2017 KIA OPTIMA

3 recalls, 355 complaints - 235 TSBs - 5/5 safety rating

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

Defect Description

Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Mot... Read more

Consequence

A person inside the trunk compartment may become trapped, increasing their risk of injury.

Remedy

Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.

319,436 vehicles affected

Manufacturer: Kia America, Inc.

ENGINE

Defect Description

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pi... Read more

Consequence

A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy

Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

71,653 vehicles affected

Manufacturer: Kia Motors America

HYBRID PROPULSION SYSTEM

Defect Description

Kia Motors America (Kia) is recalling certain 2017-2018 Kia Optima hybrid vehicles. These vehicles are equipped with a Voltage Protection Device (VPD), designed to protect the high voltage battery module, that may activate inadvertently.

Consequence

If the VPD activates while the vehicle is being operated in Electric Vehicle (EV) mode, there may be a loss of power, increasing the risk of a crash.

Remedy

Kia will notify owners, and dealers will remove the VPD switch and install two newly designed Battery Management Systems (BMS) that contain Overvoltage Protection Devices (OPDs), free of charge. The recall is expected to begin May 2018. Owners may contact Kia customer service at 1-800-333-4542. K... Read more

1,710 vehicles affected

Manufacturer: Kia Motors America

Complaint Statistics

355 total complaints 12 crashes 13 fires 4 injuries

Top Reported Components

Component	Complaints
ENGINE	91
ELECTRICAL SYSTEM	33
UNKNOWN OR OTHER	32
POWER TRAIN	32
SERVICE BRAKES	19
VEHICLE SPEED CONTROL	14
AIR BAGS	14
EXTERIOR LIGHTING	14
STEERING	13
FUEL/PROPULSION SYSTEM	13

Incident date: Jul 18, 2026

While driving at highway speed, my engine began to produce a loud knocking noise without prior warning. Within few seconds, the engine seized completely causing sudden loss of motive power.This caused a dangerous situation— loss of power steering and barking at highway speed, leaving me stranded i... Read more

Incident date: Aug 17, 2026

Loosing oil putting oil in every 3 to 4 days no leaks on ground or oil pan or drain plug.oil don't smell or looks burnt happened around did 2 oil changes in a week still the same. Car will sputer hesitation on acceleration every so often have all updateds and recalls.

Incident date: Aug 17, 2026

Incident date: Mar 15, 2024

The radio has a ghost touch, dealer does not see it as a problem. I hope government do.

Incident date: Apr 21, 2026

The contact owns a 2015 Ford F-150. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving 65 MPH, the transmission unexpectedly downshifted, with the check engine and... Read more

Incident date: Jun 1, 2026

In the past year, I have already had to replace the bulb for the "daytime running light" on the front passenger side of my Renegade. Now, the light has just popped back onto my dashboard for the 3rd time stating that the light is out again for the 3rd time in a year. I have also noticed several othe... Read more

Incident date: Jun 1, 2026

Incident date: Mar 3, 2026

Seat occupancy sensor failed for the second time. The car will randomly shut off if I am inside because it does not detect a passenger. When I exit the vehicle, the car will stay on for an extended period of time due to failed seat occupancy sensor. This is a widespread issue affecting all makes and... Read more

Incident date: Mar 3, 2026

The Pre-Collision Assist false-triggers on turns daily, flashing the red collision warning and actively applying autonomous emergency braking without any obstruction present. This phantom braking is a severe safety hazard. The vehicle has been serviced before for this issue - and is going back to th... Read more

Incident date: Mar 3, 2026

Incident date: Mar 25, 2026

Electronic power steering failure. Not complete shut down, but intermittent. Heavy steering feel when cornering at very low or highway speeds. No return to center. Notchy/sticky steering feel. No eps warning light. No electronic failure ie fuse, relay, control. Works fine today, cuts out to... Read more

Incident date: Mar 7, 2023

I was driving my 2015 prius for years and occasionally the brake, abs and traction light would come on this is a sign of a failing Brake actuator and booster. Toyota and the Ntsb ordered the following warranty enhancement https://static.nhtsa.gov/odi/tsbs/2020/MC-10181800-9999.pdf My Brake Boost... Read more

Incident date: May 1, 2023

Constant Mis-firing, must put oil in car every 3 to 4 weeks. Hesitation when driving and sputtering.

