2010 AUTOCAR ACX Recalls, Complaints & Safety

ENGINE AND ENGINE COOLING:ENGINE

Defect Description

Autocar, LLC (Autocar) is recalling certain model year 2008-2014 ACX, WX, and WXLL vehicles manufactured July 30, 2007, through February 10, 2014, and equipped with certain Cummins Westport Model ISL G or ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions... Read more

Consequence

The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.

Remedy

Cummins Inc. and Cummins Wesport Inc. will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Owners may contact Autocar at 1-765-489-5499 or Cummins Inc. at 1-800-343-7357. Autocar's number for this reca... Read more

4,192 vehicles affected

Manufacturer: Autocar, LLC

SERVICE BRAKES, AIR

Defect Description

Autocar, LLC is recalling certain model year 2005-2013 ACX, WX, and WXLL trucks built November 16, 2004, through September 10, 2012. On the affected vehicles, the air brake systems were built without the required air tank drain valve. Therefore, these vehicles fail to conform to the requirements o... Read more

Consequence

Air tanks with valves omitted will not drain if moisture is introduced into the tank, potentially reducing air capacity in the air brake system, which could cause a reduction in brake performance and equipment durability, thus increasing the risk of a crash.

Remedy

Autocar will notify owners, and dealers will repair the vehicles free of charge. The recall began on June 27, 2013. Owners may contact Autocar at 1-765-489-5499. Autocar's recall campaign number is A-1302.

82 vehicles affected

Manufacturer: Autocar, LLC

No complaints found for this vehicle.

NHTSA Safety Investigations — AUTOCAR ACX

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE — Closed — Model Year: 2014

CNG Fuel Container Burst During A Fire

On January 27, 2015 in Indianapolis, Indiana, a model year 2014 Autocar ACX / Heil Half/Pack Freedom refuse collection truck caught fire and experienced a catastrophic CNG fuel container burst. Office of Defects Investigation (ODI) personnel conducted a field examination of the incident vehicle, an ... exemplar vehicle and the incident scene, and subsequently sent information request letters to Autocar LLC, The Heil Company, Agility Fuel Systems Inc. and Hexagon Lincoln Inc.After a review of all available information, it appears that this was an isolated incident. The vehicle fire originated in the refuse storage bay and was caused by a hot load, which is a quantity of solid waste that catches fire, smolders or spontaneously combusts as a result of incompatible waste materials mixing together. Drivers are trained to eject the hot load in an empty lot, when feasible. In this instance, the driver did not eject the hot load. After expending a hand-held fire extinguisher into the hopper area of the refuse storage bay, the driver retreated from the vehicle. Fire fighters arrived at the incident scene within minutes. During firefighting efforts, two CNG fuel containers burst, sending materials into the air and across a large debris field.One fire fighter was struck in the head and shoulder area by falling debris and sustained minor injury. He was examined at the scene and did not require transport but was later transported post-incident to a medical clinic where he was diagnosed with a muscle strain to his left shoulder. Multiple structures suffered property damage and the subject vehicle was a total loss. The fire was brought under control and was extinguished 1 hour and 38 minutes after fire fighters first arrived.Post-incident analysis, including a review of the fire department?s after action report, identified several contributing factors. The truck driver was unable or unwilling to eject the hot load. Fire fighters initially misidentified the subject fuel system as liquefied petroleum gas (LPG) and believed cooling was necessary to prevent a boiling liquid expanding vapor explosion (BLEVE). Fire fighters were unfamiliar with natural gas vehicle fires, associated risks and best practices for firefighting techniques and tactics. The CNG fuel containers were located directly above the origin of the fire and were impinged by flame, thus weakening their structural integrity. The CNG fuel containers were mounted transversely with thermally-activated pressure relief devices (PRDs) mounted in each end, away from where the fire was localized. The CNG fuel containers were of Type 4 construction and thus were not good conductors of heat away from where the fire was localized and towards the PRDs. The CNG fuel containers were covered by a steel enclosure with small, circular openings providing access to the manual fuel container isolation valves equipped with integrated PRDs. Water applied to the fire likely cooled the PRDs but did not reach the area of the fuel containers where the fire was localized, thus keeping the PRDs below the activation temperature threshold as the fire progressed.ODI is aware of at least one other incident in which a substantially similar CNG refuse truck caught fire due to a hot load. In that case, the PRDs activated as intended. There was no fire suppression effort prior to the PRDs activating.The National Fire Protection Association (NFPA) Alternative Fuel Vehicle (AFV) Safety Training project (http://www.evsafetytraining.org) provides training for first responders who face emergency situations involving motor vehicles.NFPA training advises that attempts to extinguish a significant CNG fire could preventRead more

AUTOCAR ACX — All Years Overview

Complete safety history for the AUTOCAR ACX across all model years (2005–2015).

41 Total Recalls

2 Total Complaints

1 Investigations

0 Reported Crashes

0 Reported Fires

0 Reported Deaths

AUTOCAR ACX — Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2015	1	0	View
2014	2	2	View
2013	5	0	View
2012	6	0	View
2011	4	0	View
2010 (current)	2	0
2009	8	0	View
2008	10	0	View
2007	1	0	View
2006	1	0	View
2005	1	0	View

Other AUTOCAR Models

Model	Recalls	Complaints
XPEDITOR	457	7	View
LEGEND	355	0	View
XSPOTTER	114	0	View
WX	62	1	View
WXLL	61	1	View
AUTOCAR	61	2	View
XPERT	38	0	View
WXR	31	0	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2010 AUTOCAR ACX

NHTSA Safety Investigations — AUTOCAR ACX

AUTOCAR ACX — All Years Overview

AUTOCAR ACX — Year by Year

Other AUTOCAR Models