2014 HYUNDAI SANTA FE SPORT Recalls, Complaints & Safety

The passenger-side doors do not latch properly and may open after closing. This creates a safety risk while driving. The issue occurs continually and has worsened over time. Vehicle has approximately 106,265 miles. this causes the auto door locks no to work.

Knock sensor p1326 service code engine light on

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and blinked intermittently. The contact stopped at a gas station. The contact filled up the fuel tank and checked the coolant reservoir. When the contact restarted the vehicle, there was an abnormal sound coming from the engine. The vehicle failed to accelerate as intended while depressing the accelerator pedal. The vehicle failed to exceed 30 MPH without shaking or vibrating. The check engine warning light remained illuminated. The vehicle was taken to an independent mechanic who diagnosed that the engine had failed and needed to be replaced. The engine coils or the starter sensor and the O2 sensors were replaced before the independent mechanic informed the contact that the engine had failed. The vehicle was not repaired. The vehicle was then taken to the dealer, where it was confirmed that the engine had failed. The contact was informed that the vehicle was under a service warranty and the vehicle would be repaired. The manufacturer was made aware of the failure. However, the manufacturer refused to replace the engine and offered the contact monetary compensation. The vehicle was not repaired. The failure mileage was approximately 167,000.

Engine seized while driving. Recall-covered failure mode. Hyundai denial despite recall. Screenshots showed recall with VIN for engine recall and suddenly removed by Hyundai next day.

I dont know the exact component that's failed, but it is consuming way too much oil, i have to put a quart in just about everytime i drive it. When i took it the dealership to find out if it was leaking, or burning oil, they literally charged me 200 to tell me it was either leaking oil or burning it. I personally think it is burning vs leaking, because there isnt oil in my drive way. I then spoke to some one on their YouTube channel that told me to call and tell them my story and they should help me out. I did that but no one ever contacted me about the complaint. It's smokes from the engine and i feel like its just a matter of time before it blows up or catches fire. Even though I can hear the engine ticking and struggle the check engine light is not on. From what I've seen this is a known issue that they are ignoring, even though MANY people have complained. This engine has already been replaced in 2018, and the new one is going bad prematurely as well.

Gas is purging from the top of the fuel pump

I purchased this vehicle in November 2022. Hyundai and all affiliates were well aware of the engine recall. I was NEVER informed of the recall, if I was, logically I never would have purchased it. This is fraud by Toyota South in Richmond Kentucky. 6 months or so after purchasing, I began noticing the oil loss, without any oil on the ground where I park the vehicle. I researched and found the recall. I fought with the dealership and Hyundai corporate for 4 months before they said they would replace the engine with a new engine, I was told this early November 2023. I received my car back on 11/24/23. I was told the new engine came with a 12,000(?) mile warranty. I am still looking for this paperwork and will have it available soon. Fast forward to September 2025, as I am driving on I75N to Lexington from Berea, my car shudders and a smoke cloud larger than my vehicle appears behind my car. I check my oil and I am down 2 quarts, which I thought was odd considering I had checked it 2-3 weeks prior to this. I checked it in another week, and it is down 2 quarts again!! There is still no leakage, no oil on the ground, immediately I knew it was another recalled engine. Which is beyond comprehension, why would Hyundai replace a recalled engine, with a recalled engine?? So I go to the dealership and am told I have to do the 3 stage consumption test, drive 1000 miles or be down 1.5 quarts and come back. I was back within 2 days, I drove 150(?) miles and was down 1.5 quarts. The dealership and Hyundai determined the oil consumption issue is present, meaning its a recalled engine. Through phone calls with Hyundai I was told it is also remanufactured, but if you recall, I was told it was a NEW engine. Fraud #2. They refuse to fix it. This is the only vehicle in my household, and my means for income. Hyundai is costing me the right to live, the right to work. They are despicable, awful people to work with. The constant threat of fire is very stressful!!

The stationary glass that is in front of the panoramic sunroof shattered for no reason. I found that this has happened to many other people's vehicle like mine. In several incidents, the glass chips fell on passengers in the car when they opened the sunroof. I had a glass repair shop look at it. It will cost $400.00 out of pocket and I don't really want to file a claim to insurance. Can you offer any help?