Incident date: May 1, 2023

Constant Mis-firing, must put oil in car every 3 to 4 weeks. Hesitation when driving and sputtering.

Incident date: Aug 4, 2025

The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at various speeds, the instrument panel and the infotainment screen display went black. The contact stated that the failure had progressively worsened and was a daily recurring failure. The vehicle was taken to the dealer,... Read more

Incident date: Aug 4, 2025

Radiator fan leading to engine overheating, fan fails to turn on causing high engine temperatures & AC failure. Nissan is aware of issues & takes no responsibility. Early on when vehicle experienced symptoms & under warranty, I brought vehicle in several times & was told they couldn’t find anythin... Read more

Incident date: Mar 23, 2026

The van has just approx 55000 miles. While driving on highway, it suddenly lost power and from 60mph it came down to 20 miles in a matter of few seconds after few violent jerks. I was lucky that no vehicle was behind me. After that I pulled a side and then again started. It kept jerking and loosing ... Read more

Incident date: Mar 23, 2026

6 speed manual transmission. 79K miles. Vehicle was checked at a dealer due to a sluggish clutch. Dealer found low brake fluid, but no problems with the clutch. The next day the clutch failed completely and car had to be towed off the highway. Slave cylinder for the clutch is a design flaw ... Read more

Incident date: Mar 23, 2025

My son, [XXX] , has opened a complaint/Case #XXX with Kia. His 2023 KIA Forte had been idle for at least 24 hours when the engine compartment caught fire. He became aware of this when the Fire Department knocked on his apartment door around 4:00 PM 12/26/25 and said they were evacuating the building... Read more

Fire

Incident date: Feb 11, 2026

I believe my vehicle has suffered a cracked/fractured or broken intake valve on cylinder number 4. There is very low compression in that cylinder. I checked it and it only managed to produce 25psi. I inspected the cylinder with a borescope camera and there is no damage or excessive wear to the pisto... Read more

Incident date: Aug 27, 2025

I was in a accident where I was going a okay speed in traffic where suddenly the car in front of me brakes and my emergency brakes did not activate so I had to slam on mines to avoid impact but the car behind me hit me causing me to impact the car in front and with no airbag deployment from impact i... Read more

Crash

Incident date: Aug 27, 2025

Crash

Incident date: Aug 27, 2025

ICCU failure

Incident date: Sep 30, 2025

The ICCU system's fuse failed.The car is currently with the dealership for repairs and could be available for inspection there if needed. The car was rendered inoperable and shut down while operating the vehicle. The abrupt breakdown could have been a hazard to the driver, passengers of the vehicle,... Read more

Incident date: Feb 5, 2026

Car has had 2 separate, distinct failures of the DC/DC converter which result in electrical faults rendering all systems unusable (gearbox, steering, etc.) and making the care immobile. I have had it replaced once in September 2025 following a failure, and then the replacement failed in January 2026... Read more

Incident date: Feb 5, 2026

The contact owns a 2020 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V093000 (Seat Belts); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of tim... Read more

Incident date: Sep 30, 2025

The contact owns a 2017 Ford Edge. The contact received notification of NHTSA Campaign Number: 25V544000 (Service Brakes, Hydraulic). The local dealer was contacted and confirmed that parts were not yet available for the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was ... Read more

Incident date: Sep 30, 2025

I received TWO safety recalls that my dealer has never fixed. One for the ABS System R61/NHTSA 15V-675 and one for the beauty cover R32/NHTSA 15V-431. I was supposed to be contacted when the parts were available and never was. My beauty cover has come off and my ABS system randomly turns off. I a... Read more

Incident date: Jan 13, 2026

Advanced driving system - Truck with leave a lane unprovoked and will fight you to recover manually. I have another Toyota with the same system (2024 Grand Highlander) and it works perfect. Not confirmed by dealer yet. It will be next week. Not inspected yet. Automatic lane centering just stops... Read more

Incident date: Dec 14, 2025

The contact owns a 2018 Ram 2500. The contact received notification of NHTSA Campaign Number: 24V896000 (Service Brakes, Hydraulic); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The... Read more

Incident date: Jan 2, 2026

I have been experiencing unintended acceleration when I press on my brakes. Fortunately, there hasn't been any accidents yet but it's a very dangerous situation.

