2004 BLUE BIRD VISION

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2006 VISION CONVENTIONAL STYLE SCHOOL BUSES MANUFACTURED FROM JUNE 26, 2003, THROUGH DECEMBER 9, 2004. THE STARTER CABLE MAY CONTACT AND POTENTIALLY CHAFE AGAINST THE STEEL BRAIDED POWER STEERING HOSE THEREBY CREATING A DIRECT SHORT.

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2006 VISION CONVENTIONAL STYLE NON SCHOOL BUSES MANUFACTURED FROM JUNE 26, 2003, THROUGH DECEMBER 9, 2004. THE STARTER CABLE MAY CONTACT AND POTENTIALLY CHAFE AGAINST THE STEEL BRAIDED POWER STEERING HOSE THEREBY CREATING A DIRECT SHORT.

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 VISION NON-SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 19, 2003 THROUGH JULY 2, 2008. THE POWER CABLES RUNNING TO THE POWER DISTRIBUTION UNIT STUD AND DRIVER'S CONTROL MODULE STUD MAY HAVE BEEN INSTALLED WITH THE LUG (EYELET) FLAT SIDE UP. WHEN THIS CONDITION EXISTS, VIBRATION MAY WEAR THE INSULATION PERMITTING DIRECT CONTACT BETWEEN THE BARE LUG AND THE PDU OR DCM WHICH COULD CAUSE A DIRECT SHORT IN THE ELECTRICAL SYSTEM.

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 VISION SCHOOL BUSES MANUFACTURED FROM JANUARY 30, 2003 THROUGH SEPTEMBER 24, 2008. THE POWER CABLES RUNNING TO THE POWER DISTRIBUTION UNIT STUD AND DRIVER'S CONTROL MODULE STUD MAY HAVE BEEN INSTALLED WITH THE LUG (EYELET) FLAT SIDE UP. WHEN THIS CONDITION EXISTS, VIBRATION MAY WEAR THE INSULATION PERMITTING DIRECT CONTACT BETWEEN THE BARE LUG AND THE PDU OR DCM WHICH COULD CAUSE A DIRECT SHORT IN THE ELECTRICAL SYSTEM.

BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2010 ALL AMERICAN, VISION, MICRO BIRD, AND CONVENTIONAL SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 30, 2003 AND MAY 7, 2009. INCORRECT OFFSET LEG BARRIER PADS OR 2/3 SEAT BACK PADS MAY HAVE BEEN INSTALLED. BUSES WITH INCORRECT PADS INSTALLED FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

THE HYDRAULIC BRAKE HOSES FROM THE MASTER CYLINDER TO THE CHASSIS FRAME MAY HAVE BEEN IMPROPERLY ROUTED OR RETAINED ON CERTAIN 2004 THROUGH 2009 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND TRANSIT BUSES MANUFACTURED FROM JANUARY 11, 2004 THROUGH APRIL 22, 2008.

THE HYDRAULIC BRAKE HOSES FROM THE MASTER CYLINDER TO THE CHASSIS FRAME MAY HAVE BEEN IMPROPERLY ROUTED OR RETAINED ON CERTAIN 2004 THROUGH 2009 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND TRANSIT BUSES MANUFACTURED FROM JANUARY 11, 2004 THROUGH APRIL 22, 2008.

CERTAIN BLUE BIRD MY 2004 THROUGH 2007 VISION SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 9, 2003, AND SEPTEMBER 21, 2006, EQUIPPED WITH PARKER SINGLE CHECK VAVLES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.

CERTAIN BLUE BIRD MY 2004 THROUGH 2007 VISION SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 9, 2003, AND SEPTEMBER 21, 2006, EQUIPPED WITH PARKER SINGLE CHECK VAVLES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.

CERTAIN 2004-2007 MY VISION SCHOOL BUSES MANUFACTURED BETWEEN AUGUST 5, 2003, AND JUNE 13, 2006, EQUIPPED WITH OPTION 40280-02 AMMETER SHUNT. THE POWER CABLE ORIGINALLY INSTALLED BETWEEN THE TOE BOARD AND THE SHUNT MAY BE TOO SHORT AND MAY BREAK DUE TO ENGINE VIBRATION.

