2015 VOLKSWAGEN GOLF SPORTWAGEN Recalls, Complaints & Safety

The contact owns a 2015 Volkswagen Golf Sportwagen. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. The vehicle was taken to an independent mechanic, who determined that the camshaft module and variable valve timing (VVT) gears needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,900.

PTC auxiliary heater core connection point failure . It was reported that the wrong type of metal was used for the main electrical connection point for this part causing significant over heating further leading to melting and burning plastic. This then introduces potentially dangerous fumes into the vehicle cabin via the HVAC system. If unaddressed this would likely cause fire damage. The problem has been reproduced by multiple vehicle owners and happens during cold conditions as it supplies heat to the cabin prior to the engine hitting optimal operating temperatures. No warning messages or codes are thrown as a result of this issue. It is a hazard and could cause harm to operators of the vehicles affected.

PTC auxiliary heater core failure causing near fire event. The failure causes the main power input to melt causing a burning plastic smell and smoke. The problem has been reproduced by multiple vehicle owners and happens during cold conditions as it supplies heat to the cabin prior to the engine hitting optimal operating temperatures. No warning messages or codes are thrown as a result of this issue. It is a hazard and could cause harm to operators of the vehicles affected.

While operating my 2015 Volkswagen Golf SportWagen, the ignition key becomes stuck in the steering column and does not release as designed. This appears related to known steering column defects and recalls (NHTSA Campaign 18V464000 / 19V615000). My dealer states my VIN is not covered, but this is a known issue for my model year. This creates a safety hazard as it may prevent the vehicle from being shut off or parked securely.

Clock spring failure at 10 years 1400000 miles causing airbag light to come on. Airbag in steering wheel presumably doesn't work properly. The car has been looked at by a dealership who quickly confirmed clock spring failure, but falls outside of VW warranty replacement for this vehicle. There was no warning prior to failure of the clock spring.

Engine fire due to exhaust equipment malfunction, if it was not attended to or noticed quickly it could lead to loss of control of vehicle, causing injury or death to occupants or other motorists. This occurred after having a recall completed.

Fire

Engine fire due to exhaust equipment malfunction, if it was not attended to or noticed quickly it could lead to loss of control of vehicle, causing injury or death to occupants or other motorists. This occurred after having a recall completed.

Fire

In the last year, my car has experienced multiple instances of the Diesel Particulate Filter (DPF) warning light, check engine light, and a flashing glow plug light on the dashboard. Despite multiple visits and repairs at Sheehy Volkswagen of Springfield, these issues persist, particularly in sub-freezing temperatures. Upon independent inspection of the engine compartment, I found multiple exposed wires, broken wires, and poorly repaired broken wires. The most significant concerns are as follows: Repeated DPF Issues: Over the last three years, the DPF warning and related issues have recurred each winter. Initial attempts to rectify the issue included a DPF regeneration procedure, which temporarily cleared the fault codes but did not address the underlying problem. The DPF was finally replaced in mid-2024, yet the same problems manifested with a brand new component just months later. Extended Repair Time: Sheehy Volkswagen of Springfield had my vehicle for a total of six months (Dec-23 to May-24), during which they were unable to diagnose or fix the problem despite escalating the case to Volkswagen HQ (Business Case Numbers: BT1167682 and BT1177805). This delay is unacceptable. Poor Customer Service: Throughout this period, customer service was unsatisfactory. I was frequently passed between customer service representatives, none of whom were sufficiently informed about the ongoing repairs. Incorrect Diagnosis and Repairs: After replacing the DPF, ECM, temperature sensor, and wiring harnesses, the issue persisted. It was eventually suggested that a wiring problem might be to blame, yet no comprehensive solution was provided. Incompetence and Safety Concerns: Upon retrieving my vehicle, I noticed white smoke emanating from the engine compartment, which I discovered was due to the coolant reservoir being overfilled. Additionally, an independent inspection revealed exposed and poorly repaired wires, posing a serious safety hazard.