Incident date: Dec 23, 2025

I am submitting this complaint to formally report ongoing and unresolved vehicle safety defects involving a leased 2025 Hyundai Santa Fe. These defects include persistent toxic or chemical odors inside the passenger cabin, electrical and body control system malfunctions, and unintended vehicle opera... Read more

Incident date: Dec 23, 2025

The contact owns a 2015 Ford Explorer. The contact stated that while reversing, the rear view camera displayed a distorted image and turned off. The contact received a recall notification of NHTSA Campaign Number: 25V695000 (Back Over Prevention); however, the recall remedy parts were not available.... Read more

Incident date: Dec 9, 2025

I brought my 2023 Yukon in for the 6.2 GM inspection, and was told my engine was good, and the engine oil was changed. Approximately 3 weeks later the engine in the Yukon failed (seized) while I was towing my boat at 55mph, nearly causing an accident. I was able to pull the vehicle and boat to t... Read more

Incident date: Dec 9, 2025

Vehicle flashed with a "check hybrid system. Stop safely" warning and then forced me to slow until my vehicle stopped - I could no longer press the gas pedal. I was on a highway and luckily was able to pull over safely before the vehicle came to a complete stop, but that was not guaranteed. I ended ... Read more

Incident date: Oct 1, 2024

The paint is cracking and peeling off by the back window on the roof creating rust areas.

Incident date: Oct 1, 2024

Rear view camera system is intermittent and the dealer has been unable to resolve the issue. This is a large vehicle and it is very dangerous to back up without this camera working.

Crash

Incident date: Apr 5, 2024

The contact owns a 2020 Ford Expedition. The contact stated that while reversing, the rearview camera image was distorted or blank. The contact stated that the failure was related to NHTSA Campaign Number: 25V442000 (Back Over Prevention). There were no warning lights illuminated. The vehicle was ta... Read more

Incident date: Oct 2, 2025

My car is equipped with Full Self Driving. When I use that mode the car drives over , on, or dangerously close to the middle yellow line. Basically it drives you into oncoming traffic every single time I use it. It also has erratic fluctuations in throttle control that would confuse other drivers an... Read more

Incident date: Oct 2, 2025

Oil filter gets stripped on oil cooler housing and cracks and leaks damaging engine.

Incident date: Jan 6, 2023

The contact owns a 2017 Ford Expedition. The contact received notifications of NHTSA Campaign Numbers: 22V648000(Visibility, Electrical System), 25V236000 (Service Brakes, Hydraulic), and 25V572000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The contac... Read more

Incident date: Jul 25, 2025

Audi Pre-Sense keeps braking prematurely when there is no car present or in its field of view. The SUV brakes without warning and when trying to make a left turn (happened twice already) or while driving on the highway. When the vehicle brakes without warning there is a chance that another vehicle w... Read more

Incident date: Jul 25, 2025

My 2019 has the coolant intrusion in cylinder 2 issue. The dealership recommended a long block replacement and quoted me $10,850 to do this. It is a safety concern and I was advised not to drive it. The engine could seize if not repaired and put myself and others in danger. The extended warranty ... Read more

Incident date: Sep 1, 2023

This is the second engine failure. First engine was completed being installed on 7/26/24 also reported catastrophic engine failure. Second engine was installed completion date on 4/04/25 it also had spun 2 rob bearings

Incident date: Aug 14, 2025

Coolant leak and cover gasket failure. Buick has been in the shop multiple times for coolant issues and leaks. Next step is for the shop to remove the entire front end to adequately repair. Constant issue and other complaint relay the same

Incident date: Dec 31, 1969

The contact owns a 2023 Jeep Wagoneer. The contact stated that several unknown lights on the instrument cluster were illuminated and flashing. Additionally, the headlights were flashing, and the camera screen was blank. The contact stated that while depressing the brake pedal, additional force was n... Read more

Incident date: Aug 11, 2025

The contact owns a 2016 Nissan Rogue. The contact stated that while operating the vehicle, there was an abnormal whining sound coming from the front of the vehicle. The vehicle was taken to the local dealer, and it was determined that the sound was coming from the CVT transmission. The vehicle was l... Read more

Incident date: Feb 1, 2025

The contact owns a 2024 Honda CR-V. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the power-reduced error message was displayed. The contact stated that the vehicle wa... Read more

Showing 50 of 355 complaints.

