PIPER PA-36-285
Galena, KS — May 14, 2013
Event Information
| Date | May 14, 2013 |
| Event Type | ACC |
| NTSB Number | CEN13LA280 |
| Event ID | 20130515X63932 |
| Location | Galena, KS |
| Country | USA |
| Coordinates | 37.06889, -94.66472 |
| Highest Injury | MINR |
Aircraft
| Make | PIPER |
| Model | PA-36-285 |
| Category | AIR |
| FAR Part | 137 |
| Aircraft Damage | SUBS |
Conditions
| Light Condition | DAYL |
| Weather | VMC |
Injuries
| Fatal | 0 |
| Serious | 0 |
| Minor | 1 |
| None | 0 |
| Total Injured | 1 |
Event Location
Probable Cause
The loss of engine power due to improper maintenance by an unknown individual that led to the degradation and deterioration of the No. 2 piston, which was undetected because of overdue maintenance.
Full Narrative
On May 14, 2013, about 1050 central daylight time, a Piper PA-36-285 airplane, N57719, conducted a forced landing near Galena, Kansas. The commercial pilot sustained minor injuries. The airplane sustained substantial damage to the fuselage. The airplane was registered to and operated by Four States Sky Ag Inc. under the provisions of 14 Code of Federal Regulations Part 137 as an agricultural application flight. Visual meteorological conditions prevailed for the flight, which operated without a flight plan. The local flight departed the Swalley Airpark (78KS), Baxter Springs, Kansas, about 1045.
According to a statement provided by the pilot to the responding Federal Aviation Administration (FAA) inspectors, the airplane had departed 78KS and he had just began to level off when he noticed a decrease in oil pressure. The engine experienced a total loss of power before the pilot could set up for a forced landing. The airplane collided with terrain in an open field.
An examination of the engine conducted by the FAA inspectors revealed that the number 2 cylinder piston had failed. A large amount of aluminum particles were observed in the oil and the oil filter. Each spark plug had two spark plug washers. Maintenance records determined that the recommended oil change time had been exceeded. The mechanic that performed the last annual inspection stated he had not installed the extra spark plug washers and was not aware of their presence on the engine. It could not be determined who installed the additional spark plug washers.
About This NTSB Record
This aviation event was investigated by the National Transportation Safety Board (NTSB). NTSB investigates all U.S. civil aviation accidents to determine probable cause and issue safety recommendations to prevent future accidents.