2020 FORD F-350 Recalls, Complaints & Safety

Box Separation from the box side to the box rear. box integrity compromised. Truck has always been used under the capacity ratings. I have 2 ford doing the same thing.

I am the owner of a 2020 Ford F‑350 equipped with the 6.7L Power Stroke diesel engine. My vehicle is subject to an open safety recall, NHTSA 24V957, involving the high‑pressure fuel system. I have been informed by an authorized Ford dealer that there is currently no effective repair remedy available. While I have not experienced loss of power, my vehicle has exhibited abnormal transmission shifting behavior beginning around 40,000 miles. This concern was documented by the dealer and described as normal operation. The condition persisted and was documented again around 60,000 miles, although the dealer stated they could not replicate the issue. Given the unresolved safety recall and ongoing powertrain behavior, I am concerned about vehicle safety, drivability, and long‑term reliability, and I am submitting this complaint to document the risk before a safety‑related failure occurs.

Vehicle produced symptoms over time: Loss of Ford Pass connectivity, Inconsistent turn signal function, occasional dashboard alarm for Open Driver Door while driving, unwarranted security alarm triggers when still at home. Second to last incident was an unwarranted security alarm that triggered, and was unable to be stopped by use of the security controls (lock/unlock, alarm key button). Horn "wore out" as if fuse burned. Disconnected battery to stop. Two days later, after reconnecting the battery I drove the vehicle, Horn was not functional, and I was unable to stop the engine. Once started, the vehicle did not turn off, even with key completely removed from ignition switch. This was repeatable, every ignition cycle, thereafter. I drove to the dealer, that morning. The dealer mechanic was required to shut off the engine. Dealer mechanic diagnosed failed Battery Junction Box. After Repair, Mechanic diagnosed faulty Body Control Module. Dealer mechanic also recommended replacement of full "Main" wiring harness, interconnecting the two. The cause for all failures was corrosion and electrical shorts due to water ingress. I am aware Ford has issued numerous TSBs and recalls for faulty BCMs, in the same age range as this vehicle. Also, TSBs for water intrusion into the BCM. The mechanic took photos of corrosion on both the BCM and main wiring harness. My prior vehicle was a 2011 Ford F-150, with the same 6.2L engine. No such faults were experienced up to Nov. 2023 sale. Photos of the corrosion on main wiring harness and BCM attached. Dealer has possession of the vehicle. Repairs in progress. Ford has declined support for faulty components; Recalls not associated with this vehicle. Estimated repairs to date on 6 year old vehicle on critical electronics in excess of $7,000.

Truck started jerking and shifting hard when driving. Contacted ford and they said that they needed to do a software update. Did the software update and it got extremely worse not wanting to shift into gear. Take the truck to ford in November to have fixed said I needed a new tranny. My extended warranty approves a used one they put it in same thing happening. Send that one back and put another one in same issue with that tranny. It is now March and they cant find another used tranny to fix my truck. After reading many things online it comes down to the CDF drum the bushing/sleeve moves inside the drum. Ford is aware of this issue and has upgraded/revised a drum. Why is this not a recall issue?

The contact owns a 2020 Ford F-350. The contact stated that while driving at 70 MPH, the vehicle went into LIMP Mode and unintendedly decelerated and shut off. The vehicle was towed to the residence, and a dealer was contacted. The contact associated the failure with NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL). The vehicle was towed to the dealer, and the contact was informed that the CP4 high-pressure fuel pump needed to be replaced. The engine was repaired, and the vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the recall was on pause. The failure mileage was 270,000.

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Numbers: 24V957000 (FUEL SYSTEM, DIESEL), 25V626000 (STEERING), and 25V686000 (BACK OVER PREVENTION). The contact stated that while driving at an undisclosed speed, the steering wheel was wobbly. The steering wheel detached from the housing four inches and independently moved up and down. The contact had not lost control of the vehicle. The contact was unsure if any warning lights were illuminated. The vehicle was driven to the dealer at slow speeds. The dealer determined that the steering column upper shaft had separated. The dealer informed the contact that the recall repair stated that the upper shaft would be repaired or replaced. The contact was informed that replacing the steering column was not part of the recall repair and the contact would be responsible for additional repairs. The vehicle was not yet repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the additional repairs. The failure mileage was approximately 100,000.