Supplementary auxiliary electric heater ground connector melted and could have caused a fire. Original part #5Q0963235B. A recall (17V-62) for this part was active for various Audi and VW models but for whatever reason my car was not included. Car was brought to Valenti VW on 3/1/24 for inspection after burning smell was emitting from vents. Dealer was unable to locate the source of the problem. Discovered the defective heater myself during fall season when heat was necessary. Please see attached photos. I feel I am entitled to reimbursement for the costs associated with getting this dangerous situation repaired.

The contact's partner owns a 2015 Volkswagen Golf Sportwagen. The contact stated that while driving at approximately 30 MPH, he observed that the air bag warning light was illuminated. The contact also heard an abnormal soft clicking sound in the cabin while turning the steering wheel to the left or to the right. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 15V483000 (Air Bags); however, the VIN was not included. The failure mileage was unknown.

The emissions modification calibration by Volkswagen causes the coolant to be exposed to elevated temperatures due to higher exhaust gas recirculation (EGR) use to control emissions. These elevated higher temperatures degrade the coolant faster than designed and lead to precipitates falling out of solution in the factory filled G13 coolant. This causes buildup and deposits to form throughout the cooling system, particularly in the heater core which can block proper coolant flow & lead to coolant system failure, specifically of hoses associated with the heater core. When these fail the engine can over heat, and stop which causes loss of steering, propulsion and braking abilities. There is a similar problem on 2012 models with the TDI engine, which has been addressed but the 2015 models are being stranded on the roads creating a safety hazard to the drivers of the vehicles and other motorists on the road.

Both rear coil springs failed. One broke at the top and bottom and one broke at the bottom. The incident date is the date that it was found. I don’t know how long they have been this way.

TDI Auxiliary heater (PTC) brown ground wire melting and causing a terrible plastic burning smell inside cabin. Wire likely will cause a fire. Many reports of this happening to other individuals on the Internet forum TDIforum.com

In 2019, VW issue a recall (37M2) Shift Lever Micro Switch for failing resulting in noncompliant Theft Protection and Rollaway Prevention. The recall was issued for 2015-2019 Golf and 2017-2019 Golf Sportwagen, HOWEVER, in Canada, the recall included 2015-2019 Golf Sportwagen. I have a 2015 Golf Sportwagen (USA) with a failing Shift Lever Micro Switch. There is no different between the Canadian and US Model for this part. I believe that VAG should include 2015 models in the recall.

I earlier made a report about my issue- but since then I discovered that BOTH rear springs were broken - multiple times- Repair was completed and I’ve attached photos of old parts Additional research shows that VW has an active recall campaign open on rear springs for the 2013 and 2014 Sportwagen and some 2015, but not the 2015 that I own….

The contact owns a 2015 Volkswagen Golf Sportwagen. The contact stated that while her son was stopped at a gas station, he shifted the gear shift lever to park and the hazard warning lights illuminated; however, none of the four door latches would lock as needed. The contact took the vehicle to the local dealer, where it was diagnosed that the gear shifter assembly needed to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer had been informed of the failure. The failure mileage was approximately 140,000.

The contact owns a 2015 Volkswagen Golf Sportwagen. The contact stated while driving approximately 35 MPH, the vehicle started to run rough. The contact shifted the vehicle into park(P) when she reached her destination and smelled an odor of gasoline. The contact observed that gasoline was leaking out of the fuel tank under the wheel well. The contact stated that the driveway was wet from the gasoline. The contact stated no warning light was illuminated. The contact had attempted earlier in the day to fuel the vehicle and was unable to fill the fuel tank. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the fuel tank, fuel pump seal, fuel tank hardware, passenger’s side rear trailing arm bolts, heat shield nuts, purge valve, and evap canister needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact related the failure to a recall repair performed on the vehicle under NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine and Engine Cooling). The failure mileage was approximately 68,000.

Broken rear suspension coil spring 08/2023- found part laying on the ground under my car-

As I was leaving work yesterday, I noticed that the Air Bag indicator was showing on the dash. It was not showing when I drove it to work. I also noticed that my Cruise Control is no longer working.

