2022 TESLA MODEL 3

18 recalls, 1,506 complaints - 60 TSBs - 5/5 safety rating

EXTERIOR LIGHTING:HEADLIGHTS

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2017-2023 Model 3 and 2020-2023 Model Y vehicles. The headlight low beams may be too bright and exceed the maximum light output. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, ... Read more

Consequence

Headlight low beams that are too bright can reduce visibility for oncoming drivers, increasing the risk of a crash.

Remedy

The remedy is currently under development. Owner notification letters are expected to be mailed September 15, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-003.

20,349 vehicles affected

Manufacturer: Tesla, Inc.

BACK OVER PREVENTION:SOFTWARE

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2017, 2021-2023 Model 3, 2020-2023 Model Y, 2021-2023 Model S, and Model X vehicles operating software version 2026.8.6. The rearview camera image may be delayed when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requiremen... Read more

Consequence

A delayed rearview image reduces the driver's view behind the vehicle, increasing the risk of a crash.

Remedy

Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed July 3, 2026. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-26-00-001.

218,868 vehicles affected

Manufacturer: Tesla, Inc.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to co... Read more

Consequence

Driving with improperly inflated tires increases the risk of a crash.

Remedy

Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

696,281 vehicles affected

Manufacturer: Tesla, Inc.

LATCHES/LOCKS/LINKAGES:HOOD:LATCH

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Consequence

An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.

Remedy

Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.

1,849,638 vehicles affected

Manufacturer: Tesla, Inc.

SEAT BELTS:FRONT:WARNING LIGHT/DEVICES

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirem... Read more

Consequence

A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.

Remedy

Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.

125,233 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM:SOFTWARE

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Sta... Read more

Consequence

Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.

Remedy

Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.

6,557 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicle... Read more

Consequence

Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

Remedy

Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

2,193,869 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM:ADAS:DRIVER MONITORING:SOFTWARE

Defect Description

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope... Read more

Consequence

In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.

Remedy

Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.

2,031,220 vehicles affected

Manufacturer: Tesla, Inc.

STEERING:AUTOMATED/ADAPTIVE STEERING

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling s... Read more

Consequence

FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.

Remedy

Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.

362,758 vehicles affected

Manufacturer: Tesla, Inc.

SEAT BELTS:REAR/OTHER:ANCHORAGE

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3 vehicles. The second-row left seat belt buckle and second-row center seat belt anchor may have been incorrectly reassembled during vehicle service.

Consequence

An incorrectly reassembled seat belt anchor can impair the performance of the seat belt during a crash, increasing the risk of injury.

Remedy

Tesla Service will inspect and reassemble the seat belt anchors as necessary, free of charge. Owner notification letters were mailed December 20, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-20-004.

24,064 vehicles affected

Manufacturer: Tesla, Inc.

VISIBILITY:POWER WINDOW DEVICES AND CONTROLS

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehi... Read more

Consequence

A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.

Remedy

Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.

1,096,762 vehicles affected

Manufacturer: Tesla, Inc.

BACK OVER PREVENTION:DISPLAY FUNCTION

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S, Model X, and 2022 Model 3 and Model Y vehicles operating certain firmware releases. The infotainment central processing unit (CPU) may overheat during the preparation or process of fast-charging, causing the CPU to lag or restart.

Consequence

A lagging or restarting CPU may prevent the center screen from displaying the rearview camera image, gear selection, windshield visibility control settings, and warning lights, increasing the risk of a crash.

Remedy

Tesla will perform an over-the-air (OTA) software update that will improve CPU temperature management, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-009.

129,960 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2018-2022 Model 3 Performance vehicles. The unit of speed (mph or km/h) may fail to display on the speedometer while in Track Mode. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Control an... Read more

Consequence

The driver may not know how fast the vehicle is traveling without the mph or km/h unit display, increasing the risk of a crash.

Remedy

Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 17, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-008.

48,184 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM:SOFTWARE

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these veh... Read more

Consequence

Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

Remedy

Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer se... Read more

594,894 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM:SOFTWARE

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these veh... Read more

Consequence

Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.

Remedy

Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3... Read more

578,607 vehicles affected

Manufacturer: Tesla, Inc.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:AIR HANDLER/CHAMBER, DUCTS, AND VALVES

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these ve... Read more

Consequence

Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.

Remedy

Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.

26,681 vehicles affected

Manufacturer: Tesla, Inc.

ELECTRICAL SYSTEM:SOFTWARE

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Fede... Read more

Consequence

The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.

Remedy

817,143 vehicles affected

Manufacturer: Tesla, Inc.

STEERING:AUTOMATED/ADAPTIVE STEERING

Defect Description

Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first c... Read more

Consequence

Failing to stop at a stop sign can increase the risk of a crash.

Remedy

Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.

53,822 vehicles affected

Manufacturer: Tesla, Inc.

Complaint Statistics

1,506 total complaints 53 crashes 8 fires 45 injuries 1 deaths

Top Reported Components

Component	Complaints
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL	304
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING	248
SERVICE BRAKES	149
VEHICLE SPEED CONTROL	125
UNKNOWN OR OTHER	94
ENGINE	93
ELECTRICAL SYSTEM	75
FORWARD COLLISION AVOIDANCE: WARNINGS	72
STEERING	52
POWER TRAIN	45

Incident date: Aug 23, 2026

At approximately 32,916 miles, the powered trunk lift strut on my 2022 Tesla Model 3 separated from its mounting ball stud during normal use. There was no collision or external impact. When the strut separated, it struck the rear glass and caused the glass to break. Tesla inspected and repaired the ... Read more

Incident date: Aug 23, 2026

Incident date: Aug 4, 2026

My 2022 Tesla Model 3 Long Range has developed a failure of the Autopilot/ADAS computer. The AP computer remains installed in the vehicle and is available for inspection. The vehicle operated normally before software update 2026.26.6. Following the update, Driving Visualization and Autopilot began ... Read more