What happened: While driving in Montana on September 21, 2025, the cabin suddenly filled with gasoline fumes and the accelerator pedal stopped responding. After pulling over, flames erupted from under the hood and the vehicle was completely destroyed within minutes. The passenger-side door could not be opened from the inside at first, delaying escape and creating a serious safety risk. No warning lights or messages appeared before or during the fire. (1) While driving, gasoline suddenly filled the cabin and the accelerator pedal stopped responding. Within seconds, the vehicle caught fire. The cause appears related to the fuel system, and possibly the ABS module. The vehicle was completely destroyed but remains available for inspection in a private tow lot. (2) The fire spread extremely quickly. Both occupants were nearly trapped inside when the passenger-side door would not open from the inside, delaying escape. The vehicle burned on the shoulder of a busy highway in Montana, posing danger to us and to surrounding motorists. (3) Not after this fire, but a similar problem occurred in 2023 when gasoline filled the cabin and caused the engine to stall. At that time, Hyundai replaced the engine under warranty. (4) No. The vehicle has not yet been inspected by the manufacturer, police, or insurance. It is secured in a private tow lot and is available for inspection. (5) No. There were no warnings at all before or during the failure. Even as gasoline filled the cabin and the vehicle caught fire, the check engine light stayed off and no alerts appeared. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fire

What happened: While driving in Montana on September 21, 2025, the cabin suddenly filled with gasoline fumes and the accelerator pedal stopped responding. After pulling over, flames erupted from under the hood and the vehicle was completely destroyed within minutes. The passenger-side door could not be opened from the inside at first, delaying escape and creating a serious safety risk. No warning lights or messages appeared before or during the fire. (1) While driving, gasoline suddenly filled the cabin and the accelerator pedal stopped responding. Within seconds, the vehicle caught fire. The cause appears related to the fuel system, and possibly the ABS module. The vehicle was completely destroyed but remains available for inspection in a private tow lot. (2) The fire spread extremely quickly. Both occupants were nearly trapped inside when the passenger-side door would not open from the inside, delaying escape. The vehicle burned on the shoulder of a busy highway in Montana, posing danger to us and to surrounding motorists. (3) Not after this fire, but a similar problem occurred in 2023 when gasoline filled the cabin and caused the engine to stall. At that time, Hyundai replaced the engine under warranty. (4) No. The vehicle has not yet been inspected by the manufacturer, police, or insurance. It is secured in a private tow lot and is available for inspection. (5) No. There were no warnings at all before or during the failure. Even as gasoline filled the cabin and the vehicle caught fire, the check engine light stayed off and no alerts appeared. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fire

What happened: While driving in Montana on September 21, 2025, the cabin suddenly filled with gasoline fumes and the accelerator pedal stopped responding. After pulling over, flames erupted from under the hood and the vehicle was completely destroyed within minutes. The passenger-side door could not be opened from the inside at first, delaying escape and creating a serious safety risk. No warning lights or messages appeared before or during the fire. (1) While driving, gasoline suddenly filled the cabin and the accelerator pedal stopped responding. Within seconds, the vehicle caught fire. The cause appears related to the fuel system, and possibly the ABS module. The vehicle was completely destroyed but remains available for inspection in a private tow lot. (2) The fire spread extremely quickly. Both occupants were nearly trapped inside when the passenger-side door would not open from the inside, delaying escape. The vehicle burned on the shoulder of a busy highway in Montana, posing danger to us and to surrounding motorists. (3) Not after this fire, but a similar problem occurred in 2023 when gasoline filled the cabin and caused the engine to stall. At that time, Hyundai replaced the engine under warranty. (4) No. The vehicle has not yet been inspected by the manufacturer, police, or insurance. It is secured in a private tow lot and is available for inspection. (5) No. There were no warnings at all before or during the failure. Even as gasoline filled the cabin and the vehicle caught fire, the check engine light stayed off and no alerts appeared. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fire

