1987 BLUE BIRD WANDERLODGE Recalls, Complaints & Safety

UNKNOWN OR OTHER

Defect Description

THE PATIO AWNING IS INADEQUATELY ATTACHED TO MOTORHOME AND IT COULD BEGIN TO UNRAVEL FROM THE REAR CAUSING A SHEARING OF THE FRONT LOCK. ONCE THE LOCK IS FREE, THE ENTIRE AWNING CAN BE EXPOSED TO WIND PRESSURE AND BE TORN FROM THE SIDE OF THE MOTORHOME WHILE THE VEHICLE IS IN MOTION.

Consequence

THE TORN AWNING MAY SEPARATE FROM THE MOTORHOME WHILE THEVEHICLE IS IN MOTION, CAUSING A HIGHWAY HAZARD WHICH COULD RESULT IN A VEHICLEACCIDENT.

Remedy

A RETROFIT KIT WILL BE INSTALLED ON THE MOTORHOMES.

365 vehicles affected

Manufacturer: BLUE BIRD BODY COMPANY

ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD

Defect Description

TURN INDICATOR AND HEADLIGHT WIRING HARNESS CAN COME IN CONTACT WITH THE STEERING POST.

Consequence

WHEN STEERING POST TURNS, IT CAN RUB THROUGH INSULATIONCAUSING ELECTRICAL SHORTS.

Remedy

REPAIR DAMAGED WIRES AND REROUTE WIRING HARNESS TO AVOID CONTACT WITH STEERING POST.

200 vehicles affected

Manufacturer: BLUE BIRD BODY COMPANY

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS

Defect Description

INCORRECT CIRCUIT BREAKER CAN BECOME OVERLOADED AND TRIP, AND NOT RESET FOR 40-60 SECONDS.

Consequence

BUS WOULD LOSE TURN SIGNALS, TAIL LIGHTS, STOP LIGHTS,HEADLIGHTS, AND/OR WINDSHIELD WIPERS.

Remedy

REPLACE 50 AMP BREAKER WITH 105 AMP BREAKER.

505 vehicles affected

Manufacturer: BLUE BIRD BODY COMPANY

Complaint Statistics

1 total complaints

Top Reported Components

Component	Complaints
TIRES:TREAD/BELT	1

Incident date: Aug 17, 2000

REAR DRIVER'S SIDE HANKOOK DYNAMIC RADIAL F26 TIRE 12R22.5 16 PLY EXPERIENCED TREAD SEPARATION, CAUSING $3000 WORTH OF DAMAGE TO VEHICLE. *SLC

NHTSA Safety Investigations, BLUE BIRD WANDERLODGE

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2005

Front Tire Overload

As detailed in the opening resume for this investigation dated November 16, 2015, Blue Bird Corporation (BBC) conducted recall 07V-586 with two subsequent amendments to address overloaded front axles and tires on the subject vehicles.Following the remedy installations, NHTSA received nine petitions ... and seven consumer complaints (many from the same owners who had filed petitions) alleging the remedial actions taken by BBC were inadequate.At the time, NHTSA was aware of two consumer complaints and three crashes of vehicles that received the 07V-586 recall remedy.One of the complaints was similar to the petitions in that it focused on utility loss and not safety issues.The second complaint (received May 2014) described a crash that occurred in May 2013 that was also identified in media reports. The second and third crashes occurred in August 2013 and January 2015. All three crashes allegedly resulted from failure of one of the front tires.During this investigation, NHTSA requested information from BBC including details about the three referenced crashes and if they were aware of any additional failures.BBC responded that they were not aware of any other failures and had only received crash information on one of the incidents from sources other than NHTSA.In order to understand why the tires failed prior to or during each of the three crashes, NHTSA attempted to collect as much information about each incident as possible.This included insurance documents, photographs, police accident reports, vehicle weights, maintenance history, and the failed tires.In the case of two of the crashes, not enough information could be obtained to determine the exact cause of the tire failure and crash.In the case of the third crash, the tire was collected and analyzed.This analysis found that the tire failed as a result of impact damage and not overloading.In October 2015, BBC initiated a customer service campaign (S15YF) where owners would be notified that BBC would replace the front wheels and tires on the subject vehicles.This action was taken to address owner concerns that the ride comfort in the vehicle was bad and that tire pressure was difficult to maintain at the required 130psi.The new wheels and tires installed by BBC increased the load capacity of the tire, allowing owners to carry the maximum load of the coach at a lower tire pressure.At the time of the closing of this investigation, NHTSA does not have the necessary evidence to establish the existence of an unreasonable risk to motor vehicle safety in the subject vehicles.NHTSA is not aware of any front axle failures in the subject vehicles for any reason. The single tire failure crash where sufficient evidence had been preserved resulted from the vehicle striking an object damaging the tire.The action taken by BBC to increase the load capacity of the tires on the subject vehicles addresses the safety concerns prompting this investigation.This investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists.The agency may take further action if warranted by the circumstances.Read more

DP, Closed , Model Year: 2005

Alleged inadequate recall remedy 07V-586

On December 11, 2007, Blue Bird Corporation (BBC) submitted an uninfluenced recall 07V-586 to the agency.This recall described a defect on fifty eight 2005?2007 Model Year (MY) Wanderlodge Recreational Vehicles (RV) where the curb weight of the front axle could exceed the axle?s 16,000 pound rating.... Read more

BLUE BIRD WANDERLODGE - All Years Overview

Complete safety history for the BLUE BIRD WANDERLODGE across all model years (1966, 2005).

76 Total Recalls

7 Total Complaints

2 Investigations

0 Reported Crashes

0 Reported Fires

0 Reported Deaths

BLUE BIRD WANDERLODGE - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2005	1	0	View
2004	1	0	View
2003	1	0	View
2002	2	1	View
2001	3	0	View
2000	5	0	View
1999	9	0	View
1998	5	0	View
1997	4	0	View
1996	2	0	View
1995	1	1	View
1994	1	0	View
1993	1	0	View
1991	2	0	View
1990	2	0	View
1989	2	0	View
1988	4	0	View
1987 (current)	3	1
1986	3	0	View
1985	3	0	View
1984	2	0	View
1983	1	0	View
1982	2	0	View
1981	1	0	View
1973	1	0	View
1972	3	0	View
1971	2	0	View
1970	2	0	View
1969	2	0	View
1968	2	0	View
1967	2	0	View
1966	1	0	View

Other BLUE BIRD Models

Model	Recalls	Complaints
ALL AMERICAN	720	222	View
VISION	537	24	View
TC2000	214	39	View
VISION SCHOOL BUS	196	4	View
ALL AMERICAN SCHOOL BUS	148	9	View
CONVENTIONAL	125	20	View
MICRO BIRD	120	0	View
VISION TRANSIT BUS	73	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

1987 BLUE BIRD WANDERLODGE

Complaint Statistics

Top Reported Components

NHTSA Safety Investigations, BLUE BIRD WANDERLODGE

BLUE BIRD WANDERLODGE - All Years Overview

BLUE BIRD WANDERLODGE - Year by Year

Other BLUE BIRD Models