Incident date: Aug 4, 2026

Incident date: Aug 1, 2026

With its latest upgrade, 2026.20.6.11 with full self-driving V14 Light, Tesla no longer allows users to set a max speed. This is very dangerous, especially in school zones where the vehicle, with Full Self-Driving, consistently misreads the speed limit. There is no way to revert this "upgrade." Many... Read more

Incident date: Aug 25, 2026

The Tesla service center in San Antonio Texas installed new tires and a new wheel on my vehicle and one of the tires was installed inside out based on the manufacturer’s specifications. I’ve been driving this vehicle for about 4 months /5k miles with the risk of this tire malfunctioning and caus... Read more

Incident date: Aug 25, 2026

To Whom It May Concern, I am reporting what I believe is a foreseeable child-safety risk involving Tesla’s Toybox feature. Tesla allows parents to PIN-restrict Arcade, Theater, and the web browser, but Toybox remains accessible. Recently, I briefly went inside my home to use the bathroom, and my... Read more

Incident date: Aug 20, 2026

My 2022 Tesla Model 3 has experienced recurring intermittent loss/reduction of power steering assistance. The vehicle displays “Steering assist reduced – Steering may require increased effort.” The problem has occurred multiple times over a period of months and may disappear after the vehicle ... Read more

Incident date: Aug 9, 2026

the suspension lower lateral links bushings are wearing down without much usage. my car had 31k miles and the bushings already need to be replaced. this is very dangerous.

Incident date: Jul 27, 2026

I am the owner of a 2022 Tesla Model 3. The front control arms on this vehicle are defective as manufactured. From the factory, these components have demonstrated premature failure, abnormal noise, loosening, and/or separation risk that is not consistent with normal wear on a low-mileage vehicle of ... Read more

Incident date: Jul 27, 2026

Incident date: Aug 7, 2026

The contact owns a 2018 Ram 1500. The contact stated that while stopped and attempting to turn left, the steering wheel became firm, making it difficult to turn the steering wheel. The vehicle was turned off and restarted; however, the failure persisted. The vehicle was pulled over to the side of th... Read more

Incident date: Apr 7, 2026

The contact owns a 2024 Ram 1500. The contact stated that while driving at an undisclosed speed, after making a right turn, the front passenger's side wheel detached from the ball joint. The vehicle was uncontrollable. The vehicle crashed into a street sign. The passenger’s side of the vehicle the... Read more

Crash 1 injured

Incident date: Aug 1, 2026

I bought this truck from a reputable GM dealership 2.5 weeks before this happening occurred. Tires only had 50k miles on them when they were rated for 80k miles: the front driver side Ttire ruptured while on major hwy in texas. No signs of air loss and the road was clear of any debris. Steering star... Read more

Incident date: Aug 1, 2026

Incident date: Aug 7, 2026

The contact owns a 2023 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, there was an abnormal rattling sound coming from the moon roof. The contact stated that the abnormal sound was like the moon roof was detaching from the vehicle. The vehicle was taken to the dea... Read more

Incident date: Aug 4, 2026

Fuel Leak: I can smell heavy gas fumes inside the vehicle cabin. Fire Hazard: The vehicle is unsafe to drive due to an imminent risk of a fuel fire. Corporate Refusal: Kia Corporate refused to generate a case number and my local dealership refused to service the vehicle leaving a dangerous safety d... Read more

Incident date: Aug 1, 2026

The driver side rear coil spring broke abruptly on both the top and bottom leaving the majority of the spring mechanically unattached. The driver side rear shock also broke from the additional strain on it. With a complete loss of suspension on the rear driver side, as I hit bumps on the freeway, I ... Read more

Incident date: Apr 7, 2026

Cracked engine block due to coolant intrusion, which seems to be a known problem as engine blocks were redesigned for 2019 models. Could lead to overheating, engine damage, and even fires from my understanding. In Ford dealer service center at the moment, they confirmed diagnosis. White smoke from e... Read more

Incident date: Jun 5, 2026

2024 Audi Q8 e-tron, VIN [XXX], [XXX]. Vehicle has had four documented electrical/drive system malfunctions in 12 months, all tied to high heat. We regularly drive our [XXX] child in this vehicle and no longer feel safe doing so. XXX: Electrical system malfunction warning while driving. Taken to Au... Read more

Incident date: Jun 5, 2026

No incident but steering assisted reduced could cause an issue. Also the fix is to reset the computer by detaching the negative pole on the battery. This could be an issue due to the heat in the car someone could get burned.

Incident date: Jun 5, 2026

On XXX I was waiting at a light and the check engine light was blinking. When I started up, the car was very sluggish. It continued to be sluggish on my trip home - 5 miles. I brought it to Meineke [XXX] [XXX]. They ascertained that the engine was shot. They flushed out the oil in the engine and ... Read more

Incident date: Jan 29, 2026

The initial safety issue began with the rear-view camera going blank and the Uconnect 5 screen freezing while the vehicle was operating in reverse. My vehicle's service record indicates that Safety Recall 24V-436 / FCA Campaign 79B was marked as "Completed" in the FCA system on June 19, 2024—even... Read more

Incident date: Jan 29, 2026

Tesla software update 2026.20.6.11 v14 Lite NA-2025.44 removed manual speed control for Full Self-Driving. The driver can no longer set a maximum speed. The vehicle chooses its own speed and it is frequently wrong and dangerous. Curves are the worst failure. The car enters curves too fast. It accel... Read more

Incident date: Jul 31, 2026

So while I was driving my car going 60 on the highway it seemed to be having electrical issues all the lights on my dash popped on then popped off and only a few lights actually stayed on I can't remember exactly but the check engine and my abs stayed on and then on my screen it read to me warning p... Read more

Incident date: Jul 31, 2026

Incident date: Jul 12, 2026

I am reporting a severe safety recall compliance failure and fraudulent reporting by an authorized dealership regarding a 2023 Audi electric vehicle. On May 30, 2024, under Repair Order 227719, the dealership officially certified to the NHTSA and Audi that Safety Recall 93U6 (Compact/Portable Chargi... Read more

Incident date: Jul 12, 2026

The contact owns a 2022 Mercedes-Benz GLE350 4Matic. The contact stated that while driving approximately 35-40 MPH and depressing the brake pedal, several unknown warning lights illuminated, and the vehicle jerked and lost motive power. The contact pulled over to the side of the road until the vehic... Read more

Incident date: Jul 9, 2026

Electrical system (Hy-bird System). Yes it's available for inspection. Yes my safety was at risk. Yes Yes No warning lamps, messages or other symptoms of the problem prior to the failure. After the first recall was completed.

