2023 FORD MAVERICK HYBRID Recalls, Complaints & Safety

While driving highway speeds the vehicle suddenly lost power. Had to immediately pull to the shoulder of the highway with heavy traffic that got very close to my rear bumper due to the sudden decrease in speed. There was no advance warning of power loss. Upon stopping on the shoulder the vehicle was put in park and the key turned to the off position. After a short wait the ignition key was turned to the on position and was able to resume trip at highway speeds. Notified Ford close to my location and it was checked for fault codes and road tested with no defect found., Now concerned that the vehicle might fail again day or night leaving us stranded or causing a vehicle accident due to the sudden reduction in speed.

I am reporting a premature and dangerous failure of the front CV (Constant Velocity) axle assembly on my 2023 Ford Maverick. While driving at 50 mph the vehicle began experiencing violent, uncontrollable shaking and shuddering in the front end, particularly under acceleration. This is an issue which affects all Mavericks for this model year. Ford has recalled/reimbursed replacements for the 2022 model year but not other ones yet. This failure causes significant instability and compromises steering control, creating a high risk of a crash when merging into traffic or maintaining highway speeds. The vibration is severe enough to distract the driver and could lead to a total loss of motive power if the axle snaps or the joint fully separates.

When driving at higher speeds (60-70mph) and needing to pass another vehicle the clutch slips which triggers the accelerator to shut down. Leaving you helpless in the passing lane. All you can do is hope there is space to safely pull off the road and shut the engine off. This puts it in limp mode.

AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The 2023 Ford Maverick Hybrid is experiencing a recurring safety failure of the Front CV Axle Shafts. The vehicle exhibits violent, uncontrollable shaking of the front end during acceleration at highway speeds (40–65 MPH). This severe vibration compromises vehicle stability and steering control, creating a significant safety risk during merging or overtaking maneuvers. The vehicle was previously repaired for this exact issue by an authorized Ford dealer on May 30, 2024 (at ~32,000 miles). However, the failure has recurred 18 months and 33,000 miles later. Inspection of the current failed parts reveals that during the 2024 warranty repair, the dealership installed obsolete, superseded part numbers (Series "NZ", specifically NZ67-3B436) instead of the updated, corrected design (Series "SZ") released by Ford to fix this known defect. Because the dealership replaced defective parts with the same defective/superseded design, the safety hazard has returned prematurely. The defect was previously confirmed by a dealer technician. The current failure is confirmed by visual inspection of the part labels showing the obsolete "NZ" code. No warning lights appeared prior to failure; the symptom is immediate mechanical vibration under load.

This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".

I had been driving for 2 hours on the interstate when the truck starts losing power and warning lights start flashing. I got the truck to the shoulder before it slammed to a stop. I turned the engine off and waited until all the power turned off before restarting. The truck would only run in limp mode at 35 mph. I drove on the shoulder of the interstate to the next exit. I disconnected the battery and reconnected which allowed me to drive it normally to the dealership. After two days the dealer called to say they didn’t see any codes and there wasn’t anything wrong with it even after I sent pictures of the warning messages. This is the 5th time this has happened under similar circumstances.

This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".

I had been driving for 2 hours on the interstate when the truck starts losing power and warning lights start flashing. I got the truck to the shoulder before it slammed to a stop. I turned the engine off and waited until all the power turned off before restarting. The truck would only run in limp mode at 35 mph. I drove on the shoulder of the interstate to the next exit. I disconnected the battery and reconnected which allowed me to drive it normally to the dealership. After two days the dealer called to say they didn’t see any codes and there wasn’t anything wrong with it even after I sent pictures of the warning messages. This is the 5th time this has happened under similar circumstances.

The car have a Big vibration when speed up over 45 MPH

PREMATURE CV axle failure due to regenerative braking. This cause violent wobble leading to the death wobble

At 20k miles the vehicle starts shaking back and forth and rattling while accelerating and I brought it to the dealership and its being serviced under warranty to get both front CV axels replaced. It was shaking so badly and vibrating the whole vehicle, the dealership told me it was unsafe to drive when they saw how badly the axels failed. There were no warnings or check engine lights. Especially dangerous because it doesn't shake at low speeds only when accelerating and at high speeds.

Vehicle stopped accelerating while doing an U turn with oncoming traffic. Had to pull over because the vehicle would not move.

Truck shakes when accelerating and limits acceleration and safety. Belief is the CV axles failing.

Vehicle started shaking during acceleration above 40 mph. Felt like the wheels were going to come off. The issue is that the front axle drive shafts are very corroded and failing.