NHTSA Safety Ratings, 2017 KIA OPTIMA

2017 Kia Optima 4 DR FWD

Category	Rating
Overall Rating	5 / 5 ★★★★★
Frontal Crash	5 / 5 ★★★★★
Frontal Crash, Driver	5 / 5 ★★★★★
Frontal Crash, Passenger	4 / 5 ★★★★☆
Side Crash	5 / 5 ★★★★★
Side Crash, Driver	5 / 5 ★★★★★
Side Crash, Passenger	5 / 5 ★★★★★
Rollover	5 / 5 ★★★★★
Rollover Risk	9.8%

Safety Technology

Feature	Status
Electronic Stability Control	Standard
Forward Collision Warning	Optional
Lane Departure Warning	Optional

Source: NHTSA 5-Star Safety Ratings Program. Ratings are based on crash tests conducted by the National Highway Traffic Safety Administration.

EPA Fuel Economy, 2017 KIA OPTIMA

Trim / Engine	City MPG	Highway MPG	Combined MPG	Fuel Type	Annual Fuel Cost
1.6L 4-cyl, Automatic (AM7) (Front-Wheel Drive)	28.0	37.0	31.0	Regular	$2,000
2.0L 4-cyl, Automatic (S6) (Front-Wheel Drive)	22.0	31.0	25.0	Regular	$2,450
2.4L 4-cyl, Automatic (S6) (Front-Wheel Drive)	24.0	34.0	28.0	Regular	$2,200

CO2 Emissions: 286.0 g/mile (Large Cars)

Source: U.S. Environmental Protection Agency (EPA). Actual fuel economy may vary based on driving conditions.

Technical Service Bulletins, 2017 KIA OPTIMA

235 manufacturer communications from 151 unique bulletins. TSBs describe known problems and recommended fixes from the manufacturer.

Most Affected Components

Component	Bulletins
060000 ENGINE AND ENGINE COOLING	50
110000 ELECTRICAL SYSTEM	44
350000 EQUIPMENT	19
010000 STEERING	17
100000 POWER TRAIN	13
060000 ENGINE (PWS)	10
070000 FUEL SYSTEM, GASOLINE	9
118000 ELECTRICAL SYSTEM:SOFTWARE	7

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN: PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: VOLTAGE REGULATOR PERFORMANCE ENHANCEMENT (SA278) CLOSED - This revised bulletin is now closed. This bulletin provided the procedure to increase the torque on the voltage regulator screws on some

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. T

100000 POWER TRAIN

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin has been revised to include additional information. New/revised sections of this

110000 ELECTRICAL SYSTEM

CUSTOMER SATISFACTION CAMPAIGN: OWNER RE-NOTIFICATION - This document is the owner re-notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition s

110000 ELECTRICAL SYSTEM

116300 ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE

TECHNICAL SERVICE BULLETIN: CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN CUSTOMER SATISFACTION: KIA GENUINE REMOTE START CONTROL MODULE UPGRADE FOR ANTI-THEFT LOGIC COMPATIBILITY (CS2310) - This bulletin provides information to update the software logic in the Kia Genuine Remote Start

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

100000 POWER TRAIN

110000 ELECTRICAL SYSTEM

280100 BACK OVER PREVENTION:SOFTWARE

CUSTOMER SATISFACTION CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia has developed a software upgrade that can be installed on the vehicle to restrict the operation of the vehicle's ignition system

110000 ELECTRICAL SYSTEM

116000 ELECTRICAL SYSTEM:IGNITION

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN CUSTOMER SATISFACTION: ANTI-THEFT S/W LOGIC UPGRADE & DECAL INSTALLATION (CS2303) - This bulletin provides the procedure to upgrade the software logic of the Integrated Body Control Unit (IBU) or Body Control Modu

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: BMS/OPU/MCU LOGIC IMPROVEMENT (SA411) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. Th

100000 POWER TRAIN

TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmis

070000 FUEL SYSTEM, GASOLINE

TECHNICAL SERVICE BULLETIN: FUEL PUMP FILTER INSPECTION/REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin pro

070000 FUEL SYSTEM, GASOLINE

TECHNICAL SERVICE BULLETIN: FUEL PUMP FILTER INSPECTION/REPLACEMENT - This bulletin provides information associated with the 'Warranty Extension Program' (WTY028) to inspect and, if necessary, replace the fuel pump filter assembly on 2016-2

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides inform

060000 ENGINE AND ENGINE COOLING

TECHNICAL SERVICE BULLETIN: BEARING CLEARANCE TESTER (BCT) PROCEDURES - This bulletin provides information regarding test procedure of the Bearing Clearance Tester (BCT) Special Service Tool (SST). The SST comes pre-calibrated from the supp