Incident date: May 1, 2026

The car has continually asked to to be updated through the driver control center screen. IT states that this is a dealer update and must be brought in to have this done. Until this update is completed the above systems will not work. I have brought the car in for the lat 25k miles 4 oil changes and ... Read more

Incident date: Jun 25, 2026

The contact owns a 2018 Honda Odyssey. The contact stated that while driving at various speeds and depressing the accelerator pedal, there was an abnormal rattling sound coming from the rear of the vehicle. An independent mechanic was contacted. No warning light was illuminated. The vehicle was take... Read more

Incident date: Jun 25, 2026

The contact’s wife owns a 2021 BMW X3. The contact stated that while attempting to start the vehicle on several occasions, the vehicle failed to start. The message "Vehicle Failed to Start - Contact Dealer" was displayed. The contact stated that for the vehicle to start, the contact had to turn th... Read more

Incident date: Jun 25, 2026

The contact owns a 2019 Ford Flex. The contact received notifications of NHTSA Campaign Numbers: 25V695000 (Back Over Prevention) and 25V732000 (Structure); however, the parts for the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time f... Read more

Incident date: Jun 27, 2026

CV Joints/Boot clicking and front passenger suspension squeaking, power steering making rubbing and squealing noises . Baking up-vehicle slams on brakes with nothing behind me. Dealership claims everything is fine and can't recreate issues.

Incident date: May 25, 2026

The charging system for the battery failed when I was on an out of state road trip. The voltage of the bike would drop between 11 and 12 volts when slowing down. I slowed down to make a tight turn on a canyon highway when the bike lost power and stalled. The motorcycle continued to stall several mor... Read more

Incident date: May 25, 2026

Regarding Safety Recall Notice 25S53 / NHTSA Recall 25V347, I received the recall literature June 2025. This past week, a trim piece in this recall came off the vehicle while in motion. This is a safety hazard and can cause accidents. Upon reaching out to Ford, NO remedy is available and might h... Read more

Incident date: Jun 18, 2026

Our vehicle does not respond to the throttle pedal being depressed when the AC has been turned on at full and the car has been in direct sunlight for a period of time. We reside in Florida so it is common to enter the vehicle during the summer months and the cabin temperatue is in excess of 200 degr... Read more

Incident date: Jun 18, 2026

own a 2021 Jeep Gladiator Overland, VIN [XXX]. My vehicle is affected by a safety recall involving the power steering wiring and potential fire risk. I have been advised that parts may not be available until September. I am concerned about the safety of my vehicle and would like Jeep to document my ... Read more

Incident date: Jun 5, 2026

I am a [XXX] resident. While commuting to work in [XXX], my GMC Terrain experienced a sudden, catastrophic failure of the brake vacuum pump while traveling at highway speeds. When I attempted to slow down for the exit, the brake pedal instantly became extremely stiff and nearly impossible to depress... Read more

Incident date: Mar 31, 2026

“The vehicle experiences phantom braking while driving, where the Collision Mitigation Braking System (CMBS) activates without warning even when there are no vehicles or objects in front of me. The vehicle suddenly brakes on its own, creating a major safety hazard and risk of rear-end collisions. ... Read more

Incident date: Mar 31, 2026

Incident date: Apr 25, 2026

When driving my Kia Sportage on the highway, the screen panel goes completely dark while using the GPS. No warning lights what so ever. This is a major issue for me because I'm depending on the GPS to safely get to where I want to go. I have gotten lost 3 or 4 times in areas that I'm not familiar w... Read more

Incident date: Apr 23, 2026

my car is a 2018 we bought it used in 2020 we had to had the transmission flushed and coils replaced . that didn't work . we had drum issues and gear slippage . now i. have to put a new transmission in the car

Incident date: Apr 23, 2026

I passed the recall inspection on 12/17/2025 and the higher viscosity oil was put into my vehicle. On 12/25/2025 my vehicle's engine shut off while I was traveling on the highway (I-25). The vehicle went into to neutral and I had to pull over to the side of the highway without power. The vehicle sta... Read more

Incident date: Feb 22, 2022

A collision occurred when the vehicle failed to detect a stationary stop‑sign pole directly in front of it. The forward collision‑avoidance system did not provide any braking assistance or intervention before impact. The vehicle is equipped with the full safety and driver‑assistance package, i... Read more

Showing 50 of 1,506 complaints.

NHTSA Safety Ratings, 2022 TESLA MODEL 3

2022 Tesla Model 3 4 DR AWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	5 / 5 ★★★★★
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	5 / 5 ★★★★★
Rollover Risk	6.6%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Standard
Lane Departure Warning	Standard

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

Technical Service Bulletins, 2022 TESLA MODEL 3

60 manufacturer communications from 27 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
350000 EQUIPMENT	13
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL	9
160000 STRUCTURE	7
353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE	5
251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)	4
353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT	4
353620 EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT	4
110000 ELECTRICAL SYSTEM	3

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Tesla does not provide physical owner's manual copies. Instead, all available owner?s manual content is integrated into the vehicle software, and only the content relevant for a given vehicle, based on vehicle configuration and software ver

350000 EQUIPMENT

353620 EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

350000 EQUIPMENT

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

353620 EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

353620 EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Owner's Manual.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Owner's Manual.