Vehicle information: Ford Maverick 2023 Hybrid, with roughly 37,000 miles, observed failure on [XXX]. The failed component/system is the A/C evaporator condensation drain system. The drain line became clogged, which I believe is a critical defect in either the design, component, or construction of the drainage system. The lack of a fail-safe in this system, instead of draining water outside of the vehicle, the condensation backed up and leaked directly into the vehicle's cabin onto the driver and passenger side footwells. The vehicle is currently at the dealership (Windward Ford), undergoing diagnosis/repair, and available for inspection upon request. The pooling of a large volume of water on both the driver and passenger side floorboards to include the path of where the water originates as it collects at the footwell, creates an unreasonable risk of safety failure due to the proximity of critical electrical systems; fire/short circuit risk, loss of vehicle control due to damage to electronic modules from water intrusion, as well as health hazard with prolonged saturation of pores material resulting to mold and mildew growth. The issue has been reproduced at the dealership (Windward Ford), and confirmed that the issue is an A/C evaporator drain clog, causing the leak, and the carpet and interior padding were saturated, requiring extensive cleaning and replacement. The failed component/system has been inspected by technicians at the dealership. The diagnosis and repair estimates are on file with the dealership. There were no warning lamp indicators or messages, just the damped smell, which was noticed a few weeks prior to the visual indicator of a water puddle in the floorboard. The odor is a direct result of the ongoing, hidden water leak and saturation of the carpet, indicating a slow, chronic problem caused by the defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Receive "Has Entered Deep Sleep Mode" daily notification through the Ford APP. The dealership keeps telling me there isn't anything wrong with the battery, as it's test good. Even though the can see (an I've shown them) the notifications. It's being driven as it's my daily driver. It hasn't put me at risk at this time.

My entire front end is vibrating badly. I replaced all tires and did a front end alignment. It didn't fix the issue. I took it to the dealership for diagnosis and they said the axels are bad and a known issue on the make model and year.

The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 65 MPH, the check engine warning light illuminated, and the "Service Engine Immediately" message was displayed. The contact stated that the vehicle started losing motive power. The accelerator pedal was depressed, but the vehicle decelerated to 5 MPH. The contact stopped and had the vehicle towed to a dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact used a handheld scanner and retrieved DTC: P1061 (Faulty Rod Bearing). The vehicle was towed to the same dealer, but the dealer was unable to duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the same dealer where it was determined that the long block needed to be replaced. The vehicle was not repaired. The contact spoke with a mechanic and was informed that the failure was related to Customer Satisfaction Program: 23N06 (Long Block Replacement). The manufacturer was contacted for confirmation that the vehicle was covered under the CSP; however, the contact was informed that the vehicle was not covered under the CSP. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

The 12-volt battery loses charge and issues a warning that remote features have been disabled. This issue has been going on since January 2025. To date, I have recharged the battery 15 times, plus taken it to 2-different Ford dealerships for warranty service. Both were unable to resolve the problem. Beginning with the 2025 model year, Ford commenced installing AGM 12-volt batteries which resolved the problem. The vehicle is still under warranty but the dealerships simply recharge the battery and return the vehicle. My vehicle is not part of the Ford recall for this problem. The root cause appears to be poor quality Chinese batteries used in the early model years.

At approximately 37,000 miles, the CV axles on my 2023 Ford Maverick Hybrid required replacement due to premature wear. Now, at around 62,200 miles, the vehicle is experiencing excessive vibration and shaking during acceleration, particularly noticeable at moderate to high speeds. This issue appears to be related to the powertrain or suspension system and may indicate a recurring or unresolved problem with the CV axles or associated components. The vibrations are severe enough to affect vehicle control, especially during lane changes or merging onto highways. When accelerating to merge into highway traffic, the vehicle shakes and vibrates so profusely that it feels like the car is going to shake apart. This makes it difficult to accelerate normally and safely, putting both the driver and surrounding vehicles at risk. The shaking could lead to loss of traction or steering instability, increasing the likelihood of an accident. This issue has been widely reported by other Ford Maverick owners and has been a frequently discussed problem in forums and owner communities for over a year. Despite its prevalence, there appears to be no long-term fix other than replacing the CV axle assembly with the same OEM part, which may be the root cause of the problem. That is why I feel it is important to bring this to your attention — it is a known issue with no real correction, and it continues to affect vehicle safety. No warning lights or messages appeared prior to the onset of the problem. The component is available for inspection upon request.

violent shaking on accelerating

Battery in truck continually dead Malfunctioning equipment had left me stranded Vehicle has been inspected numerous times and ford will Not fix

The contact owns a 2023 Ford Maverick Hybrid. The contact stated that while driving at an undisclosed speed and depressing the brake pedal, the pedal vibrated and pulsated, but the vehicle did not immediately stop, causing the braking distance to be extended. Additionally, the contact stated that the warning message "Pre Collision Activated" was erroneously displayed while driving with no other vehicles or large objects nearby. The vehicle was taken to the local dealer, who was unable to determine the cause of the failures. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 10,000.

The contact owns a 2023 Ford Maverick. The contact stated that on three occasions, while the vehicle was parked, the vehicle failed to start. The contact attempted to jumpstart the vehicle however, the vehicle failed to start. The vehicle was taken to a dealer to be diagnosed, and it was determined that the battery needed to be replaced. The vehicle was repaired but the failure reoccurred three months later. The contact stated that the dealer replaced the battery, and the vehicle was taken to the dealer, where it was determined that the battery was defective and needed to be replaced. The battery was replaced however, the failure reoccurred approximately four months later. The vehicle was taken to a different dealer, where it was diagnosed that the battery needed to be replaced. The manufacturer was notified of the failure. The contact believed that the failure was related to Manufacturer Recall Number: 53801. The failure mileage was approximately 22,000.