060000 ENGINE AND ENGINE COOLING

VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to update the software programming on your vehicle's Engine Control Mo

060000 ENGINE AND ENGINE COOLING

VOLUNTARY EMISSIONS SERVICE CAMPAIGN: THETA 2.0L T-GDI ULEV LOGIC IMPROVEMENT FOR EMISSIONS (SC205) - This bulletin provides the procedure to update the emissions-related logic of the Engine Control Unit (ECU) on some 2016-2020MY Optima (JF

060000 ENGINE AND ENGINE COOLING

SC205_POC: PROOF OF CORRECTION CARD

060000 ENGINE AND ENGINE COOLING

SC205_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION STICKER

060000 ENGINE AND ENGINE COOLING

VOLUNTARY EMISSIONS SERVICE CAMPAIGN: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Voluntary Emissions Service Campaign (SC205).

060000 ENGINE AND ENGINE COOLING

VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers that Kia is conducting a Voluntary Emissions Service Campaign on 2016-2020 MY Kia Optim

350000 EQUIPMENT

VOLUNTARY EMISSIONS SERVICE CAMPAIGN: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals that Kia is conducting a Voluntary Emissions Service Campaign on 2016-2020 MY Kia Optima vehicles equipped with the 2.0

060000 ENGINE AND ENGINE COOLING

070000 FUEL SYSTEM, GASOLINE

WARRANTY EXTENSION: OWNER NOTIFICATION - This document is the owner notification advising that Kia is extending the New Vehicle Limited Warranty coverage for repairs related to low-pressure fuel pump failure in 2016-2020 MY Optima vehicles

070000 FUEL SYSTEM, GASOLINE

WARRANTY EXTENSION: REIMBURSEMENT FORM - This document is a Reimbursement Request form that was mailed with the customer letter advising them to submit the form if they had paid for repairs for this same matter prior to the warranty extensi

070000 FUEL SYSTEM, GASOLINE

WARRANTY EXTENSION: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the Warranty Extension (WTY028).

070000 FUEL SYSTEM, GASOLINE

WARRANTY EXTENSION: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers that Kia is extending the New Vehicle Limited Warranty coverage for repairs related to low-pressure fuel

070000 FUEL SYSTEM, GASOLINE

WARRANTY EXTENSION: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals that Kia is extending the New Vehicle Limited Warranty coverage for repairs related to low-pressure fuel pump failure for 2016-2020 MY Op

060000 ENGINE AND ENGINE COOLING

PITSTOP: INJECTOR HARNESS ROUTING FOR PI1802Y/Z AND PI1803Y/Z ENGINE REPLACEMENTS - This bulletin provides information to address a no-start or hard start with poor running condition after engine replacement under PI1802Y/Z or PI1803Y/Z. So

110000 ELECTRICAL SYSTEM

TECHNICAL SERVICE BULLETIN: MDPS WARNING LAMP DIAGNOSTIC INSPECTION & SINGLE PARTS REPLACEMENT - This bulletin provides information regarding the diagnosis of Motor Driven Power Steering (MDPS), also known as Electronic Power Steering (EPS)

010000 STEERING

060000 ENGINE AND ENGINE COOLING

TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA/KAPPA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. Th

010000 STEERING

WARRANTY EXTENSION: OWNER NOTIFICATION - This document is the notification to owners of the warranty extension program for WTY023. Kia is extending the New Vehicle Limited Warranty coverage for repairs related to the Motor Driven Power Stee

010000 STEERING

061500 ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION

060000 ENGINE (PWS)

010000 STEERING

WARRANTY EXTENSION: QUESTION AND ANSWER - This document is the Question and Answer Guide containing the most frequently asked questions regarding the warranty extension (WTY023). Kia America, Inc., is extending the New Vehicle Limited Warra

010000 STEERING

WARRANTY EXTENSION: DEALER PARTS AND SERVICE MANAGER MEMO - This document is the announcement to the dealer Parts and Service Managers of the warranty extension program for WTY023. Kia America, Inc., is extending the New Vehicle Limited War

010000 STEERING

WARRANTY EXTENSION: DEALER PRINCIPAL MEMO - This document is the announcement to the dealer principals of the warranty extension program for WTY023. Kia America, Inc., is extending the New Vehicle Limited Warranty coverage for the Motor Dri