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

Owner's Manual

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

350000 EQUIPMENT

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

353600 EQUIPMENT:ELECTRICAL:INFOTAINMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

353620 EQUIPMENT:ELECTRICAL:INFOTAINMENT:VIDEO (TOUCH)SCREEN/MONITOR/UNIT

353610 EQUIPMENT:ELECTRICAL:INFOTAINMENT:SOFTWARE

350000 EQUIPMENT

010000 STEERING

On some Model 3 and Model Y vehicles, the steering wheel cover material may separate from the steering wheel at the 3 o'clock and 9 o'clock position (Figures 1 and 2). NOTE: The material separation of the steering wheel cover is cosmetic on

010000 STEERING

160000 STRUCTURE

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

160000 STRUCTURE

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

350000 EQUIPMENT

160000 STRUCTURE

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

350000 EQUIPMENT

355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

160000 STRUCTURE

On some Model 3 vehicles, water may have leaked inside the trunk area through the trunk lid.

162700 STRUCTURE:BODY:TRUNK LID

On some Model 3 vehicles, water may have leaked inside the trunk area through the trunk lid.

160000 STRUCTURE

On some Model 3 vehicles, water may have leaked inside the trunk area through the trunk lid.

160000 STRUCTURE

On some Model 3 vehicles, water may have leaked inside the trunk area through the trunk lid.

220000 SEATS

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

143100 AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

143100 AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

220000 SEATS

Certain Model 3 and Model Y vehicles may need a different Occupant Classification System (OCS) installed in the front passenger seat before servicing its subcomponents.

110000 ELECTRICAL SYSTEM

Certain Model 3 vehicles were equipped with a RH body controller module which might have a damaged component. Though the module is operational, should the component fail, the fresh air intake/recirculation setting of the vehicle?s climate c

160000 STRUCTURE

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

Some Heat Pump Model 3 vehicles were built without a hydraulic control unit (HCU) wake-up wire, and in rare circumstances, braking and stability control related alerts may appear on the instrument cluster and touchscreen during the vehicle

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

110000 ELECTRICAL SYSTEM

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

070000 FUEL SYSTEM, GASOLINE

100000 POWER TRAIN

251000 ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)

070000 FUEL SYSTEM, GASOLINE

100000 POWER TRAIN

NHTSA Safety Investigations, TESLA MODEL 3

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Open , Model Year: 2018

Lower Lateral Link detachment

The Office of Defects Investigation (ODI) has received 156 complaints alleging a suspension failure in model year (MY) 2018-2020 Model 3 and MY 2021-2023 Model Y vehicles. The suspension failure involves the detachment of the front lower lateral link, which potentially causes a loss of vehicle direc... Read more

DP, Closed , Model Year: 2022

Emergency egress controls are not readily accessible and clearly identifiable.

The Office of Defects Investigation (ODI) has completed its review of a defect petition received on November 24, 2025, requesting an investigation into the emergency mechanical door release in 2022 Model Year (MY) Tesla Model 3. The petition alleges that the controls for the emergency mechanical d... oor release are not accessible and clearly identifiable and thus fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) 206. A vehicle equipped with electric door handles without an accessible mechanical door release creates a risk to safety when the electric door handle becomes inoperative due to loss of power and occupants are unable to easily locate the mechanical door release to exit the vehicle in case of an emergency. A concealed or hard to locate emergency door release could prevent an operator or occupant from exiting the vehicle in the event of an emergency, such as a crash or fire. The potential risk for entrapment can result in a severe injury or death of the operator and other occupants of the vehicle. As of March 13, 2026, out of the population of 179,031 subject vehicles, NHTSA has identified one (1) consumer complaint, in NHTSA’s databases alleging that the mechanical door release is concealed and unlabeled, resulting in a risk of entrapment in the event of an emergency, as cited in the Petition. The complaint is for the same Vehicle Identification Number (VIN) as the subject vehicle of the Petition. The allegation describes a front impact collision, where the vehicle lost electrical power, and the electric door mechanism stopped working. The 2022 MY Model 3 has a mechanical release for the front doors, located in front of the window switch on the door's interior and consists of a lever that can be pulled up to open the door. The subject vehicle does not have a mechanical release for the back doors. The owner’s manual for the 2022 MY Tesla Model 3 includes a section labeled “In Case of Emergency” that details how to open doors from the interior when the vehicle has no electrical power. The owner’s manual refers to the mechanical release as a “manual door release.” The owner’s manual instructs the operator to “pull up the manual door release located in front of the window switches.” The owner’s manual includes an illustration showing the mechanical door release lever and its location on the door. The illustration depicts an image of the door with the window switch and lever, including a blue arrow pointing to the location of the lever to demonstrate the upward movement required to operate the lever. The lever shown in the illustration does not contain a label to identify it. Although they vary in design and location, mechanical releases for the front doors are available on all Tesla models. The location and operation of the mechanical release is described in the owner’s manual for each Tesla model. Further, the owner’s manual cautions the operator that the mechanical door release should only be used when the subject vehicle has no power or if otherwise necessary. If the subject vehicle has power, the button located at the top of the interior door handle should be used to open the doors. The Petition also stated the lack of an accessible mechanical emergency door release is a violation of the requirements of Federal Motor Vehicle Safety Standard (FMVSS) 206 (49 CFR § 571.206). FMVSS 206 specifies performance requirements for vehicle door locks, latches, hinges, and attachment components to prevent passenger ejection during crashes. It applies to passenger cars, trucks, and buses with a GVWR of 4,536 kg (10,000 lbs.) or less, focusing on maintaining latch engagement under inertial loads and structural integrity. No requirements exist in the standard that address the Petitioner’s concern regarding the labeling and location of an emergency mechanical door release in passenger cars. On November 4, 2025, NHTSA’s Office of Rulemaking received a petition to initiate the issuance of a new Federal Motor Vehicle Safety Standard (FMVSS) to mandate a robust and obvious door egress system in all motor vehicles. The request has been granted, and the Agency will accordingly commence a rulemaking proceeding. See 49 CFR § 552.9. A decision as to the issuance of a rule will be made on the basis of all available information developed in the course of the rulemaking proceeding, in accordance with statutory criteria. Id. The Agency has thoroughly assessed the material submitted by the Petitioner, consumer complaint information in NHTSA’s databases, and other relevant information already in possession of the Agency. NHTSA does not believe that the issues presented by the Petitioner indicate the likelihood of a safety related defect that would warrant a defect investigation, and the issue is best addressed through the rulemaking process. After full consideration of the available information and the commencement of the related rulemaking proceeding, the Petition is denied. Further specifics can be found in the Federal Register Notice. The ODI report cited above can be viewed at NHTSA.gov under ODI Number 11701894 and the Defect Petition can be viewed under ODI Number 11698174.Read more