CERTAIN 2001 THROUGH 2006 MY BLUE BIRD ALL AMERICAN, TC2000, AND VISION TRANSIT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2001, AND JULY 15, 2005. THESE BUSES ARE EQUIPPED WITH A BATTERY DISCONNECT SWITCH THAT HAS CONNECTIONS THAT MAY BE LOOSE ON THE BATTERY SWITCH STUDS CREATING THE POTENTIAL FOR THE BUS TO SHUT DOWN WHILE IN OPERATION.

CERTAIN SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE STOP ARM SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

CERTAIN BLUE BIRD 2002 THROUGH 2006 MY ALL AMERICAN, CONVENTIONAL, MINIBIRD, MICROBIRD, VISION, AND TC2000 SCHOOL BUSES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.

CERTAIN BLUE BIRD MY 2004-2006 VISION SCHOOL BUSES EQUIPPED WITH HYDRAULIC BRAKES MANUFACTURED BETWEEN MARCH 24, 2003, AND APRIL 25, 2005. THE HYDRAULIC BRAKE DASH WARNING LIGHT WAS INCORRECTLY LABELED WITH THE CANADIAN VERSION WHICH USES SYMBOLS RATHER THAN WORDS AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS.

CERTAIN 2004-2006 MY BLUE BIRD VISION CONVENTIONAL SCHOOL AND NON SCHOOL BUSES MAUNFACTURED FROM JUNE 12, 2003, THROUGH FEBRUARY 22, 2005. A SHORT CAN OCCUR IN THE CROSSING ARM CIRCUIT OR THE 8-WAY WARNING LIGHT CIRCUIT, CAUSING THE HEAVY DUTY TRANSISTOR W/BUILT IN CIRCUIT PROTECT TO TRIP RESULTING IN AN INADVERTENT ENGINE SHUTDOWN.

CERTAIN BLUE BIRD 1999-2005 ALL AMERICAN, TC/2000, MICRO BIRD, VISION, CONVENTIONAL, AND COMMERCIAL SERIES SCHOOL BUSES EQUIPPED WITH SURE-LOC WHEELCHAIR SECUREMENT SYSTEMS AND MANUFACTURED BETWEEN FEBRUARY 17, 1999, AND AUGUST 13, 2004. CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.

ON CERTAIN CONVENTIONAL STYLE SCHOOL BUSES, ONLY THOSE EQUIPPPED WITH AIR BRAKES, THE UNDERHOOD FIREWALL LOCATION OF THE AIR BRAKE MANIFOLD MAY PERMIT RAINWATER ENTRY INTO THE PARKING BRAKE EXHAUST PORT FITTING OF THE MANIFOLD. IN FREEZING WEATHER, THIS WATER COULD FORM ICE BLOCKING THE EXHAUST PORT. WHEN THIS OCCURS, THE PARKING BRAKE DOES NOT OPERATE AS DESIGNED.

2004 MY BLUE BIRD VISION CONVENTIONAL TYPE SCHOOL BUSES MANUFACTURED FROM JUNE 12, 2003, THROUGH SEPTEMBER 24, 2003. THE BUS BAR THAT CONNECTS THE AMMETER SHUNT TO THE ENGINE INTAKE GRID HEATER MEGAFUSE WAS INCORRECTLY INSTALLED. THE IMPROPER INSTALLATION OF THIS BUS BAR CREATES EXCESSIVE ELECTRICAL RESISTANCE AND POTENTIAL OVERHEATING IN THE GRID HEATER POWER CIRCUIT.

ON CERTAIN SCHOOL BUSES, THE POWER CABLES THAT RUN FROM THE STARTER TO THE POWER DISTRIBUTOR UNIT MAY CHAFE AGAINST THE BOTTOM CORNER OF THE FRONT FLOOR PANEL, RESULTING IN AN ELECTRICAL SHORT.