Owner: [XXX] VIN: [XXX] Vehicle: 2014 Hyundai Santa Fe Sport My daughter purchased this vehicle in April 2025 from a licensed Chrysler dealership. On [XXX], the engine suddenly seized while driving, without warning, and would not restart. This VIN was part of Recall 17V-226 (Hyundai Campaign 162). Dealer records show the recall was closed with inspection only (“engine inspection, oil, dipstick”), not an engine replacement. The failure matches the defect description of the recall (bearing wear from restricted oil flow). Hyundai is refusing to repair it, claiming sludge and “maintenance neglect,” despite my daughter only owning it for 5 months and having an oil change at Hyundai in May 2025. This engine failure proves the prior “inspection” remedy was ineffective. Hyundai is also denying coverage under the lifetime warranty extension (TXXI), which explicitly applies to subsequent owners for bearing failures. This is a serious safety issue. My daughter lost power in traffic, and the vehicle is still unrepaired. This complaint is being submitted on behalf of the registered owner, [XXX] , by her mother [XXX] , who is the primary contact. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on a steep, narrow grade with no safe shoulder, my 2014 Hyundai Santa Fe Sport suddenly lost all forward power. The engine would rev but the vehicle would not accelerate. I was left stranded in traffic, with cars behind me and nowhere safe to pull off, creating an immediate risk of being rear-ended or rolling back into other vehicles. I had to call for a tow to avoid a serious crash. The vehicle was marked as having all recall campaigns completed, including the rod bearing inspection and knock sensor update, which were supposed to protect against catastrophic engine failure. Clearly, those campaigns were not sufficient to prevent the failure I experienced. At the time of failure, the vehicle displayed the check engine light and drivability symptoms consistent with abnormal combustion and potential bearing damage. Hyundai denied lifetime warranty coverage under the Theta II engine settlement without performing the required inspection. Instead, I was left with an estimate for engine-related repairs that exceeded the value of the vehicle, effectively rendering it a total loss. This failure is exactly what Hyundai’s recall notices describe as a risk: sudden engine failure, loss of motive power, and increased risk of crash. The fact that this happened to my vehicle despite “completed” recall campaigns raises serious concerns about whether the defect remains unresolved and whether Hyundai is adequately honoring its recall and settlement obligations. I am requesting that NHTSA investigate whether Hyundai is improperly denying warranty coverage without inspection and whether vehicles that were marked as repaired under these recalls are still at risk of catastrophic engine failure, stalling, and loss of motive power on public roads. The settlement administrator also works for Hyundai is just referring customers back to Hyundai Customer Care. They are not honoring this CLASS ACTION lawsuit and acting in BAD faith and putting lives at risk.

My drivers side door opened while driving. The latch wouldn’t allow me to close my door.

Loud knocking sound. Vehicle in Limp Mode. Blinking CEL - Error code P1326 VIN - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2014 Hyundai Santa Fe Sport suffered a blown head gasket that required me to pay $9,000 for a full engine replacement. Hyundai is aware of ongoing problems with their 2.0 turbo motors, but the recall only covers the rod bearing failure/knock sensor issue. Many owners, including myself, are experiencing blown head gaskets, and several believe this failure is directly related to the same underlying engine defect. This is not an isolated case—numerous complaints online and in owner forums describe the same problem. Despite the high repair cost and known engine vulnerabilities, Hyundai refuses assistance because my vehicle is outside the mileage limit, even though the defect is widely reported and appears to be a design/manufacturing issue, not normal wear and tear. I believe NHTSA should investigate whether the head gasket failures in these 2.0 turbo engines are linked to the same defect that prompted Hyundai’s engine recalls, as it presents significant safety risks (engine overheating, sudden power loss, potential for fire). In 2018, the Center for Auto Safety formally petitioned the NHTSA to investigate 2011–2014 Hyundai Santa Fe models (among others) due to a high number of non-collision fire complaints, including reports of melted wires, smoke, and burning odors in the engine bay . While this isn’t directly about head gasket failures, it underscores a pattern of serious safety-related issues affecting that generation of Santa Fe vehicles.

Vehicle is only 10 years old and barely has 120k miles on it. Consistent maintenance and oil changes are done. My son was driving on the highway and the vehicle died suddenly and coasted to the side of the road. We had it towed to a repair shop and after some testing they said the engine has seized up. Most likely related to the common rod bearing issue with these motors, but this is not on the recall for some reason. This should not happen on a car with so low miles and use! Luckily my son was safe and not in an accident when this happened.