AQ, Open , Model Year: 2017

Compliance with Standing General Order 2021-01 Reporting Requirements

The Office of Defects Investigation (“ODI”) has identified numerous incident reports submitted by Tesla, Inc. (“Tesla”) in response to Standing General Order 2021-01 (the “SGO”), in which the reported crashes occurred several months or more before the dates of the reports. The majority o... f these reports involved crashes in which the Standing General Order in place at the time required a report to be submitted within one or five days of Tesla receiving notice of the crash. When the reports were submitted, Tesla submitted them in one of two ways. Many of the reports were submitted as part of a single batch, while others were submitted on a rolling basis. Preliminary engagement between ODI and Tesla on the issue indicates that the timing of the reports was due to an issue with Tesla’s data collection, which, according to Tesla, has now been fixed. NHTSA is opening this Audit Query, a standard process for reviewing compliance with legal requirements, to evaluate the cause of the potential delays in reporting, the scope of any such delays, and the mitigations that Tesla has developed to address them. As part of this review, NHTSA will assess whether any reports of prior incidents remain outstanding and whether the reports that were submitted include all of the required and available data. The SGO reports cited in the Opening Resume, can be found at NHTSA.gov/SGOCrashReporting under the following SGO 2021-01 report IDs: 13781-11020-1 13781-10844-1 13781-10843-1 13781-10530-1 13781-10160-1 13781-10159-1 13781-10157-1 13781-10146-1 13781-10122-1 13781-10098-1 13781-10097-1 13781-10096-1 13781-10095-1 13781-10094-1 13781-10093-1 13781-10023-1 13781-10022-1 13781-10021-1 13781-10020-1 13781-10017-1 13781-10016-1 13781-10015-1 13781-10014-1 13781-10013-1 13781-10012-1 13781-6047-1 13781-9930-1 13781-9917-1 13781-9928-1 13781-9925-1 13781-9924-1 13781-9923-1 13781-9922-1 13781-9835-1 13781-9834-1 13781-9833-1 13781-9832-1 13781-9831-1 13781-9830-1 13781-9829-1 13781-9827-1 13781-9818-1 13781-9780-1 13781-9779-1 13781-9778-1 13781-9777-1 13781-9775-1 13781-9774-1 13781-9773-1 13781-9772-1 13781-9771-1 13781-9770-1 13781-9728-1 13781-9688-1 13781-9715-1 13781-9714-1 13781-9713-1 13781-9712-1 13781-9711-1 13781-9710-1 13781-9709-1 13781-9696-1 13781-9695-1 13781-9694-1 13781-9693-1 13781-9692-1 13781-9691-1 13781-9690-1 13781-9687-1 13781-9686-1 13781-9342-1 13781-9319-1 13781-9019-1 13781-8910-1 13781-8732-1 13781-8712-1 13781-8310-1 13781-7897-1 13781-7895-1 13781-7835-1 13781-7798-1 13781-7797-1 13781-7758-1 13781-7757-1 13781-7756-1 13781-7755-1 13781-7667-1 13781-7399-1 13781-7398-1 13781-7397-1 13781-7396-1 13781-7395-1 13781-7394-1 13781-7393-1 13781-7389-1 13781-7388-1 13781-7387-1 13781-7386-1 13781-7385-1 13781-7383-1 13781-7187-1 13781-7186-1 13781-7185-1 13781-7184-1 13781-7181-1 13781-7023-1 13781-6399-1 13781-6389-1 13781-6388-1 13781-6387-1 13781-6386-1 13781-6379-1 13781-6378-1 13781-6377-1 13781-6375-1 13781-6214-1 13781-6172-1 13781-6155-1 13781-6154-1 13781-6122-1 13781-6120-1 13781-6118-1 13781-5800-1Read more

PE, Closed , Model Year: 2017

Actually Smart Summon sessions resulting in low-speed impacts.

On January 6, 2025, the Office of Defects Investigations (ODI) opened Preliminary Evaluation 24003 (PE24033) to investigate Actually Smart Summon (Summon) sessions resulting in crashes during active sessions. According to Tesla, Summon is a short-distance SAE Level 2 system, controlled by the user f... rom a cell phone within a certain distance and intended for use in parking lots and on private property. ODI analyzed complaint data provided by Tesla as well as complaints submitted to ODI from consumers to identify Summon incidents resulting in crashes. ODI's analysis indicates that almost all Summon reported crashes involved minor property damage claims with no reported incidents involving a vulnerable road user, injury, fatality, or major property damage as indicated by an air bag deployment or vehicle tow away. Out of millions of Summon sessions, a fraction of 1% resulted in an incident. Almost all those incidents took place where, typically early in a Summon session, the system or person using the app failed to fully detect or respond appropriately to vehicle surroundings resulting in minor impacts. Incidents took place when app users did not have a complete 360-degree view of the surroundings in the app to assess situational awareness. This limited the app user’s ability to determine whether an impact was imminent during initial vehicle maneuvers such as reversing in close proximity to an obstacle or a curb. ODI found that the impacts most often occurred with parking gates, adjacently parked vehicles, and short parking bollards. During this investigation, ODI identified two Summon crashes related to camera blockages. In both crashes, Summon attempted to navigate a snowy parking lot with snow partially or fully obstructing the forward-facing cameras. Summon did not detect the camera blockage and the vehicles collided with unoccupied parked vehicles while navigating the parking lot. App users in both instances did not command a vehicle stop or pause despite the obstructed camera visible in the camera stream in the app. On January 15, 2025, Tesla released Over-the-Air (OTA) Software (SW) Update Action numbers 578998 and 579185 for vehicles in service to implement a camera blockage detection condition. Both OTAs improve camera blockage detection mechanisms. Additionally, on January 20, 2025, and January 30, 2025, Tesla identified additional system requirements associated with camera visibility checks and released OTA SW-578752 and SW-580322, respectively. These firmware updates reduce false negative camera blockage detections due to snow or condensation. In its investigation, ODI identified one Summon incident where the vehicle did not yield for a gate arm blocking a garage exit lane and the app user did not command a vehicle stop or pause, resulting in an impact. On February 6, 2025, Tesla deployed OTA SW-578839 to improve vehicle reaction to dynamic gates. This OTA update upgraded vehicle perception systems through a high-fidelity occupancy determination network, which uses data from vehicle sensory systems to improve reconstruction of field objects with high accuracy. On November 20, 2025, Tesla further improved vehicle performance by adding object detections from a separate neural network through OTA SW-580514. Owners of the affected vehicles received all six OTA SW updates. Tesla also released these SW updates to production vehicles. See online public file for detailed descriptions of all six OTA SW updates. Due to low incident occurrence and low incident severity, this preliminary evaluation is closed. The closing of this investigation does not constitute a finding that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by future circumstances. For additional information regarding this investigation, see the complete online public file.Read more