The contact owns a 2020 Ford F-350. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (FUEL SYSTEM, DIESEL) and 25V686000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact received a letter from the manufacturer stating that parts for NHTSA Campaign Numbers: 24V957000 (FUEL SYSTEM, DIESEL), were available. The vehicle was taken to the dealer, where the contact was informed that while the software was being downloaded, the software update failed several times. The failure had occurred on several vehicles, and the dealer showed the contact that the service program update sent by the manufacturer to "Pause" and not to attempt any repairs starting February 02, 2026, until further notice. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue, and a case was filed. The contact had not experienced a failure.

A component has not yet failed but an existing recall (Ford recall 24S78 / NHTSA ID 24V957) describes the potential for loss of motive power increasing the risk of a crash. This recall was issued in December of 2024. I received a notice in January of 2026 that the repair was available, went to my local dealer and was told the recall had been paused on 02/03/2026 - no actual repair is currently available. I live full-time in my 2021, 20,000 lb., 5th-wheel RV and frequently tow it with no other option than my 2020 F350 with the open recall. To quote the recall document, "Ford has not issued instructions to stop driving your vehicle under this safety recall" but a loss of motive power is exponentially worse when towing a large load which is what this vehicle was purpose-built to do.

Ford sent this recall letter in October, 2025. It’s unbelievable, and unacceptable that Ford would describe a “potential loss of steering control resulting in a crash or injury (or death). However we don’t instruct you to stop driving your vehicle. Parts to fix your defective steering column which could come apart in your hands while driving down the interstate with loved ones, or towing (full ton trucks are meant for heavy towing) won’t be available until 1st quarter 2026”. Are you serious? It’s now halfway through 1st quarter 2026, & still no follow up from Ford. How many people have to die, before the actuaries at NHTSA decide it’s time to put pressure on Ford to expedite this fix? I had no choice but to risk driving my truck 1,200 miles to Florida last week. Thankfully, we made it. However, I refuse to drive it any further as it’s parked in my driveway. I will not hook up my boat or horse trailer until Ford manufactures a new, safe part, and installs it in my truck’s steering to correct this deadly condition. What is NHTSA doing to pressure Ford to get this done? If you send me a standard, boiler plate answer like others have received “be patient, don’t call us, call Ford (and talk to their AI robot)” I will get together with others affected by this recall, and we will go to the media, and possibly higher, if that’s what it takes. Shame on you, claiming to be on the side of living people who just want to stay alive.

Driving the vehicle at highway speeds (around 55mph). Driver hear a loud hum, lost power and needed to pull over. The rear axle housing grenaded and twisted the pinion clean off the rear axle. The truck was loaded with tools and pulling a trailer. However this load was well within the GVWR of the vehicle

This recall has been going on for over three months. I have canceled vacations and other trips due to the severity of this recall. I haul a truck camper and I do disaster relief/recovery with several groups. I use my truck to get there and sleep in my camper due a lack of resources during a disaster. This recall has prevented me from responding. Ford has given no indication of when this is to be repaired.

This has occured multiple times. While driving on freeway at speeds between 65 and 75 MPH and hitting rough asphalt, the vehicle begins shaking violently, almost to the point of losing control. It will only stop if I slow down to under 40 mph or stopping altogether. This has been very frightening when it occurs in traffic on freeways. It seems to occur mainly when on a curve.

I have the 7.3 gas engine. It is now sounding like a typewriter. I've been told I could have a $8,000 to $13,000 repair or total engine replacement. My truck is just under 97,000 miles and this has been a known issue for the Job 1 engines. Ford is not taking ownership of these lifter/cam issue. I was told I could have my engine lock up on me while driving. I am autistic and have an autoimmune issue that cause me to have a disabilities. It does not seem right, that a long term, multiple Ford owner now could have their engine fail or lock up while I'm driving, not to mention I may need a complete new engine from this design error. From what I've read, the Job 2 of these engines they've enlarged oil recyclers or something to correct this issue. Can you help us that have this major saftey issue?

The contact owns a 2020 Ford F-350. The contact stated that while driving at an undisclosed speed, the engine power failure warning light illuminated, and the engine seized. The contact stated that the failure had occurred while towing a small vehicle. The contact coasted the vehicle to the shoulder of the road, which was very unsafe. The contact stated that while attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to an independent mechanic, where it was diagnosed with high-pressure fuel pump failure, cylinder rod and head gasket failures. The contact was informed that the high-pressure fuel pump had exploded and sent fuel all over and into the engine. The contact was informed that the engine had failed due to a high-pressure fuel pump failure. The contact was advised to tow the vehicle to the dealer. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, parts for the recall repair were unavailable. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the dealer to schedule a diagnostic test. The failure mileage was approximately 138,527.