Hello, To whom this may concern, The ABS light turned on the dashboard on a Tuesday evening. My wife kept driving. In the next couple of days, it would feel like the car was all over the road, under braking. It seemed very hard to take off. On Friday, I was outside and heard the car was making a noise. As an automotive technician, I knew the ABS module was cycling nonstop. I pulled the fuse out of the fuse panel to make sure it wouldn't catch fire. We took the car back to the dealer when the bulletin came out for these cars catching fire due to an ABS issue years ago. I went to the dealer on that Saturday and informed them of the ABS module cycling nonstop. They told me that the bulletin had been done already and there was nothing they could do for me. I called Hyundai customer support, and they forced me to pay a diagnostic charge of $220 to tell me it was a failure internally in the ABS module and that they wouldn't cover the repairs. I found it very surprising that Hyundai only had to change a fuse to prevent cars from catching fire. It doesn't make sense to me how the NHTSA allowed them to only change a fuse and not the module that Hyundai said was faulty. This puts every car that I drive next to in danger, with the module going off nonstop while I drive down the road. This has all happened in the last month. Please hold Hyundai truly accountable for this nonsense. It is unacceptable that they can get away with just changing a fuse to prevent a fire, and not fix the actual issue, the ABS module. Thank you,

January 2024, my 2014 Hyundai Santa Fe entered limp mode and displayed code P1326—known to indicate engine bearing failure under Hyundai Recall 162. I took it to Terry Reid Hyundai (Cartersville, GA), paid $175 for diagnostics, and was told the vehicle “passed.” However, I was never given a bearing clearance test (BCT) result, and no VIN-tied data was submitted to Hyundai’s internal WebDCS system, as required by TSB 23-EM-001H. Later communication with Hyundai confirmed that all BCT results—pass or fail—must be submitted and tied to the VIN in WebDCS, yet Terry Reid produced no record. Instead, they provided a blank Multi-Point Inspection (MPI) sheet and handwritten notes—none of which constitute a BCT or fulfill Hyundai protocol. In April 2025, the engine failed catastrophically. Shottenkirk Hyundai performed a proper BCT, revealing cylinder #2 at 1.13mm (well beyond failure limit), and submitted both the test and an oil sample to the lab. The oil analysis showed no sludge, fuel, or coolant contamination, contradicting Veritas Global Protection’s and Hyundai’s claim of owner neglect. Despite clear lab evidence, Veritas denied my claim, falsely asserting: The sludge existed before contract purchase (no proof), No rod bearing clearance documentation was submitted (Shottenkirk did), A prior P0420 code related to the catalytic converter caused sludge (mechanically inaccurate). Hyundai’s consumer affairs rep later claimed internal records can’t be shared, that even more evidence wouldn’t matter, and that Hyundai branded the engine based on “exceptional neglect” solely due to one missing oil change receipt—despite a clean oil report and lack of dealership testing. She also confirmed Hyundai does not notify consumers when engines are branded.This pattern shows coordinated misrepresentation between Hyundai, Veritas, and Terry Reid Hyundai. They failed to follow protocol, withheld required data, falsely blamed the consumer, and denied a legitimate claim despite lab evidence

I closed my door and the driver door latch became stuck and will no longer open from the inside or outside. I have tried to open it myself, ask a mechanic and a locksmith and no one can open the door without damaging the door.

On June 22 2025 while driving on Interstate 17, the vehicle engine started to lose power and the engine light started to flash on and off. Pulled over and the vehicle stalled and was not able to turn on again. The vehicle is available for inspection. Safety was a concern as we had to change over 3 lanes as we were losing power. The problem has been confirm that the engine has failed and they are numerous TSBs out for engine failure on the Theta II engines, vehicle also qualifies for 15yr/150K engine warranty. The vehicle engine is branded which is a manufacturer defect and never was replaced. The vehicle was towed by AAA to a AAA repair shop and said diagnosis was given thereafter vehicle was towed to dealership which it currently sit at. However Hyundai denied claim because service record was not provided (I was not the owner of vehicle on the years they are requesting) I do have my records from when I owned the vehicle however service advisor stated I did not need to provide my records since they dated back to where I didn't owned vehicle. I purchase vehicle from a dealership. If any more information is needed please advis. I would just like my engine replaced.

