FUEL SYSTEM, DIESEL
CERTAIN 1998 THROUGH 2002 BLUE BIRD ALL AMERICAN, TC2000 SCHOOL AND TRANSIT BUSES, AND COMMERCIAL SERIES BUSES EQUIPPED WITH CUMMINS ISB DIESEL ENGINES. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.
Remedy: CUSTOMERS WILL BE NOTIFIED BY CUMMINS TO BRING THEIR VEHICLES TO AN AUTHORIZED DEALER TO HAVE THE FUEL LIFT PUMP REPLACED FREE OF CHARGE. FOR MORE INFORMATION, CUSTOMERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
18,891 vehicles affected
EQUIPMENT ADAPTIVE/MOBILITY
CERTAIN BLUE BIRD 1999-2005 ALL AMERICAN, TC/2000, MICRO BIRD, VISION, CONVENTIONAL, AND COMMERCIAL SERIES SCHOOL BUSES EQUIPPED WITH SURE-LOC WHEELCHAIR SECUREMENT SYSTEMS AND MANUFACTURED BETWEEN FEBRUARY 17, 1999, AND AUGUST 13, 2004. CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
Remedy: BLUE BIRD WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN SEPTEMBER 21, 2004. OWNERS WHO TAKE THEIR BUSES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AT BLUE BIRD AT 478-822-2242.
372 vehicles affected
SUSPENSION
VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH HENDRICKSON REAR AIR SUSPENSION. INADEQUATE TIGHTENING OF THE 5/8" BOLTS ON THE REAR AIR SUSPENSION HANGER BOLTS AND ON REAR AXLE TORQUE ARM AXLE SEAT STUDS.
Remedy: DEALERS WILL REPLACE THE 5/8" GRADE 8-HANGER BOLTS. IN ADDITION, AXLE SPRING SEAT FASTENERS WILL BE CHECKED FOR PROPER TIGHTNESS AND, IF NEEDED, TIGHTENED TO SPECIFICATIONS. OWNER NOTIFICATION BEGAN JANUARY 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-478-822-2242.
2,692 vehicles affected
ELECTRICAL SYSTEM:WIRING
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH REAR MOUNTED ENGINES. THE 12-VOLT POWER SUPPLY CABLE(S) MAY BE CHAFFED BY HOSES, HARNESSES, FRAME COMPONENTS, OR CLAMPS.
Remedy: DEALERS WILL REMOVE AND INSPECT THE 12-VOLT POWER CABLE(S) FROM THE BATTERY TO THE STARTER AND, IF NECESSARY, WILL REPLACE THE CABLES. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BLUE BIRD AT 1-912-822-2242.
5,631 vehicles affected
SERVICE BRAKES, AIR:ANTILOCK
VEHICLE DESCRIPTION: TRANSIT AND SCHOOL BUSES EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." AN INTERNAL DIAGNOSTIC SYSTEM IN THE ABS MAY NOT DETECT AN EXTREME WHEEL SPEED SENSOR AIR GAP. SUCH A CONDITION COULD POSSIBLY OCCUR DURING (1) ORIGINAL ASSEMBLY OR (2) SUBSEQUENT WHEEL END SERVICE.
Remedy: THE ABS ECU WILL BE REMOVED AND REPLACED OR THE ECU WILL BE REPROGRAMMED.
1,269 vehicles affected
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH ELECTRONIC ENGINES AND FELSTED ELECTRONIC ACCELERATOR PEDALS. THE RETURN SPRINGS CAN BREAK ON THE ACCELERATOR PEDALS THAT ARE EQUIPPED WITH STAINLESS STEEL OR ELECTROPLATED MUSIC WIRE RETURN SPRINGS.
Remedy: REPLACEMENT ACCELERATOR PEDALS EQUIPPED WITH RETURN SPRINGS MANUFACTURED OF MUSIC WIRE WITH ONE ADDITIONAL COIL ON EACH SPRING AND WITH AN ORGANIC COATING, ELIMINATING ELECTROPLATING WILL BE INSTALLED.
6,914 vehicles affected
VISIBILITY:WINDSHIELD
VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH TRANSIT SLIDING PUSHOUT WINDOWS. POTENTIAL STICKING AND/OR BINDING OF THE PUSHOUT WINDOW INNER FRAME WITHIN THE OUTER FRAME RESULTS IN OPENING FORCES EXCEEDING THE REQUIREMENTS OF FMVSS NO. 217, "BUS WINDOW RETENTION AND RELEASE."
Remedy: OWNERS WILL BE PROVIDED WITH STEP-BY-STEP PROCEDURES FOR MODIFYING THE TRANSIT SLIDING PUSHOUT WINDOWS TO CONFORM THE FMVSS 217 REQUIREMENTS.
2,088 vehicles affected