Ever since I purchased the car new, the backup camera goes blank above 5 mph. It is a major annoyance and safety issue to suddenly have to change my rear viewing options. When cold, the car fast idles at 6 or more mph in reverse with the camera offering no assistance. Complaints to the dealership yielded the answer that the factory had no fix. Now I see Honda recall 23V046 about the same condition that I'm experiencing and that appropriately Honda is fixing their problem. Can VW be invited to fix my problem (its problem)? I understand that my son's Toyota camera blanks above 30 mph, more than reasonable.

I backed up my car and upon turning the wheel I heard some crackling from the steering wheel. The airbag and transmission error lights came on and I lost functionality of all the buttons on the steering wheel and the horn. Based on research, this is a clock spring that has been recalled for other model years.

My vehicle has been smoking inside cab and through vent system. After troubleshooting, discovered the brown ground wire and surrounding plastic of the PTC auxiliary heater has been burning. VW said the have no inventory for replacement parts and no date getting these in. I asked if there was a recall for this issue and they said there was not. Once the issue was located, I discovered a recall for the exact same issue on Audi vehicles. I am fortunate a fire did not ignite next to my leg while driving, however I did breath in a large amount of the smoke as the issue intermittently occured and the issue wasn't easily discovered. I am very frustrated VW would allow a fire hazzard to exist next to foot pedals. This should have been fixed long ago with a recall instead of forcing me and my family to breathe in smoke and risk a much larger fire. There were no warning lights and a dealer has not inspected the issue. However, brown cable housing is burnt/blackened.

A defect that meets the definition of a nonconformity in Washington State, and that is covered under warranty, caused the vehicle to stall while driving and caused the vehicle to not accelerate when the accelerator was pressed. My safety was put at risk when this happened on a 50 mph road because vehicles behind me expected my vehicle in front of them to accelerate in a predictable way with the flow of traffic. Another time, a stall happened as I turned onto a highway. I had come to a stop, waited for the traffic light, and then turned right and pressed the accelerator as I normally would to get up to 50 mph. A flashing glow plug light came on, and the car immediately had zero propulsion, and so I turned the steering wheel to roll to the side of the road and turned on my hazard lights. I was fortunate that I was not rear-ended. On another occasion, I came off of the interstate as normal, but when I tried to drive over the overpass at a slight incline, the vehicle was unable to accelerate to 20 mph, and would only go about 5 mph no matter how much the accelerator was pressed. This happened multiple times, but not all of the time, and it was unpredictable when it would happen. It was dangerous to me because I could not time traffic circles with confidence that I would be able to press the accelerator and get up to speed without being struck from the left, or turn out onto busy roads with confidence I wouldn't be t-boned, or merge with traffic on the highway. The mileage on the vehicle at the first attempt to diagnose/repair the defect was 63935 on 10/11/2019 when a VW dealership diagnosed and replaced two glow plugs under warranty. Several more times it was warr. repaired. In November 2021, after the vehicle was repaired and failed on the dealership test drive, an engineer from Volkswagen inspected the vehicle, it was further repaired and released to me. A couple of months later, the vehicle stalled on a highway and a flashing glow plug light came on.

The screen which is for the radio and back up camera has started to "flicker" This looks to be a common problem people are fixing it by having the head unit replaced but clearly it's a safety issue since the backup camera is hard to use. This is a dieselgate car so it wasn't purchased new until 2017 and it seems crazy for this to be happening when the car has only been on the road for 5 years. https://www.youtube.com/watch?v=MgRQp6E16Rc

The clock spring fails. Causing the airbag light to illuminate. The car is a 2015 and the first clock spring failed in January 2021, with around 155,00 miles (estimate). Second one failed this week with 162,000 miles. I know the car is old, but the part that gets power to the airbag should last more than 2 years. Volkswagen extended the warranty of the part, but we were outside for both repairs now. The dealer tells me this part is fixed on a regular basis to the point he was surprised he was able to get the part. I feel like for the part that supplies power to the airbag, an extended warranty is not sufficient. (For the information below, I was in a parking lot when the clock spring broke, so speed was irrelevant, np accident occurred)

I did a left-U turn- heard a loud sound, and then all the electrical things on my steering wheel failed, like horn, air bag, and controls. The failed airbag light is on, and it has other warning lights as well. I am now not protected in a crash, nor can I use my horn. I believe from a bit of research that my car has what I think is the same clockspring defect that VW has had in a TON of their vehicles- mine has failed- but does not seem to fall into a safety recall. Why is that? This seems to be a serious safety problem they have had- and I believe it should be covered by the manufacturer.

