2010 AUTOCAR WX Recalls, Complaints & Safety

PARKING BRAKE

Defect Description

Autocar, LLC (Autocar) is recalling certain 2012-2016 Xpert, 2010-2020 Xspotter, 2008-2020 Xpeditor, 2008-2010 WXLL and WX vehicles. A worn parking brake control valve can leak air into the vent line, creating excessive back pressure and causing the parking brake to release unexpectedly.

Consequence

The unexpected release of the parking brake may allow the vehicle to rollaway, increasing the risk of a crash.

Remedy

Dealers will remove the vent line and fitting from the valve, free of charge. Owner notification letters were mailed March 23, 2023. Owners may contact Autocar customer service at 1-888-218-3611. Autocar's number for this recall is ACX-2023 ACTT-2301.

11,353 vehicles affected

Manufacturer: Autocar, LLC

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

Autocar, LLC (Autocar) is recalling certain model year 2008-2014 ACX, WX, and WXLL vehicles manufactured July 30, 2007, through February 10, 2014, and equipped with certain Cummins Westport Model ISL G or ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions... Read more

Consequence

The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.

Remedy

Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Owners may contact Autocar at 1-765-489-5499 or Cummins Inc. at 1-800-343-7357. Autocar's number for this reca... Read more

4,192 vehicles affected

Manufacturer: Autocar, LLC

SERVICE BRAKES, AIR

Defect Description

Autocar, LLC is recalling certain model year 2005-2013 ACX, WX, and WXLL trucks built November 16, 2004, through September 10, 2012. On the affected vehicles, the air brake systems were built without the required air tank drain valve. Therefore, these vehicles fail to conform to the requirements o... Read more

Consequence

Air tanks with valves omitted will not drain if moisture is introduced into the tank, potentially reducing air capacity in the air brake system, which could cause a reduction in brake performance and equipment durability, thus increasing the risk of a crash.

Remedy

Autocar will notify owners, and dealers will repair the vehicles free of charge. The recall began on June 27, 2013. Owners may contact Autocar at 1-765-489-5499. Autocar's recall campaign number is A-1302.

82 vehicles affected

Manufacturer: Autocar, LLC

No complaints found for this vehicle.

Technical Service Bulletins — 2010 AUTOCAR WX

4 manufacturer communications from 2 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE (PWS)	2
350000 EQUIPMENT	1
356000 EQUIPMENT ADAPTIVE/MOBILITY	1

350000 EQUIPMENT

AUTOCAR: VEHICLES WITH FIVE PIECE FRONT ENGINE CROSS MEMBERS HAVE SIDE BRACKET FAILURES AND INFORMATION IS PROVIDED FOR REPLACEMENT OF BRACKETS THAT FAILED DURING HEAVY DUTY OPERATIONS. MODELS 2007-2010 WX, WXR XPEDITORS.

356000 EQUIPMENT ADAPTIVE/MOBILITY

AUTOCAR: VEHICLES WITH FIVE PIECE FRONT ENGINE CROSS MEMBERS HAVE SIDE BRACKET FAILURES AND INFORMATION IS PROVIDED FOR REPLACEMENT OF BRACKETS THAT FAILED DURING HEAVY DUTY OPERATIONS. MODELS 2007-2010 WX, WXR XPEDITORS.

060000 ENGINE (PWS)

AUTOCAR: VEHICLES WITH FIVE PIECE FRONT ENGINE CROSS MEMBERS HAVE SIDE BRACKET FAILURES AND INFORMATION IS PROVIDED FOR REPLACEMENT OF BRACKETS THAT FAILED DURING HEAVY DUTY OPERATIONS. MODELS 2007-2010 WX, WXR XPEDITORS.