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part for the recall repair was not available. The contact stated that parts were still not available for approximately one year. The contact stated it should not take the manufacturer that long to write a new software program. In addition, the contact stated that the vehicle was purchased and used for recreational purposes. The dealer was contacted several times. The contact stated that on the last conversation with the dealer, the contact was informed that parts should be available in several months; however, parts were still unavailable. The manufacturer was contacted. The contact had not experienced a failure.

The contact owns a 2020 Ford F-350. The contact stated that while driving approximately 55 MPH, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact was able to pull over but was unable to restart the vehicle. The vehicle was towed to a local dealer, where it was diagnosed, and it was determined that the diesel fuel system needed to be replaced. The vehicle was repaired and was covered under warranty. The contact stated that one month later, the vehicle experienced a failure while he was driving. The vehicle was towed to the same dealer, who determined that the diesel fuel system had failed. The contact was advised that the vehicle was no longer covered under warranty and would be repaired out of pocket. The contact had the vehicle towed to a diesel repair shop. The contact stated that the repair shop replaced the diesel fuel system, and the vehicle was repaired. The contact stated that in January of 2025, notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel) was received. The contact called the manufacturer and was referred to the dealer for assistance. The failure mileage was approximately 47,000.

The contact owns a 2020 Ford F-350. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (FUEL SYSTEM, DIESEL), 25V626000 (STEERING), and 25V686000 (BACK OVER PREVENTION); however, the parts to do the recall repairs were not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was stopped on the side of the road and idling, the engine made a chirping sound and then shut off. No warning light was illuminated. The vehicle was towed to the dealer, who determined that the high-pressure fuel pump had failed. The contact was informed that the vehicle was not covered under the recall due to the mileage exceeding the warranty coverage. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.

The steering column upper shaft may have been manufactured wrong and can result in losing the steering. I can not drive the vehicle. I live far from Boise and I'm missing family events and hunting for which I paid tags/license. The parts for this will not be in till next year sometime, per the recall letter. The vehicle has not been inspected and the recall letter doesn't ask for it to be. There has not been any problems up until now.

The contact owns a 2020 Ford F-350. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The vehicle returned to normal functionality, but the failure became a regular occurrence. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the lifter in cylinder #2, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The contact stated that the original engine was replaced at 39,400 miles in 2022. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 35,000. The VIN was not available.

I was driving when the steering column upper sharft sperated from the steering wheel. i was driving without any control of the steering. They still have not inspected this. I had it towed to Capital Ford of Sept 3rd. This is directly related to recall 25V626. This can happen while driving and is terrifying especally because there is zero warrning and you do not expect this to happen.

Crash 1 injured

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the vehicle had experienced the failure listed in the recall, causing the check engine warning light and “WRENCH” icon to illuminate. The vehicle was not repaired. The failure mileage was 49,000.

I have sent in a previous complaint as our truck would die in the middle of the road, due to the fuel pump. It is unacceptable that Ford has not resolved the recall issue in 9 months. Our truck is needed daily for our business. Please make Ford take action.

I own a 2020 Ford F-350 Super Duty (VIN: [XXX] , mileage: ~20,000). The vehicle is subject to a recall involving the transmission output planetary four assembly replacement. Ford and the dealer insist that the transmission must be disassembled and rebuilt to complete this recall. I do not agree with this solution because it permanently alters the integrity of the original transmission. Additionally, the dealer (Route 23 Auto Mall, Butler NJ) has repeatedly mishandled repairs, including installing the fuel filter incorrectly multiple times. I have opened several case numbers with Ford Customer Service: Recall Case No: [XXX](02/02/2024) Fuel filter dealer error: [XXX] (01/06/2025), [XXX] (01/15/2025), [XXX] (08/26/2025) Transmission recall follow-up: [XXX] (02/25/2025) Buyback case (denied): [XXX] (03/04/2025) Despite multiple cases, Ford refused to buy back the vehicle because it is registered under a company name. This is unfair and leaves me with a defective and unsafe vehicle. I request NHTSA to investigate this recall and require Ford to provide a new transmission replacement instead of a rebuild, and to review Ford’s handling of dealer errors and warranty obligations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I WAS DRIVING FORWARD APPROX 5 MPH AND LOST ALL CONTROL OF THE STEERING. THE STEERING WHEEL WAS NOT MOVING THE FRONT TIRES AT ALL. THERE WAS NO WARNING, AND INDICATION THAT THE STEERING WAS GOING BAD. THE TRUCK IS 2020 WITH APPROX 80,0000 MILES. NOT LIFTED, NO OFF ROADING. THE STEERING WHEEL WILL JUST SPIN NO STOP TO IT IN EITHER DIRECTION. MY UNDERSTANING WITH THIS TRUCK IS THERE IS NO INTERMIDATED SHAFT SO IT DIDNT SLOWLY GO OUT. THE NIGHT BEFORE MY FAMILY AND I WERE COMING DOWN FROM LAKE TAHOE WITH A BOAT ATTACHED. HAD THIS HAPPENED AT THAT SPPED WITH A TRAILER IT WOULD HAVE BEEN A VERY DIFFERENT OUTCOME.