EA, Closed , Model Year: 2023

Loss of steering control

On July 28, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23014) to investigate instances of loss of electronic power-assisted steering in MY 2023 Tesla Model 3 and MY 2023 Tesla Model Y vehicles manufactured by Tesla, Inc. The complaints allege a sudden and unex... pected inability to turn the steering wheel or an increase in effort required to turn the steering wheel. These conditions were alleged to occur both during the drive cycle, at various speeds, and at vehicle start up. Consumers reported receiving the warning message “Steering assist reduced” either before, during, or after the loss of steering control, and some consumers described their steering begin to feel “notchy” or “clicky” either prior to or just after the incident. On February 1, 2024, PE23014 was upgraded to EA24001 to further investigate the alleged defect in the affected vehicles. Tesla identified the cause of the increase in steering effort as an overvoltage breakdown (the voltage applied exceeds the maximum design limit), which can overstress motor drive components on the printed circuit board of the vehicle’s steering Electronic Control Unit (ECU). If the primary motor drive components experienced an overvoltage breakdown occurrence while the vehicle was traveling above 0 mph, electronic power-assisted steering would be diverted to secondary motor drive components. The secondary, or backup, motor drive components would maintain electronic power-assisted steering until the vehicle reached 0 mph. If the vehicle was operating on the secondary system and reached 0 mph, the driver would lose electronic power-assisted steering with manual steering remaining available. Only manual steering would remain until the vehicle’s steering ECU is replaced. On February 19, 2025, Tesla filed safety recall 25V092 to address the loss of electronic power-assisted steering. The recall filing documents state that a steering ECU software update, identified as 2023.38.4, was introduced into production vehicles and provided to affected fleet vehicles through an over-the-air (OTA) update beginning in October 2023. The updated software was designed to prevent overvoltage breakdown and overstress of motor drive components on the printed circuit board. ODI’s analysis of related Vehicle Owner Questionnaires (VOQs) and Tesla field data found that complaint traffic declined following the 2023.38.4 software release. In view of the recall action taken by Tesla, ODI is closing this EA. ODI will continue to monitor the effectiveness of the remedy as is consistent with the Agency’s authority and practice. NHTSA reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2023

Loss of steering control

On July 28, 2023, The Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-014) after receiving 12 Vehicle Owner Questionnaires (VOQs) reporting loss of steering control in model years (MY) 2023 Tesla Model 3 and Y vehicles. During PE23-014, ODI interviewed complainants, sent ... an Information Request (IR) letter to Tesla, and convened technical meetings with Tesla that included a joint inspection of a crashed vehicle. The investigation identified 2,388 total complaints regarding the alleged defect, including 124 complaints through VOQs and 2,264 complaints through manufacturer data. ODI is associating 1 crash to this investigation (11544655), where a driver was unable to complete a right hand turn in the intersection and hit a vehicle. This vehicle was subject to a joint inspection by ODI and Tesla. The steering rack was recovered by ODI with the consumer’s permission. ODI’s interviews of allegations supplied to the agency, in the form of VOQs, identified patterns of the incoming complaint traffic. Complaints allege an inability to turn the steering wheel, while other complaints allege an increase in required effort to turn the steering wheel. These conditions were reported to occur during the drive cycle as well as at start-up. Approximately one-third of complaints with a reported speed occurred at vehicle start-up or speeds less than 5 mph. Interviews with failures reported at speeds over 5 mph, half reported an inability to turn the steering wheel. A majority of complaints with a reported speed reported between 5 mph and 35 mph with approximately 1 in 10 occurring on open roads at speeds 35 mph and over. The highest reported speed regarding an alleged inability to turn the steering wheel is 75 mph. A majority of allegations reported seeing a warning message, “Steering assist reduced”, either before, during or after the loss of steering control. A portion of drivers described their steering begin to feel “notchy” or “clicky” either prior to or just after the incident. There have been multiple allegations of drivers blocking intersections and/or roadways. ODI is aware of over 50 vehicles which were allegedly towed as a result of the condition from a variety of areas including, driveways, parking lots, side of road and intersections. Multiple complaints state they were able to temporarily remedy the condition by power cycling the vehicle, but the issue reoccurred until the steering rack was replaced. Tesla supplied four steering rack part numbers on the subject vehicles. The investigation identified part numbers, 1044832-00-A and 1188832-00-A accounted for 2,187 of the complaints and 4 did not have original part number in the information request. ODI has upgraded PE23-014 to an Engineering Analysis (EA24-001) due to continued complaint traffic and to characterize the system conditions leading to- and stemming from- the alleged defect in vehicles supplied with steering rack part numbers 1044832-00-A and 1188832-00-A To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