-the failed part is available for inspection -fire hazard, shock hazard and toxic fume hazard - Audi has issued a recall for the same part on their vehicles https://static.nhtsa.gov/odi/rcl/2017/RCONL-17V622-5223.pdf -there were no warning lamps or other symptoms Description of the Issue: The ground terminal on the Auxiliary Heater also sometimes known as the Supplmentary PTC Heater (P/N 5Q0.963.235)began to corrode which caused it to get so hot that the insulation melted, the heater housing melted and live wires became loose in the passenger compartment. The burning plastic also created terrible fumes inside of the car. Here is a picture of a live wire that has melted the housing and come loose. https://forums.tdiclub.com/index.php?media/aux-heater-1-jpg.140387/ Here is the melted housing where the terminal should normally be. https://forums.tdiclub.com/index.php?media/aux-heater-2-jpg.140386/ This seems to be a common issue in these vehicles and is well known to the car enthusiast community. Here are some links to forums posts which document this issue https://forums.tdiclub.com/index.php?threads/burning-smell-from-heat.513304/ https://www.youtube.com/watch?v=dnNW-onPK9M&ab_channel=mr-fix https://www.seatcupra.net/forums/threads/ptc-heater-burning-smell.459372/

On starting the car the system monitoring safety features shows first a fault detected in the ABS, then the air bag, then tire pressure and sometimes indicates that the key battery should be replaced. It also turns off the idle control that raises the rpm when the brake peddle is released when stopped, and defeats the roll back when stopped on a hill. This started over six months ago and was intermittent, often turning off (no symbols lighted) and idle controls restored after a few minutes. About 5 weeks ago it became constant. In fact, the tire pressures are within the specifications, the key battery is new and measures 3V as expected. The status of the ABS and airbag cannot be checked by the consumer. This problem was reported to the Dealer, Flow Companies of Asheville, who found that the left rear speed sensor was faulty, but did not have the part. Replacement is now scheduled for October 3. This replacement hopefully will restore the monitoring system. My concern is that a monitoring system designed such that a fault in one system triggers false positive warnings in other safety related functions is dangerous. That it also affects the idle controls should not be acceptable. I have reviewed the TDI Forum and Golf Forums and found that this lighting up of multiple faults is not a rare occurrence. A faulty ABS speed sensor is sometimes the cause, other times is seems that moisture is penetrating a connector or cable. In any case a safety monitoring system providing false information should not be tolerated. I also drive a 2003 VW TDI Jetta, it also monitors the air bag, ABS and other systems, but a fault in one does not trigger a cascade of false positives.

After turning on the vehicle, I turned the steering wheel and heard a click, then the airbag malfunction warning light came on immediately. Horn and all steering wheel buttons have stopped working (radio control, cruise control etc). and airbag warning light remains on. This seems obviously to be the broken clock spring problem. Vehicle has about 105,000 miles on it. I am not sure if the steering area was ever serviced during a previous safety recall, but I have never had any service on the steering wheel or issues in that area.

steering wheel clock spring malfunction, it is broke

The contact owns a 2015 Volkswagen Golf Sportwagen. The contact stated that upon parking the vehicle, the tire pressure warning light was illuminated. The contact stated that the rear end of the vehicle was very low. Additionally, her children informed her that their buttocks hurt whenever the vehicle would hit a bump while driving. The contact was able to continue to drive the vehicle. The vehicle was taken to the dealer who diagnosed the failure as a bilateral rear coil spring fracture. The manufacturer was notified of the failure and informed the contact that they could not assist because the VIN was not included in NHTSA Campaign Number: 19V188000 (Suspension). The vehicle was not repaired. The failure mileage was approximately 60,000.