016000 STEERING:ELECTRIC POWER ASSIST SYSTEM

110000 ELECTRICAL SYSTEM

016000 STEERING:ELECTRIC POWER ASSIST SYSTEM

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

PRODUCT IMPROVEMENT CAMPAIGN: ENGINE REPLACEMENT INSTRUCTIONS FOR DTC P1326 (PI1802Y/Z) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin are

356000 EQUIPMENT ADAPTIVE/MOBILITY

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

117000 ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

This bulletin provides information regarding test procedure of the Bearing Clearance Tester (BCT) Special Service Tool (SST). The SST comes pre-calibrated from the supplier however, in some cases, due to variable shop compressor air pressur

350000 EQUIPMENT

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

356000 EQUIPMENT ADAPTIVE/MOBILITY

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

010000 STEERING

TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF C-MDPS MOTOR, ECU, WORM GEAR AND/OR STEERING COLUMN HOUSING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar

160000 STRUCTURE

TECHNICAL SERVICE BULLETIN: INFORMATION FOR HEADLAMP CONDENSATION AND MOISTURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This b

120000 EXTERIOR LIGHTING

060000 ENGINE AND ENGINE COOLING

100000 POWER TRAIN

TECHNICAL SERVICE BULLETIN: 7-SPEED DUAL CLUTCH TRANSMISSION (DCT) ANTI-JUDDER LOGIC IMPROVEMENT - This bulletin provides the procedure to update the software logic of the Dual Clutch Transmission (DCT) system on some 2016-2020MY Optima (JF

100000 POWER TRAIN

TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the mar

356000 EQUIPMENT ADAPTIVE/MOBILITY

TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR OF THE DUAL PINION MOTOR DRIVER POWER STEERING SYSTEM - This bulletin provides information regarding the availability of partial repair (depending on faulty components) of the Dual Pinion Motor Dri

350000 EQUIPMENT

010000 STEERING

260000 FORWARD COLLISION AVOIDANCE

PITSTOP: FRONT RADAR SENSOR MOUNTING INSPECTION (PS704) - This pitstop provides information regarding front radar sensor alignment on 2014MY and later vehicles that may exhibit a warning light ON related to radar sensor alignment errors in

110000 ELECTRICAL SYSTEM

010000 STEERING

130000 VISIBILITY

TECHNICAL SERVICE BULLETIN: WINDOW REGULATOR DRUM GEAR REPLACEMENT - This bulletin provides the procedure to replace the window regulator drum gear on some 2016-2017MY Optima (JFa) vehicles, produced from September 01, 2015 through July 31,

060000 ENGINE AND ENGINE COOLING

TECHNICAL SERVICE BULLETIN: EXCESSIVE OIL CONSUMPTION NU/GAMMA/THETA ENGINES - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bul

350000 EQUIPMENT

060000 ENGINE AND ENGINE COOLING

350000 EQUIPMENT

TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed on the table

100000 POWER TRAIN

010000 STEERING

110000 ELECTRICAL SYSTEM

010000 STEERING

060000 ENGINE AND ENGINE COOLING

110000 ELECTRICAL SYSTEM

060000 ENGINE AND ENGINE COOLING

010000 STEERING

110000 ELECTRICAL SYSTEM

PITSTOP: MFC, CONCERNS FOR DISABLED OPERATION - This Pitstop provides information regarding concerns with disabled operation of Multi-Function Camera (MFC) on some Kia vehicles. When normal operation is not possible due to certain outside e

136000 VISIBILITY:WINDSHIELD WIPER/WASHER

PITSTOP: CORRECT PROCEDURE FOR RAISING WINDSHIELD WIPERS - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. When servicing windshield wi

130000 VISIBILITY

034510 SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER

PITSTOP - BRAKE CALIPER LEAK INSPECTION - This PITSTOP provides information related to a brake caliper fluid/oil substance found on some Kia vehicles, due to possible excess assembly oil applied during assembly.

350000 EQUIPMENT

TECHNICAL SERVICE BULLETIN: IBAU SYSTEM REPAIR FOR NOISE AND AIR BLEEDING - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulle

Showing 100 of 235 bulletins.

NHTSA Safety Investigations, KIA OPTIMA

Investigations opened by NHTSA into potential safety defects. These are separate from recalls and may or may not result in a recall.