Engine failure and metal debris and timing belt slipped time. Loss of power and we parked it flashing engine light. Massey Hyundai said it’s not a recall but when I research there’s a lot of engine failure recalls so I’m not quite understanding what the situation is and we still owe money on the vehicle. They basically told us to junk it. This has been the worst situation I have ever went through with a vehicle. I’ve never owned a Hyundai and I probably never will ever buy another Hyundai. I just wanna know why my engine failed and nobody can tell me why Massey hundai cannot tell me why. they just want me to remove it from their service center or they’re gonna charge me $500 to dispose of it. I’ve never heard of such stuff in my life. This is too overwhelming, especially when it happened. My daughter just had reconstructive foot ankle surgery and has pins in her foot. We were stranded an hour and a half away from home at a doctors appointment for a check up for her foot. Our Insurance towed it, but left us standing and hundred degree weather which was a complete nightmare, especially when you have someone that can’t walk and just had surgery not that that’s any of your fault. I just want to know why my engine failed why there was metal debris why can’t no one tell me. $10,000 for a new motor or charge you $500 to remove it from our lot. I can’t even lie about this stuff. It’s insane. I still owe money on the vehicle. I had to refinance it during Covid. If you could just like, give me some sort of information I don’t even know where to turn to at this point and if I can’t turn to the dealership, who do I turn to.

Seat belt has been fraying for years and has not return to original position on the I-beam when not being used. Repair shops say it’s normal for vehicle.

My 2014 Hyundai Santa Fe Sport 2.0 Turbo suffered a complete engine seizure while driving due to a blown head gasket, which caused all coolant to leak out. The engine locked up suddenly while my daughter was operating the vehicle, creating a serious safety hazard. She was fortunate to pull over safely, but this type of failure could have resulted in a crash. I was forced to pay over $9,000 for a full engine replacement. This engine is the Theta II 2.0L Turbo GDI, which is part of multiple class action lawsuits and safety recalls due to engine seizure, bearing failure, and fire risk. Hyundai Customer Care has refused to assist or reimburse me. This failure involved no prior warning signs, and the gasket failure appears to be consistent with design flaws already documented in these engines. I am submitting this complaint as I believe this is a defect that poses a safety risk, especially given how suddenly the engine failed during normal driving.

I was on an expressway with 70 mph speeds and could only drive at 55 mph. A flashing motor light came on and then a thunking/clicking sound. It would not accelerate and also lunging. Towed to an independent mechanic close to where I was who confirmed blown engine. Having towed to Hyundai dealership.

Engine seized

Engine is burning oil at a rapid rate. Completed oil change on 12/6/2024 at 94380 miles. On [XXX] check engine light came on at 96684 miles. Dipstix Oil Change checked oil level and level was at least 2 quarts low. Dipstix Oil Change filled oil reservoir. On [XXX], check engine light came back on. SUV was taken to AutoZone and computer said light was due to bad oxygen sensor. Deal's Auto changed oxygen sensor for $557 on 2/24/2025 at 96708 miles. On [XXX], check engine light came back on and engine had a knocking noise. Vehicle was towed to Hyundai in Batesville, MS on 4/17/2025 for $498. Engine was checked by Hyundai on 5/23/2025. Oil level was at least 2 quarts low and dealership recommended an oil change (paid by me) to see if there is oil consumption. I live 8 hours from dealership and already know there is oil consumption. Dealership wants to simply get the vehicle off their hands and is placing consumer at risk with lazy diagnosis. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am submitting this complaint regarding a serious engine defect in my 2014 Hyundai Santa Fe, which suffered rod bearing failure and now requires a full engine replacement at a cost of approximately $8,600. This failure occurred on April 13, 2025, despite regular oil changes and proper maintenance throughout my 1 year and 7 months of ownership. According to my certified mechanic, the vehicle was evaluated using Hyundai’s own rod bearing clearance test protocol, which it failed. The results were submitted to Hyundai by the repair shop, but the manufacturer denied the claim—despite their own diagnostic test confirming the issue. I later discovered that my vehicle may fall under NHTSA Campaign Number 17V226000 (Recall 162), which addresses machining errors in the Theta II GDI engine that can cause premature bearing wear. I am requesting that NHTSA investigate whether my vehicle should be formally included in this recall or covered under Hyundai’s extended warranty program for rod bearing failures. This issue represents a serious safety risk. The engine began knocking suddenly, without any warning lights or codes, and still had another month or 1,419 miles left till next service and oil level was normal. Vehicle had to be towed to a service facility. A failure while driving could have resulted in a complete engine seizure, placing my family and others at risk. I respectfully request that NHTSA review this issue and investigate Hyundai’s handling of such claims, especially where their own testing confirms a known defect.