060000 ENGINE (PWS)

AUTOCAR: THE FIVE PIECED FRONT ENGINE CROSS MEMBERS SIDE BRACKETS EXPERIENCED SIDE BRACKET FAILURES AFTER EXTENDED PERIOD OF HEAVY DUTY OPERATION. MODELS 2007-2010 WX, WXR XPEDITORS. *PE

NHTSA Safety Investigations — AUTOCAR WX

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 2008

Vehicle Roll Away

On April 1, 2020, following information received from the Office of Defects Investigation (ODI) network of fleet contacts, ODI opened PE20-003 to investigate reports of vehicle roll away in certain model year (MY) 2008-2020 Autocar and Mack refuse trucks equipped with certain Bendix PP-1 push-pull p... neumatic park brake control valves with a pipe-away exhaust configuration. Prior to ODI’s investigation,[KK(1] Bendix Commercial Vehicle Systems LLC (Bendix), the subject component manufacturer, published two related technical service bulletins (TSBs): Bendix Push-Pull Type Control Valves Service Data SD-03-3611 Rev. 007 (2019-03) and Bendix PP-1 & PP-8 Park Control Valve Wear and Replacement Notice Technical Bulletin TCH-003-056 (2019-11-20). ODI sent Information Request (IR) letters to motor vehicle manufacturers Autocar LLC (Autocar) and Volvo Trucks North America/Mack Trucks, Inc. (Volvo/Mack) and motor vehicle equipment manufacturer Bendix. IR response data from all three manufacturers was analyzed and cross-referenced to gain further understanding. To date, ODI is aware of 5 vehicle roll-away incidents related to the alleged defect condition in the subject vehicles equipped with the subject components, resulting in 4 crashes and 1 injury. On December 9, 2021, Volvo/Mack notified the agency of a safety recall (21V953) to address a safety defect in certain MY 2008-2019 TerraPro (MRU) and MY 2019-2022 TerraPro (TE) trucks originally equipped with the subject components. [KK(2] On January 1, 2023, Autocar notified the agency of a safety recall (23V023) to address a safety defect in certain MY 2008-2020 ACX (Xpeditor), MY 2012-2020 ACMD (Xpert), MY 2010-2020 ACTT (Xspotter), MY 2008-2010 WX and MY 2008-2010 WXLL trucks. Volvo/Mack and Autocar's recall remedies involve removing the vent line fitting threaded into the exhaust port of the subject PP-1 valve. [VD(3] Both Autocar and Mack have stopped equipping new refuse trucks with park control valves using the exhaust pipe-away configuration. After discussions between ODI and Bendix concerning ways to prevent new PP-1 valves from being sold and installed with a potential for the exhaust to become restricted, Bendix will take the following actions: 1) issue a letter to all original equipment (OE) customers with important safety information warning them about the safety risk of attaching plumbing to the exhaust port when the subject component is used as a park control valve; and 2) affix a warning label on all aftermarket parts warning not to install pipe-away exhaust port plumbing. In view of the recalls being conducted by Volvo/Mack and Autocar, and the actions taken by Bendix, ODI has closed this Preliminary Evaluation. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist in equipment or other model or MY vehicles that have not been recalled. The agency reserves the right to take further action if warranted.Read more

AUTOCAR WX — All Years Overview

Complete safety history for the AUTOCAR WX across all model years (2002–2014).

59 Total Recalls

1 Total Complaints

1 Investigations

1 Reported Crashes

0 Reported Fires

0 Reported Deaths

AUTOCAR WX — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2014	1	0	View
2013	2	0	View
2012	2	0	View
2011	2	0	View
2010 (current)	3	0
2009	6	0	View
2008	10	0	View
2007	7	0	View
2006	4	0	View
2005	6	0	View
2004	9	1	View
2003	4	0	View
2002	3	0	View

Other AUTOCAR Models

Model	Recalls	Complaints
XPEDITOR	457	7	View
LEGEND	355	0	View
XSPOTTER	114	0	View
WXLL	61	1	View
AUTOCAR	61	2	View
ACX	42	2	View
XPERT	38	0	View
WXR	31	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2010 AUTOCAR WX

Technical Service Bulletins — 2010 AUTOCAR WX

Most Affected Components

NHTSA Safety Investigations — AUTOCAR WX

AUTOCAR WX — All Years Overview

AUTOCAR WX — Year by Year

Other AUTOCAR Models