DP, Open , Model Year: 2017

Sudden Unintended Acceleration

The Office of Defects Investigation (ODI) received a petition requesting that ODI reevaluate its decision to deny DP20-001 on the basis that intermittent high electrical current demands on the vehicles' 12VDC systems may have caused some or all of the incidents examined by ODI in DP20-001. The petit... Read more

DP, Closed , Model Year: 2017

Defect Petition Interlock Request

On March 21, 2023, the Office of Defects Investigation (ODI) received a petition requesting a “recall of all Tesla cars” produced from 2013 to the date on which the petition was filed due to what Petitioner considers to be the increased likelihood of pedal misapplication. Attached to the Petitio... Read more

EA, Closed , Model Year: 2017

Autopilot System Driver Controls

The Office of Defects Investigation (ODI) upgraded PE21020 to EA22002 on June 8, 2022, to extend work and deepen the PE21020 crash analysis, to supplement that analysis with additional data, and to perform vehicle evaluations to understand how Tesla’s Autopilot system may exacerbate human factors ... or behavioral safety risks by undermining the effectiveness of the driver’s supervision. To support this work, ODI collected additional crash information and assessed vehicle control authority, driver engagement technologies, and related human factors considerations associated with partial automation via analysis of peer vehicle data and hands-on vehicle evaluation, assessments from NHTSA human factors subject matter experts, and reviews of related publications dedicated to partial driving automation. Autopilot is the simultaneous use of the features that Tesla calls Traffic-Aware Cruise Control (TACC) and Autosteer. TACC is a type of adaptive cruise control that, like traditional cruise control, maintains a set speed but also slows or accelerates as necessary to maintain the vehicle’s following distance from a vehicle in front. As designed, Autosteer detects lane markings and the presence of other nearby vehicles and objects to keep the vehicle in its driving lane. Autopilot is characterized by Tesla as an SAE Level 2 (“L2 system”) partial driving automation system that provides driver assistance through steering, propulsion, and braking within a specified driving environment under direct supervision of the driver. L2 systems should be designed to support the driver’s need to monitor the system in response to the constantly changing driving environment and, if necessary, take over the dynamic driving task. To ensure sufficient driver engagement, vehicles with L2 systems should employ driver engagement systems and usage controls that are appropriate and sufficient for the L2 system design and driver expectations. ODI completed an analysis of 956 crashes reported up to August 30, 2023. In approximately half (489) of those crashes, ODI found: 1.) that there was insufficient data to make an assessment; 2.) the other vehicle was at fault; 3.) Autopilot was found to not be in use; or 4.) the crash was otherwise unrelated to EA22002. Of the remaining 467 crashes, ODI identified trends resulting in three categories: collisions in which the frontal plane of the Tesla struck another vehicle or obstacle with adequate time for an attentive driver to respond to avoid or mitigate the crash (211), roadway departures where Autosteerwas inadvertently disengaged by the driver’s inputs (111), and roadway departures in low traction conditions such as wet roadways (145). ODI observed this pattern across all Tesla models and hardware versions. Crash and human factors assessment showed that Autopilot controls did not sufficiently ensure driver attention and appropriate use. At the same time, peer analysis and vehicle evaluations established that Autopilot invited greater driver confidence via its higher control authority and ease of engagement. This mismatch of weak usage controls and high control authority was evident in these crash categories, which included indications of driver disengagement from the driving task. This mismatch was also evident in roadway departures when the system was engaged in low traction conditions outside of Tesla’s recommendations.Additional information regarding NHTSA’s crash analysis is available in the EA22002 file. ODI reviewed these findings with Tesla during several conversations in Quarter 4 of 2023. On December 12, 2023, Tesla filed a Defect Information Report (DIR) (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system. Tesla’s DIR described the functionality of this system, stated that the prominence and scope of the system’s controls may be insufficient to prevent driver misuse, and described a remedy to improve the effectiveness of driver warnings and to reduce mode confusion. ODI completed an extensive body of work via PE21020 and EA22002, which showed evidence that Tesla’s weak driver engagement system was not appropriate for Autopilot’s permissive operating capabilities. This mismatch resulted in a critical safety gap between drivers’ expectations of the L2 system’s operating capabilities and the system’s true capabilities. This gap led to foreseeable misuse and avoidable crashes. During EA220002, ODI identified at least 13 crashes involving one or more fatalities and many more involving serious injuries, in which foreseeable driver misuse of the system played an apparent role. ODI’s analysis conducted during this investigation, which aligns with Tesla’s conclusion in its Defect Information Report, indicated that in certain circumstances, Autopilot’s system controls and warnings were insufficient for a driver assistance system that requires constant supervision by a human driver. Given Tesla’s recall (23V838) of all vehicles equipped with Autopilot for insufficient controls to prevent misuse, ODI is closing EA22002. Concurrent with that closing, ODI has opened a Recall Query (RQ24009) to assess the effectiveness of the 23V838 remedy. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2018