Cruise control randomly disengaged without the brake pedal or cancel cruise button being depressed. Has happened several times in the last 1.5 years of car ownership. No hazardous road conditions were present, car did not slip and was not accelerating quickly. Sudden unexpected changes in speed, such as those caused by cruise disengaging suddenly, are hazardous. Problem has not been inspected or reproduced by a dealer. No warning lights appeared.

We’re having the same shift lever micro switch problem that has already been recalled on tons of VW’s in 2019. The car is a rollaway risk and refuses to start as a result

I HAVE A 2015 VW GOLF SPORTWAGEN WITH ABOUT 47K MILES. 9 MONTHS AGO I HAD MY CLOCK SPRING GO BAD IN MY VEHICLE, WHICH RENDERED MY AIRBAG TO BE DISABLED. THE REPLACEMENT WAS COVERED UNDER THE 3YR/36K MIKE WARRANTY THAT COMES WITH THE CAR NEW (THIS IS A TDI MODEL, SO THE IN-SERVICE DATE IS MAY 2018 -CAR HAS APPROX. 32K MILES ON IT AT THE TIME OF REPAIR). TODAY (MARCH 2021), I HAD MY CLOCK SPRING GO BAD AGAIN, WHICH DISABLED MY AIRBAG, AGAIN. VW TELLS ME THAT MY MODEL SPECIFICALLY ISN'T COVERED UNDER AN EXISTING EXTENDED WARRANTY THAT HAS BEEN ISSUED TO RESOLVE THIS PROBLEM. THIS IS A WIDESPREAD PROBLEM WITH ALMOST ALL MODELS OF VW FROM 2010-2018 AND THE NHTSA IS WELL AWARE. MY MODEL OF CLOCK SPRING, ALTHOUGH USED IN MANY OF THESE OTHER MODELS THAT ARE COVERAGE BY THIS EXTENDED WARRANTY, IS NOT COVERED BY VW. I'M NOT DRIVING WITH NO AIRBAGS UNTIL I CAN AFFORD TO REPLACE OUT OF POCKET. THIS IS A KNOWN ISSUE AND SHOULD COVER ALL MODELS WHICH USE THAT SAME CLOCK SPRING THAT IS THE PROBLEM.

VW INSTALLED A RADIO SPEC FOR ANOTHER MODEL CAR IN MY VEHICLE THE REPLACEMENT PART IS A NEW PART NUMBER THIS PROBLEM CREATED A ROLLING SCREEN ON MY DISPLAY VERY DISTRACTING WHILE DRIVING I ASKED VW COSTUMER CARE TO REPLACE THE WRONG PART INSTALLED AT THERE FACTORY VW REFUSED TO COVER THE COST ,THIS IS A SAFETY ISSUE WHEN YOUR MAIN DISPLAY IN THE CAR IS FLASHING AND THE SCREEN IS ROLLING AND WILL LEAD TO ACCIDENTS I BELIEVE VW SHOULD HAVE FIXED THIS AS A URGENT SAFETY MATTER THATS IT IS DISTRACTING THEIR DRIVERS

WHEN STATIONARY, DRIVER'S FRONT DOOR HANDLE STICKS OR JAMS, MAKING ENTRY OR EXIT DIFFICULT AT TIMES. WE HAVE HAD THIS REPAIRED AT THE DEALERSHIP BEFORE, BUT IS APPARENTLY REOCCURRING. THIS HINDERS ENTRY & EXIT AND COULD VERY WELL MAKE QUICK ENTRY OR EXIT MORE PROBLEMATIC IN URGENT OR EMERGENCY SITUATIONS. ONE SUCH URGENT SITUATION IS TRYING TO GET INTO OR OUT OF OUR VEHICLE WHEN PARKED ALONG A BUSY CITY STREET BEFORE TRAFFIC ARRIVES. I DON'T KNOW WHAT SPECIFIC PART IS INVOLVED, OUTSIDE THAT THE DOOR HANDLE APPEARS TO BE THE ISSUE. THIS APPEARS TO HAPPEN IN ANY WEATHER.