Crash

I WAS DRIVING FORWARD APPROX 5 MPH AND LOST ALL CONTROL OF THE STEERING. THE STEERING WHEEL WAS NOT MOVING THE FRONT TIRES AT ALL. THERE WAS NO WARNING, AND INDICATION THAT THE STEERING WAS GOING BAD. THE TRUCK IS 2020 WITH APPROX 80,0000 MILES. NOT LIFTED, NO OFF ROADING. THE STEERING WHEEL WILL JUST SPIN NO STOP TO IT IN EITHER DIRECTION. MY UNDERSTANING WITH THIS TRUCK IS THERE IS NO INTERMIDATED SHAFT SO IT DIDNT SLOWLY GO OUT. THE NIGHT BEFORE MY FAMILY AND I WERE COMING DOWN FROM LAKE TAHOE WITH A BOAT ATTACHED. HAD THIS HAPPENED AT THAT SPPED WITH A TRAILER IT WOULD HAVE BEEN A VERY DIFFERENT OUTCOME.

Crash

When exiting the interstate and coming to a complete stop at the bottom of the exit ramp we went to make a right turn onto a two lane mountain road when we felt a hesitation and within seconds the engine began to sputter, we lost power and the check engine light came on. This was a two lane 55MPH road with no shoulder pull off. Thankfully there was no oncoming traffic in the other lane and there was also an abandoned fruit stand parking lot which were were able to drift across the road and stop in. We experienced a COMPLETE loss of power. Had there been oncoming traffic or no open parking lot just across the road we might have experiened a crash. It is important to note that we were on a vacation in the mountains and thankfully our RV was parked at the Campground we were not towing it at this time. We had to find a tow service to have the vehicle towed to the nearest Ford Dealership in the area. The Dealership notified us that there were metal shavings/flakes in the lower fuel filter housing. They told us that this was a Complete Fuel System Failure and that we would need a complete fuel system replacement of all parts. We had been notified of the recall (Safety Recall Notice 24S78/NHTSA Recall 24V957) in January 2025 and we had taken it to the local Ford Dealership who advised there was no fix for the problem at this time. The Dealership that our truck was towed to after this incident advised us that we would have to pay for all the repair costs (excess of $10,000) as this was still an open recall. We feel that this is a MAJOR safety issue - we were due to leave for home the following morning where we would have been towing a 7500lbs travel trailer on the interstate roads. Had we experienced this failure then it could have been truley tragic for not only us but other motorists. After this incident we called Ford Motor Company and advised them and they told us it was still considered an open recall with no fix available.

Transmission jerking hard down shift cause stalling Did update less then 100k miles on truck and now back doing it again

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that upon contacting several dealers, including the local dealer, the dealers informed the contact that the recall part was not yet available. The contact was concerned for her safety while driving the vehicle. The manufacturer was contacted and confirmed that the part was not yet available. The contact had not experienced a failure.

The contact owns a 2020 Ford F-350. The contact stated that while driving approximately 50 MPH, the transmission unexpectedly downshifted from 10th to 1st gear, causing the vehicle to abruptly decelerate in the middle of the road. Additionally, on several occasions, the transmission unintendedly shifted out of gear. The vehicle was taken to the local dealer who serviced the transmission, but the failures persisted. No further information was available. The vehicle was later taken to a different dealer, who diagnosed that the transmission required a complete overhaul. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 72,000.

The contact's husband owns a 2020 Ford F-350. The contact stated that while her husband was driving at unknown highway speeds, the vehicle stalled without warning. The vehicle was towed to a dealer, where it was diagnosed with a high-pressure fuel pump failure. The contact was informed that part to do the repair was on backorder, and the vehicle was towed back to the contact's residence. The contact then received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. Several local dealers were contacted and each dealer stated that the parts were unavailable. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.

