ARRIVED, PUT OUT THE FIRE.

Fire