PE, Closed , Model Year: 2011

Non-crash Vehicle Fires

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optim... Read more

RQ, Closed , Model Year: 2011

Scope and Timeliness

NHTSA opened Recall Query (RQ) 17-003 to investigate the timeliness and scope of Kia?s Theta II GDI engine recall (Recall No. 17V-224), and Kia?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Kia to administratively resolve NHTSA?s asserti... ons of violations of law in connection with RQ17-003. NHTSA?s assertions included that Kia may be liable for civil penalties on multiple grounds, including that Recall No. 17V-224 was untimely and Kia?s recall report contained certain inaccuracies.Under the Consent Order, Kia agreed to a total civil penalty of $70,000,000. The total civil penalty included a payment of $27,000,000 as a Non-Deferred Amount.Kia also agreed to a sum of $27,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order.Kia also agreed to a $16,000,000 Performance Obligation Amount to be expended by Kia to fulfill specified Safety Data Analytics Infrastructure obligations. The Consent Order also includes other terms designed to enhance Kia?s safety practices, and requires Kia to retain a Third-Party Auditor who directly reports to NHTSA.Other than RQ17-003, the Consent Order is not intended to affect any other current or future investigation of NHTSA which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-004) continues NHTSA?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Kia from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with the law, and to initiate a recall upon any future determination by Kia, or upon any finally adjudicated order from NHTSA, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Kia's ongoing performance obligations, and does not represent a determination by the agency as to Kia's performance under the Consent Order to date.Read more

PE, Closed , Model Year: 2006

Transmission Shift Cable Detachment

During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift ... Read more

EA, Closed , Model Year: 2001

POWER DOOR LOCK FAILURE

INVESTIGATION FAILED TO DISCLOSE A MALFUNCTION WITH A CLEAR AND CONSISTENT PATTERN OF COMPROMISE TO MOTOR VEHICLE SAFETY.FAILURE OF THE SUBJECT DOOR LOCKS MAY IMPEDE NORMAL EGRESS OF A VEHICLE OCCUPANT BUT DOES NOT ENTRAP THE OCCUPANT.COMPLAINTS AND WARRANTY DATA DOCUMENT THE DEFICIENCIES OF THE DOO... Read more

PE, Closed , Model Year: 2001

POWER DOOR LOCK FAILURE

THIS PE DISCLOSED THAT THE SUBJECT VEHICLES HAVE EXPERIENCED INCIDENTS OF THE ALLEGED DEFECT IN SIGNIFICANT NUMBERS.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-030) TO FACILITATE A THOROUGH REVIEW OF THE MATTER, INCLUDING EVALUATION OF THE POTENTIAL SAFETY-RELATED CONSEQUENCES.

KIA OPTIMA - All Years Overview

Complete safety history for the KIA OPTIMA across all model years (2001, 2019).

59 Total Recalls

10,397 Total Complaints

5 Investigations

536 Reported Crashes

485 Reported Fires

24 Reported Deaths

KIA OPTIMA - Year by Year

Compare recalls and complaints across model years. Click any year to see full details.

Year	Recalls	Complaints
2020	0	211	View
2019	1	321	View
2018	2	334	View
2017 (current)	3	355
2016	5	1,079	View
2015	4	1,403	View
2014	7	791	View
2013	9	1,889	View
2012	5	1,263	View
2011	5	781	View
2010	1	99	View
2009	1	166	View
2008	3	188	View
2007	2	218	View
2006	2	214	View
2005	0	180	View
2004	1	306	View
2003	2	190	View
2002	3	168	View
2001	3	231	View

Other KIA Models

Model	Recalls	Complaints
SORENTO	188	13,593	View
SPORTAGE	165	6,601	View
SEDONA	118	3,350	View
TELLURIDE	70	2,186	View
SOUL	66	7,233	View
SORENTO HYBRID	62	159	View
SOUL EV	62	50	View
FORTE	56	3,494	View

Vehicle Safety

Consumer Safety

Infrastructure

Public Health

2017 KIA OPTIMA

Complaint Statistics

Top Reported Components

NHTSA Safety Ratings, 2017 KIA OPTIMA

Safety Technology

EPA Fuel Economy, 2017 KIA OPTIMA

Technical Service Bulletins, 2017 KIA OPTIMA

Most Affected Components

NHTSA Safety Investigations, KIA OPTIMA

KIA OPTIMA - All Years Overview

KIA OPTIMA - Year by Year

Other KIA Models