Unexpected Brake Activation

On February 16, 2022, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE22002) to investigate reports of unexpected deceleration while driving with the adaptive cruise control system engaged in Model Year (MY) 2021 – 2022 Model 3 and Model Y vehicles manufactured by Tesl... a. The subject systems include Autopilot (all versions), Full Self-Driving (FSD) and Traffic Aware Cruise Control (TACC). These complaints have been colloquially referred to as “phantom braking”. ODI opened PE22002 to determine the scope and severity of the potential problem and to assess any resulting safety issues in the subject vehicles. The alleged defect is an unexpected and unrequested vehicle deceleration triggered by the subject system during subject system engagement. The alleged defect does not occur when the subject system is not in use and is separate and distinct from Automated Emergency Braking (AEB). During vehicle operation, AEB is actively monitoring in the subject vehicles regardless of subject system and its intervention is accompanied by audible and visual collision warnings. A Vehicle Owners Questionnaire (VOQ) trend originating in November 2021 prompted ODI to open PE22002. VOQ narratives reported unexpected brake activation while using TACC, Autopilot or FSD. The trend grew from 99 by the end of 2021 to 314 by February 16, 2022, when PE22002 was opened. ODI sent Information Request (IR) Letters to Tesla on May 4, 2022, and July 11, 2024, to request salient data to quantify vehicle production, field incidents, and the physical parameters of the phantom braking reports. ODI also requested information pertaining to Tesla’s internal assessments, problem resolutions, and their assessment of the alleged defect. Typically, the complaints to ODI and Tesla allege a 10-20 mph speed reduction at highway speeds over a 1-3 second time period.No collisions were identified. Drivers reported seeing no vehicles ahead in the travel lane that would have triggered the deceleration. Many complaints reported the conditions taking place on higher speed roadways in sunny conditions with shadows on the roadway. Complainants typically applied the accelerator to override the unexpected deceleration, and subject vehicles did not come to a complete stop or steer out of their travel lane. ODI analyzed data provided by Tesla in addition to consumer complaints submitted to ODI. Tesla’s complaint and field data exhibited some behavior that aligned with the transition from a radar-vision fusion system to vision-only in mid-2021. VOQ traffic coincided with public events such as Recall 21V846, the opening of PE22002, and several related media publications. In February and March of 2022, Tesla released firmware updates 2022.4.5.1 and 2022.4.5.17 respectively to target aspects of the subject system programming that affect unexpected deceleration. Incident traffic has dissipated substantially in the past years, with 45 incidents reported in 2024, 19 in 2025, and 3 since the beginning of 2026. The conditions reported, while concerning to the drivers, did not alter the vehicle’s lateral positioning in their lanes and did not cause significant loss in distance between the subject and following vehicle to lead to a collision. Complaint traffic to both NHTSA and Tesla reported the same conditions- vehicles traveling with the subject system engaged at higher speeds decelerating suddenly with no commensurate vehicle or obstacle ahead in the same lane. In view of these points, and a low demonstrated hazard to drivers, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.Read more

PE, Closed , Model Year: 2017

Tesla Passenger Play

The Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE21-023) on December 21, 2021, to evaluate the driver distraction potential and use frequency / circumstances of in-vehicle game-play functionality referred to as ?Passenger Play? in certain model year (MY) 2017-2022 Tesla Mod... Read more

PE, Closed , Model Year: 2017

Autopilot & First Responder Scenes

On August 13, 2021, NHTSA?s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE21-020) to assess the performance of Tesla?s Autopilot system (a system characterized by Tesla as an SAE Level 2 driving automation system designed to support and assist the driver in performing the ... Read more

DP, Closed , Model Year: 2017

Sudden Unintended Acceleration

On December 19, 2019, NHTSA received a petition from Mr. Brian Sparks requesting that the Agency recall all [Tesla] Model S, Model X, and Model 3 vehicles produced from 2013 to the present due to sudden unintended acceleration (SUA). In his petition and follow-up submissions, the petitioner identifi... ed a total of 232 non-duplicative complaints to NHTSA, including 203 reporting crashes. On January 13, 2020, NHTSA's Office of Defects Investigation (ODI) opened Defect Petition DP20-001 to evaluate the petitioner?s request. ODI's evaluation included reviews of all complaints and supporting information referenced by the petitioner, as well as 14 additional complaints to NHTSA related to SUA crash allegations that were either not selected by the petitioner or were submitted after the petitioner's most recent submission. The review also included analyses of available crash data (EDR, Tesla log data, and/or video data) the Agency acquired as part of the evaluation.After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into SUA in the subject vehicles. In every instance in which event data was available for review by ODI, the evidence shows that SUA crashes in the complaints cited by the petitioner have been caused by pedal misapplication. There is no evidence of any fault in the accelerator pedal assemblies, motor control systems, or brake systems that has contributed to any of the cited incidents. There is no evidence of a design factor contributing to increased likelihood of pedal misapplication. The theory provided of a potential electronic cause of SUA in the subject vehicles is based upon inaccurate assumptions about system design and log data.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Since the information before the Agency is not indicative of a vehicle-based defect, it is unlikely that any investigation opened because of granting this petition would result in an order concerning the notification and remedy of a safety-related defect. Therefore, upon full consideration of the information presented in the petition and the potential risks to safety, the petition is denied. The denial of this petition does not foreclose the Agency from taking further action if warranted or the potential for a future finding that a safety-related defect exists based upon additional information the agency may receive.The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP20-001. Those complaints and the 14 complaints ODI added to its evaluation can be viewed at NHTSA.gov. The reference numbers for the complaints added by ODI are: 11385350, 11383955, 11383233, 11383180, 11378492, 11378458, 11302076, 11299698, 11290006, 11190595, 11174504, 11115496, 11096644 and 11000097. The attached report, further detailing NHTSA?s reasons for denial of the petition, will be published in the Federal Register.Read more

TESLA MODEL 3 - All Years Overview

Complete safety history for the TESLA MODEL 3 across all model years (2017, 2026).

139 Total Recalls

7,656 Total Complaints

13 Investigations

551 Reported Crashes

85 Reported Fires

14 Reported Deaths

TESLA MODEL 3 - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2026	1	37	View
2025	3	211	View
2024	5	339	View
2023	12	734	View
2022 (current)	18	1,506
2021	22	1,235	View
2020	21	771	View
2019	22	1,061	View
2018	19	1,706	View
2017	16	56	View

Other TESLA Models

Model	Recalls	Complaints
MODEL S	283	5,158	View
MODEL X	259	2,303	View
MODEL Y	186	6,639	View
CYBERTRUCK	31	187	View
SEMI	2	6	View
ROADSTER2	1	2	View
ROADSTER	1	3	View
NEMA 10-30 ADAPTER	0	2	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2022 TESLA MODEL 3

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2022 TESLA MODEL 3

Safety Technology

Technical Service Bulletins, 2022 TESLA MODEL 3

Most Affected Components

NHTSA Safety Investigations, TESLA MODEL 3

TESLA MODEL 3 - All Years Overview

TESLA MODEL 3 - Year by Year

Other TESLA Models