Passenger, right side door mirror has failed in that while driving, regardless of speed, the mirror no longer stays outright and provides rear and blind spot view capabilities, therefore making lane changes hazardous with a high potential for crash probability. The internal mechanism(s) have failed and while driving the side mirror folds inward and collapses towards the door making it impossible to see what is next to you in an adjacent lane as well as what may be approaching from the right rear and right lane. The vehicle is scheduled to be inspected by a Ford dealership tomorrow (8/1/2025) to be assessed and see if they will replace the mirror. The mirror in question is pristine and has not been subjected to harsh treatment or been struck by any outside forces that would cause internal damage. No crash reports are associated with this vehicle.

The contact owns a 2020 Ford F-350. The contact stated while driving approximately 45-50 MPH, the passenger's side rearview mirror turned inward unintendedly, which prevented the driver from seeing the roadway. The contact stated that the mirror failed to remain in the correct position, which required the front passenger's side seat occupant to manually hold the rearview mirror at the correct angle for the driver to see the roadway. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a case was filed. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

The rear back up camera of my 2020 Ford F350 Superduty has not been working for several months, then in May of 2025, I found the recall notice about this issue and Ford has said that my vehicle isn't part of the rear back up camera recall, even though it has the same exact problem of the other vehicles involved in the recall. My vehicle was built in October of 2020 which falls into the same time frame of the other vehicle models and build dates. Will Ford be held accountable if I happen to back up and hit someone or damage something? My vehicle along with probably many other vehicles need to be added to this recall.

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000(Fuel System, Diesel); however, the part to do the repair was not yet available. The contact stated that while driving at approximately 65 MPH, the vehicle stalled. There was no warning light illuminated. The contact was able to coast to the side of the highway road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that the fuel pump had failed, causing debris to spread in the fuel system. The dealer determined that the fuel pump and the fuel system needed to be replaced. The engine was also inspected for damage. The vehicle was repaired. Upon receiving the recall notification, the manufacturer was contacted for reimbursement; however, the manufacturer advised the contact that reimbursement would be provided once the recall remedy became available. The failure mileage was approximately 150,000. VIN tool confirms parts not available.

The contact owns a 2020 Ford F-350 The contact stated while driving 25 MPH, the vehicle was quiet, and the vehicle lost power independently. No warning light was illuminated. The contact pulled over to the right side of the road while waiting for tow assistance. An Independent mechanic was contacted. The vehicle was towed to an independent mechanic and the contact was informed that the fuel pump was damaged and needed to be replaced. The vehicle was repaired. The contact related the failure to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The manufacturer was notified of the recall and informed the contact that parts for the NHTSA Campaign Number: 24V957000 (Fuel System, Diesel) was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 124,000. VIN tool confirms part not available.

The contact owns a 2020 Ford F-350 used for hauling a 24-foot trailer. The contact stated that while driving 40 MPH, the vehicle stalled. While driving and approaching a stop, the vehicle stalled. The vehicle restarted on one occasion. The reduced power mode message was displayed. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who determined the failure was due to the high-pressure fuel pump. The vehicle was repaired. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and informed about NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The failure mileage was approximately 56,000.

The connectors (part #1 HUZZ-14S411-HB) and (part #2 HUZZ-14S411-FA) are located in on the frame of the truck where the back wheels throw water towards when driving on wet terrain. They tend to hold water which causes electrical damage. This is happening on multiple ford trucks from 2020 - current models. This is causing tail light, AC, radio and other failures to occur.

The contact owns a 2020 Ford F-350. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning light was illuminated. The contact stated that the failure persisted. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

Our 2020 Ford F-350 experienced a catastrophic mechanical failure while in motion. The driveline disconnected, the rear axle locked up, and the transmission bellhousing was destroyed—leaving the truck completely immobile and blocking traffic. This occurred with no prior warning and posed a significant crash risk. At the time, Ford Safety Recall 22S22 (related to a known defect in the transmission’s output planetary four assembly) was open and had not yet been completed. The symptoms and failure we experienced match the failure scenario described in Ford's own bulletin for 22S22: driveline separation, internal transmission damage, and loss of control or Park function. Ford has denied coverage, stating the failure was due to a "loose pinion flange nut" and unrelated to the recall. However, they have not provided any inspection documentation, photos, or evidence that the recalled components were properly inspected or ruled out as the root cause. We have repeatedly requested this documentation from both Ford and the dealership, but neither has provided it. We are concerned that the failure was caused by the exact defect identified in Recall 22S22, and that Ford is failing to take responsibility or follow full recall procedures—including post-failure inspection and transparency. We are requesting that NHTSA investigate this case as a potential mishandling of a known safety defect and failure to comply with recall responsibilities.