I own a 2014 Hyundai Santa Fe Sport 2.0T which has had door latch issues. Recently, the front passenger side door latch needed to be fully replaced due to a failure which caused the door to be loose latching and the latch sensor always showing open. I paid out-out-pocked for this repair as the Hyundai dealership said there are models which this exact issue was identified, but they said the parts extension had not been placed for my exact vehicle. They were also confused as to why this was not being covered as they see so many of these same repairs. Now, less than one month later, the front driver's side door is now experiencing lock issues in which a loud grinding noise is occurring when the vehicle attempts to lock or unlock the door. Additionally, the door does not unlock some of the time from the external and the manual door handle on the interior is getting harder and harder to open. Both of these issues are consistent with other recalls for other Hyundai models and consistent with the door latch module and actuator failure. I would like to file a complaint regarding this issue as it seems to be a common issue with Hyundai models using this door latch module. I believe the parts extension and repairs for these door latches should be covered by Hyundai especially as this becomes a large safety issue with driving the vehicle with concerns of door latch stability and security.

Parts of the ABS system under the hood burned, while the vehicle was parked in my garage, affecting electrical and other parts. I found information online about a recall for this same problem. I have never received a notification of this recall before. I went that same day [XXX] to my local dealer. They gave me an appointment for service for the next day and left the vehicle with them on 04/03/2025. I called the dealer after one week and they told me they already verified the vehicle and notified Hyundai company and are waiting for them to approve the repair. I called the dealer again today 04/23/2025, after 3 weeks and the they told me they are “still waiting for Hyundai Company to approve the repair. That they don’t know how much time this may take and that it may take a lot more time”. In the meantime, and after the bad and risky experience, I have one car less in my house. I understand this is a process but also, considering that this was caused by a factory defect I understand they should be responsible and solve the problem in a timely manner. Thank you. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fire

Parts of the ABS system under the hood burned, while the vehicle was parked in my garage, affecting electrical and other parts. I found information online about a recall for this same problem. I have never received a notification of this recall before. I went that same day [XXX] to my local dealer. They gave me an appointment for service for the next day and left the vehicle with them on 04/03/2025. I called the dealer after one week and they told me they already verified the vehicle and notified Hyundai company and are waiting for them to approve the repair. I called the dealer again today 04/23/2025, after 3 weeks and the they told me they are “still waiting for Hyundai Company to approve the repair. That they don’t know how much time this may take and that it may take a lot more time”. In the meantime, and after the bad and risky experience, I have one car less in my house. I understand this is a process but also, considering that this was caused by a factory defect I understand they should be responsible and solve the problem in a timely manner. Thank you. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fire

Parts of the ABS system under the hood burned, while the vehicle was parked in my garage, affecting electrical and other parts. I found information online about a recall for this same problem. I have never received a notification of this recall before. I went that same day [XXX] to my local dealer. They gave me an appointment for service for the next day and left the vehicle with them on 04/03/2025. I called the dealer after one week and they told me they already verified the vehicle and notified Hyundai company and are waiting for them to approve the repair. I called the dealer again today 04/23/2025, after 3 weeks and the they told me they are “still waiting for Hyundai Company to approve the repair. That they don’t know how much time this may take and that it may take a lot more time”. In the meantime, and after the bad and risky experience, I have one car less in my house. I understand this is a process but also, considering that this was caused by a factory defect I understand they should be responsible and solve the problem in a timely manner. Thank you. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Fire

The engine was replaced under a recall related to an engine knock code. About two weeks later, the vehicle lost all power while driving. The dealership confirmed a failure in the high-pressure fuel line and that the turbo had failed at the same time. The same visit revealed oil leaks, and shortly after, the vehicle began emitting white and black smoke. Their technician stated the failures were due to “consequential damage from engine failure.” The problems have continued to return, and I’ve been told the vehicle is unsafe to drive. Hyundai is now refusing to fully cover the cost of repair, offering only 15% off, despite all of the damage being directly linked to the replacement engine. I transport children in this vehicle. My safety and theirs have been at risk multiple times because of these unresolved and ongoing failures.