Both front axles had to be replaced at 62000 miles. Just about of fords power train warranty. Have read multiple issues of these trucks having the same problem.

2023 Maverik Hybrid at around 30,000 miles Vehicle would start shaking while accelerating. I took it to the dealership and they had to replace all the components in the front end of the truck. I know have about 60,000 miles on the vehicle and I'm having the same shaking problem while accelerating. It looks like this is a common occurrence with this vehicle. It is no longer under warranty and is going to cost a lot to get fixed. Not excited about having a major repair every 30,000 miles.

Cv axles went out at 55k causing shaking at highway speeds while accelerating. Frequently when starting the car the steering wont activate right away even after the car begins to move for 5-10 feet. Dealer cant replicate because it doesnt happen every time. But it is still doing it and may cause a crash in the future....

The contact owns a 2023 Ford Maverick Hybrid. The contact stated while driving 65 MPH, the vehicle unintendedly decelerated to 35 MPH while driving downhill and decelerated to 6 MPH while driving uphill. The message "Engine Repair" was displayed, and the power train warning light was illuminated. The vehicle was taken to the dealer, where the diagnostic trouble codes were cleared; however, the vehicle was not diagnosed or repaired. The contact stated that the PCM was previously updated under an unknown recall in 2024; however, the failure recurred while driving. The vehicle was taken to Maguire's Ford of Hershey, Inc. (100 N Thistledown Dr, Palmyra, PA 17078); where the diagnostic trouble codes were cleared; however, the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 25V158000 (Power Train, Electrical System); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the dealer and to the NHTSA Hotline for assistance. The failure mileage was approximately 400.

The vehicle has less than 12,000 miles. Vehicle repeatedly entered "deep sleep" mode, disabling vehicle remote features and lights inside of vehicle. Took to dealership multiple times. Battery test showed sulfation and can no longer function as designed. Factory 12v battery replaced and software update completed yet still experiencing the same “deep sleep” mode.

While traveling at speed there was a severe malfunction of the vehicle's stereo system. While driving the stereo was initially silent but later began to produce extremely loud noise/static. The volume of the noise was so extreme I had to take my hands off the steering wheel to cover my ears. The stereo did not respond to any power or volume input to stop the sound and I was forced to quickly pull over to the side of the road to turn off and exit the vehicle. The sound only stopped after exiting the vehicle and locking with the key fob. There were no warning signals prior to this failure. I have experienced this problem several times in the past while the vehicle was parked, when first starting the vehicle. This was the first instance of experiencing the problem while driving, within the first 1 minute after starting the vehicle. The stereo was initially on and set to a reasonable volume level, but was malfunctioning and completely silent. After driving for ~45 seconds the stereo began producing this extremely loud noise. I have found several reports of similar stereo issues with the Ford Maverick and also F150 trucks that are equipped with a similar B&O sound system. This malfunction could potentially lead to an extremely dangerous situation, inability to safely operate the vehicle, and loss of situational awareness. I have dash cam footage of the incident, which I can provide upon request.

The front of the vehicle started shaking with acceleration. This shaking became worse and vehicle was unsafe to drive. The vehicle was brought to ford dealership and they will be replacing the front half shafts and brackets.

Total 12v battery drain/failure which is a known problem with the Ford Maverick Hybrid, could not even put hazards on to avoid getting hit on the side of the road. Ford tests battery and says battery is good, but the problem is the Maverick Hybrid is not adequately charging the battery when it is driven.

On Tuesday, [XXX], my wife and I were driving her, new to her, 2023 Ford Maverick Hybrid XLT, that we purchased from Stuckey Ford in Bellefonte, PA on [XXX]. She was behind the wheel. We were heading west on [XXX] and had just passed into Pennsylvania by crossing the Delaware River. The check engine light and battery lights went on suddenly & we immediately lost power. The power steering was no longer working, but the brakes were. As we were in the passing lane going 65 mph & there was an 18-wheeler in the right lane, we could not cross two lanes to reach the Matamoras exit ramp. She steered into the median between lanes to our left. The Maverick would not start. We were about 6" off the left hand white line of the west bound passing lane. I called 911 who sent a PA State Trooper to park behind us with his flashers on. We were towed off the [XXX] exit ramp to a garage. We tried to start the truck five times, it would not start. The sixth time it did start but when the tow truck operator tried it, the truck only started intermittently. We called the nearest Ford Dealer, Healy in Goshen, NY. We were towed to Healy the same afternoon. They said their diagnostics could find no problems. Their invoice is attached. Since the event on [XXX], the Maverick has not turned on when the key is turned & brake pedal depressed multiple times. When this happens the same two lights (check engine & battery) stay on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)