Fire

The engine was replaced under a recall related to an engine knock code. About two weeks later, the vehicle lost all power while driving. The dealership confirmed a failure in the high-pressure fuel line and that the turbo had failed at the same time. The same visit revealed oil leaks, and shortly after, the vehicle began emitting white and black smoke. Their technician stated the failures were due to “consequential damage from engine failure.” The problems have continued to return, and I’ve been told the vehicle is unsafe to drive. Hyundai is now refusing to fully cover the cost of repair, offering only 15% off, despite all of the damage being directly linked to the replacement engine. I transport children in this vehicle. My safety and theirs have been at risk multiple times because of these unresolved and ongoing failures.

Fire

The engine was replaced under a recall related to an engine knock code. About two weeks later, the vehicle lost all power while driving. The dealership confirmed a failure in the high-pressure fuel line and that the turbo had failed at the same time. The same visit revealed oil leaks, and shortly after, the vehicle began emitting white and black smoke. Their technician stated the failures were due to “consequential damage from engine failure.” The problems have continued to return, and I’ve been told the vehicle is unsafe to drive. Hyundai is now refusing to fully cover the cost of repair, offering only 15% off, despite all of the damage being directly linked to the replacement engine. I transport children in this vehicle. My safety and theirs have been at risk multiple times because of these unresolved and ongoing failures.

Fire

Car hesitates, lagging at stop lights/slow traffic has completely shutdown while moving in traffic. Several episodes include complete shut down unable to crank following a stop multiple times in last 7 months. 2 Hyundai Dealerships have not been able to duplicate or repair specific issues or stop from occurring. Other repairs were attempted by Dealerships in efforts to correct problems. Car has been towed 5 times under extended warranty.75K- 83K miles. Battery discharge warning still appears even after new battery, plus other engine parts were replaced. Anxiety PTSD is my status.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated while driving 55 MPH, the engine seized. The contact stated that several unknown warning lights were illuminated. The contact pulled over to the side of the roadway. The vehicle failed to restart and was towed to the local dealer, where it was diagnosed that the ring around the engine needed to be replaced. There was an excessive amount of oil leaking. The vehicle was repaired. The manufacturer was contacted by mail and phone, and a complaint was filed. The failure mileage was approximately 120,000.

The contact owns a 2014 Hyundai Santa Fe Sport. While the contact's son was driving 70 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle lost motive power. The vehicle was driven to the shoulder of the road and the vehicle was turned off. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 83,000.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated while driving approximately 55 MPH, the vehicle started losing motive power. The contact coasted off to the side of the road. The contact stated that the vehicle stalled. The contact stated that several warning lights had illuminated on the instrument cluster. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that a rod bearing had failed, and the engine needed to be replaced. The vehicle was not repaired. The contact stated that prior to the engine failure the contact observed that the vehicle was consuming an excessive amount of engine oil. The contact was adding approximately 1-quart of oil every week. The manufacturer was informed of the failure. The failure mileage was approximately 196,000.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated while driving at approximately 70 MPH, the vehicle stalled, and the RPMs dropped. There was no warning light illuminated. A Police Officer responded and there was an abnormally strong chemical odor present. The vehicle was towed to the residence. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that while his wife and daughter were driving, the vehicle unexpectedly decelerated to approximately 25 MPH. The contact stated that the check engine warning light was illuminated. The contact's wife was able to pull the vehicle to the side of the road. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the local dealer was in contact with the manufacturer. The contact related to the failure with the Technical Service Bulletin: 19-01-002H-1 (Engine Monitoring Logic Product Improvement). The failure mileage was approximately 185,000.